268 of the 875 complaints about the 2022 Chevrolet Silverado 1500 are about the engine — 31% of everything reported for this model year. Half of the failures with a mileage on record happened before 43,000 miles.
268
Complaints
1
Crashes
4
Fires
3
Injuries
Filed with NHTSA, in their own words.
ENGINE
Engine is the 6.2L V8. Engine has started consuming oil. Consumed approximately 3 quarts of oil over 4k miles. 0 signs of external leakage.
NHTSA complaint #11764226 — an unverified report by a vehicle owner.
ENGINE
I took my truck in to have a bad fuel pump module looked at. During the inspection they found some metal in the oil and it was confirmed by more being in the oil filter. This truck had previoulsy been cleared on the NHTSA Campaign 25V-274, but now it appears that it is a part of that recall. The dealer has initiated the work with the chevy corporate offices and I am working to secure a rental/ loaner car. I am filing this in the event there are any issues getting the new replacement engine.
NHTSA complaint #11763375 — an unverified report by a vehicle owner.
ENGINE
Coolant Control Valve is malfunctioning. Check engine code P1098, Running Fans Loud cooling fans running at full blast shortly after turning off the engine. General Motors issued special coverages N252508341 extending coolant control valve warranty protection up to 15 years or 150,000 miles for select 3.0L Duramax vehicles. Unfortunately, GM says my VIN isn’t covered by the extended warranty even though it has all the same issues as those that are covered down to the check engine code notes on their bulletin N252508341.
NHTSA complaint #11763175 — an unverified report by a vehicle owner.
ENGINE
I experienced a crankshaft bearing failure while driving my 6.2L V8 Chevrolet Silverado on the highway / freeway. Thankfully I was able to exit highway / freeway to avoid a car collision due to loss of power. My truck was towed to a certified Chevy dealer. This is a known issue for 2019-2026 6.2L V8 L87 engines. The truck was previously inspected by a certified Chevy dealer for prior L87 engine recall. It passed and they changed the oil type to 0w-40. Prior to this event, my truck was at the dealer for a low oil pressure issue / oil pan replacement. I picked it up from the dealer after the vehicle was repaired and drove it for about three days and then experienced the crankshaft bearing failure. No warning lamps illuminated prior to failure. My truck is currently at the dealer waiting for a new engine.
NHTSA complaint #11762684 — an unverified report by a vehicle owner.
ENGINE
The vehicle has blown 3 motors in 3 years. I took felivery 3/17/23. The first engine blew at 8,000 miles on 10/27/24. The second one blew 8/29/25 The 3rd one blew 4/12/26 at 52,000 miles on the vehicle.
NHTSA complaint #11762504 — an unverified report by a vehicle owner.
ENGINE
I did the 0w-40 oil swap and now my truck is having more issues than before the recall, doing a “oil consumption test”
NHTSA complaint #11761761 — an unverified report by a vehicle owner.
ENGINE
NHTSA VEHICLE SAFETY COMPLAINT Vehicle: 2022 Chevrolet Silverado K1500 Trail Boss Engine: 6.2L V8 VIN: [XXX] Selling Dealer: Harris Hankins Chevrolet, Bay Springs, Mississippi I purchased this 2022 Chevrolet Silverado K1500 Trail Boss from Harris Hankins Chevrolet in Bay Springs, Mississippi. The truck is equipped with the 6.2L V8 engine and has experienced repeated and serious engine failures. The vehicle is currently operating on its third engine. The original factory-installed engine suffered a major engine failure at approximately 27,000 miles. The vehicle was taken to a Chevrolet dealership, where the original engine was replaced. The second engine failed within approximately 30 miles of leaving the dealership following the first engine replacement. This failure resulted in the vehicle requiring another engine replacement. The truck is now operating with its third engine. I have periodically noticed abnormal valvetrain noise coming from this third engine. Considering that the first two engines experienced major failures, I am very concerned that this abnormal valvetrain noise may indicate another developing engine problem or potential engine failure. This 2022 Chevrolet Silverado has therefore experienced two major engine failures at very low mileage and is now on its third engine, which is periodically exhibiting abnormal valvetrain noise. I believe these repeated engine failures represent a serious vehicle safety concern. A sudden engine failure or loss of propulsion while traveling at highway speeds or in traffic could create a dangerous situation for the driver, passengers, and other motorists. I am requesting that the National Highway Traffic Safety Administration (NHTSA) formally document my vehicle’s history and investigate these repeated failures involving the Chevrolet/GM 6.2L V8 engine. The dealership has the service records and repair documentation concerning the previous engine failures and engine replacements. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FO
NHTSA complaint #11761767 — an unverified report by a vehicle owner.
ENGINE
Purchased vehicle in August of 2025 and there was an open recall for engine issues at that time. Took vehicle back to dealership in October or November for dealer to inspect. The vehicle passed the engine test and oil was changed to a heavier weight. From October/November 2025 I’ve been noting that there’s been a significant loss of engine oil prior to scheduled maintenance that requires anywhere between 4-5quart top off every three months or so. Feels like the vehicle is sluggish and has no “get-up”. Also, the Auto Emergency Brake light/system keeps malfunctioning. Even after it’s been replaced several times the light comes back on and you’re not able to control the forward collision gauge.
NHTSA complaint #11760674 — an unverified report by a vehicle owner.
ENGINE
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving at 70 MPH on Interstate 10, the vehicle stalled. The contact was able to pull the vehicle over; however, the vehicle failed to restart. A battery warning message and a no-start message were displayed. The vehicle was towed to a local dealer, where it was diagnosed that the engine was locked due to bearing failure. The engine was replaced. The manufacturer was notified of the failure via phone call and written letter, and the contact was provided with service points. The failure mileage was approximately 53,874.
NHTSA complaint #11760030 — an unverified report by a vehicle owner.
ENGINE
Coolant Control Valve is malfunctioning. Running Fans: Loud cooling fans running at full blast shortly after turning off the engine. Extended Warranty Coverage: General Motors issued special coverages (N252508341 / N252508340) extending coolant control valve warranty protection to 15 years or 150,000 miles for select 3.0L Duramax vehicles. Unfortunately, GM says my VIN isn’t covered by the extended warranty even though it has all the same issues as those that are.
NHTSA complaint #11759739 — an unverified report by a vehicle owner.
ENGINE
Engine failure. 5.3L motor
NHTSA complaint #11759847 — an unverified report by a vehicle owner.
ENGINE
July 11, 2026 I experienced a lifter failure. Towed to GM dealer on July 13th. Dealer comfirmed lifter failure and camshaft damage and metal contamination throughout engine. Dealer installed replacement engine using my mechanical breakdown policy since I was out of factory warranty. Picked up truck one month later with new engine and the transmission started slipping and shuttering. Took back to dealer who claimed metal fragments in fluid and said transmission needed to be replaced. I then made a second claim on my mechanical breakdown policy and the dealer replaced the transmission. All of these issues are known issues with the engine and transmission.
NHTSA complaint #11759506 — an unverified report by a vehicle owner.
ENGINE
Lifters failed at 4,000 miles.
NHTSA complaint #11758846 — an unverified report by a vehicle owner.
ENGINE
Engine abruptly lost power in middle of high speed lane. I did not have enough momentum to make it to safety, totally on the shoulder, Transmission locked up, couldn’t move vehicle to safety, Extremely dangerous situation!!!
NHTSA complaint #11758852 — an unverified report by a vehicle owner.
ENGINE
While traveling in bumper to bumper highway traffic in my 2022 Chevrolet Silverado RST, I attempted to accelerate and the vehicle suddenly malfunctioned. I experienced sever loss/restriction of propulsion and the vehicle would not respond normally to accelerator input. I was able to maneuver toward the shoulder of the road while avoiding a major multi-car pile up involving innocent motorists. When I attempted to stop, I did not have normal braking ability and was unable to stop in the manner I expected. I had to use the shoulder of the highway to slow the truck down until I could come to a complete stop. This created an immediate risk of serious or fatal collision on the highway, and as I maneuvered the truck out of traffic to the side of the road. Had I been unable to reach the shoulder of the road, I could have been struck by surrounding traffic. Had this failure occured un an urban area or at an intersection, near pedestrians, or at a school bus stop- I could have seriously injured or killed people or myself. After I was able to come to a complete stop. I shut it off and turned it back on, then the truck read there was no gas left (I had a 1/2 tank). This incident is not isolated electronic glitch, I have experienced electrical malfunctions including the truck failing to start, unlocking, responding at all. This all occured after an engine replacement due to a recall. I am concerned that there are unresolved electrical and power-distribution, communication-network, propulsion or braking issues that presents a serious safety risk to myself and others. My concern is that if this malfunction occurred on my drive to work in the city, around pedestrians- it could have resulted in multiple fatalities.
NHTSA complaint #11758426 — an unverified report by a vehicle owner.
ENGINE
Component/system failed: The 6.2L L87 engine. The engine ultimately seized and the vehicle became inoperable. The engine should be available for inspection because it is being replaced under GM Special Coverage N252494003. Safety risk: The engine unexpectedly shut off while driving at highway speeds. Loss of propulsion in traffic creates a significant collision risk. The inability to restart left the vehicle disabled. Confirmed: An independent repair facility confirmed that the engine was seized prior to towing it to the GM dealer. Yesterday the GM dealer confirmed i had a seized engine and it was going to be replacement under N252494003 special coverage entention. Inspections: My truck was inspected in October 25, for the recall. My truck passed this test, and was subsequently was told my oil spec has been revised. Warnings/symptoms: no warning was given
NHTSA complaint #11758561 — an unverified report by a vehicle owner.
ENGINE
The vehicle previously received the official GM Recall Campaign 25V-274 remedy/inspection, but suffered catastrophic engine failure and sudden loss of propulsion afterwards.
NHTSA complaint #11758156 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that the engine temperature increased while driving approximately 60 - 70 MPH. The message “Reduced Speed due to High Temperature” was displayed. The temperature gauge increased to high and then down to low. There were no warning lights illuminated. The contact stated that the failure was caused by the coolant control valve. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The contact was advised that an error message needed to be displayed before moving forward. The failure mileage was approximately 65,000.
NHTSA complaint #11757746 — an unverified report by a vehicle owner.
ENGINE
I have a 2022 silverado ltd with the 6.2. I purchased the truck about a month and a half ago the previous owner had the 40 weight oil recall completed prior to my purchase. I had the oil changed when it said 45 percent life remaining far before it was due a certified chevy dealer completed the oil change with the 40 weight correct oil. Well about 8 days ago I went out and started the truck and heard a clunk sound like a failing starter would make. So later that day I notice a ticking noise as well as a chirping noise. Coming from engine bay. I made note of it. Ever since the noise began I have kept close eyes on it the ticking and chirping rise and fall when I give it gas. Yesterday when I started it the clunk noise happened but this time I felt a shudder or stutter I looked at the rpms and they didn't move at all with the shudder. I have an appointment Monday morning to take it to the dealer I looked into the recall for the thicker oil. And learned that this motor is pretty much junk and multiple issues I haven't driven it since yesterday because the issues I'm having correspond with complete engine failure at any point and I do not want to be on the highway and it happen that would put me and other motorist at risk injury. There has been no warning lights no engine light just the initial clunk the first time and since that it's just been getting worse
NHTSA complaint #11757236 — an unverified report by a vehicle owner.
ENGINE
The motor seized. My life was at risk. I was on the highway. The vehicle was reported to the Chevy dealership and diagnose that the motor is locked.
NHTSA complaint #11757202 — an unverified report by a vehicle owner.
ENGINE
* Engine/ Yes available for inspection. * Has not happened yet, however the risk exists. * Yes, oil consumption and has been confirmed by dealer and monitored every 1,000 miles. * Been inspected by local dealer only. * Yes, low oil pressure light came on. I was 2 qtrs. LOW, XXX My vehicle was inspected and according to them "passed". 0W-40 was introduced and a new oil cap indicates the change. GM explains that it is acceptable to burn up to 2 qtrs. of oil between oil changes. They have me come to the dealer every 1,000 miles to check the oil level. I came back from a work-related function, putting approx. 220 miles. It was time for oil level inspection, and my engine was found to be 1/2qtr. LOW. I ask them to top it off and I was told; “we do not stock this oil in bulk; you have to buy a qt. and we'll put it in." I have been a car owner since I was [XXX], now [XXX] and have never heard such nonsense in my life. In fact, in my lifetime, I have NOT experienced engine burning oil. This is a 6.2 liter with 57,700 and my fear is that something catoptric will happen to the motor resulting in no recourse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11756893 — an unverified report by a vehicle owner.
ENGINE
I was driving down the road and all of a sudden the check engine light came on, the check the parking brake light came on, and the service electronic stability control system light came on. The engine then started making a knocking sound. These trucks have a known lifter issue. I had a 2021 that had the same problem. It was still under warranty so I was able to get out from under it. This one isn’t and they want $9,000 to replace the engine. There is a recall on the 6.2 liter but not for the 5.3 liter for some reason. These engines have an issue
NHTSA complaint #11756437 — an unverified report by a vehicle owner.
ENGINE
While driving 65mph on the highway the engine locked up and shut down. There was a loss of propulsion and steering making it difficult to safely maneuver off the highway.
NHTSA complaint #11755896 — an unverified report by a vehicle owner.
ENGINE
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving approximately 30 MPH and towing a trailer on Route 16 with his children inside the vehicle, within 10 minutes of driving, there was smoke coming from underneath the vehicle and entering the cabin. There were no warning lights illuminated. The driver pulled over safely. Additionally, the contact stated that there was no issue prior to the failure. First responders arrived on the scene but were unable to use fire extinguishers to contain the fire. The contact called 9-1-1. Within approximately 10 minutes, the vehicle was fully engulfed in flames, which reached an estimated height of 10 feet. A Police report and a Fire Department report were filed. The driver and his two children sustained smoke inhalation. The contact's daughter was vomiting; however, medical attention was not provided. The contact stated that a nearby vehicle and the trailer were damaged from the fire. The vehicle was towed to a tow yard. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 67,000.
NHTSA complaint #11754645 — an unverified report by a vehicle owner.
ENGINE
Engine sudden loss of propulsion while driving on interstate w/out warning. Pulled to side and check engine light and hot oil warning came on prior to engine dying. Had to call tow and dealer says engine needs to be replaced but they won’t ship vehicle back after repair and it’s 4 hours from my house, that I need to pick it up
NHTSA complaint #11754171 — an unverified report by a vehicle owner.
ENGINE
While traveling at night on the highway at excess of 70mph the engine in my 2022 Chevrolet Silverado 1500 6.2L L87 experienced a sudden, complete mechanical failure and loss of propulsion while driving. There were no warning lights, sounds or any other indication the motor would instantly stop working. This created an immediate crash hazard for me, my children and my dog. The vehicle is completely inoperable and I paid $125 to have it towed home. Upon talking to the dealership service ce manager they are refusing to inspect/replace my engine under Safety Recall N252494001. The same dealer is also requiring a large diagnostic fee prior to looking at the vehicle and has stated they will require additional fees as needed. They also refused to provide a loaner vehicle.
NHTSA complaint #11750101 — an unverified report by a vehicle owner.
ENGINE
Intermittent knock on start up. Goes away within 10-15 seconds of continuous run. Same noise would also reoccur when towing a load.
NHTSA complaint #11749885 — an unverified report by a vehicle owner.
ENGINE
Vehicle's replacement motor from GM recall (2nd motor) failed at 6200 miles. Rear tires briefly lock up causing slight swerving before the system shifted to "N"eutral. Upon restart, starter was unable to crank over seized engine. DTC confirmed P0016 crank shaft position out of alignment.
NHTSA complaint #11749609 — an unverified report by a vehicle owner.
ENGINE
We purchased our 2022 Chevrolet Silverado 1500 ZR2 in XXX, it was discovered in the purchase process that the vehicle had an active recall on the engine which was pending a "fix." This was completely downplayed by the dealership as a minor issue that would be addressed. We waited several weeks for the "fix," which was essentially a change in the oil viscosity. On XXX, our [XXX] son, was out of town, driving the vehicle, which suddenly lost all power on the highway leaving him completely stranded. The vehicle would not turn over at all or even shift into neutral. There were no warning signs, no sensors activated, in fact, the Chevy App showed (and still shows) the vehicle as "everything looks good" "no diagnostic issues!" We had the vehicle towed back to our hometown/dealership (Missoula, Chevrolet in Missoula, MT), where it has now been determined, the engine completely seized up/failed, the original "fix" was not adequate, and we are now waiting for a new engine to be put into the vehicle! After reading about other vehicle owners experiences, I am quite skeptical of the new engine as there have been multiple experiences where the new engines had the same issue. This recall is impacting the safety of drivers, most concerning was our [XXX] left stranded in a rural area with very spotty cell service, and the vehicle would not even shift to neutral to get it to a safer area, this needs to be addresses as soon as possible to prevent others from being put into this situation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11748484 — an unverified report by a vehicle owner.
ENGINE
Truck continues to shutter after having the torque converter replaced and the 2nd injector replaced. Been in the shop several times over the last few years, and still giving warnings on the dash saying, reduce acceleration drive safely. Feel like we just got a terrible vehicle. Almost paid off, and it’s just unreliable. Sadly we need this truck every single day, and the local dealerships have now pushed the problem out so far that we’re passed out 60k warranty period.
NHTSA complaint #11748331 — an unverified report by a vehicle owner.