2021 Chevrolet Equinox problems

FUEL/PROPULSION SYSTEM

The fuel pump of my Chevy equinox failed while I was driving in the middle of a busy highway causing my engine to lose power putting myself and my passengers in danger along with everybody else on the highway because I could not accelerate and I had to push my vehicle off the highway. Shortly after the engine stalled, the display for the fuel went from reading 3/4 of a tank to empty in a matter of a second. When I tried to restart the engine it would not register that there was any fuel in a tank even though it was 3/4 of the way full. This problem has been identified under the recall number 23V-013 but for some reason my VIN number is not included in this recall, even though it's a well-known issue for this year, make and model. Just before the engine stalled the check engine light came on.

NHTSA complaint #11758331 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

While driving on the interstate, the moonroof glass began opening without any input from the moonroof controls. The power sunshade was still closed at the time. I opened the sunshade manually so it would not interfere with the glass. After the glass opened, I was unable to get it to remain fully closed. When I was able to close the glass, it would reopen on its own several more times. I also heard a clicking sound during the repeated opening and closing. After this occurred, the power sunshade also stopped operating correctly. It would open fully, but when closing, it would stop approximately halfway and leave the front portion of the moonroof uncovered. It would not close completely. There were no warning lights or other dashboard indications during the incident. The only way I was eventually able to get both the moonroof glass and the sunshade to close completely was to leave the vehicle turned off for approximately two hours and then perform the moonroof reset/initialization procedure. After the reset, both the glass and sunshade returned to normal operation. The most concerning part of the incident was that the moonroof glass opened by itself while the vehicle was being driven, without anyone touching the controls.

NHTSA complaint #11758041 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving on the interstate, the moonroof glass began opening without any input from the moonroof controls. The power sunshade was still closed at the time. I opened the sunshade manually so it would not interfere with the glass. After the glass opened, I was unable to get it to remain fully closed. When I was able to close the glass, it would reopen on its own several more times. I also heard a clicking sound during the repeated opening and closing. After this occurred, the power sunshade also stopped operating correctly. It would open fully, but when closing, it would stop approximately halfway and leave the front portion of the moonroof uncovered. It would not close completely. There were no warning lights or other dashboard indications during the incident. The only way I was eventually able to get both the moonroof glass and the sunshade to close completely was to leave the vehicle turned off for approximately two hours and then perform the moonroof reset/initialization procedure. After the reset, both the glass and sunshade returned to normal operation. The most concerning part of the incident was that the moonroof glass opened by itself while the vehicle was being driven, without anyone touching the controls.

NHTSA complaint #11758041 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I am reporting a severe mechanical failure involving the fuel pump module on my 2021 Chevrolet Equinox. My vehicle exhibits symptoms that match NHTSA Recall Campaign 23V-013 / GM Campaign N222372310 (Inadequate Fuel Pump Flow). However, when checking my VIN, GM indicates my vehicle is currently excluded from the official recall population. My car hesitates to accelerate on the highway, will randomly sputter when at a constant speed, I have had a checked engine light come on which was cleared after it being inspected but was not fixed. This creates an extreme hazard and risk of my car completely stalling, or the risk of an accident when trying to accelerate on the interstate or just merging with the traffic flow. Given that the symptoms and component failures on my vehicle are identical to those documented in NHTSA Campaign 23V-013, I request that NHTSA investigate an expansion of this recall to include additional 2021 Chevrolet Equinox models. Additionally, I request General Motors cover the cost of diagnosis and repair under safety recall warranty provisions.

NHTSA complaint #11756705 — an unverified report by a vehicle owner.

POWER TRAIN

The high pressure fuel pump seized, shattering the camshaft, dropping metal fragments into the cylinders causing total engine failure. GM issued a safety recall for certain 2021-2022 Chevy equinox due to a defective fuel pump modules but it was not accurate. GM is currently facing major class action lawsuits alleging that their equinox fuel pumps are fundamentally defective. The lawsuits highlight that the component fails, causing catastrophic damage and GMs initial recall fixes were inadequate.

NHTSA complaint #11751317 — an unverified report by a vehicle owner.

ENGINE

The high pressure fuel pump seized, shattering the camshaft, dropping metal fragments into the cylinders causing total engine failure. GM issued a safety recall for certain 2021-2022 Chevy equinox due to a defective fuel pump modules but it was not accurate. GM is currently facing major class action lawsuits alleging that their equinox fuel pumps are fundamentally defective. The lawsuits highlight that the component fails, causing catastrophic damage and GMs initial recall fixes were inadequate.

NHTSA complaint #11751317 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The high pressure fuel pump seized, shattering the camshaft, dropping metal fragments into the cylinders causing total engine failure. GM issued a safety recall for certain 2021-2022 Chevy equinox due to a defective fuel pump modules but it was not accurate. GM is currently facing major class action lawsuits alleging that their equinox fuel pumps are fundamentally defective. The lawsuits highlight that the component fails, causing catastrophic damage and GMs initial recall fixes were inadequate.

NHTSA complaint #11751317 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING

The contact owns a 2021 Chevrolet Equinox. The contact stated that while driving at an undisclosed speed on a busy highway, the engine seized, and the vehicle failed to restart. No warning lights were illuminated. The local Police assisted in pushing the vehicle onto the shoulder of the road. A mobile mechanic diagnosed the vehicle with a failed Camshaft position sensor. The vehicle was not repaired. The vehicle was later towed to another independent mechanic, where it was diagnosed with a failed timing chain. The vehicle was not repaired. The vehicle was then towed to the dealer, where it was diagnosed with a failed engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. Additionally, the contact stated that a routine oil change was performed on the vehicle a couple of weeks prior to the failure. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 86,000.

NHTSA complaint #11749103 — an unverified report by a vehicle owner.

POWER TRAIN

The electronic brake control module causes the car to no start and goes into limp mode. Cuts off the power to every system in the entire dashboard including the transmission making the car very dangerous to drive.

NHTSA complaint #11748322 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The electronic brake control module causes the car to no start and goes into limp mode. Cuts off the power to every system in the entire dashboard including the transmission making the car very dangerous to drive.

NHTSA complaint #11748322 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

The electronic brake control module causes the car to no start and goes into limp mode. Cuts off the power to every system in the entire dashboard including the transmission making the car very dangerous to drive.

NHTSA complaint #11748322 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have no sound at all no turn signals, no seat belt no nothing, had Chevy in leesburg tell me I need an update did that and being told to replace radio and amplifier

NHTSA complaint #11744599 — an unverified report by a vehicle owner.

POWER TRAIN

My car only has 60,000 miles and it shifts hard. Also my drivers seat belt has issues latching

NHTSA complaint #11742225 — an unverified report by a vehicle owner.

SEAT BELTS

My car only has 60,000 miles and it shifts hard. Also my drivers seat belt has issues latching

NHTSA complaint #11742225 — an unverified report by a vehicle owner.

ENGINE

I was driving in GA and my low engine power light came on and I lost complete ability to brake. The brake pedal was hard and would not go down. I towed my car to Jim Ellis Chevrolet in Atlanta. They called a few days later and told me I needed extensive engine repairs that would cost over $5,000 but GM would take care of some of it. I paid $1980.00. I went to pick up my car and was nervous because I lost brakes on a highway and was afraid. I asked them if they were sure everything was repaired and I would be safe and they told me it was tested extensively and driven and all was good. I drove around 2 hours after leaving and my engine light came on and my brakes failed again going 70 miles an hour surrounded by semis. I called Jim Ellis and they told me to tow it to Walter Jackson who told me it was a vacuum pump that they would have had to remove during the repairs. In addition there is a class action against GM about these pumps for my year and make of car. I have asked for a refund from Jim Ellis contacting ownership, GM, Service Team and no one will respond to my calls or emails. I filed a customer complaint with GM and they are accepting zero responsibility as well. I paid thousands of dollars between both repairs and rental cars and the least I would like for them putting my life and others around me at risk on a freeway is my money back.

NHTSA complaint #11742151 — an unverified report by a vehicle owner.

SERVICE BRAKES

I was driving in GA and my low engine power light came on and I lost complete ability to brake. The brake pedal was hard and would not go down. I towed my car to Jim Ellis Chevrolet in Atlanta. They called a few days later and told me I needed extensive engine repairs that would cost over $5,000 but GM would take care of some of it. I paid $1980.00. I went to pick up my car and was nervous because I lost brakes on a highway and was afraid. I asked them if they were sure everything was repaired and I would be safe and they told me it was tested extensively and driven and all was good. I drove around 2 hours after leaving and my engine light came on and my brakes failed again going 70 miles an hour surrounded by semis. I called Jim Ellis and they told me to tow it to Walter Jackson who told me it was a vacuum pump that they would have had to remove during the repairs. In addition there is a class action against GM about these pumps for my year and make of car. I have asked for a refund from Jim Ellis contacting ownership, GM, Service Team and no one will respond to my calls or emails. I filed a customer complaint with GM and they are accepting zero responsibility as well. I paid thousands of dollars between both repairs and rental cars and the least I would like for them putting my life and others around me at risk on a freeway is my money back.

NHTSA complaint #11742151 — an unverified report by a vehicle owner.

POWER TRAIN

On way to [XXX] car started hesitating stop at Oreily’s they hooked up said 3rd cylinder was misfiring took to Bruner Chevrolet I told them what the read out said on the 3rd cylinder misfiring they said catalytic converter was messed up and changed it out drove car home still hesitating went back to Bruner Chevrolet I asked them about the recall on the fuel injector module they said my car was not on the recall said it needed the spark plugs and fuel injectors maintenance they did all that then they test drove the car engine light came on said the fuel injector needed to be replaced cost me 866.33 for all this what I want to know if the fuel injector module wasn’t working properly would it cause all of this my car only has 40,800 miles on it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11740881 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

On way to [XXX] car started hesitating stop at Oreily’s they hooked up said 3rd cylinder was misfiring took to Bruner Chevrolet I told them what the read out said on the 3rd cylinder misfiring they said catalytic converter was messed up and changed it out drove car home still hesitating went back to Bruner Chevrolet I asked them about the recall on the fuel injector module they said my car was not on the recall said it needed the spark plugs and fuel injectors maintenance they did all that then they test drove the car engine light came on said the fuel injector needed to be replaced cost me 866.33 for all this what I want to know if the fuel injector module wasn’t working properly would it cause all of this my car only has 40,800 miles on it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11740881 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My 2021 Chevrolet Equinox, VIN [XXX] , previously showed an active recall related to fuel system and stalling issues. The recall no longer appears under my VIN, but the same dangerous symptoms are happening. The vehicle jerks during acceleration, hesitates, loses power, and stalls while driving. These problems create a major safety concern because the vehicle can suddenly lose power in traffic. The symptoms match the original recall-related issues that were previously associated with this vehicle. I am requesting that the vehicle be inspected for recall-related failures, warranty coverage, special coverage adjustments, or goodwill assistance due to the safety risk involved. I would like documentation showing whether the recall repair was previously completed on this VIN and whether any warranty remains on the repaired or replaced parts. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11740256 — an unverified report by a vehicle owner.

SEAT BELTS

It appears that both driver's and passenger's inertia locking mechanism are defective. They do not lock keeping driver and passenger from going forward into dashboard. I had to make sudden stop the other day, and wife (passenger) went flying into the dashboard and hit her head. After assuming the seat belts auto locked when in use, we were surprised. Since then we pull the seat belts all the way out and release them and have to repeat this step 8-10 times before it catches, and then a slight move forward unlocks the restraint. SOmething isn't right about this, and I'll bet numerous cars are the same way, you only know once you have to stop quickly. I reported to the dealer, but the want $200 approximately just to look at it, and maybe $400-$800 each to fix something that should be covered by GM.

NHTSA complaint #11735095 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I am writing to report a safety concern with my 2021 Chevrolet Equinox. The rear bumper has begun to separate from the body of the vehicle and becomes loose during normal use. This issue appears to be related to how the bumper is attached (clips, fasteners, or design), not due to any collision or damage. A loose rear bumper creates a potential safety hazard, as it could detach while driving or pose a risk to other drivers. I recommend that Chevrolet investigate this issue for a possible defect and consider a recall if this is found to be a common problem among similar vehicles.

NHTSA complaint #11733877 — an unverified report by a vehicle owner.

POWER TRAIN

REPLACED A PROPELLOR SHAFT AT 59,000 MILES 8/23/2025. PAID $859.00. UNAWARE THIS COULD HAVE BEEN REPAIRED AND COVORERD BY A MANUFACTURERS WARRANTEE. SIX MONTHS LATER MY MECHANIC(1) AND CAR DEALER(2) RECOMMEND A BODY CONTROL MODULE AND POSSIBLE REAR DIFFERENTIAL REPLACEMENT ESTIMATED BETWEEN $1500-$3500. THIS VEHICLE STILL HAS LESS THAN 69000. THIS HAS BEEN A HARDSHIP AFTER PURCHASING A NEWER VEHICLE SO I COULD HAVE FEWER REPAIRS TO MY BUDGET.

NHTSA complaint #11724768 — an unverified report by a vehicle owner.

ENGINE

The check engine light came on and the engine lowered performance because the intercooler froze and cracked. Despite there being a service update to stop that from happening, we were never informed of the update from Chevy, only once it had happened did they tell us about the update and included it in the repair cost.

NHTSA complaint #11720694 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2021 Chevrolet Equinox. The contact stated that while driving 35-40 MPH in traffic, the vehicle stalled, and the power steering and brakes became inoperable. The check engine warning light was illuminated. The contact was able to pull to the side of the road. The vehicle was restarted after a long while. The failure recurred on several occasions. The vehicle was taken to an independent mechanic, where it was diagnosed with fuel pump failure. The mechanic replaced the fuel pump; however, the failure persisted. The vehicle was taken to another independent mechanic, where it was diagnosed with fuel pump module failure. The vehicle was not repaired due to the cost. The contact associated the failure with NHTSA Campaign Number: 23V013000 (Fuel System, Gasoline). The vehicle was taken to the dealer, and the contact was informed that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 72,000.

NHTSA complaint #11718722 — an unverified report by a vehicle owner.

ENGINE

CASE NUMBER 11715650 , check engine light went on , and the vehicle reduced speed, I took car into dealership, they said the engine had an ice problem and a repair would be needed, they said that this was a flaw in design, and it should be part of a recall, and that this is a common problem with this vehicle. the cost of a repair would be around $1000.00 . T fill this should be covered by the manufacture because of a design flaw.

NHTSA complaint #11715945 — an unverified report by a vehicle owner.