Owners have filed 1,040 complaints
about the 2011 Ford Fiesta with NHTSA between 2010 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 1 of 9 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Ford Fiesta. 50 means typical for this
model; 100 means roughly double.
Severity — 50
9.7% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 53
31% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
8949.4%
Door
3418.9%
Automatic Transmission
2312.8%
Latch
2111.7%
Control Module (Tcm/Pcm/Tecm)
42.2%
Fuses AND Circuit Breakers
42.2%
Clutch Assembly
31.7%
Headlights
21.1%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
495.7%
1,000 – 9,999 miles
586.8%
10,000 – 24,999 miles
708.2%
25,000 – 49,999 miles
18021.1%
50,000 – 74,999 miles
22426.2%
75,000 – 99,999 miles
14316.7%
100,000 – 149,999 miles
9811.5%
150,000+ miles
323.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Aug 2010peak 35Aug 2026
NHTSA investigations into the 2011 Ford Fiesta
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
RQ19005Opened 19 Dec 2019Closed 7 Feb 2022LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Door Latch Failures
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl sprin...
EA15002Opened 27 Feb 2015Closed 13 Nov 2015LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Door Latch Failure
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta, MY 2013 Ford Fusion and MY 2013 Lincoln MKZ vehicles. All of the affected vehicles share the same door latch design.ODI has received 281 unique reports related to the alleged problem, with over 100 claiming that the door(s) opened inadvertently while the vehicle was in motion. There were no crashes reported however three separate injuries were indicated, all caused by a rebounding door striking a consume...
PE14028Opened 11 Sep 2014Closed 18 Mar 2015LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Door Latch Failure
On September 11, 2014 the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE14-028) to investigate claims of doors failing to latch and/or inadvertently opening on model year (MY) 2011-2013 Ford Fiesta vehicles. ODI has received 207 unique reports related to the alleged problem, with sixty-five claiming that the door(s) opened inadvertently while the vehicle was in motion. Two injuries were reported, both caused by a rebounding door striking a consumer after they attempted to close it. In response to ODI's Information Request (IR), Ford Motor Company (Ford) responded wit...
Recalls on the 2011 Ford Fiesta
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
20V331000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
15V246000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Ford Motor Company (Ford) notified the agency on April 23, 2015, that they are recalling certain model year 2013-2014 Ford Fusion and Lincoln MKZ vehicles manufactured July 1, 2012, to May 31, 2013, and 2012-2014 Fiesta vehicles manufactured February 1, 2012, to May 31, 2013. On April 30, 2015, Ford expanded the recall to cover an additional 119,567 vehicles, including certain model year 2011 Ford Fiestas manufactured from November 11, 2009, to May 31, 2013 and certain model year 2013 Ford Fusion and Lincoln MKZ vehicles manufactured from February 1, 2012, to June 30, 2012. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
12V488000
AIR BAGS
Ford is recalling certain model year 2011-2013 Fiesta vehicles, manufactured from November 3, 2009 through September 21, 2012. The vehicles fail to comply with Federal Motor Vehicle Safety Standard (FMVSS) No. 208, "Occupant Crash Protection." The passenger side curtain air bag will not deploy in the event of a side impact collision when the front passenger seat is empty. Although the side curtain air bag system was designed to suppress the side curtain air bag under this scenario, that information is not explained in the owner's guide for these vehicles as required by FMVSS No. 208.
Risk: An occupant in the right rear seating position will not have coverage from the side curtain air bag in a side impact collision when the front passenger seat is empty, increasing the risk of injury to the right rear occupant.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201727411,899 units in Canada
Electrical
In certain vehicles registered and operated in areas where road salt is used on the roadways during winter months for extended time periods (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island and Newfoundland-Labrador), moisture containing road salt could enter the battery junction box and cause corrosion of the fuse and wiring terminals. This could result in a loss of electrical connectivity in some circuits related to the powertrain, potentially causing the vehicle to stall without the ability to restart. This could also affect the exterior lighting, which would decrease vehicle conspicuity. These conditions could increase the risk of crash causing injury and/or damage to property. Correction: Dealers will inspect, clean any corrosion off the terminals and replace any defective fuses. Seals will also be installed in the battery junction box to prevent future moisture entry.
Recall 201517550,681 units in Canada
Structure
On certain vehicles, the door latches may have a broken pawl spring tab. This could result in the door not latching correctly. As a result, doors which appear to be latched could unlatch while driving. This could increase the risk of injury to a vehicle occupant seated next to the door, or result in damage to property. Correction: Dealers will replace all four door latches with a more robust part.
Recall 201233227,967 units in Canada
Airbag
On certain vehicles, the Restraint Control Module will turn OFF the right side air curtain, as well as the front passenger seat-mounted side airbag, when the Occupant Classification System (OCS) senses the right front seat is not occupied. Although the vehicle meets prescribed Standards for side impact protection, failure of the right side air curtain to deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the right rear seat occupant. Correction: Dealers will reprogram the Restraint Control Module.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 173,712 milesPlano, TXFire
UNKNOWN OR OTHER
I NOTOICE BLACK SMOKE COMING OUT FROM MUFFLER AND ENGINE. THE AC QUITE BLOWING COLD AIR, AND CHECK ENGINE LIGHT STARTED FLASHING. FIRE IN THE ENGINE COMPART AND WHERE THE AC LINES IN BACK FIRE WALL ON THE BACK. IS WHERE FLAMES WHERE NOTICE
NHTSA complaint #11364388 — an unverified report by a vehicle owner.
at 180,000 milesShelby Township, MICrash1 injured
SEAT BELTS
ON AUGUST 5 I FELL ASLEEP AND RAN INTO THE BACK OF A TRUCK STOPPED AT A LIGHT. MY KNEE AIR BAG DEPLOYED BUT THE STEERING WHEEL BAG DID NOT AND THE SHOULDER BELT DID NOT DEPLOY CAUSING ME TO HIT THE STEERING WHEEL VERY HARD BRUISING MY STERNUM AND CAUSING SURROUNDING MUSCLE INFLAMMATION THAT IS STILL SORE TODAY.
NHTSA complaint #11363779 — an unverified report by a vehicle owner.
at 180,000 milesShelby Township, MICrash1 injured
AIR BAGS
ON AUGUST 5 I FELL ASLEEP AND RAN INTO THE BACK OF A TRUCK STOPPED AT A LIGHT. MY KNEE AIR BAG DEPLOYED BUT THE STEERING WHEEL BAG DID NOT AND THE SHOULDER BELT DID NOT DEPLOY CAUSING ME TO HIT THE STEERING WHEEL VERY HARD BRUISING MY STERNUM AND CAUSING SURROUNDING MUSCLE INFLAMMATION THAT IS STILL SORE TODAY.
NHTSA complaint #11363779 — an unverified report by a vehicle owner.
at 180,000 milesShelby Township, MICrash1 injured
STRUCTURE:BODY
ON AUGUST 5 I FELL ASLEEP AND RAN INTO THE BACK OF A TRUCK STOPPED AT A LIGHT. MY KNEE AIR BAG DEPLOYED BUT THE STEERING WHEEL BAG DID NOT AND THE SHOULDER BELT DID NOT DEPLOY CAUSING ME TO HIT THE STEERING WHEEL VERY HARD BRUISING MY STERNUM AND CAUSING SURROUNDING MUSCLE INFLAMMATION THAT IS STILL SORE TODAY.
NHTSA complaint #11363779 — an unverified report by a vehicle owner.
at 70,000 milesBirmingham, ALCrash
POWER TRAIN
TAKARA RECALL I'VE OWNED THIS DEATH TRAP SINCE 2012 AND HAS HAD THE DUAL TRANSMISSION REPLACED AT LEAST TWICE.. IT HAS ALWAYS JERKED AND STALLED OUT ON ME WHILE TRAVELING THROUGH INTERSECTIONS, PULLING OFF FROM STOP SIGNS/RED LIGHTS, AND WHILE DRIVING UP HILLS. IT'S EMBARRASSING, BUT MOST OF ALL UNSAFE FOR ME, MY CHILDREN, AND OTHER DRIVERS.
NHTSA complaint #11235217 — an unverified report by a vehicle owner.
at 70,000 milesBirmingham, ALCrash
VEHICLE SPEED CONTROL
TAKARA RECALL I'VE OWNED THIS DEATH TRAP SINCE 2012 AND HAS HAD THE DUAL TRANSMISSION REPLACED AT LEAST TWICE.. IT HAS ALWAYS JERKED AND STALLED OUT ON ME WHILE TRAVELING THROUGH INTERSECTIONS, PULLING OFF FROM STOP SIGNS/RED LIGHTS, AND WHILE DRIVING UP HILLS. IT'S EMBARRASSING, BUT MOST OF ALL UNSAFE FOR ME, MY CHILDREN, AND OTHER DRIVERS.
NHTSA complaint #11235217 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Stevensville, MD
ENGINE
Ford has had a long known issue with 2011-2015-FIESTA ( Cuautitlan ) they issued a Customer Satisfaction Program that ended June 2025. I purchased the car July 2026 used w/o none issues. Checked VIN for recall and Maryland Inspected. Driving it one week and the check engine light comes on. Apparently the TCM recognized a change in driving pattern but FORD will not honor the replacement. How is it not a safety issue with the vehicle can decide not to engage risking a collision? I am willing to pay for the labor of the part but would like the part covered as it should.
NHTSA complaint #11758235 — an unverified report by a vehicle owner.
Elyria, OH
STEERING
While driving my car with my two little nieces in the backseat, I heard a sound that made me think a wheel was coming off. As long as I was driving straight, the vehicle seemed to be okay. But when I made a turn onto the next road, something broke underneath the car and we began to spin around. It felt like the wheels were rubbing under the floor of the car and we were in the middle of the street. When I got out, I saw the rear wheels were cocked at an angle to the rest of the car. I thank God we weren't on a busy highway where we could have all been killed.
NHTSA complaint #11691605 — an unverified report by a vehicle owner.
Elyria, OH
UNKNOWN OR OTHER
While driving my car with my two little nieces in the backseat, I heard a sound that made me think a wheel was coming off. As long as I was driving straight, the vehicle seemed to be okay. But when I made a turn onto the next road, something broke underneath the car and we began to spin around. It felt like the wheels were rubbing under the floor of the car and we were in the middle of the street. When I got out, I saw the rear wheels were cocked at an angle to the rest of the car. I thank God we weren't on a busy highway where we could have all been killed.
NHTSA complaint #11691605 — an unverified report by a vehicle owner.
at 106,902 milesOakland Park, FL
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2011 Ford Fiesta. The contact stated that while driving at various speeds, the vehicle stalled. There was no warning light illuminated. The vehicle was pushed to the side of the road on several occasions. The vehicle was able to restart after 10 minutes; however, the failure recurred upon resuming driving. The vehicle was taken to an independent mechanic, where it was diagnosed. The mechanic related the failure to Ford Campaign Number: 15B22 (Transmission Control Module Reprogramming for Overt TCM Failure Warning). The dealer was contacted, and an appointment was scheduled for the vehicle to be repaired under Ford Campaign Number: 15B22. The contact stated that upon towing the vehicle to the dealer, the dealer refused to service the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 106,902.
NHTSA complaint #11684826 — an unverified report by a vehicle owner.
Lake In The Hills, IL
ELECTRICAL SYSTEM
I am having issues with the fuse box under the hood. I keep shorting out on my headlights ans AC clutch relay. I've purchased new head lights (bulbs), replaced them and they still didn't work. I checked the fuses after investigation online and they have blown. I had my AC completely fixed and it ran fine for a while, then stopped working. I had it checked and was told the AC relay clutch fuse was loose. I replaced it. Three weeks later it shorted out, again.
NHTSA complaint #11678059 — an unverified report by a vehicle owner.
at 130,000 milesAbingdon, VA
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2011 Ford Fiesta. The contact stated that while driving on a main road at 30 MPH, the transmission shifted independently to neutral(N). The contact pulled over and restarted the vehicle. The contact shifted to drive(D) and drove to the residence. The vehicle was towed to the local dealer, where it was diagnosed that the transmission control module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 130,000.
NHTSA complaint #11677798 — an unverified report by a vehicle owner.
at 144,000 milesPelion, SC
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owns a 2011 Ford Fiesta. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed but the vehicle failed to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the failure was not duplicated. Additionally, the contact received notification of Customer Satisfaction Program 14M02; however, the dealer informed the contact that there was no indication of transmission failure. The vehicle was not diagnosed or repaired. The contact stated that the failure failure recurred. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair could not be covered under an unknown special program or recall. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 144,000.
NHTSA complaint #11677361 — an unverified report by a vehicle owner.
at 144,000 milesPelion, SC
ENGINE
The contact owns a 2011 Ford Fiesta. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed but the vehicle failed to accelerate. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the failure was not duplicated. Additionally, the contact received notification of Customer Satisfaction Program 14M02; however, the dealer informed the contact that there was no indication of transmission failure. The vehicle was not diagnosed or repaired. The contact stated that the failure failure recurred. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair could not be covered under an unknown special program or recall. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 144,000.
NHTSA complaint #11677361 — an unverified report by a vehicle owner.
Fostoria, OH
UNKNOWN OR OTHER
I am reporting a serious mechanical and safety issue involving my 2011 Ford Fiesta. After receiving a partially state-funded engine replacement in June 2025, my vehicle began experiencing serious transmission problems shortly after. Within a month, it went into limp mode multiple times, and warning lights appeared: the wrench light, incline warning, and “Transmission Malfunction – Service Now” messages. A diagnostic scan revealed multiple DTCs related to the Transmission Control Module (TCM), Input/Output Shaft Speed Sensors, and Clutch A disengagement (P286F) — which I understand are linked to known issues with this model’s transmission. These failures make the car dangerous to drive. The vehicle has lost power unexpectedly, putting me at risk of an accident. I’ve also been told by the repair shop that I may now need a new transmission and/or TCM, despite just receiving a major engine repair. I am unable to afford another large repair and this situation has severely impacted my ability to travel safely. I am requesting an investigation into the Ford Fiesta’s transmission problems and to confirm whether this should have been covered by a recall or warranty extension. I want to also add that my transmission clutch was repaired by Ford only 2 years ago. Please advise if this falls under known manufacturer defects or safety bulletins, and whether Ford Motor Company can be held responsible for the faulty transmission and associated safety risks.
NHTSA complaint #11675540 — an unverified report by a vehicle owner.
Fostoria, OH
ELECTRICAL SYSTEM
I am reporting a serious mechanical and safety issue involving my 2011 Ford Fiesta. After receiving a partially state-funded engine replacement in June 2025, my vehicle began experiencing serious transmission problems shortly after. Within a month, it went into limp mode multiple times, and warning lights appeared: the wrench light, incline warning, and “Transmission Malfunction – Service Now” messages. A diagnostic scan revealed multiple DTCs related to the Transmission Control Module (TCM), Input/Output Shaft Speed Sensors, and Clutch A disengagement (P286F) — which I understand are linked to known issues with this model’s transmission. These failures make the car dangerous to drive. The vehicle has lost power unexpectedly, putting me at risk of an accident. I’ve also been told by the repair shop that I may now need a new transmission and/or TCM, despite just receiving a major engine repair. I am unable to afford another large repair and this situation has severely impacted my ability to travel safely. I am requesting an investigation into the Ford Fiesta’s transmission problems and to confirm whether this should have been covered by a recall or warranty extension. I want to also add that my transmission clutch was repaired by Ford only 2 years ago. Please advise if this falls under known manufacturer defects or safety bulletins, and whether Ford Motor Company can be held responsible for the faulty transmission and associated safety risks.
NHTSA complaint #11675540 — an unverified report by a vehicle owner.
Fostoria, OH
ENGINE
I am reporting a serious mechanical and safety issue involving my 2011 Ford Fiesta. After receiving a partially state-funded engine replacement in June 2025, my vehicle began experiencing serious transmission problems shortly after. Within a month, it went into limp mode multiple times, and warning lights appeared: the wrench light, incline warning, and “Transmission Malfunction – Service Now” messages. A diagnostic scan revealed multiple DTCs related to the Transmission Control Module (TCM), Input/Output Shaft Speed Sensors, and Clutch A disengagement (P286F) — which I understand are linked to known issues with this model’s transmission. These failures make the car dangerous to drive. The vehicle has lost power unexpectedly, putting me at risk of an accident. I’ve also been told by the repair shop that I may now need a new transmission and/or TCM, despite just receiving a major engine repair. I am unable to afford another large repair and this situation has severely impacted my ability to travel safely. I am requesting an investigation into the Ford Fiesta’s transmission problems and to confirm whether this should have been covered by a recall or warranty extension. I want to also add that my transmission clutch was repaired by Ford only 2 years ago. Please advise if this falls under known manufacturer defects or safety bulletins, and whether Ford Motor Company can be held responsible for the faulty transmission and associated safety risks.
NHTSA complaint #11675540 — an unverified report by a vehicle owner.
at 123,000 milesLong Beach, CA
POWER TRAIN
The contact owns a 2011 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the vehicle jerked, and failed to accelerate as intended while depressing the accelerator pedal. The vehicle stalled while driving. The contact waited for a short while and was able to restart the vehicle. The contact was able to move over to the side of the road. No warning lights were illuminated. The contact stated that on a separate occasion, while attempting to reverse out of a parking space, the vehicle failed to function while in reverse(R). The vehicle was taken to the dealer where it was diagnosed that the transmission PTU had failed. The vehicle was repaired. The contact stated that recently while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact was able to pull into a parking lot. An unknown warning light was illuminated. The contact turned off the vehicle and waited for a while and was able to restart the vehicle. The contact stated that while attempting to enter the driveway, the vehicle failed to respond while in reverse(R) and failed to move while in drive(D). The vehicle was not diagnosed or repaired. The dealer informed the contact that the vehicle warranty had expired in March 2025. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 123,000.
NHTSA complaint #11675149 — an unverified report by a vehicle owner.
at 196,489 milesBosque, NM
POWER TRAIN
The contact owns a 2011 Ford Fiesta. The contact stated that the vehicle hesitated or jerked while depressing the accelerator pedal with the check engine warning light illuminated on the instrument panel. The vehicle was taken to the dealer where the contact was informed that the shift motor was defective. The contact was informed that the part was covered under warranty and the vehicle was repaired. The contact stated that after the repair, the check engine warning light returned while leaving the dealer parking lot. The contact continued driving the vehicle and the vehicle entered LIMP Mode while driving to the residence. The vehicle was returned to the dealer the next day and the contact was informed that the transmission control module was defective and needed to be replaced. The dealer informed the contact that the repair was not covered under warranty and the contact was provided an estimate for the repair; the vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance and the contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 196,489.
NHTSA complaint #11671919 — an unverified report by a vehicle owner.
Alliance, OH
ELECTRICAL SYSTEM
Door locks keep unlocking and locking as I'm driving. It is very loud. 4 or 5 times as I'm going 35 and 60 mph
NHTSA complaint #11665936 — an unverified report by a vehicle owner.
at 144,000 milesPueblo, CO
ELECTRICAL SYSTEM
The contact owns a 2011 Ford Fiesta. The contact stated while driving at approximately 65 MPH, the vehicle stalled. The contact stated that the engine malfunction, ABS, and Hill Assist warning lights were illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed; however, the contact was unaware of the diagnostic result. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same mechanic who again diagnosed the vehicle and informed the contact that the vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken to a local dealer. The dealer diagnosed the vehicle and determined that the throttle body, engine electrical harness, and engine mounts needed to be replaced. The vehicle was repaired. The contact stated that the failure had reoccurred, and the vehicle stalled with white smoke coming from the exhaust pipes. The contact had not taken the vehicle back to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 144,000.
NHTSA complaint #11631636 — an unverified report by a vehicle owner.
at 144,000 milesPueblo, CO
ENGINE AND ENGINE COOLING
The contact owns a 2011 Ford Fiesta. The contact stated while driving at approximately 65 MPH, the vehicle stalled. The contact stated that the engine malfunction, ABS, and Hill Assist warning lights were illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed; however, the contact was unaware of the diagnostic result. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same mechanic who again diagnosed the vehicle and informed the contact that the vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken to a local dealer. The dealer diagnosed the vehicle and determined that the throttle body, engine electrical harness, and engine mounts needed to be replaced. The vehicle was repaired. The contact stated that the failure had reoccurred, and the vehicle stalled with white smoke coming from the exhaust pipes. The contact had not taken the vehicle back to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 144,000.
NHTSA complaint #11631636 — an unverified report by a vehicle owner.
at 144,000 milesPueblo, CO
ENGINE
The contact owns a 2011 Ford Fiesta. The contact stated while driving at approximately 65 MPH, the vehicle stalled. The contact stated that the engine malfunction, ABS, and Hill Assist warning lights were illuminated. The contact had taken the vehicle to an independent mechanic where it was diagnosed; however, the contact was unaware of the diagnostic result. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back to the same mechanic who again diagnosed the vehicle and informed the contact that the vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken to a local dealer. The dealer diagnosed the vehicle and determined that the throttle body, engine electrical harness, and engine mounts needed to be replaced. The vehicle was repaired. The contact stated that the failure had reoccurred, and the vehicle stalled with white smoke coming from the exhaust pipes. The contact had not taken the vehicle back to the dealer. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 144,000.
NHTSA complaint #11631636 — an unverified report by a vehicle owner.
at 82,000 milesParamus, NJ
POWER TRAIN
The contact owns a 2011 Ford Fiesta. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where the battery was replaced. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated to respond and sputtered. The contact stated that while attempting to start the vehicle the following day, the vehicle failed to start and was towed to an independent mechanic to be diagnosed. The mechanic related the failure to the transmission. The contact was referred to the dealer for an unknown recall repair. The manufacturer was notified of the failure and referred the contact to the dealer for the TCM to be replaced under Ford Campaign Number: 14M02. The vehicle was towed to the dealer, where the TCM was replaced; however, the dealer informed the contact that the TCM could not be programmed to the transmission clutch. The dealer determined that the transmission clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 82,000.
NHTSA complaint #11615956 — an unverified report by a vehicle owner.
at 82,000 milesParamus, NJ
ENGINE
The contact owns a 2011 Ford Fiesta. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer, where the battery was replaced. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle hesitated to respond and sputtered. The contact stated that while attempting to start the vehicle the following day, the vehicle failed to start and was towed to an independent mechanic to be diagnosed. The mechanic related the failure to the transmission. The contact was referred to the dealer for an unknown recall repair. The manufacturer was notified of the failure and referred the contact to the dealer for the TCM to be replaced under Ford Campaign Number: 14M02. The vehicle was towed to the dealer, where the TCM was replaced; however, the dealer informed the contact that the TCM could not be programmed to the transmission clutch. The dealer determined that the transmission clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 82,000.
NHTSA complaint #11615956 — an unverified report by a vehicle owner.
at 105,000 milesCarthage, NC
ELECTRICAL SYSTEM
The contact owns a 2011 Ford Fiesta. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who determined that there was abnormal corrosion around the wiring harness, causing an electrical fault. The vehicle was not repaired. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 22N11. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 105,000.
NHTSA complaint #11587871 — an unverified report by a vehicle owner.
Oldsmar, FL
WHEELS
The car hasn’t been sold since 2021 and I was told there where no issues with the car but it was sold as is it doesn’t start needs a new modem head gaskets maybe and it’s a lot that needs repairing
NHTSA complaint #11580696 — an unverified report by a vehicle owner.
Oldsmar, FL
UNKNOWN OR OTHER
The car hasn’t been sold since 2021 and I was told there where no issues with the car but it was sold as is it doesn’t start needs a new modem head gaskets maybe and it’s a lot that needs repairing
NHTSA complaint #11580696 — an unverified report by a vehicle owner.
Oldsmar, FL
ENGINE
The car hasn’t been sold since 2021 and I was told there where no issues with the car but it was sold as is it doesn’t start needs a new modem head gaskets maybe and it’s a lot that needs repairing
NHTSA complaint #11580696 — an unverified report by a vehicle owner.
Mexicali, CA
POWER TRAIN
Transmission overheating stopped car
NHTSA complaint #11576437 — an unverified report by a vehicle owner.
Mexicali, CA
ELECTRICAL SYSTEM
Transmission overheating stopped car
NHTSA complaint #11576437 — an unverified report by a vehicle owner.