Owners have filed 202 complaints
about the 2004 Chevrolet Avalanche with NHTSA between 2004 and 2021.
The largest single group is the electrical system.
Across this model's run it ranks 6 of 12 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 49
Against the median year of the Chevrolet Avalanche. 50 means typical for this
model; 100 means roughly double.
Severity — 36
6.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 48
28% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2004 compares with every other Chevrolet Avalanche
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
116.4%
1,000 – 9,999 miles
169.2%
10,000 – 24,999 miles
116.4%
25,000 – 49,999 miles
4224.3%
50,000 – 74,999 miles
3620.8%
75,000 – 99,999 miles
2413.9%
100,000 – 149,999 miles
2514.5%
150,000+ miles
84.6%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2004peak 6Nov 2021
NHTSA investigations into the 2004 Chevrolet Avalanche
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA04012Opened 30 Apr 2004Closed 28 Feb 2005SERVICE BRAKES, HYDRAULIC:POWER ASSIST
HYDRAULIC PUMP FAILRES
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Recalls on the 2004 Chevrolet Avalanche
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06V289000
ENGINE AND ENGINE COOLING
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
06E043000
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
05V163000
SEAT BELTS:REAR/OTHER
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
05V043000
SERVICE BRAKES, HYDRAULIC
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
04V129000
STRUCTURE:BODY:TAILGATE:HINGE AND ATTACHMENTS
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE GALVANIZED STEEL TAILGATE SUPPORT CABLES THAT RETAIN THE TAILGATE IN THE FULL OPEN (HORIZONTAL) POSITION MAY CORRODE, WEAKEN, AND EVENTUALLY FRACTURE. IF BOTH CABLES FRACTURED, THE TAILGATE WOULD SUDDENLY DROP AND STRIKE THE TOP SURFACE OF THE REAR BUMPER.
Risk: ANYONE SITTING OR STANDING ON THE HORIZONTAL SURFACE OF THE TAILGATE WHEN BOTH CABLES FRACTURED COULD BE INJURED BY FALLING FROM THE TAILGATE. ON VEHICLES THAT HAVE HAD THE BUMPER REMOVED, THE TAILGATE MAY DROP EVEN LOWER. ADDITIONALLY, IF THERE IS CARGO ON THE TAILGATE THE CARGO MAY FALL OFF IF THE SUPPORT CABLES FRACTURE.
04V045000
SERVICE BRAKES, HYDRAULIC
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Risk: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2011074190,310 units in Canada
Heater And Defroster
On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury. Correction: Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.
Recall 20061951,485 units in Canada
Fuel System
On certain vehicles, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result. Fuel leakage in the presence of an ignition source could result in a fire. Correction: Dealers will replace the engine fuel rail pulse damper retainer clip.
Recall 200511973,473 units in Canada
Seats And Restraints
On certain vehicles, the 2nd row centre occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants. A lap portion of the seat belt routing that is not low and snug on the hips can allow unfavourable occupant kinetics in the event of a crash. Moreover, the higher routing allows the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Correction: Dealers will modify the guide loop.
Recall 20050335,014 units in Canada
Brakes
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause injury to people in the immediate area. In addition, the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort. Correction: Dealers will test and, if necessary, replace the Hydro-Boost assembly.
Recall 2004102301,974 units in Canada
Other
On certain vehicles, the galvanized-braided-steel tailgate support cables used to support the tailgate in the full open (horizontal) position can corrode over time and fracture when loads are applied to them. Tailgate support cable corrosion may not be visible because of the plastic sheathing covering the cable. If one cable fractured, the remaining cable may retain the tailgate in a horizontal position. If the remaining cable was weakened by corrosion, it could fracture within moments of the first cable fracture. If both cables fractured, the tailgate would suddenly drop approximately 10 degrees and strike the top surface of the rear bumper. If anyone is sitting or standing on the horizontal surface of the tailgate when both cables fracture, they could fall and be injured. On vehicles without a rear bumper, the tailgate may drop to a lower position. Correction: Dealers will replace the existing galvanized support cables with stainless steel support cables.
Recall 20040374,075 units in Canada
Brakes
On certain vehicles, the relief valve o-ring seal within the brake hydro-boost module could fail. If this happens during braking applications, the driver may be able to hear an engine compartment noise similar to the sound that occurs when the steering wheel is turned to a full stop position. The driver could also experience a slight increase in steering efforts while braking and parking. Under certain driving conditions, a slight increase in the applied brake pedal effort may be required to achieve the same vehicle deceleration rate as prior to the seal failure. Correction: Dealers will inspect the hydro-boost module, and replace it, if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 91,000 milesWest Frankfort, ILCrash
STRUCTURE:BODY
MY HUSBAND, 3 YEAR OLD, ANY MYSELF WERE DRIVING BACK FROM A DOCTOR APPOINTMENT WHEN WE HAD TO MAKE A SUDDEN STOP BECAUSE OF A DRIVER 2 CARS AHEAD OF US THAT QUICKLY APPLIED BRAKES TO MAKE A QUICK RIGHT HAND TURN. THE DRIVER IN FRONT OF US IN TURN HAD TO APPLY HIS BREAKS ON AND WHEN MY HUSBAND APPLIED THE BRAKES ON OUR 2004 CHEVROLET AVALANCHE THERE WERE NO BRAKES!! OUR 3 YEAR OLD WAS ASLEEP IN THE BACKSEAT!! WE HIT HIM OF COURSE BECAUSE WE COULD NOT STOP (GOING DOWNHILL ON A BUSY HIGHWAY) WE ENDED UP HAVING TO COAST UP THE HILL IN THE MIDDLE OF THE LANE BECAUSE THERE WAS NOWHERE SAFE FOR US TO PULL OFF . THERE WERE ALMOST SEVERAL OTHER ACCIDENTS DUE TO IT BEING A BLIND SPOT FOR DRIVERS COMING OVER THE HILL BOTH WAYS AND WE WERE STUCK THERE BECAUSE WE HAD NO WAY TO STOP OURSELVES AGAIN. SO AFTER ALL THAT WE ENDED UP NEEDING OUR TRUCK TOWED AND THE BRAKE LINES ARE CORRODED AND HAD BUSTED!! SO NOT ONLY DO WE HAVE A TOW BILL NOW WE ARE RESPONSBILE FOR REPLACING THEM! THE ESTIMATE IS $800!!! THANKS GM! WE WILL BE SELLING THIS ONE SOON! GM WON'T DO A RECALL ON THESE AFTER ALL THE COMPLAINTS AND ACCIDENTS ABOUT THE BRAKE LINES ON HERE? SERIOUSLY? WE HAD NO CLUE ABOUT ANY OF THIS UNTIL TODAY! THE MECHANIC THAT IS FIXING OURS TODAY TOLD US HE HAS 2 MORE THAT HAVE THE EXACT SAME ISSUE AND HAVE TO BE REPLACED ON THEIRS TOO! I GUESS IT TAKES PEOPLE DYING OR GETTING SERIOUSLY INJURED BEFORE THE CAR MANUFACTURES HAVE TO TAKE RESPONSIBILITY. AND WHAT MAKES IT EVEN WORSE IS THAT THE WHOLE BRAKE LINE REPLACEMENT IS AVAILABLE (FOR US TO PURCHASE) AND IT'S ONLY ABOUT $160!! NICE TO KNOW THE SAFETY OF OUR FAMILY, FRIENDS, AND OTHER MOTORISTS AREN'T WORTH IT TO THEM. JUST 2 MILES EARLIER WE DROVE THOUGH A SCHOOL ZONE!!!!! AS THE KIDS WERE LEAVING FOR THE DAY! THANK GOD THEY LASTED THAT 2 EXTRA MILES AND NO ONE WAS SERIOUSLY INJURED OR KILLED.
NHTSA complaint #10716593 — an unverified report by a vehicle owner.
at 91,000 milesWest Frankfort, ILCrash
SERVICE BRAKES
MY HUSBAND, 3 YEAR OLD, ANY MYSELF WERE DRIVING BACK FROM A DOCTOR APPOINTMENT WHEN WE HAD TO MAKE A SUDDEN STOP BECAUSE OF A DRIVER 2 CARS AHEAD OF US THAT QUICKLY APPLIED BRAKES TO MAKE A QUICK RIGHT HAND TURN. THE DRIVER IN FRONT OF US IN TURN HAD TO APPLY HIS BREAKS ON AND WHEN MY HUSBAND APPLIED THE BRAKES ON OUR 2004 CHEVROLET AVALANCHE THERE WERE NO BRAKES!! OUR 3 YEAR OLD WAS ASLEEP IN THE BACKSEAT!! WE HIT HIM OF COURSE BECAUSE WE COULD NOT STOP (GOING DOWNHILL ON A BUSY HIGHWAY) WE ENDED UP HAVING TO COAST UP THE HILL IN THE MIDDLE OF THE LANE BECAUSE THERE WAS NOWHERE SAFE FOR US TO PULL OFF . THERE WERE ALMOST SEVERAL OTHER ACCIDENTS DUE TO IT BEING A BLIND SPOT FOR DRIVERS COMING OVER THE HILL BOTH WAYS AND WE WERE STUCK THERE BECAUSE WE HAD NO WAY TO STOP OURSELVES AGAIN. SO AFTER ALL THAT WE ENDED UP NEEDING OUR TRUCK TOWED AND THE BRAKE LINES ARE CORRODED AND HAD BUSTED!! SO NOT ONLY DO WE HAVE A TOW BILL NOW WE ARE RESPONSBILE FOR REPLACING THEM! THE ESTIMATE IS $800!!! THANKS GM! WE WILL BE SELLING THIS ONE SOON! GM WON'T DO A RECALL ON THESE AFTER ALL THE COMPLAINTS AND ACCIDENTS ABOUT THE BRAKE LINES ON HERE? SERIOUSLY? WE HAD NO CLUE ABOUT ANY OF THIS UNTIL TODAY! THE MECHANIC THAT IS FIXING OURS TODAY TOLD US HE HAS 2 MORE THAT HAVE THE EXACT SAME ISSUE AND HAVE TO BE REPLACED ON THEIRS TOO! I GUESS IT TAKES PEOPLE DYING OR GETTING SERIOUSLY INJURED BEFORE THE CAR MANUFACTURES HAVE TO TAKE RESPONSIBILITY. AND WHAT MAKES IT EVEN WORSE IS THAT THE WHOLE BRAKE LINE REPLACEMENT IS AVAILABLE (FOR US TO PURCHASE) AND IT'S ONLY ABOUT $160!! NICE TO KNOW THE SAFETY OF OUR FAMILY, FRIENDS, AND OTHER MOTORISTS AREN'T WORTH IT TO THEM. JUST 2 MILES EARLIER WE DROVE THOUGH A SCHOOL ZONE!!!!! AS THE KIDS WERE LEAVING FOR THE DAY! THANK GOD THEY LASTED THAT 2 EXTRA MILES AND NO ONE WAS SERIOUSLY INJURED OR KILLED.
NHTSA complaint #10716593 — an unverified report by a vehicle owner.
Sacramento, CACrash2 injured
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, AN ELK JUMPED IN FRONT OF THE VEHICLE AND THE CONTACT ATTEMPTED TO AVOID A CRASH. AS A RESULT, THE CONTACT CRASHED INTO A DIRT MOUNTAIN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT AND THE FRONT PASSENGER SUSTAINED HEAD TRAUMA AND UPPER BODY INJURIES. THE CONTACT AND THE FRONT PASSENGER REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10654851 — an unverified report by a vehicle owner.
at 199,000 milesPowhatan, VACrash
SERVICE BRAKES
DRIVING IN HEAVY TRAFFIC ON I 95 SOUTH ON THE WAY TO VACATION, BRAKES FAILED WHEN I ATTEMPTED TO SLOW DOWN. I REAR ENDED ANOTHER VEHICLE. HAD TRUCK IN SHOP FOR WEEK AND FOUND SEVERAL PROBLEMS WITH LINES AND 2 LEAKS. I HEARD THAT THERE IS A KNOWN METAL DEFECT WITH 2001-2004 BRAKE LINES. I CAN'T FIND ANY RECALL INFORMATION.
NHTSA complaint #10628325 — an unverified report by a vehicle owner.
at 30,000 milesOxford, MIFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE STEERING WHEEL BECAME HOT. THE COMPONENTS ON THE STEERING WHEEL ILLUMINATED AND UPON FURTHER INVESTIGATION THE CONTACT NOTICED THAT THE WIRES HAD MELTED. THE CONTACT ALSO NOTICED THAT THE RADIO BECAME VERY HOT AND MELTED THE CD INSIDE OF THE SYSTEM. THE CONTACT ALSO STATED THAT THE INSTRUMENT CLUSTER FAILED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD PAY FOR A NEW INSTRUMENT CLUSTER, BUT NOT THE INSTALLATION. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 146,000.
NHTSA complaint #10460905 — an unverified report by a vehicle owner.
ST. Paul, MNCrash2 injured
AIR BAGS
REAR ENDED A SUV AT 40 MPH WITHOUT BREAKING AND THE AIR BAGSA DID NOT DEPLOY.
NHTSA complaint #10427782 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 178,000 milesBroomfield, CO
SERVICE BRAKES, HYDRAULIC
The contact owns a 2004 Chevrolet Avalanche. The contact stated that upon starting the vehicle, the brake warning light illuminated. The vehicle was taken to an independent mechanic who diagnosed that the rear brakes needed to be replaced. The contact stated that the vehicle was repaired however, the failure reoccurred while driving. The vehicle was taken to another independent mechanic who replaced the parking brakes and the brake fluid; however, the failure persisted. The contact stated that the brake pedal would hesitate to respond when depressed, causing a 100-feet in stopping distance delay. The dealer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 04V045000 (Service Brakes, Hydraulic) since the VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 178,000.
NHTSA complaint #11441492 — an unverified report by a vehicle owner.
at 92,207 milesBaton Rouge, LA
WHEELS
4"TAKATA RECALL" THE CONTACT OWNS A 2004 CHEVY AVALANCHE WITH A SET OF CAPITOL PRECISION TRAC LL TIRES ON IT. WHILE PULLING OFF IN THE VEHICLE AND DRIVING AROUND 35 MPH YOU COULD FEEL THE BACK END SHAKING AND WOBBLING LIKE THE LUG NUTS WERE LOOSE. THE VEHICLE WAS PULLED OFF THE ROAD TO INVESTIGATE THE SHAKING ISSUE WHERE WAS FOUND THAT THE TIRES TREAD WAS SEPARATING MAKING HUMPS AND WAVES IN THE TREAD. THIS HAPPENED ON THE HIGHWAY AT 92,207 MILES ON VEHICLE AND 7, 319 MILES ON 265/70R17 CAPITOL PRECISION TRAC LL TIRES. THE VEHICLE WAS PARKED FOR A FEW DAYS UNTIL GETTING TIRES TO REPLACE THE CAPITOL TIRES BUT ONCE THE VEHICLE STARTED MOVING TO TAKE IT TO THE SHOP TO REPLACE THE TIRES THE FRONT HAD STARTED TO SHAKE JUST LIKE THE BACK AT 92,221 MILES ON THE VEHICLE BUT NOT AS MUCH. WALMART CHANGED THE TIRES AND THE TECHNICIAN REPORTED THE TIRES WERE REALLY BAD WITH TREAD SEPARATING FROM THE TIRE AND ALSO THAT THIS BRAND TIRE WERE RECALLED. I HAVE TAKEN THESE TIRES BACK TO TIRE PROS WHERE IT WAS PURCHASED AND NOW IS AWAITING THEM TO SEND THESE TIRES BACK TO THE TIRE COMPANY FOR AN INVESTIGATION OF THE TIRE. THE RECALL # IS 14T013-8570 IF I'M NOT MISTAKEN.
NHTSA complaint #10854512 — an unverified report by a vehicle owner.
at 92,207 milesBaton Rouge, LA
STEERING
4"TAKATA RECALL" THE CONTACT OWNS A 2004 CHEVY AVALANCHE WITH A SET OF CAPITOL PRECISION TRAC LL TIRES ON IT. WHILE PULLING OFF IN THE VEHICLE AND DRIVING AROUND 35 MPH YOU COULD FEEL THE BACK END SHAKING AND WOBBLING LIKE THE LUG NUTS WERE LOOSE. THE VEHICLE WAS PULLED OFF THE ROAD TO INVESTIGATE THE SHAKING ISSUE WHERE WAS FOUND THAT THE TIRES TREAD WAS SEPARATING MAKING HUMPS AND WAVES IN THE TREAD. THIS HAPPENED ON THE HIGHWAY AT 92,207 MILES ON VEHICLE AND 7, 319 MILES ON 265/70R17 CAPITOL PRECISION TRAC LL TIRES. THE VEHICLE WAS PARKED FOR A FEW DAYS UNTIL GETTING TIRES TO REPLACE THE CAPITOL TIRES BUT ONCE THE VEHICLE STARTED MOVING TO TAKE IT TO THE SHOP TO REPLACE THE TIRES THE FRONT HAD STARTED TO SHAKE JUST LIKE THE BACK AT 92,221 MILES ON THE VEHICLE BUT NOT AS MUCH. WALMART CHANGED THE TIRES AND THE TECHNICIAN REPORTED THE TIRES WERE REALLY BAD WITH TREAD SEPARATING FROM THE TIRE AND ALSO THAT THIS BRAND TIRE WERE RECALLED. I HAVE TAKEN THESE TIRES BACK TO TIRE PROS WHERE IT WAS PURCHASED AND NOW IS AWAITING THEM TO SEND THESE TIRES BACK TO THE TIRE COMPANY FOR AN INVESTIGATION OF THE TIRE. THE RECALL # IS 14T013-8570 IF I'M NOT MISTAKEN.
NHTSA complaint #10854512 — an unverified report by a vehicle owner.
at 92,207 milesBaton Rouge, LA
UNKNOWN OR OTHER
4"TAKATA RECALL" THE CONTACT OWNS A 2004 CHEVY AVALANCHE WITH A SET OF CAPITOL PRECISION TRAC LL TIRES ON IT. WHILE PULLING OFF IN THE VEHICLE AND DRIVING AROUND 35 MPH YOU COULD FEEL THE BACK END SHAKING AND WOBBLING LIKE THE LUG NUTS WERE LOOSE. THE VEHICLE WAS PULLED OFF THE ROAD TO INVESTIGATE THE SHAKING ISSUE WHERE WAS FOUND THAT THE TIRES TREAD WAS SEPARATING MAKING HUMPS AND WAVES IN THE TREAD. THIS HAPPENED ON THE HIGHWAY AT 92,207 MILES ON VEHICLE AND 7, 319 MILES ON 265/70R17 CAPITOL PRECISION TRAC LL TIRES. THE VEHICLE WAS PARKED FOR A FEW DAYS UNTIL GETTING TIRES TO REPLACE THE CAPITOL TIRES BUT ONCE THE VEHICLE STARTED MOVING TO TAKE IT TO THE SHOP TO REPLACE THE TIRES THE FRONT HAD STARTED TO SHAKE JUST LIKE THE BACK AT 92,221 MILES ON THE VEHICLE BUT NOT AS MUCH. WALMART CHANGED THE TIRES AND THE TECHNICIAN REPORTED THE TIRES WERE REALLY BAD WITH TREAD SEPARATING FROM THE TIRE AND ALSO THAT THIS BRAND TIRE WERE RECALLED. I HAVE TAKEN THESE TIRES BACK TO TIRE PROS WHERE IT WAS PURCHASED AND NOW IS AWAITING THEM TO SEND THESE TIRES BACK TO THE TIRE COMPANY FOR AN INVESTIGATION OF THE TIRE. THE RECALL # IS 14T013-8570 IF I'M NOT MISTAKEN.
NHTSA complaint #10854512 — an unverified report by a vehicle owner.
at 130,000 milesPacific Palisades, CA
UNKNOWN OR OTHER
MY VEHICLE HAS A KELSEY HAYES ABS MODULE THAT HAS ALREADY FAILED TWICE. FIRST AT ABOUT 75.000 MILES AND NOW AT 130.000 MILES, ALWAYS WHILE DRIVING. THE MODULE WAS RECALLED IN 2002 AND THE MANUFACTURER WAS GIVEN A CHANCE TO REDESIGN IT, BUT IT IS STILL A BAD PART. THE BLOGS ARE FULL OF OWNERS CONSTANTLY COMPLAINING ABOUT THIS. I HAD TO TAKE GM TO THE MAT TO REPLACE THE FIRST ONE SINCE THE TRUCK WAS MANUFACTURED AFTER THE FIRST RECALL. THIS TIME AROUND I DIDN'T HAVE THE TIME OR PATIENCE TO DO SO AN WENT AHEAD AN REPLACED IT OUT OF MY OWN POCKET. IA M ALSO STUCK WITH THIS PART AS IT IS NOT REPLACEABLE WITH ANY OTHER BRAND. THIS IS A DANGEROUS GLITCH THAT NEEDS TO BE ADDRESSED BEFORE SOMEONE GETS BADLY HURT. IN ADDITION TO THIS PROBLEM, THE LOCATION OF THE UNIT (OUTSIDE THE VEHICLE AND EXPOSED TO ALL SORT OF INCLEMENT ENVIRONMENTS) IS RIDICULOUS! NO CLEVER DESIGNER WOULD HAVE CHOSEN THIS PLACEMENT.
NHTSA complaint #10838992 — an unverified report by a vehicle owner.
at 145,000 milesCedar Rapids, IA
FUEL/PROPULSION SYSTEM
MODULE KIT,F/TNK F/PMP,LVL S/FUEL PUMP MODULE ASSEMBLY IS LEAKING FUEL, BECASE OF POOR GRADE PLASTIC AND METAL CONSTRUCTION, THIS ALSO HAPPENED ON MY 2002 TRAILBLAZER BUT WAS COVERED BY A RECALL,NO SUCH RECALL COVERS MY 2004 AVALACHE EVEN THOUGH IT IS THE SAME PROBLEM, COST TO FIX 870.89 ESTIMATE, TO REMOVE GAS TANK AND REPLACE FUEL PUMP MODULE ASSEMBLY, CANT SEND PICS HAVE DROP GAS TANK AND THAT COST IS 250.00, VEHILE STARS SLOWLY THEN WHEN PARKED EMPTIES FUEL LINES ON TOP OF TANK THEN ON TO GROUND VERY DANGEROUS, SERVICE MANAGER BIG JIM 319 261 0999 , SAYS THIS IS A COMMON PROBLEM, HE KNEW WHAT IT WAS BEFORE INSPECTING ON HOUSTE, IF 2002 IS COVERED WHY IS 2004 NOT COVERED? WANT MY 1000.00 BACK FROM GM
NHTSA complaint #10809055 — an unverified report by a vehicle owner.
at 67,869 milesFort Washington, MD
SERVICE BRAKES
MY SON HAD BORROWED THE TRUCK AND WAS RETURNING IT WITH HIS 4 AND 5 YEAR OLD SONS IN THE VEHICLE. HE WAS IN A TRAFFIC CIRCLE AND HAD TO BRAKE TO AVOID AN ACCIDENT. IMMEDIATELY AFTERWARDS THE BRAKE FAILURE WARNING CAME ON AND THE TRUCK HAD NO BRAKES. FORTUNATELY HE WAS ONLY GOING ABOUT 25 MPH AND WAS ABLE TO PARK IT ON THE SHOULDER AND NO ONE WAS INJURED. I WAS ABLE TO GET IT TO A LOCAL DEALER FOR REPAIR TO THE TUNE OF $1,952. THEY DIAGNOSED THE PROBLEM AS A RUSTED BRAKE LINE THAT RUPTURED AND DAMAGED THE LEFT CALIPER. WE GOT NO PRIOR WARNING OF THE BRAKE FAILURE. IN 2012 I ALSO HAD A SUDDEN BRAKE FAILURE WHILE LEAVING A PARKING GARAGE. THERE WAS NO PRIOR WARNING OR INDICATION THAT THE BRAKES WERE NOT FUNCTIONING. AGAIN I TOOK IT TO A LOCAL DEALER AND WAS TOLD THAT THERE WAS A LEAK IN THE MASTER CYLINDER AND I HAD TO HAVE THAT REPLACED. NO ONE MENTIONED ANYTHING AT THAT TIME ABOUT RUSTING BRAKE LINES. ALTHOUGH THE TRUCK IS 11 YEARS OLD IT ONLY HAS 67,871 MILES.
NHTSA complaint #10789227 — an unverified report by a vehicle owner.
at 125,000 milesCampton, MI
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. WHILE DRIVING APPROXIMATELY 7 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE ABS WARNING INDICATOR ILLUMINATED. THE EMERGENCY BRAKE WAS ENGAGED AND THE VEHICLE FAILED TO STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES WERE RUSTED AND THE VEHICLE HAD MULTIPLE BRAKE LEAKS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
NHTSA complaint #10765013 — an unverified report by a vehicle owner.
at 136,000 milesMurfeesboro, TN
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED WHEN THE BRAKE PEDAL WAS DEPRESSED AND THE BRAKE SYSTEM FAILED TO ENGAGE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER BOOSTER AND THE ABS SYSTEM WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 136,000.
NHTSA complaint #10761210 — an unverified report by a vehicle owner.
at 39,000 milesBelle Vernon, PA
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. WHILE REVERSING AT A LOW SPEED, THE BRAKE PEDAL WAS DEPRESSED BUT IT TOOK A LONGER DISTANCE TO STOP THE VEHICLE. THE BRAKE WARNING LIGHT ILLUMINATED AND SERVICE BRAKE SYSTEM WAS DISPLAYED ACROSS THE MESSAGE BOARD. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT DISCOVERED THAT ONE OF THE BRAKE LINES HAD FRACTURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 39,000.
NHTSA complaint #10750301 — an unverified report by a vehicle owner.
at 189,000 milesContinental, OH
SERVICE BRAKES
THE BRAKE LINE BURST AS I WAS SHIFTING INTO DRIVE COULD NOT STOP VEHICLE, SHIFTED IT INTO PARK AND WAS ABLE TO STOP BEFORE HITTING SOMEONE. WHY ARE THESE LINES NOT MADE OF STAINLESS STEEL? BETTER YET WHY IS THIS AGENCY NOT DOING ANYTHING ABOUT THIS? THEY JUMP ALL OVER A KEY SWITCH THAT MAY CAUSE A PROBLEM BUT DO NOTHING FOR SOMETHING AS IMPORTANT AS BE ABLE TO SAFELY STOP OUR VEHICLES.
NHTSA complaint #10731835 — an unverified report by a vehicle owner.
at 167,000 milesTroy, OH
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR FLASHED AND REMAINED ILLUMINATED. THE DEALER STATED THAT THE DRIVER SIDE AIR BAG MODULE NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.
NHTSA complaint #10723497 — an unverified report by a vehicle owner.
at 163,000 milesMentor, OH
SERVICE BRAKES
WHEN BRAKING THE PEDAL WAS SINKING ALL THE WAY TO THE FLOOR. I PUMPED BRAKES AND WAS ABLE TO STOP. HAD A LEAK OF BRAKE FLUID SO FILLED BRAKE FLUID AND ATTEMPTED TO DRIVE HOME/CLOSER TO MY MECHANIC. I WAS AT A COMPLETE STOP AT A TRAFFIC LIGHT WHEN MY BRAKE PEDAL SUNK TO THE FLOOR AND MY VEHICLE STARTED TO ROLL FORWARD TOWARDS CROSS TRAFFIC. I PUMPED BRAKE PEDAL BUT NO EFFECT. I SHIFTED INTO NEUTRAL AND WAS ABLE TO STOP LONG ENOUGH TO PUT VEHICLE IN PARK. CALLED A TOW TO MECHANIC. WAS TOLD MY BRAKE LINE HAD RUSTED OUT. HE FIXED 2 LINES. WITH IN A WEEK (5/8/15) I HAD ANOTHER LEAK OF BRAKE FLUID. ANOTHER TOW TO MECHANIC. HE FIXED ANOTHER BRAKE LINE. ON 5/24/15 ANOTHER BRAKE LINE BROKE. ANOTHER TOW. MECHANIC IS REPLACING THE REMAINING 5 LINES. ALL IN ALL COST IS OVER $1000 TO FIX.
NHTSA complaint #10722676 — an unverified report by a vehicle owner.
at 149,904 milesSpotsylvania, VA
SERVICE BRAKES
CATASTROPHIC BRAKE FAILURE WHEN ATTEMPTING TO STOP VEHICLE AT 45 MILES PER HOUR. BRAKE PEDDLE WENT TO FLOOR ALMOST CAUSING A MAJOR CRASH. GMC DEALER STATED BRAKE LINES TOTALLY RUSTED OUT AND RUPTURED CAUSING TOTAL BRAKE FAILURE. DEALER STATED BRAKE LINES DISINTEGRATED IN THE TECHNICIANS HANDS WHEN THE TECH WAS REMOVING OLD LINES. I HAVE READ SIMILAR EXPERIENCES FROM OTHER GM OWNERS ON THE INTERNET. THIS IS A MAJOR SAFETY ISSUE WHICH IF IT HAS NOT THUS FAR WILL RESULT IN INJURY AND OR DEATH. I AM ONE OF THE LUCKY ONES WHO WAS ABLE TO AVOID AN ACCIDENT. I AM SURE THIS WONT BE THE SAME OUTCOME FOR OTHERS. DEALER INFO: ULTIMATE BUICK GMC 5150 JEFFERSON DAVIS HIGHWAY FREDERICKSBURG VA 22408 TEL # 540-898-6200 SERVICE ADVISOR IAN DOUGHTY RO339073 THANKS FOR ANY ASSISTANCE IN ADDRESSING THIS SAFETY ISSUE.
NHTSA complaint #10716821 — an unverified report by a vehicle owner.
at 91,000 milesWest Frankfort, ILCrash
STRUCTURE:BODY
MY HUSBAND, 3 YEAR OLD, ANY MYSELF WERE DRIVING BACK FROM A DOCTOR APPOINTMENT WHEN WE HAD TO MAKE A SUDDEN STOP BECAUSE OF A DRIVER 2 CARS AHEAD OF US THAT QUICKLY APPLIED BRAKES TO MAKE A QUICK RIGHT HAND TURN. THE DRIVER IN FRONT OF US IN TURN HAD TO APPLY HIS BREAKS ON AND WHEN MY HUSBAND APPLIED THE BRAKES ON OUR 2004 CHEVROLET AVALANCHE THERE WERE NO BRAKES!! OUR 3 YEAR OLD WAS ASLEEP IN THE BACKSEAT!! WE HIT HIM OF COURSE BECAUSE WE COULD NOT STOP (GOING DOWNHILL ON A BUSY HIGHWAY) WE ENDED UP HAVING TO COAST UP THE HILL IN THE MIDDLE OF THE LANE BECAUSE THERE WAS NOWHERE SAFE FOR US TO PULL OFF . THERE WERE ALMOST SEVERAL OTHER ACCIDENTS DUE TO IT BEING A BLIND SPOT FOR DRIVERS COMING OVER THE HILL BOTH WAYS AND WE WERE STUCK THERE BECAUSE WE HAD NO WAY TO STOP OURSELVES AGAIN. SO AFTER ALL THAT WE ENDED UP NEEDING OUR TRUCK TOWED AND THE BRAKE LINES ARE CORRODED AND HAD BUSTED!! SO NOT ONLY DO WE HAVE A TOW BILL NOW WE ARE RESPONSBILE FOR REPLACING THEM! THE ESTIMATE IS $800!!! THANKS GM! WE WILL BE SELLING THIS ONE SOON! GM WON'T DO A RECALL ON THESE AFTER ALL THE COMPLAINTS AND ACCIDENTS ABOUT THE BRAKE LINES ON HERE? SERIOUSLY? WE HAD NO CLUE ABOUT ANY OF THIS UNTIL TODAY! THE MECHANIC THAT IS FIXING OURS TODAY TOLD US HE HAS 2 MORE THAT HAVE THE EXACT SAME ISSUE AND HAVE TO BE REPLACED ON THEIRS TOO! I GUESS IT TAKES PEOPLE DYING OR GETTING SERIOUSLY INJURED BEFORE THE CAR MANUFACTURES HAVE TO TAKE RESPONSIBILITY. AND WHAT MAKES IT EVEN WORSE IS THAT THE WHOLE BRAKE LINE REPLACEMENT IS AVAILABLE (FOR US TO PURCHASE) AND IT'S ONLY ABOUT $160!! NICE TO KNOW THE SAFETY OF OUR FAMILY, FRIENDS, AND OTHER MOTORISTS AREN'T WORTH IT TO THEM. JUST 2 MILES EARLIER WE DROVE THOUGH A SCHOOL ZONE!!!!! AS THE KIDS WERE LEAVING FOR THE DAY! THANK GOD THEY LASTED THAT 2 EXTRA MILES AND NO ONE WAS SERIOUSLY INJURED OR KILLED.
NHTSA complaint #10716593 — an unverified report by a vehicle owner.
at 91,000 milesWest Frankfort, ILCrash
SERVICE BRAKES
MY HUSBAND, 3 YEAR OLD, ANY MYSELF WERE DRIVING BACK FROM A DOCTOR APPOINTMENT WHEN WE HAD TO MAKE A SUDDEN STOP BECAUSE OF A DRIVER 2 CARS AHEAD OF US THAT QUICKLY APPLIED BRAKES TO MAKE A QUICK RIGHT HAND TURN. THE DRIVER IN FRONT OF US IN TURN HAD TO APPLY HIS BREAKS ON AND WHEN MY HUSBAND APPLIED THE BRAKES ON OUR 2004 CHEVROLET AVALANCHE THERE WERE NO BRAKES!! OUR 3 YEAR OLD WAS ASLEEP IN THE BACKSEAT!! WE HIT HIM OF COURSE BECAUSE WE COULD NOT STOP (GOING DOWNHILL ON A BUSY HIGHWAY) WE ENDED UP HAVING TO COAST UP THE HILL IN THE MIDDLE OF THE LANE BECAUSE THERE WAS NOWHERE SAFE FOR US TO PULL OFF . THERE WERE ALMOST SEVERAL OTHER ACCIDENTS DUE TO IT BEING A BLIND SPOT FOR DRIVERS COMING OVER THE HILL BOTH WAYS AND WE WERE STUCK THERE BECAUSE WE HAD NO WAY TO STOP OURSELVES AGAIN. SO AFTER ALL THAT WE ENDED UP NEEDING OUR TRUCK TOWED AND THE BRAKE LINES ARE CORRODED AND HAD BUSTED!! SO NOT ONLY DO WE HAVE A TOW BILL NOW WE ARE RESPONSBILE FOR REPLACING THEM! THE ESTIMATE IS $800!!! THANKS GM! WE WILL BE SELLING THIS ONE SOON! GM WON'T DO A RECALL ON THESE AFTER ALL THE COMPLAINTS AND ACCIDENTS ABOUT THE BRAKE LINES ON HERE? SERIOUSLY? WE HAD NO CLUE ABOUT ANY OF THIS UNTIL TODAY! THE MECHANIC THAT IS FIXING OURS TODAY TOLD US HE HAS 2 MORE THAT HAVE THE EXACT SAME ISSUE AND HAVE TO BE REPLACED ON THEIRS TOO! I GUESS IT TAKES PEOPLE DYING OR GETTING SERIOUSLY INJURED BEFORE THE CAR MANUFACTURES HAVE TO TAKE RESPONSIBILITY. AND WHAT MAKES IT EVEN WORSE IS THAT THE WHOLE BRAKE LINE REPLACEMENT IS AVAILABLE (FOR US TO PURCHASE) AND IT'S ONLY ABOUT $160!! NICE TO KNOW THE SAFETY OF OUR FAMILY, FRIENDS, AND OTHER MOTORISTS AREN'T WORTH IT TO THEM. JUST 2 MILES EARLIER WE DROVE THOUGH A SCHOOL ZONE!!!!! AS THE KIDS WERE LEAVING FOR THE DAY! THANK GOD THEY LASTED THAT 2 EXTRA MILES AND NO ONE WAS SERIOUSLY INJURED OR KILLED.
NHTSA complaint #10716593 — an unverified report by a vehicle owner.
at 73,245 milesRockwood, MI
UNKNOWN OR OTHER
WHILE DRIVING OR IN PARK THE TACHOMETER STICKS AS DOES THE SPEEDOMETER. THIS HAS LASTED FROM MINUTES TO DAYS. THE VEHICLE APPEARS TO RUN PROPERLY, HOWEVER, I AM VERY LEERY OF MY SAFETY AND THE SAFETY OF MY CHILDREN WHEN THEY ARE IN CONTROL OF THE VEHICLE.
NHTSA complaint #10716262 — an unverified report by a vehicle owner.
at 73,245 milesRockwood, MI
ELECTRICAL SYSTEM
WHILE DRIVING OR IN PARK THE TACHOMETER STICKS AS DOES THE SPEEDOMETER. THIS HAS LASTED FROM MINUTES TO DAYS. THE VEHICLE APPEARS TO RUN PROPERLY, HOWEVER, I AM VERY LEERY OF MY SAFETY AND THE SAFETY OF MY CHILDREN WHEN THEY ARE IN CONTROL OF THE VEHICLE.
NHTSA complaint #10716262 — an unverified report by a vehicle owner.
at 67,000 milesPhiladelphia, PA
ELECTRICAL SYSTEM
WHILE DRIVING ALL MY CLUSTER GAUGES FROZE...I WAS PARKED AND IT STILL SAID I WAS GOING 40MPH...HOW IS THIS NOT A RECALL? NO CLUE HOW FAST I WAS GOING,NOR HOW MUCH FUEL I HAD...WE SHOULD BE REIMBURSED SOMETHING.
NHTSA complaint #10701963 — an unverified report by a vehicle owner.
at 88,000 milesWhite House, TN
POWER TRAIN
4X4 TRANSMISSION BEGAN LOCKING AND SLIPPING. DEVELOPED A DISTINCTIVE "CLUNKING" SOUND WHEN SHIFTING BETWEEN GEARS. NOW MOST NOTICEABLE BETWEEN SECOND AND THIRD. ADDITIONAL GRINDING SOUND OCCURS WHEN DRIVING. NOTICEABLE AT ALL SPEEDS.
NHTSA complaint #10667464 — an unverified report by a vehicle owner.
at 65,000 milesDoyles Town, PA
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED WHILE DRIVING 25 MPH ATTEMPTING TO ENGAGE THE BRAKES, THE VEHICLE FAILED TO STOP AND THE PEDAL PRESSED TO THE FLOOR. THE CONTACT HAD TO ENGAGE THE EMERGENCY BRAKES IN ORDER FOR THE VEHICLE TO STOP. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. THE VIN NUMBER WAS UNAVAILABLE.
NHTSA complaint #10659848 — an unverified report by a vehicle owner.
Sacramento, CACrash2 injured
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET AVALANCHE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, AN ELK JUMPED IN FRONT OF THE VEHICLE AND THE CONTACT ATTEMPTED TO AVOID A CRASH. AS A RESULT, THE CONTACT CRASHED INTO A DIRT MOUNTAIN. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT AND THE FRONT PASSENGER SUSTAINED HEAD TRAUMA AND UPPER BODY INJURIES. THE CONTACT AND THE FRONT PASSENGER REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #10654851 — an unverified report by a vehicle owner.
at 136,000 milesWhitelaw, WI
ENGINE
VEHICLE STARTED EXPERIENCING A GRADUAL COOLANT LOSS, FOUND OUT VEHICLE HAS A MANUFACTURED FAULTY CYLINDER HEAD(S) FROM CASTECH. WILL COST $$$$ TO REPAIR. GM WILL NOT ADDRESS THE PROBLEM EXCEPT WITH GM #06-06-01-019B INFORMATION ON GRADUAL COOLANT LOSS OVER TIME WITH NO EVIDENCE OF LEAK FOUND, (JUNE 12, 2007).
NHTSA complaint #10644138 — an unverified report by a vehicle owner.
at 92,134 milesWhisett, NC
SERVICE BRAKES
I WAS TRAVELING WEST ON WENDOVER AVENUE IN GREENSBORO, NORTH CAROLINA APPROXIMATELY 8:20 AM ON THURSDAY OCTOBER 2, 2014. WHILE TRAVELING A TRAFFIC SIGNAL WAS TURNING RED AND I BEGAN SLOWING. AS I WAS ATTEMPTING TO SLOW DOWN THE BRAKE PEDAL CONTINUED TO TRAVEL TO THE FLOOR AND THE BRAKE LIGHT WARNING AND SERVICE BRAKE SYSTEM LIGHT CAME ON. I WAS QUICKLY CLOSING IN ON THE VEHICLE IN FRONT OF ME AND REDUCED MY SPEED BY STANDING ON THE BRAKED AND USING ENGINE SPEED SHIFTING FROM DRIVE TO 3RD TO 2ND AND THEN TO FIRST GEAR. I WAS ABLE TO STOP WITHIN A FOOT OF THE CAR IN FRONT OF ME. AFTER THIS I PULLED OVER TO INSPECT MY VEHICLE. I LOCATED A BLOWN BRAKE LINE THAT WAS SEVERELY CORRODED ON THE DRIVERS SIDE ALONG THE FRAME OF THE VEHICLE. BRAKE FLUID WAS LEAKING OUT. IN ADDITION, THE OTHER BRAKE LINES APPEAR TO BE EXTREMELY CORRODED AS WELL. THIS IS A MAJOR CONCERN CONSIDERING BRAKES ARE SUCH A CRITICAL COMPONENT TO SAFE DRIVING. IT APPEARS THE BRAKE LINES ARE NOT MADE FOR A SUITABLE QUALITY FOR SUCH A CRITICAL SYSTEM. THE EXHAUST PIPE, WHICH IS UNDER THE VEHICLE AS WELL, IS NOT CORRODED AND IS MADE OUT OF SUITABLE QUALITY MATERIAL. IF THERE ARE OTHER VEHICLES OUT THERE ON THE ROAD WITH SIMILAR MATERIALS THE RESULTS MAY BE INJURIOUS OR DEADLY. PLEASE HELP TO ADDRESS AND RECTIFY THIS SITUATION WITH CHEVROLET.
NHTSA complaint #10640822 — an unverified report by a vehicle owner.
at 89,000 milesEast Northport, NY
SERVICE BRAKES
WHILE DRIVING IN TOWN LOCALLY, THE BRAKING SYSTEM FAILED WHILE TRYING TO STOP AT A TRAFFIC LIGHT. I WAS ABLE TO EVENTUALLY STOP THE TRUCK BY APPLYING EXTREME PRESSURE ON THE BRAKE PEDAL. I PULLED THE TRUCK OVER SAFELY & NOTICED BRAKE FLUID ON THE GROUND UNDER THE DRIVER'S DOOR. I HAD THE TRUCK TOWED TO A LOCAL MECHANIC WHO INSPECTED THE BRAKING SYSTEM. ALL OF THE BRAKE LINES UNDER THE DRIVER'S DOOR WERE SEVERELY RUSTED ALONG WITH THE ONE LINE THAT HAD FAILED.
NHTSA complaint #10638048 — an unverified report by a vehicle owner.