Owners have filed 142 complaints
about the 2015 Chrysler 300 with NHTSA between 2015 and 2025.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 8 of 17 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 19
Against the median year of the Chrysler 300. 50 means typical for this
model; 100 means roughly double.
Severity — 100
21.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 68
40% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
44.0%
1,000 – 9,999 miles
88.0%
10,000 – 24,999 miles
1919.0%
25,000 – 49,999 miles
2626.0%
50,000 – 74,999 miles
2626.0%
75,000 – 99,999 miles
1010.0%
100,000 – 149,999 miles
55.0%
150,000+ miles
22.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2015peak 10Oct 2025
NHTSA investigations into the 2015 Chrysler 300
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
RQ15004Opened 24 Jul 2015Closed 5 Jan 2016ELECTRICAL SYSTEM:SOFTWARE
Software security vulnerability
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015...
Recalls on the 2015 Chrysler 300
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
19V018000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) is recalling certain 2010 Dodge Ram 3500, Ram 4500/5500, 2010-2011 Dodge Dakota, 2010-2014 Dodge Challenger, 2010-2015 Dodge Challenger, Chrysler 300, and 2010-2016 Jeep Wrangler vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Risk: In the event of a crash necessitating deployment of the passenger's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
18E053000
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
Chrysler (FCA US LLC) is recalling certain Mopar Stage 1 Kit Performance Packages Powertrain Control Modules (PCM) Part Numbers P5160023, P5160025, and Demon Crate PCM Part Number 68412287AA. The PCMs are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Risk: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
18V332000
ELECTRICAL SYSTEM:WIRING
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Risk: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
17V097000
POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT
Chrysler (FCA US LLC) is recalling certain 2014-2017 Dodge Charger and Chrysler 300 vehicles equipped with all-wheel drive (AWD). The front driveshaft bolts may loosen and allow the front driveshaft to disconnect, potentially causing a loss of motive power.
Risk: A loss of motive power can increase the risk of a crash.
15V461000
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
Chrysler (FCA US LLC) is recalling certain model year 2013-2015 Ram 1500, 2500, 3500, 4500, and 5500, 2015 Chrysler 200, Chrysler 300, Dodge Charger, and Dodge Challenger, 2014-2015 Jeep Grand Cherokee, Cherokee, and Dodge Durango, and 2013-2015 Dodge Viper vehicles. The affected vehicles are equipped with radios that have software vulnerabilities that can allow third-party access to certain networked vehicle control systems.
Risk: Exploitation of the software vulnerability may result in unauthorized remote modification and control of certain vehicle systems, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201901679,206 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 2018396142 units in Canada
Accessories
Note: This recall affects the following Powertrain Control Modules (PCM) that were sold through dealers as high-performance accessories: - Mopar Stage 1 high performance Powertrain Control Modules (PCM), part numbers P5160023 and P5160025 (campaign U82) - Mopar high performance Powertrain Control Modules (PCM) included in the Demon Crate, part number 68412287AA (campaign U83) On certain vehicles, an electronic fault may create a situation where the cruise control cannot be deactivated. If this occurs and the driver does not apply the brakes or shift the transmission to neutral, the vehicle could maintain speed or accelerate without warning, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the PCM software and perform an update as necessary. Note: In the interim, owners are advised not to use the cruise control until the vehicle is repaired. This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act, as these aftermarket products were not regulated by the Act.
Recall 2018269635,880 units in Canada
Engine
On certain vehicles, an electronic fault may create a situation where the cruise control cannot be deactivated. If this occurs and the driver does not apply the brakes or shift the transmission to neutral, the vehicle could maintain speed or accelerate without warning, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will inspect the Powertrain Control Module (PCM) software and perform an update as necessary. Note: In the interim, owners are advised not to use the cruise control until the vehicle is repaired.
Recall 20170815,206 units in Canada
Powertrain
On certain all-wheel drive vehicles, the front propshaft bolts may be loose. This could result in the front propshaft disconnecting from the vehicle, which would lead to loss of motive power while driving and could also damage powertrain and/or underbody components and create a road hazard, increasing the risk of a crash causing injury and/or damage to property. Correction: Dealers will replace all eight front propshaft bolts.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 141,000 milesGeneva, OHCrash
AIR BAGS
The contact owns a 2015 Chrysler 300. The contact stated that while driving at 69 MPH on the freeway, when the contact attempted to switch lanes and the vehicle spun independently, causing her to collide with another vehicle on the front driver side. The contact mentioned her rear bumper detached from the vehicle. No air bags deployed. The contact did not sustain any injuries. No medical attention was required. The contact vehicle was towed to Emerine's Central Auto and Towing. The contact stated that a police report was filed. The contact stated the vehicle was previously diagnosed by an independent mechanic, and the ABS speed sensor needed to be replaced. The vehicle was repaired prior to the accident, as the ABS speed sensor was replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 141,000.
NHTSA complaint #11695281 — an unverified report by a vehicle owner.
at 141,000 milesGeneva, OHCrash
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
The contact owns a 2015 Chrysler 300. The contact stated that while driving at 69 MPH on the freeway, when the contact attempted to switch lanes and the vehicle spun independently, causing her to collide with another vehicle on the front driver side. The contact mentioned her rear bumper detached from the vehicle. No air bags deployed. The contact did not sustain any injuries. No medical attention was required. The contact vehicle was towed to Emerine's Central Auto and Towing. The contact stated that a police report was filed. The contact stated the vehicle was previously diagnosed by an independent mechanic, and the ABS speed sensor needed to be replaced. The vehicle was repaired prior to the accident, as the ABS speed sensor was replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 141,000.
NHTSA complaint #11695281 — an unverified report by a vehicle owner.
Waldorf, MDFire
ENGINE
This will be my 3rd time having this [XXX] Plastic oil filter/cooler housing replaced and this will be 2nd time having done less than a 2yr time-frame... But this time; after getting the oil changed at Walmart today, my car was about to catch on fire from majority of the oil was running done on the passenger side of the car where the transmission sits and burning off of the Hot [XXX] Catalytic Converter! It's [XXX] shame that Chrysler/Mopar had more than enough complaints about this well known Catastrophic Issue and won't take any Accountability for it... That's why Dorman [XXX] and a few more companies had at least stepped up to the plate and created an better version, of the oil filter cooler housing. Not only is it better but is also all aluminum and doesn't warp or become brittle under extreme conditions from atmospheric temperatures nor engine heat! [XXX] which eventually manifest as severe oil and coolant leaks. The number of complaints regarding the Pentastar V6 oil filter housing and cooler assembly is staggering. See them here, at [XXX] . There have been so many complaints – with the OE replacements even, that Chrysler has discontinued the manufacturing of the Pentastar oil filter housing and cooler assembly. Even more surprising is that Chrysler has known about this problem for a long time and has never issued a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11580530 — an unverified report by a vehicle owner.
Waldorf, MDFire
FUEL/PROPULSION SYSTEM
This will be my 3rd time having this [XXX] Plastic oil filter/cooler housing replaced and this will be 2nd time having done less than a 2yr time-frame... But this time; after getting the oil changed at Walmart today, my car was about to catch on fire from majority of the oil was running done on the passenger side of the car where the transmission sits and burning off of the Hot [XXX] Catalytic Converter! It's [XXX] shame that Chrysler/Mopar had more than enough complaints about this well known Catastrophic Issue and won't take any Accountability for it... That's why Dorman [XXX] and a few more companies had at least stepped up to the plate and created an better version, of the oil filter cooler housing. Not only is it better but is also all aluminum and doesn't warp or become brittle under extreme conditions from atmospheric temperatures nor engine heat! [XXX] which eventually manifest as severe oil and coolant leaks. The number of complaints regarding the Pentastar V6 oil filter housing and cooler assembly is staggering. See them here, at [XXX] . There have been so many complaints – with the OE replacements even, that Chrysler has discontinued the manufacturing of the Pentastar oil filter housing and cooler assembly. Even more surprising is that Chrysler has known about this problem for a long time and has never issued a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11580530 — an unverified report by a vehicle owner.
at 60,000 milesAtascadero, CACrash1 injured
AIR BAGS
The contact owned a 2015 Chrysler 300. The contact stated that upon pulling out of the driveway and driving downhill, the engine shut off inadvertently, and the vehicle accelerated unintendedly. The brake pedal was depressed but failed to respond, causing the vehicle to crash into a tree. There was no warning light illuminated. The air bags failed to deploy. The contact sustained a bump and soreness on the left knee, and soreness in the neck. The contact received chiropractic assistance. A police report was filed. The vehicle was a towed to a tow yard, where it was totaled. The local dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11530171 — an unverified report by a vehicle owner.
at 60,000 milesAtascadero, CACrash1 injured
VEHICLE SPEED CONTROL
The contact owned a 2015 Chrysler 300. The contact stated that upon pulling out of the driveway and driving downhill, the engine shut off inadvertently, and the vehicle accelerated unintendedly. The brake pedal was depressed but failed to respond, causing the vehicle to crash into a tree. There was no warning light illuminated. The air bags failed to deploy. The contact sustained a bump and soreness on the left knee, and soreness in the neck. The contact received chiropractic assistance. A police report was filed. The vehicle was a towed to a tow yard, where it was totaled. The local dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11530171 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 141,000 milesGeneva, OHCrash
AIR BAGS
The contact owns a 2015 Chrysler 300. The contact stated that while driving at 69 MPH on the freeway, when the contact attempted to switch lanes and the vehicle spun independently, causing her to collide with another vehicle on the front driver side. The contact mentioned her rear bumper detached from the vehicle. No air bags deployed. The contact did not sustain any injuries. No medical attention was required. The contact vehicle was towed to Emerine's Central Auto and Towing. The contact stated that a police report was filed. The contact stated the vehicle was previously diagnosed by an independent mechanic, and the ABS speed sensor needed to be replaced. The vehicle was repaired prior to the accident, as the ABS speed sensor was replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 141,000.
NHTSA complaint #11695281 — an unverified report by a vehicle owner.
at 141,000 milesGeneva, OHCrash
SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
The contact owns a 2015 Chrysler 300. The contact stated that while driving at 69 MPH on the freeway, when the contact attempted to switch lanes and the vehicle spun independently, causing her to collide with another vehicle on the front driver side. The contact mentioned her rear bumper detached from the vehicle. No air bags deployed. The contact did not sustain any injuries. No medical attention was required. The contact vehicle was towed to Emerine's Central Auto and Towing. The contact stated that a police report was filed. The contact stated the vehicle was previously diagnosed by an independent mechanic, and the ABS speed sensor needed to be replaced. The vehicle was repaired prior to the accident, as the ABS speed sensor was replaced. The manufacturer was not notified of the failure. The approximate failure mileage was 141,000.
NHTSA complaint #11695281 — an unverified report by a vehicle owner.
Orleans, IN
STEERING
Possibly a failing axle shaft. Which after researching it is a common problem in this make & model.
NHTSA complaint #11688068 — an unverified report by a vehicle owner.
Orleans, IN
UNKNOWN OR OTHER
Possibly a failing axle shaft. Which after researching it is a common problem in this make & model.
NHTSA complaint #11688068 — an unverified report by a vehicle owner.
Orleans, IN
SUSPENSION
Possibly a failing axle shaft. Which after researching it is a common problem in this make & model.
NHTSA complaint #11688068 — an unverified report by a vehicle owner.
at 32,000 milesChicago, IL
STEERING
The contact owns a 2015 Chrysler 300. The contact stated that while driving at an undisclosed speed, the steering wheel failed to turn in the intended direction. The contact stated that the traction control warning light was illuminated. The contact stated that the failure had occurred while reversing or while making a turn. In addition, the failure had occurred several times, including once while driving in the rain. The vehicle was taken to an independent mechanic; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact referenced an unknown recall; however, the VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was approximately 32,000. The VIN was unavailable.
NHTSA complaint #11685784 — an unverified report by a vehicle owner.
Fort Pierce, FL
ELECTRICAL SYSTEM
This issue has been going on since February 2024. The vehicle will completely shutdown while driving ( no matter what speed I'm going ) it will say SERVICE THE SHIFTER and stop. The first time this happened I took (towed bc vehicle willl have no power since this a SAFTEY issue ) the Vero beach Chrysler dealership the vehicle to Commuter Cars in Port St Lucie which is the dealer I purchased the car from. They kept the vehicle for 2 weeks. I paid 644$ they said they replaced the shifter and that was the problem. 2 weeks later the same thing happened while driving , I took ( towed )the car to Chrysler . Chrysler charge me 200$ and said there was nothing wrong it was the safety recalls. 5 months later it happens again I take the car to Chrysler they charged me 1000$ and said it was some type of connecter . A month later it happens again I (towed) it to chysler they said the ECM shifter module had dried up coffee on it and they wiped it off and its working fine. They charge me 445$ said it needed a battery. Now it has happened again 2 months later and they are just now saying my ECM SHIFTER is bad. The service manager was rude and disrespectful. I have our conversation recorded. I said WHY am I just now knowing this after spending thousands of dollars towing this vehicle back and forth. My son and I could have been in a major accident because the car shuts completely down while driving. They never once check this and the car has been to them 4 times.
NHTSA complaint #11659687 — an unverified report by a vehicle owner.
Jackson, TN
ENGINE
The oil filter housing cracks due to the plastic material it is made out of causing immediate loss of oil and disabling vehicle in traffic.
NHTSA complaint #11637229 — an unverified report by a vehicle owner.
Rock Springs, WY
UNKNOWN OR OTHER
Blend doors keep failing. Keeps switching from cold to hot.
NHTSA complaint #11636818 — an unverified report by a vehicle owner.
at 18,000 milesConverse, TX
SERVICE BRAKES, HYDRAULIC
The contact owns a 2015 Chrysler 300. The contact stated while driving approximately 40 MPH, the brake pedal was depressed but felt soft. The contact stated that the failure occurred at various speeds, requiring that the brake pedal be depressed with excessive force. The contact stated that the ABS and ESC warning lights were illuminated. The contact stated that while braking following a curve in the road, the rear end of the vehicle started swaying slightly to the right and left. The contact stated that the warning lights were constantly illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that one of the wheel sensors needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact had not taken the vehicle back to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11629681 — an unverified report by a vehicle owner.
at 18,000 milesConverse, TX
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2015 Chrysler 300. The contact stated while driving approximately 40 MPH, the brake pedal was depressed but felt soft. The contact stated that the failure occurred at various speeds, requiring that the brake pedal be depressed with excessive force. The contact stated that the ABS and ESC warning lights were illuminated. The contact stated that while braking following a curve in the road, the rear end of the vehicle started swaying slightly to the right and left. The contact stated that the warning lights were constantly illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that one of the wheel sensors needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact had not taken the vehicle back to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 18,000.
NHTSA complaint #11629681 — an unverified report by a vehicle owner.
Reserve, NM
UNKNOWN OR OTHER
At least 20 times. Driving down the highway doesn't matter if driving straight or cornering. The engine dies. Once I get it stopped. I put it back in park. Restart the engine and it runs. There are no codes, and can't get it to duplicate the problem at the garage. I've searched the internet and this seems to be a continuous problem and no one is finding the problem. From what I've read dealerships are just throwing parts at the problem. This is a safety issue. My daughter was almost rear-ended today.
NHTSA complaint #11608844 — an unverified report by a vehicle owner.
Inverness, FL
POWER TRAIN
Car is going crazy key won't work then it will then it won't mover then it won't work wipers stay on even when off all lights go on computer won't get a scan when it's not working it's an electric tcm pcm issue that was a recall for these cars but was told for some reason mine wasn't part of the recall now I'm having issues with that same electric and pcm tcm issue Collin at chrysler customer care told me I had to make a complaint my car is unable to move out of no where greatly hindering me
NHTSA complaint #11606192 — an unverified report by a vehicle owner.
Inverness, FL
UNKNOWN OR OTHER
Car is going crazy key won't work then it will then it won't mover then it won't work wipers stay on even when off all lights go on computer won't get a scan when it's not working it's an electric tcm pcm issue that was a recall for these cars but was told for some reason mine wasn't part of the recall now I'm having issues with that same electric and pcm tcm issue Collin at chrysler customer care told me I had to make a complaint my car is unable to move out of no where greatly hindering me
NHTSA complaint #11606192 — an unverified report by a vehicle owner.
Inverness, FL
ELECTRICAL SYSTEM
Car is going crazy key won't work then it will then it won't mover then it won't work wipers stay on even when off all lights go on computer won't get a scan when it's not working it's an electric tcm pcm issue that was a recall for these cars but was told for some reason mine wasn't part of the recall now I'm having issues with that same electric and pcm tcm issue Collin at chrysler customer care told me I had to make a complaint my car is unable to move out of no where greatly hindering me
NHTSA complaint #11606192 — an unverified report by a vehicle owner.
Waldorf, MDFire
ENGINE
This will be my 3rd time having this [XXX] Plastic oil filter/cooler housing replaced and this will be 2nd time having done less than a 2yr time-frame... But this time; after getting the oil changed at Walmart today, my car was about to catch on fire from majority of the oil was running done on the passenger side of the car where the transmission sits and burning off of the Hot [XXX] Catalytic Converter! It's [XXX] shame that Chrysler/Mopar had more than enough complaints about this well known Catastrophic Issue and won't take any Accountability for it... That's why Dorman [XXX] and a few more companies had at least stepped up to the plate and created an better version, of the oil filter cooler housing. Not only is it better but is also all aluminum and doesn't warp or become brittle under extreme conditions from atmospheric temperatures nor engine heat! [XXX] which eventually manifest as severe oil and coolant leaks. The number of complaints regarding the Pentastar V6 oil filter housing and cooler assembly is staggering. See them here, at [XXX] . There have been so many complaints – with the OE replacements even, that Chrysler has discontinued the manufacturing of the Pentastar oil filter housing and cooler assembly. Even more surprising is that Chrysler has known about this problem for a long time and has never issued a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11580530 — an unverified report by a vehicle owner.
Waldorf, MDFire
FUEL/PROPULSION SYSTEM
This will be my 3rd time having this [XXX] Plastic oil filter/cooler housing replaced and this will be 2nd time having done less than a 2yr time-frame... But this time; after getting the oil changed at Walmart today, my car was about to catch on fire from majority of the oil was running done on the passenger side of the car where the transmission sits and burning off of the Hot [XXX] Catalytic Converter! It's [XXX] shame that Chrysler/Mopar had more than enough complaints about this well known Catastrophic Issue and won't take any Accountability for it... That's why Dorman [XXX] and a few more companies had at least stepped up to the plate and created an better version, of the oil filter cooler housing. Not only is it better but is also all aluminum and doesn't warp or become brittle under extreme conditions from atmospheric temperatures nor engine heat! [XXX] which eventually manifest as severe oil and coolant leaks. The number of complaints regarding the Pentastar V6 oil filter housing and cooler assembly is staggering. See them here, at [XXX] . There have been so many complaints – with the OE replacements even, that Chrysler has discontinued the manufacturing of the Pentastar oil filter housing and cooler assembly. Even more surprising is that Chrysler has known about this problem for a long time and has never issued a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11580530 — an unverified report by a vehicle owner.
Cleveland, OH
UNKNOWN OR OTHER
I was driving on the highway with cruise and my car started to go limp, then started to accelerate without my foot on the gas. Then my check engine light came on and I pulled off and turned the car off and back on. It drove fine but when I went to have it checked they said it threw a code for my TCM. My coworker also drives a Chrysler 300 and had the same issue in the same week! He never got his checked out but his car stopped accelerating and then started again while on cruise. This is happening to a lot of Chryslers so I looked up recalls and it looks like the TCM was recalled in the 2016 300’s but my 2015 and his 2015 is having the same issues
NHTSA complaint #11554734 — an unverified report by a vehicle owner.
at 60,000 milesAtascadero, CACrash1 injured
AIR BAGS
The contact owned a 2015 Chrysler 300. The contact stated that upon pulling out of the driveway and driving downhill, the engine shut off inadvertently, and the vehicle accelerated unintendedly. The brake pedal was depressed but failed to respond, causing the vehicle to crash into a tree. There was no warning light illuminated. The air bags failed to deploy. The contact sustained a bump and soreness on the left knee, and soreness in the neck. The contact received chiropractic assistance. A police report was filed. The vehicle was a towed to a tow yard, where it was totaled. The local dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11530171 — an unverified report by a vehicle owner.
at 60,000 milesAtascadero, CACrash1 injured
VEHICLE SPEED CONTROL
The contact owned a 2015 Chrysler 300. The contact stated that upon pulling out of the driveway and driving downhill, the engine shut off inadvertently, and the vehicle accelerated unintendedly. The brake pedal was depressed but failed to respond, causing the vehicle to crash into a tree. There was no warning light illuminated. The air bags failed to deploy. The contact sustained a bump and soreness on the left knee, and soreness in the neck. The contact received chiropractic assistance. A police report was filed. The vehicle was a towed to a tow yard, where it was totaled. The local dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11530171 — an unverified report by a vehicle owner.
at 60,000 milesAtascadero, CACrash1 injured
SERVICE BRAKES, HYDRAULIC
The contact owned a 2015 Chrysler 300. The contact stated that upon pulling out of the driveway and driving downhill, the engine shut off inadvertently, and the vehicle accelerated unintendedly. The brake pedal was depressed but failed to respond, causing the vehicle to crash into a tree. There was no warning light illuminated. The air bags failed to deploy. The contact sustained a bump and soreness on the left knee, and soreness in the neck. The contact received chiropractic assistance. A police report was filed. The vehicle was a towed to a tow yard, where it was totaled. The local dealer was notified of the failure and referred the contact to the manufacturer. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 60,000.
NHTSA complaint #11530171 — an unverified report by a vehicle owner.
Brunswick, GA
STRUCTURE:BODY
My car has 122,760 miles and has had multiple fuses blow repeatedly. In the last 2wks. Today is 06-21-2023 I can change a fuse and it will blow within 15miles. Also the trim going around my windshield has disintegrated. It literally crumbled into pieces when I touched it. I noticed this almost 3 yrs ago.
NHTSA complaint #11528099 — an unverified report by a vehicle owner.
Brunswick, GA
ELECTRICAL SYSTEM
My car has 122,760 miles and has had multiple fuses blow repeatedly. In the last 2wks. Today is 06-21-2023 I can change a fuse and it will blow within 15miles. Also the trim going around my windshield has disintegrated. It literally crumbled into pieces when I touched it. I noticed this almost 3 yrs ago.
NHTSA complaint #11528099 — an unverified report by a vehicle owner.
Duncan, OK
UNKNOWN OR OTHER
My uconnect radio did a firmware update. And my rear view backup camera, and my satellite radio with my navigation system stopped working. Along with my throttle body error light came up. Also the car was parked in the driveway standing still.
NHTSA complaint #11526610 — an unverified report by a vehicle owner.
Duncan, OK
ELECTRICAL SYSTEM
My uconnect radio did a firmware update. And my rear view backup camera, and my satellite radio with my navigation system stopped working. Along with my throttle body error light came up. Also the car was parked in the driveway standing still.
NHTSA complaint #11526610 — an unverified report by a vehicle owner.