Owners have filed 107 complaints
about the 2022 BMW X3 with NHTSA between 2021 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 16 of 23 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 44
Against the median year of the BMW X3. 50 means typical for this
model; 100 means roughly double.
Severity — 63
12.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 57
33% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Warnings
721.2%
Warning
618.2%
Automatic Emergency Braking
618.2%
Adaptive Cruise Control
412.1%
Assist
39.1%
Blind Spot Detection
39.1%
Body
39.1%
Refrigerant Hoses AND Fittings
13.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
10,000 – 24,999 miles
116.7%
25,000 – 49,999 miles
116.7%
50,000 – 74,999 miles
350.0%
150,000+ miles
116.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2021peak 11Aug 2026
Recalls on the 2022 BMW X3
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
26V438000
ELECTRICAL SYSTEM:STARTER ASSEMBLY
BMW of North America, LLC (BMW) is recalling certain 2023-2024 Toyota Supra, 2022-2025 2 Series Coupe, 2021-2023 5 Series, 2022-2026 Z4, 2023-2024 4 Series Gran Coupe, 4 Series Convertible, 4 Series Coupe, 3 Series, 2021-2025 X4, and 2021-2024 X3 vehicles. Please see the recall report for a complete list of all models. The engine starter may overheat and catch fire due to wear on an internal component.
Risk: Fire increases the risk of injury.
26V056000
ELECTRICAL SYSTEM:STARTER ASSEMBLY
BMW of North America, LLC (BMW) is recalling certain 2021-2023 Toyota Supra, 2022-2023 2 Series Coupe, 2021-2024 5 Series (xDrive), 2021-2022 Z4, 2022-2024 4 Series (Gran Coupe), 2021-2024 4 Series (Convertible and xDrive Convertible), 2021-2023 4 Series (Coupe), 2021-2024 3 Series, 2021-2023 X4, 2021-2024 X3 vehicles. Please see the recall report for a complete list of all models. The engine starter may overheat and catch fire due to wear on an internal component.
Risk: Fire increases the risk of injury.
25V636000
ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
Risk: A short circuit in the starter relay may increase the risk of a fire.
25V106000
LATCHES/LOCKS/LINKAGES:DOORS:LOCK
BMW of North America, LLC (BMW) is recalling certain 2022-2024 X3 sDrive30i and X3 xDrive30i vehicles. The second-row seat side door locking modules may not function properly and allow the doors to be unlocked with a single motion. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Risk: Doors that can be inadvertently unlocked and unlatched may open unexpectedly, increasing the risk of injury to rear seat occupants.
24V764000
STRUCTURE
BMW of North America, LLC (BMW) is recalling certain 2018-2022 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the rear cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Risk: Interior rear cargo rail detachment during a crash can increase the risk of injury.
24V534000
STRUCTURE
BMW of North America, LLC (BMW) is recalling certain 2018-2023 X3 sDrive30i, X3 xDrive30i, X3 M40i, and X3 M vehicles. The attachment for the interior cargo rail may become damaged in a rear crash and result in the cargo rail detaching.
Risk: Interior cargo rail detachment during a rear crash can increase the risk of injury.
BMW of North America, LLC (BMW) is recalling certain 2022 X1 xDrive 28i, X3 xDrive30i, and 228i Gran Coupe vehicles. The high-pressure fuel rail may crack and result in a fuel leak within the engine compartment.
Risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
22V070000
POWER TRAIN:AUTOMATIC TRANSMISSION
BMW of North America, LLC (BMW) is recalling certain 2022 330i, 530i, X3 xDrive30i, and X4 xDrive30i vehicles. The mechatronics unit inside the transmission may not have been assembled properly, which could result in an internal leak.
Risk: An internal transmission leak can result in a vehicle rollaway, increasing the risk of a crash or injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202633126,247 units in Canada
Engine
Issue: On certain vehicles, the engine starter may not have been manufactured properly. As a result, the starter could overheat. Note: This recall is an expansion of Transport Canada recall no. 2026-040. Safety Risk: A starter that overheats can create the risk of a fire. Corrective Actions: To reduce the safety risk, BMW recommends not using the remote start function and not leaving the vehicle unattended with the engine running until the recall repairs have been completed. BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the engine starter.
Recall 20260406,958 units in Canada
Engine
Issue: On certain vehicles, the engine starter may not have been manufactured properly. As a result, the starter could overheat. Safety Risk: A starter that overheats can create the risk of a fire. Corrective Actions: To reduce the safety risk, BMW recommends not using the remote start function and not leaving the vehicle unattended with the engine running until the recall repairs have been completed. BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the engine starter.
Recall 2024609557 units in Canada
Structure
Issue: On certain vehicles, the recall repairs completed by a BMW dealer during recall 51 84 24RC (Transport Canada recall no. 2024-410) may not be effective. As a result, a second repair is required. On certain vehicles, the cargo area tie down rails could detach in a rear crash. Safety Risk: A cargo rail that detaches in a crash could create a risk of injury to rear passengers. Corrective Actions: BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the fasteners that secure the cargo rails to the body.
Recall 2024544587,250 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 202441013,830 units in Canada
Structure
Issue: On certain vehicles, the cargo area tie down rails could detach in a rear crash. Safety Risk: A cargo rail that detaches in a crash could create a risk of injury to rear passengers. Corrective Actions: BMW will notify owners by mail and advise you to take your vehicle to a dealership to replace the fasteners that secure the cargo rails to the body.
Reports where the owner recorded a crash, a fire, an injury or a death.
Burbank, CACrash3 injured
SERVICE BRAKES
on [XXX] I was going into a Parking Garage in Beverly Hills, CA. I got a little too far from the ticket machine so I put the BMWX3 in PARK and PUT the Emergency Brake on so I could open my door, step out and grab the ticket. The car immediately rolled backwards into a Dodge Charger behind me. That woman is suing for $150,000. It caused my insurance to double, I had to have PT on my pelvis. I had to pay the deductible to get the car repaired. BMW will not take responsibility for the malfunction. My Dad was a professional driver for FORD and I have never caused an accident in my [XXX] years of driving. The woman claims that she and her children were injured but no air bags deployed. the car rolled. It did give me quite a jolt. Her car showed no visible damage but mine was damaged - tail pipe and bumper. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11721588 — an unverified report by a vehicle owner.
Avenel, NJFire
UNKNOWN OR OTHER
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Avenel, NJFire
ENGINE
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Avenel, NJFire
FUEL/PROPULSION SYSTEM
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Laurel, MS1 injured
AIR BAGS
Airbags deployed with no impact
NHTSA complaint #11717099 — an unverified report by a vehicle owner.
Laurel, MDFire
ENGINE
While driving, noticed smoke coming from under the hood. Immediately pulled in a parking lot where the smoke turned to fire and burned the entire car by the time fire dept arrived. I was the only person in the car and was luckily able to exit the vehicle before the actual fire started. Incident reported to insurance company and they are investigating. There were no dash warning lights of any kind.
NHTSA complaint #11688575 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Millersville, MD
FORWARD COLLISION AVOIDANCE: WARNINGS
2022 BMW X3 M40i. The Driver Assistance system appears to activate normally after startup with no warning or indication that a fault is present. However, within approximately 3–5 minutes of driving, a Check Control message appears stating “Driver Assistance limited. Camera vision.” The vehicle then identifies affected systems including Pedestrian Warning, Frontal Collision Warning, Side Collision Warning, Automatic Lane Change, Active Blind Spot Detection, and Steering Assistant. A separate message states that Active Cruise Control is reduced and there may be no brake intervention for stationary vehicles. The safety concern is that the system can appear active and available before the warning appears, even though at least some driver-assistance functions may already not be operating. Before the warning was displayed, I observed that Steering Assistant/lane-keeping did not intervene and I crossed out of my lane without steering correction or a lane-departure warning. There was no prior warning that the camera-based system was malfunctioning. I cannot confirm whether the other affected safety functions were operational during this interval. A BMW dealer inspected the vehicle and physically found the KAFAS camera hood/trim warped from heat. The warped component was removed and shown to me, and the dealer ordered a replacement. BMW has issued SIB 66 13 23 addressing KAFAS camera hood deformation on affected vehicles. Fault memory also contained KAFAS codes 800ABF, 800ABE, and 800AC4 for camera field-of-view disturbance and calibration failure. This creates a potential safety defect because the driver may reasonably believe lane-keeping and other camera-based safety systems are functioning until the vehicle detects the failure several minutes later. The vehicle/component can be made available for inspection
NHTSA complaint #11758544 — an unverified report by a vehicle owner.
Millersville, MD
LANE DEPARTURE: ASSIST
2022 BMW X3 M40i. The Driver Assistance system appears to activate normally after startup with no warning or indication that a fault is present. However, within approximately 3–5 minutes of driving, a Check Control message appears stating “Driver Assistance limited. Camera vision.” The vehicle then identifies affected systems including Pedestrian Warning, Frontal Collision Warning, Side Collision Warning, Automatic Lane Change, Active Blind Spot Detection, and Steering Assistant. A separate message states that Active Cruise Control is reduced and there may be no brake intervention for stationary vehicles. The safety concern is that the system can appear active and available before the warning appears, even though at least some driver-assistance functions may already not be operating. Before the warning was displayed, I observed that Steering Assistant/lane-keeping did not intervene and I crossed out of my lane without steering correction or a lane-departure warning. There was no prior warning that the camera-based system was malfunctioning. I cannot confirm whether the other affected safety functions were operational during this interval. A BMW dealer inspected the vehicle and physically found the KAFAS camera hood/trim warped from heat. The warped component was removed and shown to me, and the dealer ordered a replacement. BMW has issued SIB 66 13 23 addressing KAFAS camera hood deformation on affected vehicles. Fault memory also contained KAFAS codes 800ABF, 800ABE, and 800AC4 for camera field-of-view disturbance and calibration failure. This creates a potential safety defect because the driver may reasonably believe lane-keeping and other camera-based safety systems are functioning until the vehicle detects the failure several minutes later. The vehicle/component can be made available for inspection
NHTSA complaint #11758544 — an unverified report by a vehicle owner.
Millersville, MD
LANE DEPARTURE: WARNING
2022 BMW X3 M40i. The Driver Assistance system appears to activate normally after startup with no warning or indication that a fault is present. However, within approximately 3–5 minutes of driving, a Check Control message appears stating “Driver Assistance limited. Camera vision.” The vehicle then identifies affected systems including Pedestrian Warning, Frontal Collision Warning, Side Collision Warning, Automatic Lane Change, Active Blind Spot Detection, and Steering Assistant. A separate message states that Active Cruise Control is reduced and there may be no brake intervention for stationary vehicles. The safety concern is that the system can appear active and available before the warning appears, even though at least some driver-assistance functions may already not be operating. Before the warning was displayed, I observed that Steering Assistant/lane-keeping did not intervene and I crossed out of my lane without steering correction or a lane-departure warning. There was no prior warning that the camera-based system was malfunctioning. I cannot confirm whether the other affected safety functions were operational during this interval. A BMW dealer inspected the vehicle and physically found the KAFAS camera hood/trim warped from heat. The warped component was removed and shown to me, and the dealer ordered a replacement. BMW has issued SIB 66 13 23 addressing KAFAS camera hood deformation on affected vehicles. Fault memory also contained KAFAS codes 800ABF, 800ABE, and 800AC4 for camera field-of-view disturbance and calibration failure. This creates a potential safety defect because the driver may reasonably believe lane-keeping and other camera-based safety systems are functioning until the vehicle detects the failure several minutes later. The vehicle/component can be made available for inspection
NHTSA complaint #11758544 — an unverified report by a vehicle owner.
Jacksonville, FL
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REFRIGERANT HOSES AND FITTINGS
- Customer Reports: ac not cooling, stopped cooling yesterday while on the highway, approved evac and recharge if needed Caused by Leaking a/c hose from compressor to condenser Tech: CHRISTOPHER ARCHER (F88) Installed 64 53 9 868 421 : B1-Pressure hose assy c Installed 64 53 9 284 018 : B1BIMIRRZN-Gasket ring Confirmed concern. Performed vehicle
NHTSA complaint #11750496 — an unverified report by a vehicle owner.
Hartland, WI
POWER TRAIN
belt tensioner failed while on highway without warning, leading to complete shutdown of the engine. Car had to be towed for repair. Complete disintegration of the timing belt, the car only had 51,000 miles. Expensive repair
NHTSA complaint #11749484 — an unverified report by a vehicle owner.
at 52,000 milesJacksonville, FL
EQUIPMENT:APPLIANCE:AIR CONDITIONER
The contact owns a 2022 BMW X3. The contact stated that while driving at an undisclosed speed in hot weather, the air conditioner failed to operate as intended. The vehicle was taken to the dealer, where it was determined that the air conditioner line was rubbing against a pulley, presenting a fire hazard. The contact was informed that the air conditioner hose needed to be replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 52,000.
NHTSA complaint #11749263 — an unverified report by a vehicle owner.
Little Rock, AR
STRUCTURE:BODY
On June 23, 2026 around 3:30pm, we were driving 70 mph on an interstate (I40) and the panoramic sunroof spontaneously shattered on our BMW X3. We were not struck by anything and there was no inclement weather or extreme heat. The sunshade was pulled so we were not hit by the glass, but we were very much in danger. My baby was in the backseat and he would have had glass all over him. We had to pull over on the highway and had to arrange for another car to take us home.
NHTSA complaint #11746577 — an unverified report by a vehicle owner.
old Bridge, NJ
ENGINE
car starts emitting white smoke with plastic burning smell inside car and outside. no notifications on dash board before this happens therefore emitting this white smoke into car which we are subjected to inhaling further
NHTSA complaint #11741989 — an unverified report by a vehicle owner.
El Paso, TX
UNKNOWN OR OTHER
regarding my 2022 BMW X3 due to ongoing issues involving low coolant warnings, coolant leaking, and repeated cooling system problems shortly after reaching approximately 55,000 miles. My vehicle began displaying “low coolant” warnings and has required frequent coolant refills despite normal driving conditions and regular maintenance.the vehicle appears to have an active coolant leak and ongoing cooling system malfunction that has not been permanently resolved.
NHTSA complaint #11739686 — an unverified report by a vehicle owner.
El Paso, TX
UNKNOWN OR OTHER
The oil filter housing failed and needed to be replaced due to be leaking coolant.. after changed that the failure of the water pump started to failed and engine started to spike high temperatures..
NHTSA complaint #11739418 — an unverified report by a vehicle owner.
El Paso, TX
ENGINE
The oil filter housing failed and needed to be replaced due to be leaking coolant.. after changed that the failure of the water pump started to failed and engine started to spike high temperatures..
NHTSA complaint #11739418 — an unverified report by a vehicle owner.
Lynnwood, WA
ENGINE
Oil Filter Housing leak confirmed on my 2022 BMW X3 M40i. My current odomoter reading is at 47K miles and I was told that I could have a catastrophic failure of my engine if not repaired. I am several weeks out of my warranty expiration date and am frustrated that BMW won't honor a warranty claim for an issue known to take a long time to find symptons before being able to fix.
NHTSA complaint #11737643 — an unverified report by a vehicle owner.
Little Rock, AR
UNKNOWN OR OTHER
While driving, my sunroof spontaneously exploded/shattered and rained glass onto me while driving.
NHTSA complaint #11734760 — an unverified report by a vehicle owner.
at 34,000 milesBakersfield, CA
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
The contact owns a 2022 BMW X3. The contact stated that while driving and stopping at a red light or stop sign, the vehicle accelerated from 20 MPH to 40 MPH. There was no warning light illuminated. The vehicle was taken to the dealer; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 34,000. The VIN was not available.
NHTSA complaint #11725049 — an unverified report by a vehicle owner.
Burbank, CACrash3 injured
SERVICE BRAKES
on [XXX] I was going into a Parking Garage in Beverly Hills, CA. I got a little too far from the ticket machine so I put the BMWX3 in PARK and PUT the Emergency Brake on so I could open my door, step out and grab the ticket. The car immediately rolled backwards into a Dodge Charger behind me. That woman is suing for $150,000. It caused my insurance to double, I had to have PT on my pelvis. I had to pay the deductible to get the car repaired. BMW will not take responsibility for the malfunction. My Dad was a professional driver for FORD and I have never caused an accident in my [XXX] years of driving. The woman claims that she and her children were injured but no air bags deployed. the car rolled. It did give me quite a jolt. Her car showed no visible damage but mine was damaged - tail pipe and bumper. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11721588 — an unverified report by a vehicle owner.
Avenel, NJFire
UNKNOWN OR OTHER
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Avenel, NJFire
ENGINE
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Avenel, NJFire
FUEL/PROPULSION SYSTEM
1. The primary failure occurred within the electrical system and engine compartment wiring. According to the official forensic report (Ref No: XXX by the Ministry of Internal Affairs of Georgia, the fire originated in the engine compartment due to an electrotechnical fault (short circuit). 2. The vehicle spontaneously exploded and caught fire while parked in a closed, underground parking facility of a commercial building. This created an immediate risk of: Mass casualties due to smoke inhalation and potential structural collapse of the parking ceiling. Fire spreading to dozens of adjacent vehicles.The explosion occurred without any prior warning, posing a lethal threat to anyone nearby. 3. The failure was officially confirmed and documented through a State Forensic Examination. The Ministry of Internal Affairs’ Forensic-Criminalistic Department conducted a comprehensive technical audit. They ruled out any external factors (arson/accelerants) and confirmed an internal electrical short circuit as the sole cause. 4. Yes. The vehicle was inspected and seized as evidence by the Criminal Police and the State Forensic-Criminalistic Department of Georgia. 5. There were no warning lights or messages displayed on the dashboard prior to parking the vehicle. The incident was a spontaneous combustion that occurred while the vehicle was stationary and unoccupied. please note that uploaded police documents are in Georgian language and I will be able to send over official translations upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11718288 — an unverified report by a vehicle owner.
Laurel, MS1 injured
AIR BAGS
Airbags deployed with no impact
NHTSA complaint #11717099 — an unverified report by a vehicle owner.
Laurel, MS
AIR BAGS
Driving and side curtain airbags deployed without accident or impact
NHTSA complaint #11709808 — an unverified report by a vehicle owner.
Mccomb, MS
UNKNOWN OR OTHER
On 12/17/25, I was driving on I-10 in New Orleans, there were no cars around that could have kicked up a rock to cause the sunroof to explode. When the sunroof exploded, I immediately pulled over and that is when I first noticed the strong smell of residue and then I heard the glass shattering. The cover to the sunroof was closed because if not, glass would have been all over me causing a major accident on major 4 lane interstate. The heat was not on to cause any type of pressure to make it explode. When I pulled over, I called 911 and Louisiana State Police answered the call. When the officer arrived he looked at the situation and he could not see a rock, bullet, or anything that would have caused it. Since he could not find anything that caused the issue, he was not able to do an incident report but told me to take it straight to the dealership. The vehicle has been to two different BMW dealerships where I have been told warranty does not cover this issue even though there are multiple reports about this being a normal occurrence with BMW after a 7 year investigation. There were no warnings before this incident. I could have killed myself along with others if I would have lost control of the car due to the car shaking with the sunroof exploded. The vehicle is able to inspected upon request if needed while it sits at the dealership. This vehicle was also bought on 10/27/25.
NHTSA complaint #11705820 — an unverified report by a vehicle owner.
Atlanta, GA
POWER TRAIN
Transfer case fluid has been replaced as well as drivetrain fluid in the front and rear and and the car is still having slight issues shuttering when stopping.
NHTSA complaint #11705644 — an unverified report by a vehicle owner.
Cupertino, CA
LATCHES/LOCKS/LINKAGES:DOORS:LOCK
The driver side rear door locking mechanism keeps locking, even when the car is unlocked with the key fob. This is a safety concern, as our granddaughter rides in the rear seat regularly and if an emergency arises where I need to get her out of the back seat quickly, the rear door can stay locked and not allow me to get her out. There were no warning notices for this issue on the dashboard system.
NHTSA complaint #11700158 — an unverified report by a vehicle owner.
Dandridge, TN
UNKNOWN OR OTHER
windshield glass excessively weak and prone to crack and chip. yes, a weak (defective windshield) has great safety concerns. yes, Safelight glass repair has repaired this windshield several times in 2 months. yes, we have recently brought this vehicle to a BMW service center. no warning light for this issue. There are several websites that confirm there is a significant problem with the windshield on this specific make. model and year.
NHTSA complaint #11699331 — an unverified report by a vehicle owner.
Pensacola, FL
ELECTRICAL SYSTEM
Starter
NHTSA complaint #11690152 — an unverified report by a vehicle owner.