Owners have filed 399 complaints
about the 2015 Chevrolet Malibu with NHTSA between 2014 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 17 of 29 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 20
Against the median year of the Chevrolet Malibu. 50 means typical for this
model; 100 means roughly double.
Severity — 84
16.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 51
30% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2015 compares with every other Chevrolet Malibu
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
1257.1%
Sun/Moon Roof Assembly
314.3%
Key/Sender
14.8%
SRS Malfunction Warning Lamp/Light
14.8%
Automatic Emergency Braking
14.8%
Pump
14.8%
AIR Bag/Restraint Control Module
14.8%
Control Module
14.8%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
125.3%
1,000 – 9,999 miles
198.4%
10,000 – 24,999 miles
2711.9%
25,000 – 49,999 miles
5423.8%
50,000 – 74,999 miles
3615.9%
75,000 – 99,999 miles
3615.9%
100,000 – 149,999 miles
3415.0%
150,000+ miles
94.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2014peak 21Aug 2026
Recalls on the 2015 Chevrolet Malibu
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Recall 20151184,927 units in Canada
Structure
Certain vehicles equipped with power-operated sunroof systems may fail to conform to Canada Motor Vehicle Safety Standard (CMVSS) 118 - Power-Operated Window, Partition and Roof Panel Systems. The roof panels could close automatically when the non-recessed portion of the “Slide” or “Tilt” switches are pressed and the roof panel is open, which is contrary to the standard. The switch could be more susceptible to an inadvertent actuation, which could result in unintended auto-closure of the roof panel, increasing the risk of injury. Correction: Dealers will update the Body Control Module (BCM), which will remove the "one touch" (momentary actuation) feature for certain switch positions.
Reports where the owner recorded a crash, a fire, an injury or a death.
Las Vegas, NVCrash1 injured
AIR BAGS
I was t-boned on the front side panel near the door at a high rate of speed. I would estimate well above the posted limit of 35 mph and my front and side airbags failed to deploy. I have video from the intersection and dash cam demonstrating the impact. My head hit off the steering wheel causing a concussion, neck and spine dislocations, bruising, and cracked xiphoid, dislocation on the left side of my chest, and cut on my ear. I went to the hospital, have the police report, and the two videos are also available. My car was totaled and towed to the lot off of Lamb, north of Craig Road.
NHTSA complaint #11752215 — an unverified report by a vehicle owner.
at 151,000 milesMeadow Bridge, WV1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving approximately 45 MPH, the vehicle abruptly stopped in the middle of the road. The contact was able to continue driving. The vehicle was later taken to the local mechanic, who diagnosed that the torque converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. During the incident, the front passenger made contact with the dashboard and sustained bruises to the left knee and finger. No medical treatment was needed. The failure mileage was 151,000.
NHTSA complaint #11691613 — an unverified report by a vehicle owner.
Tempe, AZCrash
SEAT BELTS
Unknown
NHTSA complaint #11656637 — an unverified report by a vehicle owner.
Tempe, AZCrash
AIR BAGS
Unknown
NHTSA complaint #11656637 — an unverified report by a vehicle owner.
Tempe, AZCrash
UNKNOWN OR OTHER
Unknown
NHTSA complaint #11656637 — an unverified report by a vehicle owner.
Longwood, FLFire
ENGINE
At 2:30AM car was sitting in driveway and the engine caught on fire burning the engine, front left tire etc.
NHTSA complaint #11495104 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Hazard, KY
ELECTRICAL SYSTEM
While driving my 2015 Chevrolet Malibu on a four-lane highway with a posted speed limit of 70 mph, the vehicle displayed an “Engine Power Is Reduced” message and limited the vehicle to less than approximately 25 mph. This created a serious safety concern because the vehicle could no longer maintain highway traffic speed, resulting in a significant speed differential of nearly 45 mph below the posted limit and surrounding traffic flow, creating a high risk of being struck by other vehicles. The vehicle also experienced an alternator problem while being driven on the highway. It repeatedly acted like it was not getting enough power to maintain the speed of surrounding traffic, and we had to pull over on the side of the road. The vehicle has also had an engine-related issue discovered during repairs. When the valve cover gaskets were replaced, the vacuum pump was found to be severely damaged, and metal shavings were found in the engine oil. The reduced-engine-power problem has occurred in connection with the vehicle's electrical and engine problems. The vehicle and affected components may be available for inspection upon request. The vehicle has been inspected during repairs, and the damaged vacuum pump and metal shavings in the oil were observed during that inspection. These problems create a safety risk because the vehicle can suddenly lose engine power and become unable to maintain highway speed. The loss of normal power while traveling on a four-lane highway could make it difficult to accelerate, merge, or get out of the way of other vehicles.
NHTSA complaint #11757229 — an unverified report by a vehicle owner.
Hazard, KY
ENGINE
While driving my 2015 Chevrolet Malibu on a four-lane highway with a posted speed limit of 70 mph, the vehicle displayed an “Engine Power Is Reduced” message and limited the vehicle to less than approximately 25 mph. This created a serious safety concern because the vehicle could no longer maintain highway traffic speed, resulting in a significant speed differential of nearly 45 mph below the posted limit and surrounding traffic flow, creating a high risk of being struck by other vehicles. The vehicle also experienced an alternator problem while being driven on the highway. It repeatedly acted like it was not getting enough power to maintain the speed of surrounding traffic, and we had to pull over on the side of the road. The vehicle has also had an engine-related issue discovered during repairs. When the valve cover gaskets were replaced, the vacuum pump was found to be severely damaged, and metal shavings were found in the engine oil. The reduced-engine-power problem has occurred in connection with the vehicle's electrical and engine problems. The vehicle and affected components may be available for inspection upon request. The vehicle has been inspected during repairs, and the damaged vacuum pump and metal shavings in the oil were observed during that inspection. These problems create a safety risk because the vehicle can suddenly lose engine power and become unable to maintain highway speed. The loss of normal power while traveling on a four-lane highway could make it difficult to accelerate, merge, or get out of the way of other vehicles.
NHTSA complaint #11757229 — an unverified report by a vehicle owner.
Hazard, KY
SERVICE BRAKES
While driving my 2015 Chevrolet Malibu on a four-lane highway with a posted speed limit of 70 mph, the vehicle displayed an “Engine Power Is Reduced” message and limited the vehicle to less than approximately 25 mph. This created a serious safety concern because the vehicle could no longer maintain highway traffic speed, resulting in a significant speed differential of nearly 45 mph below the posted limit and surrounding traffic flow, creating a high risk of being struck by other vehicles. The vehicle also experienced an alternator problem while being driven on the highway. It repeatedly acted like it was not getting enough power to maintain the speed of surrounding traffic, and we had to pull over on the side of the road. The vehicle has also had an engine-related issue discovered during repairs. When the valve cover gaskets were replaced, the vacuum pump was found to be severely damaged, and metal shavings were found in the engine oil. The reduced-engine-power problem has occurred in connection with the vehicle's electrical and engine problems. The vehicle and affected components may be available for inspection upon request. The vehicle has been inspected during repairs, and the damaged vacuum pump and metal shavings in the oil were observed during that inspection. These problems create a safety risk because the vehicle can suddenly lose engine power and become unable to maintain highway speed. The loss of normal power while traveling on a four-lane highway could make it difficult to accelerate, merge, or get out of the way of other vehicles.
NHTSA complaint #11757229 — an unverified report by a vehicle owner.
Las Vegas, NVCrash1 injured
AIR BAGS
I was t-boned on the front side panel near the door at a high rate of speed. I would estimate well above the posted limit of 35 mph and my front and side airbags failed to deploy. I have video from the intersection and dash cam demonstrating the impact. My head hit off the steering wheel causing a concussion, neck and spine dislocations, bruising, and cracked xiphoid, dislocation on the left side of my chest, and cut on my ear. I went to the hospital, have the police report, and the two videos are also available. My car was totaled and towed to the lot off of Lamb, north of Craig Road.
NHTSA complaint #11752215 — an unverified report by a vehicle owner.
Chicago, IL
POWER TRAIN
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving on several occasions at various speeds, the vehicle inadvertently shifted between park(P), drive(D), and neutral(N), and the selected gear was not visible or illuminated on the instrument cluster or the gear shifter panel. The doors locked and unlocked, and the engine started shaking abnormally. The contact stated that the message "Service Power Steering - Drive with Care" was displayed during the failure. The vehicle was pulled over to the side of the road after each failure and the gear shifter was slowly shifted between gears until the desired gear was selected. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11744242 — an unverified report by a vehicle owner.
Chicago, IL
STEERING
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving on several occasions at various speeds, the vehicle inadvertently shifted between park(P), drive(D), and neutral(N), and the selected gear was not visible or illuminated on the instrument cluster or the gear shifter panel. The doors locked and unlocked, and the engine started shaking abnormally. The contact stated that the message "Service Power Steering - Drive with Care" was displayed during the failure. The vehicle was pulled over to the side of the road after each failure and the gear shifter was slowly shifted between gears until the desired gear was selected. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11744242 — an unverified report by a vehicle owner.
Cynthiana, KY
WHEELS
Qdeana auto sales in Winchester ky took out my fog lights , 6by 9 speakers and replaced my wheels and tires with 3 18 inch tires that were all different brands and heights and widths and added my 4th tire that was completely a different sized. A size 17. Gave me a key fob that was broken and only that one. Made me have to buy a new one, also stole my 6 by 9s right out my car. Paid for a car straight out to them and they scammed me. They should be shut down ! And pay me my money !
NHTSA complaint #11735428 — an unverified report by a vehicle owner.
Cynthiana, KY
WHEELS
Purchased this car straight out for 4000 from deans car lot in Winchester ky over a week ago. They didn't tell me I had missing fog lights. Keyfob to far was so beat up and bent I could barely get in my car or lock my car not to mention they sent me home in that car with all 4 different brand tires and 4 different sizes. A couple tires are even plugged !! And no wouldn't help me fix any of them. They ignore me. Wasn't no crash. The car lot has been devious and I'm not happy bc that has to do with MY SAFETY. MY LIFE. MY VEHICLE. IM ROYALLY PISSED
NHTSA complaint #11732005 — an unverified report by a vehicle owner.
Cynthiana, KY
SUSPENSION
Purchased this car straight out for 4000 from deans car lot in Winchester ky over a week ago. They didn't tell me I had missing fog lights. Keyfob to far was so beat up and bent I could barely get in my car or lock my car not to mention they sent me home in that car with all 4 different brand tires and 4 different sizes. A couple tires are even plugged !! And no wouldn't help me fix any of them. They ignore me. Wasn't no crash. The car lot has been devious and I'm not happy bc that has to do with MY SAFETY. MY LIFE. MY VEHICLE. IM ROYALLY PISSED
NHTSA complaint #11732005 — an unverified report by a vehicle owner.
Cynthiana, KY
FUEL/PROPULSION SYSTEM
Purchased this car straight out for 4000 from deans car lot in Winchester ky over a week ago. They didn't tell me I had missing fog lights. Keyfob to far was so beat up and bent I could barely get in my car or lock my car not to mention they sent me home in that car with all 4 different brand tires and 4 different sizes. A couple tires are even plugged !! And no wouldn't help me fix any of them. They ignore me. Wasn't no crash. The car lot has been devious and I'm not happy bc that has to do with MY SAFETY. MY LIFE. MY VEHICLE. IM ROYALLY PISSED
NHTSA complaint #11732005 — an unverified report by a vehicle owner.
at 179,000 milesGrey, GA
POWER TRAIN
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving at an undisclosed speed, the contact attempted to stop to make a turn, and there was a popping sound coming from the vehicle before the vehicle lost motive power and stalled. The vehicle was restarted, but failed to move or respond as needed. The vehicle was towed to a dealer to be diagnosed. The vehicle was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 179,000.
NHTSA complaint #11725686 — an unverified report by a vehicle owner.
St. Louis, MO
ELECTRICAL SYSTEM
The car continues to die when I come to a stop. The error code for the engine light is P305F. I have changed both batteries along with several different sensors and spent thousands of dollars in repairs at a couple different shops and still can’t find the problem with this error code. I have fixed everything that this error code points to. The car will not pass inspection with the check engine code on. This should have been recalled as this is a very common problem.
NHTSA complaint #11712569 — an unverified report by a vehicle owner.
St. Louis, MO
ENGINE
The car continues to die when I come to a stop. The error code for the engine light is P305F. I have changed both batteries along with several different sensors and spent thousands of dollars in repairs at a couple different shops and still can’t find the problem with this error code. I have fixed everything that this error code points to. The car will not pass inspection with the check engine code on. This should have been recalled as this is a very common problem.
NHTSA complaint #11712569 — an unverified report by a vehicle owner.
Tolleson, AZ
POWER TRAIN
The transmission and engine fails repeatedly. The vehicle repeatedly stalls while accelerating at all speeds, simultaneously, the gear shift lights,dash lights, radio, etc restarts. Issue also happens when shifting gears. Issue happens at every stop light and stop sign, when the vehicle is engaged in ‘auto stop’. The vehicle has been in and out of the repair shop since 2022 for TCM/ECM failure. The vehicle has been inspected by Chevrolet twice and other repair shops. Problem persists and the vehicle is not safe to drive. The vehicle has to be jumped daily in order for it to work even after purchasing several batteries and alternators. Warranty company, SilverRock, denied claim. When shifting gears, the warning message states ‘power steering’ and all of the car lights disappear and the vehicle stalls. These issues appeared 31 days after purchase in May of 2022.
NHTSA complaint #11699309 — an unverified report by a vehicle owner.
Tolleson, AZ
ELECTRICAL SYSTEM
The transmission and engine fails repeatedly. The vehicle repeatedly stalls while accelerating at all speeds, simultaneously, the gear shift lights,dash lights, radio, etc restarts. Issue also happens when shifting gears. Issue happens at every stop light and stop sign, when the vehicle is engaged in ‘auto stop’. The vehicle has been in and out of the repair shop since 2022 for TCM/ECM failure. The vehicle has been inspected by Chevrolet twice and other repair shops. Problem persists and the vehicle is not safe to drive. The vehicle has to be jumped daily in order for it to work even after purchasing several batteries and alternators. Warranty company, SilverRock, denied claim. When shifting gears, the warning message states ‘power steering’ and all of the car lights disappear and the vehicle stalls. These issues appeared 31 days after purchase in May of 2022.
NHTSA complaint #11699309 — an unverified report by a vehicle owner.
Tolleson, AZ
ENGINE
The transmission and engine fails repeatedly. The vehicle repeatedly stalls while accelerating at all speeds, simultaneously, the gear shift lights,dash lights, radio, etc restarts. Issue also happens when shifting gears. Issue happens at every stop light and stop sign, when the vehicle is engaged in ‘auto stop’. The vehicle has been in and out of the repair shop since 2022 for TCM/ECM failure. The vehicle has been inspected by Chevrolet twice and other repair shops. Problem persists and the vehicle is not safe to drive. The vehicle has to be jumped daily in order for it to work even after purchasing several batteries and alternators. Warranty company, SilverRock, denied claim. When shifting gears, the warning message states ‘power steering’ and all of the car lights disappear and the vehicle stalls. These issues appeared 31 days after purchase in May of 2022.
NHTSA complaint #11699309 — an unverified report by a vehicle owner.
at 151,000 milesMeadow Bridge, WV1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving approximately 45 MPH, the vehicle abruptly stopped in the middle of the road. The contact was able to continue driving. The vehicle was later taken to the local mechanic, who diagnosed that the torque converter was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. During the incident, the front passenger made contact with the dashboard and sustained bruises to the left knee and finger. No medical treatment was needed. The failure mileage was 151,000.
NHTSA complaint #11691613 — an unverified report by a vehicle owner.
at 151,884 milesMeadow Bridge, WV
POWER TRAIN
The contact owns a 2015 Chevrolet Malibu. The contact stated that while driving at 40 MPH, the vehicle came to a complete stop independently. The contact stated that while attempting to reverse, the vehicle failed to respond. An independent mechanic was contacted. The vehicle was taken to the independent mechanic, and was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 151,884.
NHTSA complaint #11691602 — an unverified report by a vehicle owner.
Ringgold, GA
SEAT BELTS
The slot in the B-Pillar where the seatbelt enters and exits the trim when it's extended or retracted has an unrounded and sharp edge. Under normal use, this plastic edge cuts nylon fibers on the sides of the belt, leading to a overall loss in integrity of the safety restraint. Vehicles should have rounded plastic edges or metal oblong loops to eliminate the belt rubbing against sharp surfaces. The belt is frayed on the side facing the forward part of the vehicle, which rubs the most as it's extended that direction when the driver pulls on the belt to fasten it. An independent mechanic says it seems to be a design flaw and my seatbelt is at a high risk of ripping in the event a substantial force is applied to it by an occupant during a crash.
NHTSA complaint #11688570 — an unverified report by a vehicle owner.
Tucson, AZ
POWER TRAIN
Rocker arm malfunction. This car has repeatedly shut off while driving without warning and the rocker arm has been the only code. I saw this has been a problem for the 2014-2015 Malibu and Impala models and this should be recalled due to faulty equipment and not to be repaired at the cost of the owners.
NHTSA complaint #11686445 — an unverified report by a vehicle owner.
Bettendorf, IA
ELECTRICAL SYSTEM
I was coming home from school pickup, and the light said the engine power was reducing. Then the screen said that I couldn't go past 25 miles per hour. The skid sign came on also. The car started slowing down on its own. The car then stopped. I had to put on emergency lights quickly. I had my daughter and grandaughter in the car. Thank God we didn't get rear ended. I turned off the car and waited. I turned it back on and went home a half a mile away thankfully. I looked up for a recall and Google said that there was a potential for the same thing. The check engine light came on too. This has never happened the whole time that I've had it.
NHTSA complaint #11683262 — an unverified report by a vehicle owner.
Ferris, TX
AIR BAGS
Service airbag light goes on and off. Also passenger air bag keeps turning on and off.
NHTSA complaint #11682022 — an unverified report by a vehicle owner.
Centre, AL
UNKNOWN OR OTHER
I was driving on the interstate and the engine power reduced light came on twice. It was driveable but I got off the interstate to state roads so I could drive slower. It acts like it wants to stop. I have been afraid to drive it again.
NHTSA complaint #11674877 — an unverified report by a vehicle owner.
Moss Point, MS
UNKNOWN OR OTHER
The engine power reduced light came on twice. I have been feeling a slight hesitation when driving for a couple of months but this is the first time that light came on. It happened on i65n about 140 miles from Montgomery. I got off the interstate at Montgomery so I could drive slower and made it home to Centre, AL. But now I'm afraid to drive it far.
NHTSA complaint #11669427 — an unverified report by a vehicle owner.
Vine Grove, KY
POWER TRAIN
My car has the auto shut off and when im driving it sometimes just dies while im driving with no warning and no power steering to pull over. Also when im at a red light and the auto shut off comes on when it starts back up all my head lights turning signals radio everything goes off and comes back on when the car restarts then when u go to take off it will die and everytime I push on the gas it hesitates to go if it dont die. I took my car to an independent car repair shop and they said they have tested everything and I have also replaced the front and back batteries and I was told it is the computer and he has had several of the same car come in with the exact problem.
NHTSA complaint #11667586 — an unverified report by a vehicle owner.