Chevrolet Silverado fuel system problems

FUEL/PROPULSION SYSTEM

UPON STARTUP.. ENGINE IDLE WAS ROUGH. CHECK ENGINE LIGHT CAME ON. CODE P050D WAS FOUND. TOOK IT TO A MECHANIC AND THE INJECTORS ARE BAD

NHTSA complaint #11319257 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ALL FUEL INJECTORS IN "BANK 1" BECAME FAULTY AND NEED REPLACING IMMEDIATELY WITH LITTLE TO NO WARNING OF ISSUES. CHECK ENGINE LIGHT CAME ON AFTER MULTIPLE INJECTORS BECAME FAULTY. CHECK ENGINE LIGHT CAME ON WHILE TRAVELING ON A STRAIGHT ROAD AFTER 2 MINUTES OF HIGHWAY TRAVEL GOING 70 MPH. *LN CONSUMER STATED I'D LIKE TO ADD THE FOLLOWING INFORMATION TO MY REPORT. AFTER LOOKING FURTHER ON THE NHTSA WEBSITE, I CAME ACROSS INFORMATION IN THE 'MANUFACTURER COMMUNICATIONS' SECTION OF THE WEBSITE PERTAINING TO 2017 CHEVROLET SILVERADO 1500'S. THE NHTSA ID NUMBER IS 10163854, AND MANUFACTURER COMMUNICATION NUMBER IS N182198000. IN THIS LETTER IT EXPLAINS ISSUES WITH BANK 1 FUEL INJECTORS, AND WHAT I EXPERIENCED WITH MY PICKUP. UNDER THE 'CONDITIONS' SECTION OF THIS LETTER, PAGE 1, MY VEHICLE MEETS ALL THE CONDITIONS ASIDE FROM LIVING IN WYOMING AND NOT ONE OF THE 13 STATES LISTED. MY PICKUP IS A 2017 CHEVROLET SILVERADO WITH A 5.3L ENGINE, THE MALFUNCTION INDICATOR LAMP ILLUMINATED, I TOOK MY VEHICLE TO GARVIN MOTORS IN POWELL, WY, AND THEY SAID A DIAGNOSTIC TROUBLE CODE RETURNED WITH FUEL TO AIR RATIO ISSUE IN BANK 1. UPON FURTHER DIAGNOSTICS IT WAS REVILED THE FUEL INJECTORS NEED REPLACING IN BANK 1, JUST AS STATED IN THIS LETTER FROM GM. I HAVE BEEN IN CONTACT WITH TWO GM DEALERS IN THE AREA, AND I HAVE BEEN QUOTED TWO PRICES TO REPLACE PARTS LISTED ON THIS DOCUMENT FROM GM. I HAVE ALSO REACHED OUT TO GM, AND THEY SAID THEY WILL RESEARCH THIS LETTER MORE AND GET BACK WITH ME. I AM NOW TWO WEEKS WITHOUT A VEHICLE WHILE THE DEALERSHIP IS DEMANDING I MAKE A DECISION TO HAVE REPAIRS DONE, HOW I WILL BE ABLE TO PAY FOR REPAIRS UPON COMPLETION, AND GM CUSTOMER SUPPORT WILL NOT TAKE MY CALLS WITH TELLING ME THEY WILL BE CALLED BACK. I HAVE SPOKEN TO GM THREE TIMES ABOUT THIS WITH EACH TIME STATING THEY NEED TO LOOK INTO THE MATTER FURTHER. DENNY MENHOLT DEALERSHIP LOCATED IN CODY, WY, CURRENTLY HAS MY PICKUP WITH NO REPAIRS STARTED AT THIS TIME.

NHTSA complaint #11269972 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

MY 2017 SIVERADO WITH LESS THAN 50,000 MILES IS AT THE DEALERSHIP, DUE TO A DEFECTIVE FUEL INJECTOR ON THE #7 CYLINDER. I AM BEING TOLD IT IS NOT UNDER WARRANTY, AND THAT I WILL HAVE TO BARE THE COST OF THE REPAIR. I DO NOT FEEL THAT ON A TWO YEAR OLD VEHICLE, THAT THE FUEL INJECTOR SHOULD FAIL, NOR SHOULD I BARE THE COST OF REPLACEMENT. I AM NOT ASKING FOR A RESOLUTION, I JUST WANT OTHER TO BE AWARE OF THE DEFECT.

NHTSA complaint #11242229 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2017 CHEVROLET SILVERADO. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 19V088000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. RODENROTH MOTORS INC (3055 S MACKINAC TRAIL, SAULT STE. MARIE, MI 49783, (906) 662-4756) WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA complaint #11220999 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ENGINE HESITATION, OR MISFIRING. JERKING, OR TRANSMISSION SHUTTERING WHEN ENGINE IS AT LOW RPM AND ON INCLINE. (I.E. WHEN TRAVELING ABOUT 45MPH AND START UP A HILL, THE RPM'S ARE ABOUT 1300, AND THE TRANSMISSION DOESN'T GEAR DOWN, SO IT STARTS SHUTTERING UNTIL YOU GIVE IT MORE ACCELERATION THAN USUAL.) AFTER DEALING WITH THIS ISSUE FOR NEARLY 8 MONTHS AND 15K MILES, I BELIEVE THIS SAFETY ISSUE SHOULD BE RECALLED. DEALER ORIGINALLY ACKNOWLEDGE THE PROBLEM BUT WAS UNSURE OF THE CAUSE. AFTER 5 REPAIR ATTEMPTS THE DEALER SAY THEY CAN'T DUPLICATE AND THE VEHICLE PERFORMS AS DESIGNED.

NHTSA complaint #11112166 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE HESITATION AND SURGES IN ACCELERATION. THIS CONDITION IS A SAFETY ISSUE AS IT HESITATES PULLING INTO TRAFFIC, SURGES IN ACCELERATION HAVE CAUSED LOSS OF TIRE TRACTION ON ICE COVERED ROADWAYS NEARLY RESULTING IN A COLLISION. DEALERS HAVE ACKNOWLEDGED AN ISSUE BUT ADVISE THEY ARE STILL WAITING ON A FIX FROM GM.

NHTSA complaint #11081511 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL GAUGE WILL DROP TO EMPTY AND FUEL LIGHTS LIGHT COMES ON EVEN THOUGH THERE IS MORE THAN A HALF TANK OF GAS I USUALLY KEEP TANK ONCE IT DROPS TO BELOW A HALF TANK. SOMETIME I JINGLE MY KEYS AND IT WILL GO BACK UP SOMETIMES NOTHING.

NHTSA complaint #10853868 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS RESTARTED THE NEXT DAY AND WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP MODULE WAS CORRODED AND FULL OF WATER. THE FUEL PUMP MODULE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

NHTSA complaint #10851198 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

SIGNIFICANT CORROSION OF THE FUEL (GASOLINE) LINES CAUSING LEAK AND POSSIBLE SAFETY HAZARD (FIRE). SEVERAL FORUMS REPORT BRAKE AND FUEL LINE PREMATURE FAILURE DUE TO CORROSION. GM NOT ADDRESSING THIS KNOWN PROBLEM.

NHTSA complaint #10838689 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL LEAKING FROM ENGINE. WITH 9595 MILES ON THE ENGINE THE TRUCK LEAKS FUEL FROM THE ENGINE LIKE CRAZY. VEHICLE IS 6 MONTHS OLD. CAN'T GET CHEVY TO PICKUP THE RIG BECAUSE THEY SAY I NEED TO CALL THE FIRE DEPARTMENT - THE FIRE DEPARTMENT TELLS ME THERE IS NOTHING THEY CAN DO - BEEN BATTLING WITH CHEVY ALL DAY ON THIS. ITS A SAFETY HAZARD CABIN SMELLS LIKE THE INSIDE OF A GAS TANK - I DON'T FEEL SAVE DRIVING IT ANYWHERE.

NHTSA complaint #10821757 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

PURCHASED USED VEHICLE FROM DEALER (DANIELS CHEVROLET, BUICK, GMC TRUCKS, INC. SWAINSBORO, GA) AND AFTER SALE DISCOVERED EMISSION SYSTEM WAS DISABLED AND DPF (DIESEL PARTICULATE FILTER) HAD BEEN PHYSICALLY REMOVED; PROBABLY BY PREVIOUS OWNER.

NHTSA complaint #10816648 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2007 CHEVROLET SILVERADO. THE CONTACT STATED THAT THERE WAS CORROSION ON THE FUEL LINES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE FUEL LINE WAS CORRODED AND IT NEEDED TO BE REPLACED. THE CONTACT MENTIONED THAT THE FUEL LINES HAD PREVIOUSLY CORRODED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT PROVIDED.

NHTSA complaint #10810677 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FUEL LEAKING/SPRAYING OUT OF THE REAR AUXILIARY FUEL TANK. I NOTICED A STRONG SMELL OF RAW GASOLINE COMING FROM THE REAR OF THE VEHICLE. UPON FURTHER INSPECTION I OBSERVED THE RAW FUEL WAS COMING OUT OF THE FUEL MODULE CONNECTING FUEL LINE. THE METAL FUEL LINE SITS IN A WELL OF THE REAR TANK AND WAS COMPLETELY COVERED WITH DIRT/MOISTURE/RAW FUEL. THE TANK WAS REMOVED AND WE IMMEDIATELY NOTICED THAT THE METAL PORTION OF THE FUEL MODULE METAL PIPING WAS RUSTED THRU AND THAT WAS WHERE THE RAW FUEL WAS BEING SPRAYED/POOLING IN THE WELL AREA. THE DESIGN OF THE FUEL TANK & MODULE CREATES A PERFECT LOCATION FOR DIRT/MOISTURE TO ACCUMULATE. ANY TYPE OF IGNITION SOURCE COULD HAVE CAUSED A CATASTROPHIC FIRE AND POSSIBLE EXPLOSION. THE REMOVED ORIGINAL FUEL MODULE WAS IN PERFECT WORKING CONDITION EXCEPT FOR THE ROTTED METAL PORTION OF THE MODULE. I REPLACED THE ROTTED FUEL MODULE WITH A NEW GM OEM FUEL MODULE. THIS NEW MODULE HAS THE SAME EXACT CONSTRUCTION AS THE ORIGINAL PART. SINCE THERE IS NO POSSIBLE WAY TO CLEAN OR KEEP CLEAN THE WELL AREA OF THE TANK, I CAN ONLY ASSUME THE NEW OEM PART WILL DETERIORATE IN THE SAME MANNER. THE VEHICLE HAD ABOUT 34000 MILES ON IT WHEN THE CONDITION OCCURRED. SINCE IT IS OUT OF WARRANTY THE NEW MODULE COSTS FOR LABOR AND PARTS WAS IN EXCESS OF $1000.00. IN CONCLUSION I THINK THIS MATTER SHOULD BE INVESTIGATED FURTHER BECAUSE IT IS OBVIOUSLY A SAFETY HAZARD INVOLVING RAW FUEL BEING EJECTED FROM THE FUEL TANK UNDER PRESSURE WHILE THE PUMP IS RUNNING.

NHTSA complaint #10790208 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

ON OCTOBER 22,2015 WHILE DRIVEING ON INTERSTATE 75 THE FUEL PUMP STOPPED FUNCTIONING AND RESULTING IN A NEAR DISASTEROUS SITUATION.RESULTS $751.81 REPAIR COST PLUS TOW. THEN ONE WEEK LATER,OCTOBER 29 2015 AT WILMINGTON PIKE AND INERTSTATE 675 RED LIGHT MY BRAKE LINES BURST AND I NARROWLY AVOIDED A WRECK. REPAIR COST $870.17 .I WAS NOT NOTEAFIDE OF ANY RECALL. SO BE FAIR WARNING IF I HAD KNOWN OR BEEN I WOULD HAVE FIXED IT

NHTSA complaint #10788515 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

FIRE AND DEATH HAZARD . STRONG UNBEARABLE TOXIC SMELL ENTERING UP INTO CAB.

NHTSA complaint #10786451 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I OWN A 2014 CHEVROLET SILVERADO 1500. WHILE TRAVELING T A A LOW RATE OF SPEED/UNDER 40 MPH, THERE IS A SUDDEN LOSS OF POWER. THE VEHICLE HESITATES NUMEROUS TIMES AND STALLS. THE VEHICLE ALMOST SHUTS OFF BUT RECOVERS JUST BEFORE SHUTTING OFF AND THE START OF LOSING POWER THE VEHICLE JUMPS AND STOPS. CALLED DEALER SERVICE DEPARTMENT AND WAS TOLD THERE ARE NO RECALLS FOR MY VEHICLE. THIS PROBLEM STARTED ALMOST FROME WEEK ONE AFTER PURCHASE UNTIL THIS DATE OF REPORTING.

NHTSA complaint #10783568 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT NOTICED THERE WAS A ENGINE LEAK AND NOTICED THAT A FEW BOLTS THAT HOLD THE EXHAUST PIPE WERE MISSING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

NHTSA complaint #10747067 — an unverified report by a vehicle owner.