396 of the
2,799 complaints filed about the BMW X3
are about the electrical system —
14% of everything owners reported.
The worst model year for it is 2019.
The contact owns a 2021 BMW X3. The contact stated that while attempting to start the vehicle, the engine hesitated while turning over. The contact received notification of NHTSA Campaign Number: 26V438000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. The failure mileage was 76,494.
NHTSA complaint #11758175 — an unverified report by a vehicle owner.
I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.
NHTSA complaint #11756272 — an unverified report by a vehicle owner.
I had started my car drove out of my parking lot as I approached the highway the first intersection everything went dead no lights, snow warning lights just completely shut down and rumble as if the engine was gonna fall out a police man passed me. I was stuck in the middle of the highway. Help me push my vehicle off the road and sat with me while I called AAA. He could not get the car started. It was not the battery. He also only checked the battery terminals under the hood he hooked his portable battery charger. just gonna let me drive home hooked up, but it would not start.
NHTSA complaint #11755391 — an unverified report by a vehicle owner.
The contact owns a 2020 BMW X3. The contact stated that while driving 25 MPH, the message “Heat Management Module Malfunction” was displayed and the warning light was illuminated. The drive-train warning light was illuminated. Upon research, the contact became aware of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The vehicle was previously taken to the dealer to be diagnosed, and the contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided due to a prior good-faith repair being provided. The failure mileage was approximately 70,000.
NHTSA complaint #11754695 — an unverified report by a vehicle owner.
Electronic power control issue caused the vehicle to loose power steering. After starting and driving the vehicle an alert message showed up saying chassis malfunction and power steering issues. Vehicle was stopped and re-started but the issue didn't go away. BMW confirmed there was a malfunction with the EPS similar to the NHTSA bulletin 11V341000. Vehicle was manufactured during the period the recall covers and experience the same issues. BMW advised to contact NHTSA to have the VIN added to the recall so they can complete the repair, as otherwise it will not be covered.
NHTSA complaint #11754567 — an unverified report by a vehicle owner.
While driving on a two-lane 40 MPH road in the left lane the vehicle suddenly lost power, stopped in traffic, and displayed a transmission warning message. Multiple warning lights were "on" and the car would not restart. Additionally, the vehicle would not come out of "Park." Occupants needed to await police who stopped traffic in order for occupants to be able to exit the vehicle safely. The vehicle was towed to BMW of Atlantic City located at [XXX]. Technician found ground missing at EGS, inspected ground strap on transmission and found it severely corroded. Technician replaced ground strap and vehicle was repaired. Was advised by dealer service department that when this situation occurs, the only way to get the transmission into neutral in an emergency is to disconnect the transmission linkage under the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11751025 — an unverified report by a vehicle owner.
Since purchasing my vehicle, I have experienced numerous ongoing issues that BMW has failed to address. The problems include: A squealing and beeping noise coming from the engine. The headlights turning on by themselves. Interior lights turning on without warning. The vehicle shaking while driving. The check engine light repeatedly coming on. A recent gasoline smell that required me to take the vehicle to the shop due to safety concerns. The roof making a popping noise when driving over uneven driveways or surfaces. I have documented many of these issues with multiple videos. Despite providing evidence and repeatedly reporting these problems, BMW has ignored my concerns and has not adequately resolved the defects.
NHTSA complaint #11750438 — an unverified report by a vehicle owner.
2021 BMW X3 M40i VIN# [XXX] Starter failed with the following BMW codes: [XXX] Starter Malfunction was displayed on the Dash and car took multiple attempts or waiting 10 seconds to start. I had the starter replaced by the Dealer, who confirmed the starter required replacing. I was told it was not part of the recall based upon VIN of car? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11749372 — an unverified report by a vehicle owner.
The contact owns a 2026 BMW X3. The contact stated that while vehicle was stopped at an intersection with the engine running, the message “Auto Start Feature Off” was displayed, and the starter was cycling unexpectedly. There was no warning light illuminated. The dealer was contacted but was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 10.
NHTSA complaint #11747350 — an unverified report by a vehicle owner.
The contact’s wife owns a 2021 BMW X3. The contact stated that while attempting to start the vehicle on several occasions, the vehicle failed to start. The message "Vehicle Failed to Start - Contact Dealer" was displayed. The contact stated that for the vehicle to start, the contact had to turn the power off in the vehicle power, lock and unlock the doors using the key fob, and then, after several attempts, the vehicle eventually started. The contact associated the failure with NHTSA Campaign Number: 26V056000 (Electrical System). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
NHTSA complaint #11747188 — an unverified report by a vehicle owner.
Car suffered a complete electrical failure when stopped at a traffic light. No warnings on dash, wipers made one swipe then vehicle completely shut down. Hazards did not work. Car was towed to dealership
NHTSA complaint #11742602 — an unverified report by a vehicle owner.
The contact owns a 2020 BMW X3. The contact stated that while driving at an undisclosed speed, the drivetrain warning light illuminated on the instrument panel, causing the vehicle to jerk and run rough. The vehicle was taken to the dealer, where it was diagnosed with a heat management module failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 53,404.
NHTSA complaint #11742323 — an unverified report by a vehicle owner.
The contact owns a 2021 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000(ELECTRICAL SYSTEM); however, the part to do the recall repair was unavailable. The local dealer was contacted and it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced the failure.
NHTSA complaint #11741742 — an unverified report by a vehicle owner.
The contact owns a 2020 BMW X3. The contact stated that after parking the vehicle and turning the engine off, approximately 10 minutes later a burning rubber odor was present inside the cablin of the vehicle and smoke was present coming from under the hood. The contact opened the hood discovered flames coming from the engine. The fire and police departments were called to the scene and the fire was extinguished the flame. During the incident the vehicle destroyed and later lowed away. A fire and police report was taken. No injuries were reported. The cause of the fire was not yet determined. The manufacturer was notified of the incident. The local dealer was not contacted. The contact was informed that the VIN was not included in the NHTSA Campaign Number: ( ). The contact indicated that the vehicle had experienced that same failure listed in the recall. The failure mileage was 65,000.
NHTSA complaint #11741213 — an unverified report by a vehicle owner.
Subject: Supplemental Evidence for Existing NHTSA Complaint / ODI #11711973 I am submitting supplemental safety information for my existing NHTSA vehicle safety complaint, ODI #11711973, involving my 2025 BMW X3, VIN [XXX] . Since filing, I had an additional BMW of Sterling visit/repair estimate dated April 22, 2026, mileage 17,628, RO #[XXX]. The dealer documented additional concerns including rough acceleration/jerking during the first drive of the day, intermittent A/C not blowing cold air and randomly blowing warm air, tire/wear concerns, left rear tire tread/screw concern, rear tires worn to 3mm, and alignment recommendation. This information supplements my existing complaint involving repeated unresolved safety/electrical/system concerns, including steering/safety concerns, driver-assistance/cruise-control malfunction, tire-pressure/tire-detection issues, key/door/alarm detection issues, HVAC/defrost malfunction, and unintended movement/self-activation concerns. Please add this information and the attached repair estimate/photos/videos to ODI #11711973. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11739574 — an unverified report by a vehicle owner.
I am submitting this complaint regarding ongoing and potentially dangerous mechanical failures involving my vehicle that have repeatedly occurred despite numerous repair attempts by the dealership. Over the past year, I have taken my vehicle to the dealership more than 10 times for serious recurring issues. The problems have included: Drivetrain malfunction warnings Engine warning lights Oil leaks Smoke coming from the vehicle The vehicle unexpectedly shifting into neutral while driving Sudden loss of drivability requiring the vehicle to be towed The dealership has repeatedly stated that the issues were repaired, and at one point even provided a one-year warranty on the repair work. Despite this, the same problems have continued to occur. Most recently, the drivetrain malfunction warning and engine light returned again, smoke came from the vehicle, and the car shifted into neutral on its own, becoming completely undriveable and requiring towing. I have spent more than $10,000 on repairs related to these ongoing issues, yet the vehicle remains unreliable and unsafe. My primary concern is the safety risk posed by the drivetrain failure and the vehicle unexpectedly shifting into neutral while in operation. I am requesting that this matter be reviewed as a potential vehicle safety issue. I believe these repeated failures may present a serious risk not only to myself but potentially to other drivers as well. Thank you for your attention to this matter.
NHTSA complaint #11738436 — an unverified report by a vehicle owner.
The contact owns a 2023 BMW X3. The contact received notification of NHTSA Campaign Number: 26V056000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
NHTSA complaint #11737666 — an unverified report by a vehicle owner.
The contact owns a 2013 BMW X3. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light and drivetrain warning light illuminated. The vehicle failed to restart and was towed to the dealer. The dealer diagnosed that the positive battery terminal motherboard had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was later towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted again. The manufacturer was made aware of the failure. The approximate failure mileage was 106,000.
NHTSA complaint #11737264 — an unverified report by a vehicle owner.
The contact owns a 2020 BMW X3. The contact stated while driving at an undisclosed speed, the brake pedal was released, the auto start feature failed to function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed engine starter. The contact was informed that the engine starter needed to be replaced. The vehicle was not repaired. The contact referenced a recall, NHTSA Campaign Number: 25V636000 (Electrical System) however the contact's VIN was not associated. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 55,000.
NHTSA complaint #11737334 — an unverified report by a vehicle owner.
I have tried to set up an appointment with my local dealer for a recall notice several times, but they never have the part needed. One time they said they had the part and after dropping the car off my wife returned to find out they still did not have the part The date below is approximate
NHTSA complaint #11736163 — an unverified report by a vehicle owner.