2014 Ford Fiesta problems

UNKNOWN OR OTHER

My vehicle has an active status under Ford Safety Recall 20S15 (NHTSA Campaign 20V177) for a fractured door latch pawl spring. The defect has fully manifested: my side door physically will not latch or stay shut. There was no warning that the latch has malfunctioned. I was driving and my door swung open when I made a turn. I’ve been trying to get my car serviced because of the safety recall involving the door latch. Unfortunately, my driver’s side passenger door won’t physically shut. While my recall allows for free repairs, I can’t drive my car to the dealership because it’s unsafe. I’ve spoken to supervisors in Customer Relations, Services, and Body Shop, as well as Recall Corporate. I was also told that Lee would give me a call today, but I haven’t received a call back. Brandy Seals suggested using rope to tie the door shut, but I’m concerned about traveling from New Market in such a situation. I spoke with The Cooperate Recall Center, and they informed me that “Pick up and Delivery” is available under my provision. However, since my car is unsafe to drive, they couldn’t accommodate that request. I then asked for a mobile service van to come to my home to avoid towing, but that was denied as well. I also requested to have my car towed to the dealership, but that was denied as well. I’m a single mother of three, and this car is my only mode of transportation. Unfortunately, I don’t have the finances to pay for towing myself. Could you please assist me with this situation?

NHTSA complaint #11752239 — an unverified report by a vehicle owner.

POWER TRAIN

Brand new OEM ford clutch slave cylinder failed while in traffic. Part number DG9Z-7A564-B fell apart during test drive after it was newly installed. Lost ability to use the clutch pedal and could not pull the car out of gear while in traffic. Component was not inspected by manufacturer yet, there were no warning lights on the dash when it occurred. Was able to get the car back home and noticed brake fluid pouring out from inside the bell housing of the transmission where the slave cylinder is housed.

NHTSA complaint #11736922 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

I WAS TOLD WAY BACK WHEN THAT DOOR LATCHES HAD A DEFECT. THAT THERE WAS A RECALL. COLONIAL FORD OF DANBURY CT AVOIDED DOING THE COMPLETE RECALLS. SUCH IS SO THAT I PAID OUT OF POCKET A TRANSMISSION REBUILD AND TOOK FORD 2 YEARS TO REEMBURSE ME THE COST. BUT THE DOOR LATCH RECALL WAS STILL IN EFFECT. IT TURNS OUT THAT IM GETTING A DOOR OPEN WARNING ON DASH WHILE DOORS ARE CLOSED. THIS WAS A DEFECT RECALL GOING BACK 5-6 YEARS BUT WAS NEVER REPLACED. NOW DEALER TELLS ME MY CAR WAS'NT PART OF THE RECALL.

NHTSA complaint #11728773 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I WAS TOLD WAY BACK WHEN THAT DOOR LATCHES HAD A DEFECT. THAT THERE WAS A RECALL. COLONIAL FORD OF DANBURY CT AVOIDED DOING THE COMPLETE RECALLS. SUCH IS SO THAT I PAID OUT OF POCKET A TRANSMISSION REBUILD AND TOOK FORD 2 YEARS TO REEMBURSE ME THE COST. BUT THE DOOR LATCH RECALL WAS STILL IN EFFECT. IT TURNS OUT THAT IM GETTING A DOOR OPEN WARNING ON DASH WHILE DOORS ARE CLOSED. THIS WAS A DEFECT RECALL GOING BACK 5-6 YEARS BUT WAS NEVER REPLACED. NOW DEALER TELLS ME MY CAR WAS'NT PART OF THE RECALL.

NHTSA complaint #11728773 — an unverified report by a vehicle owner.

POWER TRAIN

Transmission was supposedly rebuilt back July 26, 3021. Now transmission has had a new dual clutch replaced but other concerns are still there jerkiness on accelerations. In 2021 the transmission was not fully rebuild as per recall. Only clutch assembly was done and not the back end. Which now could be the problem. Second, colonial Ford sated transmission rebuilt has lifetime warranty which a lie. Colonial Ford doesn’t offer lifetime. The service advisors lie about this all the time. Now the car jerks on acceleration after clutch replacement. Dealer and Ford still take no responsibility over the product! The car has 145,000 miles still under the 150,000 mile warranty isssue by you!

NHTSA complaint #11726642 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Transmission was supposedly rebuilt back July 26, 3021. Now transmission has had a new dual clutch replaced but other concerns are still there jerkiness on accelerations. In 2021 the transmission was not fully rebuild as per recall. Only clutch assembly was done and not the back end. Which now could be the problem. Second, colonial Ford sated transmission rebuilt has lifetime warranty which a lie. Colonial Ford doesn’t offer lifetime. The service advisors lie about this all the time. Now the car jerks on acceleration after clutch replacement. Dealer and Ford still take no responsibility over the product! The car has 145,000 miles still under the 150,000 mile warranty isssue by you!

NHTSA complaint #11726642 — an unverified report by a vehicle owner.

SEAT BELTS

Seat Belt retractor/pretensioner failed and was causing the passenger seatbelt light to go off. Had to repair due to automatic failing of inspection for this issue and the major safety issue this poses. Auto shop charged me $784.82 for today's repair and over $300 (don't remember exact amount, if claim moves forward I will contact them for another copy of that invoice) for a different repair on the seatbelt. I called Ford and they told me their 5 Year/60K warranty on the car expired. I told them that under Federal Code 49 USC Subsection 30120 the manufacturer is required to repair such safety, they told me they couldn't help me and to go away, despite the clear language of this code. Therefore, I am filing this complaint against the Fiesta/ Ford Motor Company (not sure who exactly, I haven't done this before) to request reimbursement under federal law for defective safety equipment. Do not have both bills. The most recent bill will be uploaded. If this claim can move forward, please let me know and I will henceforth retrieve the earlier invoice for the failed attempt at the independent auto repair shop for evaluation and possible compensation.

NHTSA complaint #11682919 — an unverified report by a vehicle owner.

POWER TRAIN

I’m reporting a failure with the Transmission Control Module (TCM) in my 2014 Ford Fiesta. The vehicle has exhibited consistent issues tied to the known PowerShift DPS6 transmission defect: including gear slipping, delayed acceleration, hesitation, and sudden loss of power while driving—particularly dangerous during intersections or merging situations. Ford previously issued Customer Satisfaction Program 14M02 to address this issue, but I was told my VIN is no longer eligible due to build date. I also requested coverage under Ford’s one-time TCM replacement extension announced in 2023, which was meant to support customers outside the 10-year window through June 30, 2025—but I was denied this assistance as well. I’ve opened a formal case with Ford Customer Relationship Center under reference number CXH05170436-N7Z6Z1, after being denied support for a documented transmission control module failure. These symptoms present a clear safety risk, and the refusal to support a documented transmission failure—even under goodwill— I hope this will be reconsidered for safety investigation.

NHTSA complaint #11678521 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)

The contact owns a 2014 Ford Fiesta. The contact stated that while his wife was driving at an undisclosed speed, the vehicle jerked, and an abnormal sound was coming from the engine. Several unknown warning lights were illuminated, and unknown messages were displayed. The contact's wife continued driving at slower speeds. The vehicle was towed to an independent mechanic who diagnosed that the transmission control module (TCM) and engine control module (ECM) had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 69,000.

NHTSA complaint #11675845 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)

The contact owns a 2014 Ford Fiesta. The contact stated that while his wife was driving at an undisclosed speed, the vehicle jerked, and an abnormal sound was coming from the engine. Several unknown warning lights were illuminated, and unknown messages were displayed. The contact's wife continued driving at slower speeds. The vehicle was towed to an independent mechanic who diagnosed that the transmission control module (TCM) and engine control module (ECM) had failed and needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 69,000.

NHTSA complaint #11675845 — an unverified report by a vehicle owner.

ENGINE

Ford and ford dealearship is not willing to provide or service 15B22 recalls.

NHTSA complaint #11675560 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

I own a 2014 Ford Fiesta. On June 23, 2025, I brought my car to McCarthy Ford in Chicago due to a check engine light and other concerns. I told them I didn’t know what was wrong and paid for a diagnosis on my car. They fixed the hood and only mentioned the issue with my catalytic converter, which I could not afford to repair at the time. However, they never mentioned or inspected the Transmission Control Module (TCM) even though my car was eligible for extended coverage under Customer Satisfaction Program 14M02, which expired a week later on June 30th, 2025. Shortly after that visit, I relocated to Phoenix, AZ, and the vehicle began showing clear TCM failure symptoms: loss of acceleration, inability to reverse, and the wrench warning light. Ford corporate told me only the original servicing dealership could escalate the case for goodwill repair, but despite multiple attempts to contact them, I have received no response. While the converter was noted, that is an emissions issue. My current problem is a known, unrelated transmission defect that has now left my car unsafe to drive. The failure occurred just days after the TCM warranty expired, and Ford’s system never flagged it during my visit. This is a serious safety issue that deserves further investigation, as it puts drivers at risk of stalling or losing control in traffic. I am requesting that NHTSA take action and require Ford to provide repairs or accountability for affected owners.

NHTSA complaint #11673505 — an unverified report by a vehicle owner.

POWER TRAIN

Vehicle presented to A&T Auto Repair with rotation-dependent clunking sound. This clunking started after loud metallic snapping noise occurred while coasting in gear on a flat surface. Mechanic noted that clunking noise came from the transaxle. Once the transmission fluid was drained, metallic grit and large chunks resembling gear teeth were found in fluid. A replacement transaxle was installed, along with a new "clutch kit" containing flywheel, pressure plate, and slave cylinder. Following installation and engine start up, slave cylinder leaked, prompting the order of new parts and replacement labor. According to Mechanic, four different slave cylinders from two separate manufacturers leaked in the same fashion upon engine startup, due to a "locking" malfunction of the slave cylinder. The recurrent nature of the parts failure seems to indicate a deficiency in part design that causes a fluid leak, possibly endangering driver and passengers in the event of a transmission failure.

NHTSA complaint #11671633 — an unverified report by a vehicle owner.

STRUCTURE:BODY

The door latch on one of the doors has a broken piece inside of it that won't allow the door to close, no dealer has checked it out yet, my safety is a concern because any of the doors could break as well and open while I'm driving

NHTSA complaint #11665792 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2014 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, and the contact became aware that the braking system had overheated. There was no warning light illuminated. The vehicle was taken to the independent mechanic, where it was diagnosed that the ABS module had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and a case was opened. The contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 64,000.

NHTSA complaint #11660340 — an unverified report by a vehicle owner.

POWER TRAIN

The vehicle has experienced ongoing failures with the DPS6 PowerShift transmission system. Symptoms included slipping between gears, failure to engage 6th gear, jerky shifting, and bucking during acceleration. A transmission warning light appeared multiple times. These issues occurred daily and worsened over time. Eventually, the vehicle became unsafe to drive—it would over-rev, buck violently, and lose power during traffic conditions. A retired Ford Senior Master Technician confirmed the issue is consistent with a faulty Transmission Control Module (TCM), which is covered under Ford’s Customer Satisfaction Program (CSP) 14M02. Despite this, the dealership refused to replace the TCM. Instead, they replaced a speed sensor and returned it to me. The vehicle broke down again within minutes and had to be returned. The dealership has now suggested dropping the transmission for further inspection at a cost of $2,500, rather than honoring CSP 14M02. They also encouraged me to trade in the vehicle instead of repairing it. The TCM failure has not been resolved, and the vehicle remains unsafe to drive.

NHTSA complaint #11659807 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

The vehicle has experienced ongoing failures with the DPS6 PowerShift transmission system. Symptoms included slipping between gears, failure to engage 6th gear, jerky shifting, and bucking during acceleration. A transmission warning light appeared multiple times. These issues occurred daily and worsened over time. Eventually, the vehicle became unsafe to drive—it would over-rev, buck violently, and lose power during traffic conditions. A retired Ford Senior Master Technician confirmed the issue is consistent with a faulty Transmission Control Module (TCM), which is covered under Ford’s Customer Satisfaction Program (CSP) 14M02. Despite this, the dealership refused to replace the TCM. Instead, they replaced a speed sensor and returned it to me. The vehicle broke down again within minutes and had to be returned. The dealership has now suggested dropping the transmission for further inspection at a cost of $2,500, rather than honoring CSP 14M02. They also encouraged me to trade in the vehicle instead of repairing it. The TCM failure has not been resolved, and the vehicle remains unsafe to drive.

NHTSA complaint #11659807 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The vehicle has experienced ongoing failures with the DPS6 PowerShift transmission system. Symptoms included slipping between gears, failure to engage 6th gear, jerky shifting, and bucking during acceleration. A transmission warning light appeared multiple times. These issues occurred daily and worsened over time. Eventually, the vehicle became unsafe to drive—it would over-rev, buck violently, and lose power during traffic conditions. A retired Ford Senior Master Technician confirmed the issue is consistent with a faulty Transmission Control Module (TCM), which is covered under Ford’s Customer Satisfaction Program (CSP) 14M02. Despite this, the dealership refused to replace the TCM. Instead, they replaced a speed sensor and returned it to me. The vehicle broke down again within minutes and had to be returned. The dealership has now suggested dropping the transmission for further inspection at a cost of $2,500, rather than honoring CSP 14M02. They also encouraged me to trade in the vehicle instead of repairing it. The TCM failure has not been resolved, and the vehicle remains unsafe to drive.

NHTSA complaint #11659807 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2014 Ford Fiesta. The contact stated that while driving at an undisclosed speed, the RPM increased quickly to over 7,000 RPM; however, the vehicle lost motive power. The contact was able to pull over to the shoulder of the roadway, where the failure persisted. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the Transmission Control Module (TCM), resulting in damages to the clutch. The contact was informed that the transmission and clutch needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 59,000.

NHTSA complaint #11652018 — an unverified report by a vehicle owner.

STRUCTURE:BODY

2014 Ford Fiesta manual sedan exhibiting recurring, dangerous hood latch malfunction (recently noticed) where hood unlatches while driving/parked & experiencing sudden power loss when AC is used (fuse removed to prevent this dangerous condition). Potential safety hazards: obstructed vision, hood detachment, engine tampering, sudden loss of control. Ford Service Advisor admitted hood latch "should" be a recall, yet dealership attempts to charge $350-$500 ($250 diagnostic) for repair instead of initiating recall. This raises concerns Ford prioritizes profit over safety, esp. since Fiesta is discontinued. Other issues include previous brake pad lock-up requiring costly ABS Hydraulic Control Unit repair & door latch recall 20S15 ("door may unlatch while driving"). Multiple recurring issues suggest vehicle may be a lemon overall. Request immediate NHTSA investigation into hood latch defect & electrical/AC power loss issue. Urge recall consideration. I will gladly allow my vehicle to be studied in a NHTSA lab to aid investigation. Concern heightened by Ford's discontinuation of model.

NHTSA complaint #11650672 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

2014 Ford Fiesta manual sedan exhibiting recurring, dangerous hood latch malfunction (recently noticed) where hood unlatches while driving/parked & experiencing sudden power loss when AC is used (fuse removed to prevent this dangerous condition). Potential safety hazards: obstructed vision, hood detachment, engine tampering, sudden loss of control. Ford Service Advisor admitted hood latch "should" be a recall, yet dealership attempts to charge $350-$500 ($250 diagnostic) for repair instead of initiating recall. This raises concerns Ford prioritizes profit over safety, esp. since Fiesta is discontinued. Other issues include previous brake pad lock-up requiring costly ABS Hydraulic Control Unit repair & door latch recall 20S15 ("door may unlatch while driving"). Multiple recurring issues suggest vehicle may be a lemon overall. Request immediate NHTSA investigation into hood latch defect & electrical/AC power loss issue. Urge recall consideration. I will gladly allow my vehicle to be studied in a NHTSA lab to aid investigation. Concern heightened by Ford's discontinuation of model.

NHTSA complaint #11650672 — an unverified report by a vehicle owner.

SERVICE BRAKES

2014 Ford Fiesta manual sedan exhibiting recurring, dangerous hood latch malfunction (recently noticed) where hood unlatches while driving/parked & experiencing sudden power loss when AC is used (fuse removed to prevent this dangerous condition). Potential safety hazards: obstructed vision, hood detachment, engine tampering, sudden loss of control. Ford Service Advisor admitted hood latch "should" be a recall, yet dealership attempts to charge $350-$500 ($250 diagnostic) for repair instead of initiating recall. This raises concerns Ford prioritizes profit over safety, esp. since Fiesta is discontinued. Other issues include previous brake pad lock-up requiring costly ABS Hydraulic Control Unit repair & door latch recall 20S15 ("door may unlatch while driving"). Multiple recurring issues suggest vehicle may be a lemon overall. Request immediate NHTSA investigation into hood latch defect & electrical/AC power loss issue. Urge recall consideration. I will gladly allow my vehicle to be studied in a NHTSA lab to aid investigation. Concern heightened by Ford's discontinuation of model.

NHTSA complaint #11650672 — an unverified report by a vehicle owner.

POWER TRAIN

Driving at highway speed, the vehicle began to switch between the 5 and 6 gear without warning several times, and a message "TRANSMISSION FAULT SERVICE NOW" appeared on the car's dashboard display. The car then started hard-shifting, would not shift into some of the gears, and would not move in reverse. The car had poor acceleration and limited power and it was difficult to pass and keep up with other road traffic. Dealer estimate $4400 for clutch repair internal to transmission.

NHTSA complaint #11650247 — an unverified report by a vehicle owner.