296 of the 1,385 complaints filed about the Ford Excursion are about the tires — 21% of everything owners reported. The worst model year for it is 2000.
296
Complaints
21%
Share of all complaints
21
Crashes
0
Fires
TIRES
LT275/65/R18 Tire developed a massive approximately 18in x 3in bubble on the inner section of tread causing significant vibration and excessive wear in that area in less than 50 miles
NHTSA complaint #11507922 — an unverified report by a vehicle owner.
TIRES
My wife, two young daughters, and I were traveling out of town for the New Year. As we were traveling southbound on I-85 between Greensboro, North Carolina and Thomasville, North Carolina, I started to notice that the vehicle was starting to vibrate. Over the course of the next +\- 10 miles the vibration became much worse and eventually forced me to get off of the highway. I exited the highway at exit 103 on I-85 southbound (NC-109) and was able to get the vehicle to a National Tire and Battery Shop located at 2 Cloniger Dr, Thomasville, NC 27360. Upon inspection, they noticed a large bulge in the driver side rear tire and told me that they thought that I might have broken a belt inside of the tire. They were able to get it off and put on the full size spare, thus allowing us to get to our destination. I strongly believe that had I not exited the highway when I did, there was a high likelyhood that the tire could have blown thus causing us to crash. With that said, this failure put my entire family at risk. The problem has not been reproduced or confirmed by a dealer or independent service center. The tire has only been inspected by the National Tire and Battery that took it off and replaced it with the full size spare. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The problem started they day of the incident as we were traveling southbound on I-85 between Greensboro, North Carolina and Thomasville, North Carolina. Tire Size - LT 265/75 R 16
NHTSA complaint #11499780 — an unverified report by a vehicle owner.
TIRES
Michelin Defender LTX M/S size 265/75R16. 4 new tires installed less than 60 days and 1,800 miles by Costco before incident. Tire air pressure checked prior to a trip. On the trip, 1 tire rapidly deflated without warning on the freeway in Arizona. Barely had enough time to pull off the freeway and onto the shoulder. The tire showed no punctures, or tread separation, but the tire sidewalls were wrinkled and distorted. Took tire to Costco for warranty and the tire shop could not find any internal punctures and were unable to determine as to why the tire went flat. They said they have never seen a tire fail like this.
NHTSA complaint #11449011 — an unverified report by a vehicle owner.
TIRES
BOUGHT MICKEY THOMPSON ATZ 305 70 16 IN APRIL. HAVE TREAD SEPARATION
NHTSA complaint #11254136 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2002 FORD EXCURSION EQUIPPED WITH TOYO OPEN COUNTRY R/T TIRES (NA), SIZE: LT285/75/R16. WHILE DRIVING 65 MPH, THE REAR PASSENGER TIRE EXPERIENCED TREAD SEPARATION. PRIOR TO THE FAILURE, THE REAR DRIVER'S TIRE WAS REPLACED BY ALLEN TIRE (LOCATED AT 1725 SUPERIOR AVE, COSTA MESA, CA 92627, (949) 646-5236) DUE TO A BULGE IN THE TIRE. THE CONTACT STATED THAT THERE WAS DAMAGE TO THE VEHICLE. THE SET OF TIRES WERE A REPLACEMENT SET. THE TIRE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14T014000 (TIRES). THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 170,000 AND THE TIRE FAILURE MILEAGE WAS 75,000.
NHTSA complaint #11218329 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH FIRESTONE STEELTEX TIRES, SIZE: 385/65-R18 (NA). WHILE DRIVING 70 MPH, THE TREAD ON THE TIRES SEPARATED AND THE CONTACT LOST CONTROL OF THE VEHICLE. AS A RESULT, A CRASH OCCURRED AND THREE OCCUPANTS SUSTAINED MAJOR AND MINOR INJURIES. ONE INJURY WAS FATAL. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VIN AND DOT NUMBER WERE NOT AVAILABLE. THE VEHICLE FAILURE MILEAGE WAS 150,000 AND THE TIRE FAILURE MILEAGE WAS 3,000.
NHTSA complaint #11076641 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2002 FORD EXCURSION EQUIPPED WITH SUNFULL MONT-PRO HT781 TIRES, SIZE: LT265/75/16. WHILE DRIVING 65 MPH, THE VEHICLE VIBRATED ABNORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE REAR PASSENGER SIDE TIRE TREAD SEPARATED, WHICH CAUSED A BUBBLE IN THE TIRE. WITHIN LESS THAN A THOUSAND MILES LATER, THE FRONT DRIVER'S TIRE ALSO EXPERIENCED THE FAILURE. THE RETAIL FACILITY WHERE THE TIRES WERE SOLD AND INSTALLED WAS NOT CONTACTED. THE TIRE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 166,000 AND THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 4,999.
NHTSA complaint #11001709 — an unverified report by a vehicle owner.
TIRES
TL* THE CONTACT OWNS A 2001 FORD EXCURSION EQUIPPED WITH FIRESTONE STEELTEX A/T TIRES, SIZE: LT265/75R16 119/116R (NA). WHILE DRIVING 55 MPH, THE TIRES EXPLODED AND CAUSED CONSIDERABLE DAMAGE TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE VEHICLE AND TIRE FAILURE MILEAGE WAS 147,000.
NHTSA complaint #10783698 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH MASTERCRAFT COURSER AWT TIRES, SIZE: LT265/75/R16 (NA). WHILE DRIVING AT APPROXIMATELY 65 MPH, THE CONTACT FELT A VIBRATION. THE VEHICLE VEERED FROM LEFT TO RIGHT, THE TREAD SEPARATED, AND THE REAR PASSENGER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. THE FOLLOWING DAY, WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE VIBRATED AND VEERED FROM LEFT TO RIGHT. THE TREAD SEPARATED AND THE REAR DRIVER SIDE TIRE BLEW OUT. THE TIRE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE VEHICLE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 104,027. THE TIRE FAILURE MILEAGE WAS 95,404. UPDATED 09/10/15
NHTSA complaint #10733638 — an unverified report by a vehicle owner.
TIRES:TREAD/BELT
TL* THE CONTACT OWNS A 2003 FORD EXCURSION EQUIPPED WITH B.F. GOODRICH RUGGED TERRAIN (NA), TIRE LINE: LT26575R16 LOAD RANGER E (NA) TIRES. THE CONTACT STATED THAT THE TREAD SEPARATED ON THE REAR PASSENGER SIDE TIRE. THE TIRE WAS NOT REPLACED. THE TIRE FAILURE MILEAGE WAS 24,000 AND THE VEHICLE FAILURE MILEAGE WAS 98,000.
NHTSA complaint #10706637 — an unverified report by a vehicle owner.
TIRES
I HAVE A SET OF AUTOGUARD TIRES SIZE 265/78/16 THAT WERE INSTALLED ON MY SUV APX NOVEMBER OF 2013 IN OCTOBER OF 2014 THE TIRES STARTED TO DEVELOPED CRACK ALONG THE BEAD LINE ABOVE THE RIM. THIS IS THE SAME EFFECT OR DEFECT THAT RESULTED IN THE RECALL OF AUTOGUARD TIRE SIZE 245/75/16. BOTH THE TIRE THAT WERE THE SUBJECT OF THE RECALL AS WELL AS THE TIRES THAT WERE INSTALL ON MY SUV WERE MANUFACTURES IN THE SAME TIME PERIOD AND I BELIEVE HAVE THE SAME DOT NO OF 4412.
NHTSA complaint #10652499 — an unverified report by a vehicle owner.
TIRES
TL* THE CONTACT OWNS A 2000 FORD EXCURSION EQUIPPED WITH FIRESTONE TIRES, TIRE LINE: STEEL TEX RADIAL A/T, TIRE SIZE: LT 265/75R16. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH ON A DIRT ROAD, THE REAR DRIVER'S SIDE TIRE EXPLODED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND DISCOVERED THAT THE TREAD WAS SEPARATED FROM THE TIRE. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 200. THE DOT NUMBER WAS VNW81XL049. DJR
NHTSA complaint #10617226 — an unverified report by a vehicle owner.
TIRES
ON 6/5/2013, I WAS DRIVING ON FREEWAY AT APPROX. 70MPH AND TREAD SEPARATED FROM RT. REAR TIRE CAUSING VEHICLE TO SWERVE INTO ADJACENT LANE. DAMAGE TO QUARTER PANEL AND RUNNING BOARD. THIS IS THE SECOND TIRE FAILURE IN THE PAST 45 DAYS.THE TIRES ARE BFGOODRICH 265/75R/16 COMMERCIAL TA LOAD RANGE E. THE FOUR NEW TIRES WERE INSTALLED ON 2/28/2011 AND HAVE APPROX. 14,300 MILES OF WEAR AT TIME OF FAILURE. THE OTHER TIRE (LEFT FRONT) FAILED ON 4/19/2013. BECAUSE OF STRONG FRONT END VIBRATION, I INSPECTED THE FRONT TIRES. I FOUND THAT IT WAS OUT OF ROUND DUE TO BELT SEPARATION. THE DEALER REPLACED THIS TIRE ALSO.
NHTSA complaint #10515876 — an unverified report by a vehicle owner.
TIRES
I PURCHASED A 2005 FORD EXCURSION LIMITED USED IN MAY OF 2011. THE VEHICLE WAS PURCHASED WITH NEW BCT RADIAL A/P LT265/75R16 TIRES. AFTER APPROXIMATELY 2 MONTHS THE VEHICLE WOULD SHAKE AND VIBRATE AT HIGHWAY SPEEDS. ONE OF THE TIRES WAS FOUND TO BE OUT OF ROUND AND WAS REPLACED WITH A BF GOODRICH TIRE. NOW 13 MONTHS AFTER PURCHASE ONE OF THE OTHER BCT TIRES HAS SIDEWALL SEPARATION IN SEVERAL LOCATIONS. I AM NOW REPLACING ALL OF THE BCT TIRES TO PREVENT A SUDDEN AND CATASTROPHIC TIRE FAILURE.
NHTSA complaint #10465933 — an unverified report by a vehicle owner.
TIRES
WHILE DRIVING ON I-84 EAST BOUND, BETWEEN THE DALLES AND PENDLETON OREGON, OUR 2002 FORD EXCURSION EXPERIENCED A TIRE TREAD SEPARATION ON THE RIGHT REAR. WE EXPERIENCED A RECURRING POPPING SOUND JUST PRIOR TO THE TREAD SEPARATION. WE WERE PULLING A LIGHT TRAILER. TREAD SEPARATED BUT TIRE REMAINED INFLATED. I WAS ABLE TO SEE THE TREAD LEAVE THE TIRE IN MY RIGHT MIRROR AS IT HAPPENED. WE WERE TRAVELING UP HILL AT THE TIME SO SPEED WAS APPROXIMATELY 63MPH. DRY ROADS AND 93 DEGREES.
NHTSA complaint #10424129 — an unverified report by a vehicle owner.
TIRES
A GOODYEAR TREVA LT245/75R16 WITH 1000 MILES ON IT HAS SUFFERED SEPARATION OF THE RUBBER NEAR THE BEAD. THE INTERNAL TIRE CONSTITUENTS ARE VISIBLE. THE DEFECT RUNS (ON THE OUTSIDE OF THE TIRE) ABOUT 8" AND THE DELAMINATION GAP IS ABOUT 1/4". THE INSIDE OF THE WHEEL DEFECT IS 1" LONG AND 1/8" GAP. PICTURES OF HE DEFECT ARE AVAILABLE. NO ACCIDENT OR VEHICLE DAMAGE HAS OCCURRED. DEALER WAS NOT RESPONSIVE TO REMEDIATION ALTHOUGH ITS BEEN REPORTED THAT GOODYEAR LOAD RANGE E LIGHT TRUCK TIRES HAVE HAD MANY "SILENT RECALLS".
NHTSA complaint #10376773 — an unverified report by a vehicle owner.
TIRES
TL* THE CONTACT OWNS A 2003 FORD EXCURSION WITH COPPER REPLACEMENT TIRES, MODEL DISCOVERY HT 265/70R/16. WHILE DRIVING AT 65 MPH, THE CASING FRACTURED FROM THE REAR PASSENGER SIDE TIRE. THE TIRE WAS REPLACED. ONE YEAR LATER, THE EXACT SAME FAILURE OCCURRED ON THE DRIVER SIDE TIRE WHERE THE CONTACT WAS INVOLVED IN A CRASH. THE VEHICLE WAS FLIPPED ONCE, PROCEEDED TO CRASH INTO A TREE AND THEN LANDED UPRIGHT. ONE PASSENGER SUSTAINED MINOR INJURIES. A POLICE REPORT WAS AVAILABLE. THE MANUFACTURER WAS CONTACTED AND REQUESTED TO FURTHER INSPECT THE TIRES. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.
NHTSA complaint #10346136 — an unverified report by a vehicle owner.
TIRES
TL* THE CONTACT OWNS A 2000 FORD EXCURSION. THE VEHICLE HAS COOPER DOMINATOR SPORT A/T TIRES, LINE SIZE LT265/75/R16, DOT NUMBER UPW8XDJ3007. THE CONTACT STATED WHEN DRIVING AT SPEEDS OF 25 MPH AND OVER, THE STEERING WHEEL WOULD BECOME EXTREMELY WOBBLY. THE FAILURE PERSISTED AND BECAME PROGRESSIVELY WORSE OVER TIME. THE TIRES WERE TAKEN TO A TIRE SPECIALIST AND THE MECHANIC ADVISED THE TIRES EXHIBITED EXCESSIVE TREAD SEPARATION. ONE OF THE FRONT TIRES EXHIBITED VISIBLE TREAD SEPARATION AND WAS REPLACED AT THE MANUFACTURER'S EXPENSE. THE REMAINING THREE TIRES WOULD BE REPLACED AT THE CONTACT'S EXPENSE. THE CONTACT WAS ABLE TO LOCATE A RECALL FOR HIS BRAND AND LINE OF TIRES HOWEVER, THE RECALL DID NOT COVER HIS SPECIFIC TIRE SIZE (NHTSA CAMPAIGN ID NUMBER: 06T016000: TIRES: TREAD/BELT). THE REMAINING FOUR TIRES WERE NOT YET REPLACED. THE TIRES WERE PURCHASED IN 2008 AND THE TIRE FAILURE MILEAGE WAS 27,000. THE CURRENT AND FAILURE MILEAGE OF THE VEHICLE WAS 136,000.
NHTSA complaint #10343067 — an unverified report by a vehicle owner.
TIRES
MASTERCRAFT TIRE LT265/75R SEPARATION AND FAILURE RESULTING IN PROPERTY DAMAGE AND TEMPORARY LOSS OF CONTROL. THIS TIRE WAS THE SECOND TO FAIL. THE FIRST FAILED AND WAS REMOVED BEFORE TOTAL FAILURE. THE 2ND TIRE THAT FAILED WAS INSPECTED 10 MILES BEFORE TOTAL FAILURE. TWO OF THE 4 MASTERCRAFT TIRES FAILED WHILE OPERATING AT CORRECT PRESSURES AND LOADS WITH SPEEDS UNDER 60MPH.
NHTSA complaint #10331519 — an unverified report by a vehicle owner.
TIRES
COPPER TIRES DOMINATOR AT LT 305 70 16 PURCHASED FROM DISCOUNT TIRE 10-14-2005. THE VEHICLE A FORD 2001 EXCURSION HAD 86000 MILES ON IT. ON 11-24-2009 A BLOWOUT OCCURRED, RIGHT REAR TIRE. DAMAGING REAR TAIL LIGHT THE PAINT ON REAR DOOR AND REAR QTR PANEL WHEEL WELL TRIM DAMAGE RUNNING BOARD DAMAGE AND WHEEL DAMAGE. THE BLOWOUT SEPARATED THE TREAD FROM THE TIRE LEAVING THE BELTS EXPOSED.
NHTSA complaint #10293692 — an unverified report by a vehicle owner.