2019 Dodge Charger problems

SERVICE BRAKES

Vehicle was sold by Westgate Crysler Jeep Dodge Ram of Raleigh with missing caliper bolt in front passenger brake system. This was detected by an independent service center while getting brake pads and rotors replaced, as they were very worn and causing the brake system to be jumpy and catchy, despite Westgate assuring they were fine. The lack of the bolt in the caliper put my entire family's life at risk from the second we drove off the lot a little over a month ago.

NHTSA complaint #11753994 — an unverified report by a vehicle owner.

STEERING

I was traveling 58 mph on hwy 270 in Malvern Arkansas. The power steering turned off, the emergency brake engaged and flashed, and the ABS shut off. I replaced the steering sensor with an original mopar part off of my vin number and if i turn tightly it still triggers a code. The entire sensor and spring has been relplaced. It was obvious the original part shorted out It is VERY SENSITIVE to heat, the hotter it gets the more shut down of power steering, and activating the emergency brake while driving is experienced. I bought this car new and have taken excellent care of it.

NHTSA complaint #11751658 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I was traveling 58 mph on hwy 270 in Malvern Arkansas. The power steering turned off, the emergency brake engaged and flashed, and the ABS shut off. I replaced the steering sensor with an original mopar part off of my vin number and if i turn tightly it still triggers a code. The entire sensor and spring has been relplaced. It was obvious the original part shorted out It is VERY SENSITIVE to heat, the hotter it gets the more shut down of power steering, and activating the emergency brake while driving is experienced. I bought this car new and have taken excellent care of it.

NHTSA complaint #11751658 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

I was traveling 58 mph on hwy 270 in Malvern Arkansas. The power steering turned off, the emergency brake engaged and flashed, and the ABS shut off. I replaced the steering sensor with an original mopar part off of my vin number and if i turn tightly it still triggers a code. The entire sensor and spring has been relplaced. It was obvious the original part shorted out It is VERY SENSITIVE to heat, the hotter it gets the more shut down of power steering, and activating the emergency brake while driving is experienced. I bought this car new and have taken excellent care of it.

NHTSA complaint #11751658 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Vehicle: Dodge Charger GT Recall: SABIC Side Airbag Inflator Replacement Dealer: ourisman chrysler dodge jeep ram of clarksville, maryland Date of Recall Repair: feb 27, 2026 Complaint Description: After the dealer performed the SABIC inflator recall on my Dodge Charger GT, the vehicle immediately developed new electrical failures that were not present before the repair. As soon as I picked up the car, the interior dome/map lights stopped working, and the right‑side exterior front lighting also failed. These failures occurred directly after the recall repair, indicating the dealer likely damaged or disconnected wiring inside the A‑pillar/B‑pillar or roof harness while accessing the inflator. This creates a safety hazard, especially at night, because the right exterior lighting is inoperative and interior lighting does not function. The dealer has not acknowledged responsibility, and the vehicle was returned to me in an unsafe condition after a federally mandated recall repair.

NHTSA complaint #11722901 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Campaign 11701038 - Warping of door panels and driving shaft area. Worried this will affect airbag deployment.

NHTSA complaint #11713844 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

- Crack at base of gas tank where fill tube attached causing fuel vapors around the car and a possible fuel leak. - Yes by independent service center. -White residue was built up around the crack in the fill tube. Independent service center confirmed the cause as - "Found plastic fuel tank leaking around the filler nipple that is plastic welded in. Also, the auxiliary pump has a dark spot like it may be sleeping as well. Need to replace the fuel tank and would recommend replacing the fuel pumps as a precaution." Final repair charge was $4437.03. Independent service center replace fuel tank and fuel pumps with Mopar parts from the closest Dodge dealer. In review with the service center they stated that fuel was dripping onto the heat shield above the exhaust and could have caused a fire. - No other agencies inspected the issue or repair. Attached a copy of the invoice and two pictures of the worn/cracked fuel tank. - No warning lights, just the smell of gasoline in my garage about 5 weeks ago. The smell would be the strongest when the tank was full but when below half tank the smell was not present.

NHTSA complaint #11708098 — an unverified report by a vehicle owner.

STEERING

Over 2 years ago I took my vehicle in for an oil change and asked them to drive it and see why it sometimes pulls the steering when going around a curve to the left. they drove it and said it never did pull. Since then, it now pulls to the right when going around curves to the right also. It is doing it more frequently and I am in fear that it will either cause me to go off the road or hit someone when it all of a sudden jerks, like it is catching on something in the tire or something. I wouldn't even let my grandson drive it when he got his learners permit. I have since then decided to look for a safer vehicle and will be trading it since no one can figure out the issue. It jerks hard all of a sudden and you have to make sure you are holding the steering wheel tight. I am reporting to hopefully prevent an accident.

NHTSA complaint #11707706 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Over 2 years ago I took my vehicle in for an oil change and asked them to drive it and see why it sometimes pulls the steering when going around a curve to the left. they drove it and said it never did pull. Since then, it now pulls to the right when going around curves to the right also. It is doing it more frequently and I am in fear that it will either cause me to go off the road or hit someone when it all of a sudden jerks, like it is catching on something in the tire or something. I wouldn't even let my grandson drive it when he got his learners permit. I have since then decided to look for a safer vehicle and will be trading it since no one can figure out the issue. It jerks hard all of a sudden and you have to make sure you are holding the steering wheel tight. I am reporting to hopefully prevent an accident.

NHTSA complaint #11707706 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

The contact owns a 2019 Dodge Charger. The contact stated that while driving at an undisclosed speed, the headlights failed to function as intended. The headlights failed to activate as intended. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The contact replaced the light bulbs; however, the failure persisted. The contact was unable to drive the vehicle at night due to the failure. Upon further investigation, the contact found a recall issued by the manufacturer for the low beam headlights failing or the wiring harness melting. The manufacturer was not made aware of the issue. The failure mileage was unknown.

NHTSA complaint #11703842 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The interior door panel on my 2019 Dodge Charger began to separate/warp from the door frame on the Front drivers and Front Passengers door panels. The vehicle had approximately 32000 miles when the issue started. The plastic trim piece is lifting and peeling away from the door next to the window sill, creating a sharp edge and a gap. This separation is causing the door lock mechanism to bind and become difficult to operate. The window operation is also negatively affected, as the glass rubs against the warped panel. I have also had to replace the window motor a little over a year ago and it is again starting to fail. AJ Dohmann now Geaux Dodge in Plaquamian Louisiana replaced this. This defect poses an unreasonable risk to safety because it could impede egress from the vehicle in an emergency due to the malfunctioning door lock. It may also compromise the integrity of the side curtain airbag deployment area. I contacted the manufacturer/dealer on 02/2020, and they indicated this is a known issue but not a safety recall, so they refused to cover the repair under warranty. The issue has reoccurred/worsened and is present on multiple doors. There were no injuries or a crash as a result of this issue. Photos of the defect are attached to this complaint.

NHTSA complaint #11701038 — an unverified report by a vehicle owner.

ENGINE

On January 6, 2025, Countryside CDJR in Georgia performed internal engine repairs on my 2019 Dodge Charger R/T, including lifter and internal engine work. Only months later, the engine suffered a catastrophic failure while driving. The vehicle became disabled and had to be towed. This raises serious concerns of improper repair or a safety-related engine defect. The dealership denies responsibility and blames a single missed oil change. A single missed oil change does not cause sudden catastrophic engine failure so soon after dealership-performed internal work. This could be related to known 5.7L HEMI lifter/camshaft issues. I am requesting that NHTSA review this failure for potential safety defect or incorrect repair contributing to engine failure.

NHTSA complaint #11698261 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Cluster info not working as it should

NHTSA complaint #11689948 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Cluster info not working as it should

NHTSA complaint #11689948 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2019 Dodge Charger. The contact stated that the driver's side headlight persistently failed to operate as needed, and the headlight bulb was replaced several times. The contact stated that while driving at an undisclosed speed, a Police Officer pulled the contact over because the headlight was inoperable. The contact stated that upon returning to the residence, the contact and her son inspected the headlight and noticed that the headlight had melted internally. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 99,000.

NHTSA complaint #11688981 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

To whom ot may concern my 2019 dodge charger headlight went out on driver side after replacement light it still didn't work and replacement of box during the process of taking bub out bulb silver housing box was extremely hot…so hot it burned his hand and then he ask me to feel the light and also it was extremely hot after inspection of the car for hour in a half the hornest was melting I looked up the recall on those vehicle and seeing there was same recall of this issue on older models there is no way that hornest would burn unless it was extremely hot Every charger I see light is out also and I believe noone can find out the problem my mechanic told me hornest was so hot it burned out When I felt the light it burned me and thos is unsafe for this light to be that hot with no kind of fan or nothing When i say every car I see headlights are out I would like to discuss how to proceed from this issue If the issue is not the bulb then issue itz getting to hot and burning the hornest

NHTSA complaint #11688668 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

To whom ot may concern my 2019 dodge charger headlight went out on driver side after replacement light it still didn't work and replacement of box during the process of taking bub out bulb silver housing box was extremely hot…so hot it burned his hand and then he ask me to feel the light and also it was extremely hot after inspection of the car for hour in a half the hornest was melting I looked up the recall on those vehicle and seeing there was same recall of this issue on older models there is no way that hornest would burn unless it was extremely hot Every charger I see light is out also and I believe noone can find out the problem my mechanic told me hornest was so hot it burned out When I felt the light it burned me and thos is unsafe for this light to be that hot with no kind of fan or nothing When i say every car I see headlights are out I would like to discuss how to proceed from this issue If the issue is not the bulb then issue itz getting to hot and burning the hornest

NHTSA complaint #11688668 — an unverified report by a vehicle owner.

STRUCTURE:BODY

To whom ot may concern my 2019 dodge charger headlight went out on driver side after replacement light it still didn't work and replacement of box during the process of taking bub out bulb silver housing box was extremely hot…so hot it burned his hand and then he ask me to feel the light and also it was extremely hot after inspection of the car for hour in a half the hornest was melting I looked up the recall on those vehicle and seeing there was same recall of this issue on older models there is no way that hornest would burn unless it was extremely hot Every charger I see light is out also and I believe noone can find out the problem my mechanic told me hornest was so hot it burned out When I felt the light it burned me and thos is unsafe for this light to be that hot with no kind of fan or nothing When i say every car I see headlights are out I would like to discuss how to proceed from this issue If the issue is not the bulb then issue itz getting to hot and burning the hornest

NHTSA complaint #11688668 — an unverified report by a vehicle owner.

AIR BAGS

Here in AZ we had some strong monsoon storms and during one last week, my car was shaken from the winds and rains so bad that my driver side curtain airbag was visible. It did not fully deploy but the bag was exposed. There is a current recall on these bags but since this happened before the recall fix(at the shop now getting replaced) should insurance have been contacted before hand since this was weather that caused the partial deployment? How safe are the replacements?

NHTSA complaint #11685331 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Car overheated and caused critical damage without warning or notification. Had my 2019 Dodge Charger GT vin got the V32 recall updating the instrument cluster software, there would have been warning or any dash notification(s) and I wouldn’t have damaged header. FCA failed to assign, notify, or remedy this recall which lead to engine damage.

NHTSA complaint #11682000 — an unverified report by a vehicle owner.

WHEELS

The contact owns a 2019 Dodge Charger. The contact stated that while driving at an undisclosed speed, the front end of the vehicle started vibrating. Additionally, the contact stated that the front passenger's side tire had sustained a blowout. The vehicle was taken to an independent mechanic where it was diagnosed that the front alignment of the vehicle had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 143,000.

NHTSA complaint #11674266 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2019 Dodge Charger. The contact stated that while driving at an undisclosed speed, the front end of the vehicle started vibrating. Additionally, the contact stated that the front passenger's side tire had sustained a blowout. The vehicle was taken to an independent mechanic where it was diagnosed that the front alignment of the vehicle had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 143,000.

NHTSA complaint #11674266 — an unverified report by a vehicle owner.

TIRES

The contact owns a 2019 Dodge Charger. The contact stated that while driving at an undisclosed speed, the front end of the vehicle started vibrating. Additionally, the contact stated that the front passenger's side tire had sustained a blowout. The vehicle was taken to an independent mechanic where it was diagnosed that the front alignment of the vehicle had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. An unknown dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 143,000.

NHTSA complaint #11674266 — an unverified report by a vehicle owner.

AIR BAGS

I brought my vehicle in for a recall to replace the airbags and headliner. When I received my car back from the dealership (Union City Chrysler Dodge Jeep Ram), the vehicle was returned with a broken windshield, water intrusion leading to mold, corroded and missing components, and now both rear doors do not function properly. These issues are safety concerns and were not present before the service. This dealership severely compromised the safety and usability of my car during a recall repair. I believe this warrants investigation and potential oversight from NHTSA, especially as this stemmed from a recall they were authorized to repair.

NHTSA complaint #11670680 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I brought my vehicle in for a recall to replace the airbags and headliner. When I received my car back from the dealership (Union City Chrysler Dodge Jeep Ram), the vehicle was returned with a broken windshield, water intrusion leading to mold, corroded and missing components, and now both rear doors do not function properly. These issues are safety concerns and were not present before the service. This dealership severely compromised the safety and usability of my car during a recall repair. I believe this warrants investigation and potential oversight from NHTSA, especially as this stemmed from a recall they were authorized to repair.

NHTSA complaint #11670680 — an unverified report by a vehicle owner.