Owners have filed 845 complaints
about the 2022 Chevrolet Silverado 1500 with NHTSA between 2021 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 13 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 58
Against the median year of the Chevrolet Silverado 1500. 50 means typical for this
model; 100 means roughly double.
Severity — 21
4.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 84
49% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2022 compares with every other Chevrolet Silverado 1500
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Warnings
1423.3%
Body
915.0%
Assist
813.3%
Latch
813.3%
Warnings
610.0%
Automatic Emergency Braking
610.0%
Adaptive Cruise Control
610.0%
Blind Spot Detection
35.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
32.5%
1,000 – 9,999 miles
1411.7%
10,000 – 24,999 miles
2420.0%
25,000 – 49,999 miles
3025.0%
50,000 – 74,999 miles
2621.7%
75,000 – 99,999 miles
1411.7%
100,000 – 149,999 miles
97.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2021peak 60Aug 2026
NHTSA investigations into the 2022 Chevrolet Silverado 1500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
2
investigations are
still open.
EA26005Opened 20 Aug 2026Still openENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
EA25007Opened 23 Oct 2025Still openENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to...
RQ26001Opened 16 Jan 2026Closed 20 Aug 2026ENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
PE25001Opened 16 Jan 2025Closed 23 Oct 2025ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing...
Recalls on the 2022 Chevrolet Silverado 1500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
26V083000
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE
General Motors, LLC is recalling certain 2020 Chevrolet Silverado 2500, 3500, GMC Sierra 2500, 3500, and 2020-2022 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles that may have been repaired incorrectly under recall 24V797. The transmission control valve may fail and cause the rear wheels to lock up.
Risk: Rear wheel lock up increases the risk of a crash.
25V274000
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Risk: Engine failure increases the risk of a crash.
24V797000
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE:SOFTWARE
General Motors, LLC (GM) is recalling certain 2020-2022 Chevrolet Silverado 1500, 2500, 3500, GMC Sierra 1500, 2500, 3500, 2021 Cadillac Escalade, Escalade ESV, Chevrolet Tahoe, Suburban, GMC Yukon, and Yukon XL vehicles equipped with diesel engines. The transmission control valve may fail and cause the rear wheels to lock-up.
Risk: Rear wheel lock-up can increase the risk of a crash.
22V903000
EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
22V873000
AIR BAGS: AIR BAG/RESTRAINT CONTROL MODULE
General Motors, LLC (GM) is recalling certain 2022 Chevrolet Silverado 1500 vehicles. The sensing diagnostic module (SDM) was left in manufacturing mode and not activated at the assembly plant prior to shipment. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: An SDM in manufacturing mode will not deploy the vehicle's air bags in a crash, increasing the risk of occupant injury.
22V463000
EXTERIOR LIGHTING:BRAKE LIGHTS
General Motors (GM) has decided that certain 2022 model year Chevrolet Silverado, and GMC Sierra vehicles equipped with an accessory sport bar. The accessory sport bar contains a high-mounted brake light that may not function. In addition, it may block the vehicle's existing high-mounted brake light. As such, these vehicles may fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "lamps, reflective devices, and associated equipment."
Risk: An inoperative high-mounted brake light can reduce visibility to other drivers and increase the risk of a crash.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 67,000 milesPortsmouth, NHFire3 injured
ENGINE
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving approximately 30 MPH and towing a trailer on Route 16 with his children inside the vehicle, within 10 minutes of driving, there was smoke coming from underneath the vehicle and entering the cabin. There were no warning lights illuminated. The driver pulled over safely. Additionally, the contact stated that there was no issue prior to the failure. First responders arrived on the scene but were unable to use fire extinguishers to contain the fire. The contact called 9-1-1. Within approximately 10 minutes, the vehicle was fully engulfed in flames, which reached an estimated height of 10 feet. A Police report and a Fire Department report were filed. The driver and his two children sustained smoke inhalation. The contact's daughter was vomiting; however, medical attention was not provided. The contact stated that a nearby vehicle and the trailer were damaged from the fire. The vehicle was towed to a tow yard. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 67,000.
NHTSA complaint #11754645 — an unverified report by a vehicle owner.
Virginia Beach, VA1 injured
UNKNOWN OR OTHER
the rear window did not stop when a child's hand was in the closing space. The [XXX] old's hand was caught, causing injury and pain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11719507 — an unverified report by a vehicle owner.
Elkton, MDCrash
ENGINE
I own a 2022 Chevy Silverado with a 6.2 liter engine. I had the original engine up until approx 80k in mileage when it failed, I was on a dark country road doing approximately 50mph and the propulsion system failed and the truck shut off, being a country road, I had minimum breaking and minimal steering. I had my [XXX] son in the car, we ended up in a culvert and I scraped either a large rock or a piece of concrete that sometimes line culverts, it did damage. At the time, until recently, I had no idea I should report this. I did know that GM had issued a recall and I believed the engineer would be covered, which it was. I never reported the damage to insurance as I didn't want my ins to go up anymore, so I have not fixed it yet. My [XXX] old was scared beyond belief. Anyhow, Williams Chevy in Elkton, Md replaced the engine free of any cost. I believe the dates are approx to be 9/26 to 10/25/ 2025.On or about 11/25 or 26th 2025, with approx 2k miles on the newly installed 6.2 liter engine, while traveling with my [XXX] son, I experienced another catastrophic engine failure.This time we were traveling on 896 in Delaware and rt 40. While crossing over, the car cut off completely again while traveling at 50mph. We barely avoided a collision on the other side of the intersection with merging traffic, I applied the Manuel breaks along with the power steering was out too. My spouse was angry that GM is still doing this knowing this could be the result.Upon the 2nd installation, I dropped the truck off on the above date. It took until 1/5/26 bor approx 1/9/26.On approx 2/12/26 I had the oil changed at a local jiffy lube. This was conducted at 3400 miles, less than the manufacturer suggests with the new 40w oil. Anyhow, yet again, my truck had zero rewarding on the dipstick. I have paperwork for both engine installs and the jiffy lube paperwork documenting the no reading on the dip stick.I am a disabled veteran and this is an unsafe and unreliable fix from GM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO
NHTSA complaint #11718442 — an unverified report by a vehicle owner.
Elkton, MDCrash
FUEL/PROPULSION SYSTEM
I own a 2022 Chevy Silverado with a 6.2 liter engine. I had the original engine up until approx 80k in mileage when it failed, I was on a dark country road doing approximately 50mph and the propulsion system failed and the truck shut off, being a country road, I had minimum breaking and minimal steering. I had my [XXX] son in the car, we ended up in a culvert and I scraped either a large rock or a piece of concrete that sometimes line culverts, it did damage. At the time, until recently, I had no idea I should report this. I did know that GM had issued a recall and I believed the engineer would be covered, which it was. I never reported the damage to insurance as I didn't want my ins to go up anymore, so I have not fixed it yet. My [XXX] old was scared beyond belief. Anyhow, Williams Chevy in Elkton, Md replaced the engine free of any cost. I believe the dates are approx to be 9/26 to 10/25/ 2025.On or about 11/25 or 26th 2025, with approx 2k miles on the newly installed 6.2 liter engine, while traveling with my [XXX] son, I experienced another catastrophic engine failure.This time we were traveling on 896 in Delaware and rt 40. While crossing over, the car cut off completely again while traveling at 50mph. We barely avoided a collision on the other side of the intersection with merging traffic, I applied the Manuel breaks along with the power steering was out too. My spouse was angry that GM is still doing this knowing this could be the result.Upon the 2nd installation, I dropped the truck off on the above date. It took until 1/5/26 bor approx 1/9/26.On approx 2/12/26 I had the oil changed at a local jiffy lube. This was conducted at 3400 miles, less than the manufacturer suggests with the new 40w oil. Anyhow, yet again, my truck had zero rewarding on the dipstick. I have paperwork for both engine installs and the jiffy lube paperwork documenting the no reading on the dip stick.I am a disabled veteran and this is an unsafe and unreliable fix from GM. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO
NHTSA complaint #11718442 — an unverified report by a vehicle owner.
Ringle, WICrash
SUSPENSION
I was pulling out onto the road and heard a noise in the front and right after my upper ball joint snapped completely off folding the tire underneath the truck and smashing the whole front end. Very lucky I was not on the highway. Had truck towed into my shop where after examination part failed prematurely. My insurance paid for it all which was just short of $10,000 in damage minus my $500 deductible and the tow bill. Now I have lost my safe driving deduction because of this claim, which caused my insurance to skyrocket. There were no prior warning signs, and I have my vehicle serviced and inspected regularly at my service provider.
NHTSA complaint #11714109 — an unverified report by a vehicle owner.
West Babylon, NYCrash
STRUCTURE:BODY
Was taking an exit car felt like lose control and got hit with the sign pole on the exit. I have been complaining for the safety reasons and the location and other issues in car to onstar and Chevy for months. Went to Freeport Chevy dealer and changed oil, when I bought the car pre-approved but the when I went for the service they said no oil was changed since the car was new. And I have been paying for all the warranty and extended service but they said all oil change and others will cost approx $3200. They changed the oil but I have been seeing on the Chevy app filter was never changed and the car didn’t feel same after the service.
NHTSA complaint #11705741 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Glen Daniel, WV
POWER TRAIN
2022 Silverado RST with the L87 engine loss propulsion in traffic of Memorial day weekend with approximately 43,800 miles on the vehicle. Has since been fixed by Chevrolet dealership. Also passed their Pico test, changed oil viscosity and oil cap still failed after their test.
NHTSA complaint #11758587 — an unverified report by a vehicle owner.
Torrance, CA
SUSPENSION
The front upper control arm failed and the driver side wheel collapsed. There was no warning. Luckily I wasn’t pulling my RV camper down a mountain, it could have been catastrophic . I towed it to Carson Chevrolet. They gave me an estimate of $6,000 + for repairs. They had no reasonable explanation.
NHTSA complaint #11758468 — an unverified report by a vehicle owner.
Charlotte, MI
ELECTRICAL SYSTEM
While traveling in bumper to bumper highway traffic in my 2022 Chevrolet Silverado RST, I attempted to accelerate and the vehicle suddenly malfunctioned. I experienced sever loss/restriction of propulsion and the vehicle would not respond normally to accelerator input. I was able to maneuver toward the shoulder of the road while avoiding a major multi-car pile up involving innocent motorists. When I attempted to stop, I did not have normal braking ability and was unable to stop in the manner I expected. I had to use the shoulder of the highway to slow the truck down until I could come to a complete stop. This created an immediate risk of serious or fatal collision on the highway, and as I maneuvered the truck out of traffic to the side of the road. Had I been unable to reach the shoulder of the road, I could have been struck by surrounding traffic. Had this failure occured un an urban area or at an intersection, near pedestrians, or at a school bus stop- I could have seriously injured or killed people or myself. After I was able to come to a complete stop. I shut it off and turned it back on, then the truck read there was no gas left (I had a 1/2 tank). This incident is not isolated electronic glitch, I have experienced electrical malfunctions including the truck failing to start, unlocking, responding at all. This all occured after an engine replacement due to a recall. I am concerned that there are unresolved electrical and power-distribution, communication-network, propulsion or braking issues that presents a serious safety risk to myself and others. My concern is that if this malfunction occurred on my drive to work in the city, around pedestrians- it could have resulted in multiple fatalities.
NHTSA complaint #11758426 — an unverified report by a vehicle owner.
Charlotte, MI
ENGINE
While traveling in bumper to bumper highway traffic in my 2022 Chevrolet Silverado RST, I attempted to accelerate and the vehicle suddenly malfunctioned. I experienced sever loss/restriction of propulsion and the vehicle would not respond normally to accelerator input. I was able to maneuver toward the shoulder of the road while avoiding a major multi-car pile up involving innocent motorists. When I attempted to stop, I did not have normal braking ability and was unable to stop in the manner I expected. I had to use the shoulder of the highway to slow the truck down until I could come to a complete stop. This created an immediate risk of serious or fatal collision on the highway, and as I maneuvered the truck out of traffic to the side of the road. Had I been unable to reach the shoulder of the road, I could have been struck by surrounding traffic. Had this failure occured un an urban area or at an intersection, near pedestrians, or at a school bus stop- I could have seriously injured or killed people or myself. After I was able to come to a complete stop. I shut it off and turned it back on, then the truck read there was no gas left (I had a 1/2 tank). This incident is not isolated electronic glitch, I have experienced electrical malfunctions including the truck failing to start, unlocking, responding at all. This all occured after an engine replacement due to a recall. I am concerned that there are unresolved electrical and power-distribution, communication-network, propulsion or braking issues that presents a serious safety risk to myself and others. My concern is that if this malfunction occurred on my drive to work in the city, around pedestrians- it could have resulted in multiple fatalities.
NHTSA complaint #11758426 — an unverified report by a vehicle owner.
Belgrade, MT
ENGINE
Component/system failed: The 6.2L L87 engine. The engine ultimately seized and the vehicle became inoperable. The engine should be available for inspection because it is being replaced under GM Special Coverage N252494003. Safety risk: The engine unexpectedly shut off while driving at highway speeds. Loss of propulsion in traffic creates a significant collision risk. The inability to restart left the vehicle disabled. Confirmed: An independent repair facility confirmed that the engine was seized prior to towing it to the GM dealer. Yesterday the GM dealer confirmed i had a seized engine and it was going to be replacement under N252494003 special coverage entention. Inspections: My truck was inspected in October 25, for the recall. My truck passed this test, and was subsequently was told my oil spec has been revised. Warnings/symptoms: no warning was given
NHTSA complaint #11758561 — an unverified report by a vehicle owner.
Charlotte, MI
SERVICE BRAKES
While traveling in bumper to bumper highway traffic in my 2022 Chevrolet Silverado RST, I attempted to accelerate and the vehicle suddenly malfunctioned. I experienced sever loss/restriction of propulsion and the vehicle would not respond normally to accelerator input. I was able to maneuver toward the shoulder of the road while avoiding a major multi-car pile up involving innocent motorists. When I attempted to stop, I did not have normal braking ability and was unable to stop in the manner I expected. I had to use the shoulder of the highway to slow the truck down until I could come to a complete stop. This created an immediate risk of serious or fatal collision on the highway, and as I maneuvered the truck out of traffic to the side of the road. Had I been unable to reach the shoulder of the road, I could have been struck by surrounding traffic. Had this failure occured un an urban area or at an intersection, near pedestrians, or at a school bus stop- I could have seriously injured or killed people or myself. After I was able to come to a complete stop. I shut it off and turned it back on, then the truck read there was no gas left (I had a 1/2 tank). This incident is not isolated electronic glitch, I have experienced electrical malfunctions including the truck failing to start, unlocking, responding at all. This all occured after an engine replacement due to a recall. I am concerned that there are unresolved electrical and power-distribution, communication-network, propulsion or braking issues that presents a serious safety risk to myself and others. My concern is that if this malfunction occurred on my drive to work in the city, around pedestrians- it could have resulted in multiple fatalities.
NHTSA complaint #11758426 — an unverified report by a vehicle owner.
Glen Daniel, WV
FUEL/PROPULSION SYSTEM
2022 Silverado RST with the L87 engine loss propulsion in traffic of Memorial day weekend with approximately 43,800 miles on the vehicle. Has since been fixed by Chevrolet dealership. Also passed their Pico test, changed oil viscosity and oil cap still failed after their test.
NHTSA complaint #11758587 — an unverified report by a vehicle owner.
Eden Prairie, MN
ELECTRICAL SYSTEM
The digital dashboard display began to flicker. Off more so than on making the dash unreadable. No speedometer, no fuel gauge, no gauges of any kind. When you received an audible notification from the vehicle, you had no way to see the message. As far as any vehicular information, you were not able to see anything.
NHTSA complaint #11758384 — an unverified report by a vehicle owner.
Shamong, NJ
ENGINE
The vehicle previously received the official GM Recall Campaign 25V-274 remedy/inspection, but suffered catastrophic engine failure and sudden loss of propulsion afterwards.
NHTSA complaint #11758156 — an unverified report by a vehicle owner.
Williamstown, NJ
POWER TRAIN
I own a 2022 Chevrolet silverado 1500 that is jumping and jolting. There is currently a federal recall and the dealership is denying to fix it for free under recall because our VIN is not yet listed, despite the vehicle suffering from the exact transmission failure reported for the same year, make and model. This matches the exact parameters of Safety Recall N252516560. The vehicle is unsafe to drive
NHTSA complaint #11757685 — an unverified report by a vehicle owner.
at 65,000 milesSan Antonio, TX
ENGINE AND ENGINE COOLING
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that the engine temperature increased while driving approximately 60 - 70 MPH. The message “Reduced Speed due to High Temperature” was displayed. The temperature gauge increased to high and then down to low. There were no warning lights illuminated. The contact stated that the failure was caused by the coolant control valve. The vehicle was taken to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The contact was advised that an error message needed to be displayed before moving forward. The failure mileage was approximately 65,000.
NHTSA complaint #11757746 — an unverified report by a vehicle owner.
Summerville, SC
POWER TRAIN
Automatic transmission failed due to code P0722 (Output Speed Sensor signal lost). The vehicle experienced sudden loss of propulsion, violent/harsh shifting, and severe drivability issues while operating on the highway. Loss of forward motive power at high speeds creates an immediate collision hazard. The vehicle was previously serviced for transmission issues but the defect recurred. The vehicle remains parked and inoperable due to safety concerns.
NHTSA complaint #11757367 — an unverified report by a vehicle owner.
Safford, AZ
POWER TRAIN
I have a 2022 silverado ltd with the 6.2. I purchased the truck about a month and a half ago the previous owner had the 40 weight oil recall completed prior to my purchase. I had the oil changed when it said 45 percent life remaining far before it was due a certified chevy dealer completed the oil change with the 40 weight correct oil. Well about 8 days ago I went out and started the truck and heard a clunk sound like a failing starter would make. So later that day I notice a ticking noise as well as a chirping noise. Coming from engine bay. I made note of it. Ever since the noise began I have kept close eyes on it the ticking and chirping rise and fall when I give it gas. Yesterday when I started it the clunk noise happened but this time I felt a shudder or stutter I looked at the rpms and they didn't move at all with the shudder. I have an appointment Monday morning to take it to the dealer I looked into the recall for the thicker oil. And learned that this motor is pretty much junk and multiple issues I haven't driven it since yesterday because the issues I'm having correspond with complete engine failure at any point and I do not want to be on the highway and it happen that would put me and other motorist at risk injury. There has been no warning lights no engine light just the initial clunk the first time and since that it's just been getting worse
NHTSA complaint #11757236 — an unverified report by a vehicle owner.
Safford, AZ
ENGINE
I have a 2022 silverado ltd with the 6.2. I purchased the truck about a month and a half ago the previous owner had the 40 weight oil recall completed prior to my purchase. I had the oil changed when it said 45 percent life remaining far before it was due a certified chevy dealer completed the oil change with the 40 weight correct oil. Well about 8 days ago I went out and started the truck and heard a clunk sound like a failing starter would make. So later that day I notice a ticking noise as well as a chirping noise. Coming from engine bay. I made note of it. Ever since the noise began I have kept close eyes on it the ticking and chirping rise and fall when I give it gas. Yesterday when I started it the clunk noise happened but this time I felt a shudder or stutter I looked at the rpms and they didn't move at all with the shudder. I have an appointment Monday morning to take it to the dealer I looked into the recall for the thicker oil. And learned that this motor is pretty much junk and multiple issues I haven't driven it since yesterday because the issues I'm having correspond with complete engine failure at any point and I do not want to be on the highway and it happen that would put me and other motorist at risk injury. There has been no warning lights no engine light just the initial clunk the first time and since that it's just been getting worse
NHTSA complaint #11757236 — an unverified report by a vehicle owner.
Brooklyn, NY
ENGINE
The motor seized. My life was at risk. I was on the highway. The vehicle was reported to the Chevy dealership and diagnose that the motor is locked.
NHTSA complaint #11757202 — an unverified report by a vehicle owner.
Bermuda Run, NC
ENGINE
* Engine/ Yes available for inspection. * Has not happened yet, however the risk exists. * Yes, oil consumption and has been confirmed by dealer and monitored every 1,000 miles. * Been inspected by local dealer only. * Yes, low oil pressure light came on. I was 2 qtrs. LOW, XXX My vehicle was inspected and according to them "passed". 0W-40 was introduced and a new oil cap indicates the change. GM explains that it is acceptable to burn up to 2 qtrs. of oil between oil changes. They have me come to the dealer every 1,000 miles to check the oil level. I came back from a work-related function, putting approx. 220 miles. It was time for oil level inspection, and my engine was found to be 1/2qtr. LOW. I ask them to top it off and I was told; “we do not stock this oil in bulk; you have to buy a qt. and we'll put it in." I have been a car owner since I was [XXX], now [XXX] and have never heard such nonsense in my life. In fact, in my lifetime, I have NOT experienced engine burning oil. This is a 6.2 liter with 57,700 and my fear is that something catoptric will happen to the motor resulting in no recourse. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11756893 — an unverified report by a vehicle owner.
East Troy, WI
POWER TRAIN
Transmission failed at 38,000 miles. Downshifted violently while driving and couldn't keep up with the 35mph speed limit. Was luckily not on a highway or far from home. Dealership noted it's a common valve body issue in the transmission. No inspections, vehicle has a branded title (hail) and Chevy claims no responsibility for the transmission failure. 0 warning signs or issues.
NHTSA complaint #11756631 — an unverified report by a vehicle owner.
Mcgregor, TX
ENGINE
I was driving down the road and all of a sudden the check engine light came on, the check the parking brake light came on, and the service electronic stability control system light came on. The engine then started making a knocking sound. These trucks have a known lifter issue. I had a 2021 that had the same problem. It was still under warranty so I was able to get out from under it. This one isn’t and they want $9,000 to replace the engine. There is a recall on the 6.2 liter but not for the 5.3 liter for some reason. These engines have an issue
NHTSA complaint #11756437 — an unverified report by a vehicle owner.
Bear, DE
ENGINE
While driving 65mph on the highway the engine locked up and shut down. There was a loss of propulsion and steering making it difficult to safely maneuver off the highway.
NHTSA complaint #11755896 — an unverified report by a vehicle owner.
at 20,000 milesSomerville, MA
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
The contact owns a 2022 Chevrolet Silverado1500. The contact stated that while driving at an undisclosed speed, the tailgate unexpectedly opened. The contact stated that the failure was a recurring failure. The dealer was contacted and stated that there was a related recall for the failure; however, the recall was only for vehicles manufactured in Canada. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.
NHTSA complaint #11755223 — an unverified report by a vehicle owner.
at 67,000 milesPortsmouth, NHFire3 injured
ENGINE
The contact owns a 2022 Chevrolet Silverado 1500. The contact stated that while driving approximately 30 MPH and towing a trailer on Route 16 with his children inside the vehicle, within 10 minutes of driving, there was smoke coming from underneath the vehicle and entering the cabin. There were no warning lights illuminated. The driver pulled over safely. Additionally, the contact stated that there was no issue prior to the failure. First responders arrived on the scene but were unable to use fire extinguishers to contain the fire. The contact called 9-1-1. Within approximately 10 minutes, the vehicle was fully engulfed in flames, which reached an estimated height of 10 feet. A Police report and a Fire Department report were filed. The driver and his two children sustained smoke inhalation. The contact's daughter was vomiting; however, medical attention was not provided. The contact stated that a nearby vehicle and the trailer were damaged from the fire. The vehicle was towed to a tow yard. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 67,000.
NHTSA complaint #11754645 — an unverified report by a vehicle owner.
Lebanon, TN
POWER TRAIN
Transmission failure with no electronic warning or codes. Hard shifting was identified while under warranty but because no codes were present no action was taken to correct the issue.
NHTSA complaint #11754410 — an unverified report by a vehicle owner.
Aurora, IL
ENGINE
Engine sudden loss of propulsion while driving on interstate w/out warning. Pulled to side and check engine light and hot oil warning came on prior to engine dying. Had to call tow and dealer says engine needs to be replaced but they won’t ship vehicle back after repair and it’s 4 hours from my house, that I need to pick it up
NHTSA complaint #11754171 — an unverified report by a vehicle owner.
Chicago, IL
POWER TRAIN
When driving, the vehicle’s computer detects an issue with the vehicle’s transmission and throws a “Reduced acceleration. Drive with care” which causes a strong jerk like if the wheel locked up momentarily. The check engine also turns on and the vehicle stays stuck in 5th gear at all times. Code P0747 is thrown as well.
NHTSA complaint #11752321 — an unverified report by a vehicle owner.
Kelso, WA
POWER TRAIN
VEHICLE: 2022 Chevrolet Silverado 1500, VIN [XXX] DEFECT: Transmission suddenly, violently downshifts from a high gear to a much lower gear with no driver input, at highway speed. Causes RPM spike, violent jerking, Check Engine Light, loss of vehicle control. Occurred 5 times. Not fixed despite 4 dealer repairs, 61 days out of service. 5/12/26 - 1st failure, 70+ mph on I-5, stuck in low gear. 5/14-6/8/26 - Repair 1, Bud Clary Chevrolet: valve body solenoid replaced. 6/13/26 - 2nd failure days later, Hwy 12 (no cell service), spouse + [XXX] infant in vehicle, forced to keep driving to reach safety. 6/13-6/17/26 - Repair 2, Harvest Chevrolet: same fault codes; valve body connector found loose. 6/17/26 - 3rd failure, same day picked up, same [XXX] location. 6/19-6/26/26 - Repair 3, [XXX] Chevrolet Diagnosed by TSB#25-NA-301: wiring found chafed/pinched. Dealer's own paperwork says cause of fault codes could not be determined. I requested full internal transmission inspection; declined. 6/26/26 - 4th failure, same day picked up, ~100 mi later, [XXX] [XXX], family in vehicle. Dealer denied promised tow after 4-hr wait; transport arranged. 7/1-7/17/26 - Repair 4, [XXX]: GM's national Technical Assistance Center directed wiring circuit replacement (GMTAC Case #XXX). Again requested internal inspection; again declined. Service tech said GM engineering was dictating repairs and I'd "just need to drive it until it fails again." 7/20/26 - 5TH FAILURE: XXX near mile marker 24 (Kalama/Woodland, WA), ~75 mph, [XXX] in vehicle. Uncommanded downshift nearly forced my truck into an adjacent semi-truck. Same day picked up from Repair 4. SUMMARY: Code P0776 present at every repair; P0716/P0717 recur. 4 fixes attempted, none resolved it. Internal inspection requested twice, denied twice. Near-collisions XXX and XXX. Infant in vehicle for 2 incidents. 2nd owner; active GM powertrain warranty through XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11751979 — an unverified report by a vehicle owner.