Audi Q7 engine problems

ENGINE

waterpump is leaking- known issue that is currently being investigated for class action lawsuit. My car is now out of warranty.

NHTSA complaint #11756120 — an unverified report by a vehicle owner.

ENGINE

car in question is a 2022 Audi q7 55 tfsi - 3.0 turbo - 40k miles 2 owner. serviced at Audi since new. under warranty until 50k car throws a p0299 code - turbo underboost condition present - coolant migration from a faulty VW/AUDI water pump is sending coolant into vacuum lines causing catastrophic engine issues - car can not be driven. Audi will not fix under warranty and is trying to charge 5,800$ to replace waterpump/ associated lines. tells me the warranty "is for some items and not others" there is a class action lawsuit for a longstanding issue that Audi has been aware of since 2020 and not offering any solution for - Case No. 26-5678, NJ.

NHTSA complaint #11754899 — an unverified report by a vehicle owner.

ENGINE

On XXX, I was driving northbound on US-101 from [XXX] to [XXX] to pick up a family member for an appointment. The vehicle had been operating normally at freeway speed. As traffic slowed for a construction zone near Summerland, I intentionally reduced speed to approximately 20 mph. At that point, I heard a sudden abnormal rotational mechanical noise from the engine compartment, best described as a flapping or rubbing sound. The noise had not been present earlier during the drive. Within moments, the engine lost power and shut down. The vehicle lost propulsion while in traffic, and power steering assist was lost after the engine stopped. I was able to safely maneuver the vehicle off the roadway. The engine would not restart. Before this incident, I did not observe any meaningful warning of an impending catastrophic engine failure. I did not observe an engine overheating warning, an oil-pressure warning, or any other dashboard warning indicating an imminent engine seizure. Before purchasing the vehicle, and during my ownership, I used Ross-Tech VCDS (Audi/VW-specific diagnostic software) as part of proactive maintenance and monitoring. Nothing identified an impending catastrophic engine failure. The vehicle was transported to an independent European repair facility for inspection. The shop determined that the engine is mechanically seized and advised that the precise initiating cause cannot be determined without engine disassembly. An Audi dealership likewise indicated that additional manufacturer-level diagnostic procedures would be required. A case was created, and Audi declined assistance. I am submitting this complaint because the engine failed suddenly during normal operation without a meaningful advance warning, resulting in an immediate loss of propulsion in traffic. I believe this type of unexpected catastrophic engine failure presents a potential safety concern if it occurs while the vehicle is being operated on a public roadway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5

NHTSA complaint #11754103 — an unverified report by a vehicle owner.

ENGINE

My 2017 Audi Q7 with the 3.0T engine has experienced repeated engine/ignition system failures. The vehicle displays a "System Malfunction" warning light accompanied by shaking and stalling. This same malfunction has occurred at least 3 separate times over the past few years. Each time, a repair shop diagnosed and replaced faulty ignition coils, and the vehicle ran normally for a period of time before the identical malfunction returned. The vehicle is currently inoperable due to the most recent occurrence. This creates a safety risk because the stalling and shaking can occur while driving, with no clear warning beyond the malfunction light appearing at the same time as the symptoms begin. A stall or loss of power while in motion, especially in traffic or on a highway, could lead to a collision. The problem has been confirmed and repaired multiple times by an independent European auto repair specialist, who stated this is a known, recurring issue with this engine/model. The vehicle has not yet been inspected by the manufacturer directly. Separately, the vehicle has also developed excessive oil consumption, requiring approximately 2 gallons of oil added roughly every 6 weeks, with the frequency increasing over the last 2 months. I am uncertain whether the oil consumption and the recurring coil/ignition failures share a common root cause, but both issues are ongoing and unresolved. The vehicle and its components are available for inspection upon request.

NHTSA complaint #11754079 — an unverified report by a vehicle owner.

ENGINE

My 2022 Audi Q7 experienced an internal water pump seal failure that allowed engine coolant to migrate into the vehicle’s vacuum system, contaminating the vacuum reservoir, valve, and connected lines. This is a known failure pattern affecting Audi/Volkswagen vehicles equipped with the 2.9T/3.0T EA839 engine family, where the water pump’s internal design allows coolant to be drawn into the vacuum circuit undetected, since the leak is internal and not visible externally. This can affect brake booster vacuum assist and turbo/drivetrain systems depending on severity. The failure occurred outside of any accident or misuse, is a documented design issue in ongoing class action litigation against Audi/Volkswagen, and required extensive repair (water pump, vacuum reservoir, valve, and related lines) once diagnosed. I am filing this complaint to document the pattern of this defect.

NHTSA complaint #11754069 — an unverified report by a vehicle owner.

ENGINE

Took my Aui Q7 in to AUDI of [XXX], on XXX for a very rough idle and surging at lights from the automatic oof/on system and the 10,000 initial service ( 8000 Mile) I was surprized when the service rep mentioned that it could be a broken motor mount as i thought it was more of a idle adjustment. They did find the driver side mount was broken and replaced it under warranty. Received the car back on the 9th, but the car was again idling very roughly, took it back immediatley. they replaced the second motor mount, under warranty. I asked why they didt replace both at the initial repoair they said it was a policy to only replace one at a time under warranty!! After receiving the car back, there is still a rough idle, transmission is out of sync, no diagnosis or adjustment for the auto/on off system at lights. Took the car back and has been at the dealer while they discuss/diagnosis with Audi technical. Several discussion with the service manager Chris Calhoun regarding these problems and resolution. Received an email 7/28/29 that the dealership wants to return the car after adjusting the transsmission, no determination of the root cause or adjustments to the auto on/off system,but i have escalated with Audi Customer Care Case#XXX.The vehichle has been in their shop for 3 weeks- 7-7 to 7/29. I am awaiting a response form their care team looking for them to repurchase the vehichle or provide a replacement as i dont feel safe or confident that the repairs were done correctly or completely. It seem that they know the issue with the motor mounts are a problem that havent been disclosed , and to have a double failure at 8000 miles seems more than bad luck. The repairs have compounded other problems, rendering a new car to a used worn car, with unresolved issues that will only require future services visits in the future , totally negating my reasons for purchasing a new car. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11753503 — an unverified report by a vehicle owner.

ENGINE

Start/stop malfunction failed; yes it is available for inspection. Driving down highway vehicle stopped with 2 adult passengers and 2 children. Yes 3 mechanics completed a diagnostic. Vehicle has not been inspected by insurance, manufacturer or police but by VW dealer, and two registered mechanics. No other warnings or symptoms.

NHTSA complaint #11752232 — an unverified report by a vehicle owner.

ENGINE

My 2018 Audi Q7 3.0T Quattro is experiencing extreme oil consumption — dropping from full to minimum level in approximately 230 miles. This is approximately 14x beyond Audi's own threshold for excessive oil consumption of 0.5 quarts per 1,000 miles. Documented timeline: May 2026 (88,692 miles): Oil change required 2.2 extra quarts beyond standard 7.2qt fill. Low oil light triggered during highway travel. June 27, 2026 (90,200 miles): Authorized Audi dealer formally documented "oil consumption is very high" in their service system and scheduled an official oil consumption test. June 28, 2026 (90,351 miles): Audi MMI system showed oil near minimum after only 151 miles. June 30, 2026 (90,397 miles): Audi MMI showed oil at Stage 2 warning after 197 miles. June 30, 2026 (90,430 miles): Audi MMI showed oil at minimum line after 230 miles total. All readings documented with timestamped photographs from Audi's own MMI system. The authorized Audi dealer has documented repeated oil top-offs in their service system. Audi USA Customer Care was contacted on June 30, 2026 and denied goodwill repair citing no active recall and vehicle out of warranty. An open case has been filed with Audi USA. The engine lubrication system appears defective. Oil dropping to minimum in under 230 miles without adequate warning poses serious safety risk of catastrophic engine failure while driving at highway speeds. The authorized Audi dealer has scheduled an official oil consumption test and inspection for July 2, 2026. Results will be available upon request. Vehicle is available for inspection upon request.

NHTSA complaint #11747856 — an unverified report by a vehicle owner.

ENGINE

My independent repair shop has just diagnosed a coolant leak weeping from the vacuum line connection at the water pump; they referred to this problem as “coolant migration”. As documented extensively by Audi in Technical Service Bulletin 19-23-45 (2070349/2), this indicates an internal seal failure of the water pump, causing pressurized engine coolant to migrate directly into the vehicle’s vacuum system. While I understand that my vehicle is technically past its 4-year factory warranty timeline, a mechanical failure of this nature at just 43,000 miles is highly premature and points to a known manufacturer design defect rather than standard wear and tear. More importantly, this defect poses an immediate, severe safety risk. Because the vacuum system directly services the power brake booster, the migration of coolant into these lines risks catastrophic contamination of the braking system. This results in a stiff brake pedal and compromised vehicle stopping ability. I am deeply concerned about operating this vehicle with an active, manufacturer-acknowledged safety hazard affecting my brakes. At this time, I have not had this problem confirmed by the dealer, but plan to in the next week. The vehicle it available for inspection upon request.

NHTSA complaint #11746888 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

See attached document for complaint.

NHTSA complaint #11743264 — an unverified report by a vehicle owner.

ENGINE

I was traveling at highway speeds in active, high-velocity traffic when my vehicle suffered a sudden, catastrophic mechanical failure that nearly resulted in a severe multi-car accident. Without any warning, the vehicle completely lost its ability to accelerate, flatly refusing to pick up speed or maintain momentum despite pressing the gas pedal. ​This unexpected, immediate drop in propulsion marooned me in high-speed lanes, leaving the vehicle dangerously vulnerable as oncoming traffic rapidly closed the distance behind me. Drivers behind me were forced to aggressively swerve and brake to avoid a high-speed rear-end collision. Moments after this life-threatening loss of power occurred, the Check Engine Light illuminated on the dashboard. ​Subsequent technical inspection revealed a severe engineering defect: the internal seals of the factory coolant control components failed, forcing pressurized engine coolant backward into the engine’s primary vacuum system. This pressurized fluid completely contaminated the vacuum lines, the vacuum reservoir tank, and the electronic solenoids—including the N75 boost control solenoid. By filling the vacuum infrastructure with liquid coolant, the engine was instantly starved of its ability to regulate turbocharger boost, triggering a critical "limp mode" and a P0299 underboost fault. ​The catastrophic failure of an internal cooling seal directly compromising an active drivability safety system represents an unreasonable and severe defect. It transforms a routine drive into an immediate, uncontrollable highway hazard. I am filing this report because this known coolant migration pattern presents a clear, present, and life-threatening danger to owners operating this engine platform.

NHTSA complaint #11742674 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2021 Audi Q7. The contact stated that while driving approximately 50 - 55 MPH, the Check Engine light had illuminated. The vehicle was taken to the dealer, who diagnosed code PO299, which referred to coolant migration into the vacuum system. The contact was unable to provide the exact parts that were needed for repairs. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer opened a case regarding the issue. The failure mileage was approximately 60,000.

NHTSA complaint #11738957 — an unverified report by a vehicle owner.

ENGINE

Front right Marker light defect alert keeps pooping up and sounding an audible alarm while I am driving even through the marker light is working perfectly. Drive train alert comes on after I add oil and the vehicle starts hesitating while I accelerate.I just got a tune up which included new spark plus and a new coils. Problem came back even after the tune up within 3000 miles. Excessive oil loss. I constantly have to add a quart of oil even after I just got an oil change and tune up. Seeing oil in the cover shield that covers the entire engine. Seems like the oil is blowing out of the cap area where you add in oil. These problems are very costly for a vehicle that I ordinary love. Please advise what can be done because I can not pay for any more repairs out of pocket. There is only 80,100 mile on the vehicle.

NHTSA complaint #11738363 — an unverified report by a vehicle owner.

ENGINE

Early fuel pump failure at 55k miles. Coolant is now leaking and the fuel pump and vac system need replacement.

NHTSA complaint #11738191 — an unverified report by a vehicle owner.

ENGINE

the first indication of an issue was oil consumption. It was using more oil than usual around the 70K mile mark. Then it started misfiring, and soon after a knocking noise coming from the engine. There are no check engine light on, after bringing it in for diagnostics, it read that it was a spark plug, once they got into the engine they discovered the cylinder had been stripped from the piston. Yes the diagnostics came from our foreign car mechanic. no, it has not been inspected by the manufacturer or police. Just the symptoms. sometimes the light would come on, and then it would go off. At this point it is off. All of this started in the fall of 2025.

NHTSA complaint #11737769 — an unverified report by a vehicle owner.

ENGINE

While my vehicle was in for the Audi piston issue, they stated my water pump needed to be replaced and isn’t covered by a recall (yet). My vehicle had less than 42,000 mile on it. I was lead to believe that this problem is coming up more often and they believe a class action lawsuit will come about. I needed to pay over $1,700 out of pocket and was told I was saving so much money because they already had the engine apart because of the piston recall. This is unacceptable.

NHTSA complaint #11737715 — an unverified report by a vehicle owner.

ENGINE

I am reporting suspected odometer fraud on my 2018 Audi Q7 3.0T Prestige (VIN: [XXX] ). Between May 8 and June 13, 2025, while I was the sole driver of the vehicle, Audi dealership service records show an odometer increase of 5,282 miles (from 78,260 to 83,542). However, independently verified GPS trip data from the Audi Connect system confirms I drove only approximately 2,103 miles during this period — a discrepancy of approximately 3,178 miles. The vehicle was serviced at two Penske-owned dealerships: Audi of Arlington (3200 Columbia Pike, Arlington, VA 22204) and Audi of Chantilly (14839 Stonecroft Center Ct, Chantilly, VA 20151). Only authorized dealer diagnostic equipment can alter odometer values. This manipulation resulted in the wrongful denial of my extended warranty coverage and a $37,567.16 out-of-pocket engine replacement. I have a fully documented demand letter with ten supporting exhibits including service records, Audi Connect trip data, and a detailed timeline. The dealerships did not respond to my demand letter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11730885 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2020 Audi Q7. The contact stated that while driving at an undisclosed speed, the transmission unexpectedly downshifted while the accelerator pedal was depressed. The check engine warning light was illuminated. The vehicle was taken to a local dealer, where the water pump, coolant pump, vacuum line, and vacuum reservoir were replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

NHTSA complaint #11724096 — an unverified report by a vehicle owner.

ENGINE

I discovered this item while researching another issue. There was a class action law suit against VW/Audi for the Water Pump and coolant leaking into the system. The class action covered the year and model for my Audi (2020 Q7) but my VIN was not included. The class action ended in 2024. On 8/4/25, My water pump went out because of coolant going into system. A $6,000 repair. I brought the issue up with Audi. No response.

NHTSA complaint #11720200 — an unverified report by a vehicle owner.

ENGINE

The car has always (including during warranty period) required addition of engine oil in between scheduled maintenance interval, and problem got worse as function of age/miles. Audi has diagnosed this issue and it has been determined that the engine consumes excessive oil and requires new piston skirt. The cost of the labor is not something Audi is willing to pay for and there is a class action lawsuit. Audi has sent an email/letter to certain owners of the vehicle. My VIN for some reason wasn't included but now Audi has verified, but not willing to pay for the cost to replace the engine or fix it.

NHTSA complaint #11716861 — an unverified report by a vehicle owner.