9,505 of the
36,407 complaints filed about the Ford Escape
are about the engine —
100% of everything owners reported.
The worst model year for it is 2017.
am reporting a potential safety defect involving my 2014 Ford Escape Titanium 1.6L EcoBoost. While driving, I suddenly heard a pop/burst from under the hood. The vehicle then began producing white smoke/steam. There were no warning lights or temperature warnings before the smoke began. The high-temperature/overheating warning appeared only after the vehicle was already smoking/steaming. I immediately pulled over and stopped the vehicle. Green coolant had sprayed throughout the engine compartment. An independent repair shop confirmed that the plastic return-side heater-hose union/connector broke, causing a severe coolant leak. The shop recommended replacing the connector and coolant, performing a cooling-system pressure test, and a combustion leak test to check for possible engine damage. This failure created a safety risk because the vehicle suddenly lost coolant while being driven and gave almost no advance warning before overheating. The vehicle has not been inspected by Ford for this specific failure. I am concerned because these symptoms appear similar to the coolant-loss/overheating concerns addressed by Ford Safety Recall 17S09 involving certain 2014 Ford Escape 1.6L EcoBoost vehicles. My VIN is not currently listed in that recall. I am reporting this so NHTSA can determine whether similar sudden cooling-system failures are occurring in vehicles outside the original recall population.
NHTSA complaint #11764180 — an unverified report by a vehicle owner.
My car has experienced Catastrophic Engine Failure. There is a coolant intrusion into the cylinders and now the car is inoperable. It runs for 2 minutes before shutting the engine off.
NHTSA complaint #11764179 — an unverified report by a vehicle owner.
My 2018 Ford Escape SE 1.5L EcoBoost is actively suffering from the manufacturer defect outlined in Ford TSB 19-2375 (coolant intrusion into the engine cylinders). The vehicle shakes violently on startup, emits heavy white smoke from the tailpipe, and displays an 'Engine Fault Service Now' warning. Because it is burning through coolant, this vehicle poses an immediate safety risk of sudden power loss, highway stalling, or catastrophic engine failure while driving. My job requires me to transport vulnerable medical patients, and this severe defect makes the vehicle entirely unsafe to operate on public roads.
NHTSA complaint #11764020 — an unverified report by a vehicle owner.
We purchased a 2019 Ford Escape 1.5L new from the dealer. We've put only 25,000 miles on it, but are now facing a well known issue (coolant intrusion) that they failed to inform us about. This is despite our vehicle meeting literally every requirement to be included in their Customer Service Program, they told us it is not tied to our VIN and are out of luck. Our car is now worthless. If we had been notified we would have taken the necessary precautions. Again, this is a known issue, with a current Class Action lawsuit in place, that Ford failed to notify us of. We are now out tens of thousands of dollars in replacing a car we have barely driven.
NHTSA complaint #11764175 — an unverified report by a vehicle owner.
Engine will periodically and randomly stall and quit while driving. Mostly in city but it quit while driving on highway I-10 at 65 mph in one incident.
NHTSA complaint #11764188 — an unverified report by a vehicle owner.
The contact owns a 2017 Ford Escape. The contact stated that while the vehicle was at the service center for an instrument panel failure, a diagnostic test was performed on the engine. The contact was informed that in addition to the instrument panel failure, there was coolant inside the cylinders, and the engine needed to be replaced. The vehicle was not yet repaired. The failure mileage was 105,000.
NHTSA complaint #11763703 — an unverified report by a vehicle owner.
I recently purchased this vehicle for 2400.00 from a private seller. Within 3 weeks of very minor driving the car got 1 block from home and showed very hot and dumped all the coolant. And that was the 1st time it had been driven that day and it was 69 degrees outside. We let it sit for about a week and refilled the coolant. It drove great for about 2 weeks and then out of the blue it stalls while I'm driving it down the road. Had it towed home and my mechanic came and did a tune up. We had very fouled plugs and replaced all the coil wires. Put in a emissions treatment as well as checking everything. It started after killing my battery several times and seemed to be fine. Drove it around the block and it stalled after being fine only to find coolant in the spark plug areas and somehow my vin isn't listed in the recall. My mechanic said I should write you guys to let you know that I should be included as he believes that is exactly what happened to me. Please help. Thank you
NHTSA complaint #11763508 — an unverified report by a vehicle owner.
My coolant mixing with the oil cause a severe overage. This is what I understood my recall to be about but the FORD dealership refused to fix it on June 1st. Now I’m subject to a very expensive car repair.
NHTSA complaint #11763228 — an unverified report by a vehicle owner.
Bought car in 2023, one year later engine failure due to overheating from head gasket issue widespread with this vehicle. Replaced engine, and two years later facing identical issue with another engine failure. Unidentifiable coolant leak led to low oil pressure and car shaking on the highway. Will require yet another engine replacement.
NHTSA complaint #11763110 — an unverified report by a vehicle owner.
On July 7, 2026, at approximately 113,080 miles, my 2016 Ford Escape displayed a “Transmission Fault – Service Now” warning. The exact failed component is currently UNKNOWN, but the issue appears to involve the transmission/powertrain and possibly an electrical fault. While driving, I experienced abnormal symptoms including a rotational/squeaking noise from the front-right area and an air-leak/pressure-type noise from the right side. The pressure-type noise could also be heard while revving the vehicle at idle. The Check Engine Light also illuminated. I took the vehicle to an independent repair facility on July 7, 2026. The mechanic documented the symptoms and diagnostic trouble codes and advised that additional electrical diagnosis was necessary to determine the exact cause. The transmission itself has not been conclusively diagnosed as failed, and I am not claiming a specific failed internal component without further inspection. I consider this a serious safety concern because an unresolved transmission or powertrain malfunction could potentially cause improper shifting, hesitation, reduced propulsion, loss of acceleration, or other unexpected vehicle behavior while driving in traffic. I contacted Ford regarding the problem and followed up again on July 17, 2026. After receiving no resolution, I contacted Ford again on September 9, 2026. Ford advised me that there was no exact timeframe for when the ASO would contact me and that the ASO may or may not contact me at all. I requested that Ford make a final escalation of the safety concern. Ford confirmed that my escalation and my intention to submit the unresolved safety issue to NHTSA were documented under Ford case CXH-08511841-T8X5L4. To my knowledge, Ford has not inspected the vehicle or provided a substantive resolution to the transmission/powertrain concern. I am also concerned that this may not be an isolated maintenance issue. I am aware of other owners reporting transmission and powertrain problems.
NHTSA complaint #11763197 — an unverified report by a vehicle owner.
IN 2022 THE ENGINE WAS REPLACED (DUE TO A FORD DEFEC CALLED COOLANT INTRUTION) THE MILAGE WAS 49000. THE MILAGE IS NOW 78825 AND THAT ENGINE IS FAILING DUE TO COOLANT INTRUCTION. AS A SINGLE GRANDPARENT I SHOULD NOT HAVE TO FORK OUT $11000 DOLLARS FOR A NEW ENGINE IF ITS STILL A FORD DEFECT
NHTSA complaint #11763157 — an unverified report by a vehicle owner.
The engine is having issues. There is coolant leaking into the engine. Causing for the engine to shake upon starting the car. Issues that can come from operating the vehicle are overheating, fire and explosion of engine. I took the car for diagnostics at a Ford dealership and they confirmed that it is a fault with the engine that Ford is aware about but issued no recall. The check engine light first appeared on Saturday 9/05/2026 and that same day upon igniting the engine that was the first time that the engine rattled when starting the vehicle.
NHTSA complaint #11763165 — an unverified report by a vehicle owner.
Coolant leaks internally into the engine cylinders. This is resulting in needing a full engine replacement for $15,000. It has been confirmed by the dealership. The check engine light came on.
NHTSA complaint #11762866 — an unverified report by a vehicle owner.
Slow coolant leak that is a known issue with engine. This caused the water pump to go bad and engine to risk overheating. Has been looked at by 3 independent mechanics all confirmed this is a known issue causing major concerns. No warning! Just suddenly lost all coolant! No engine needs replaced!
NHTSA complaint #11762707 — an unverified report by a vehicle owner.
Error code p0016 came up and I started investigating and found coolant intrusion which was a known defect during manufacturing by ford. I was driving normally when the vehicle accelerated really slowly after a stop which could have caused a traffic accident if it happened while in traffic
NHTSA complaint #11762592 — an unverified report by a vehicle owner.
White foggy smoke from exhaust. Backing sensor or driving sensor are off when sensing environment. Car suspension not fully stable sorta drift to left or right.
NHTSA complaint #11762391 — an unverified report by a vehicle owner.