Owners have filed 77 complaints
about the 2018 Ford Transit with NHTSA between 2018 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 5 of 10 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 37
Against the median year of the Ford Transit. 50 means typical for this
model; 100 means roughly double.
Severity — 54
10.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 72
43% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
12.5%
1,000 – 9,999 miles
615.0%
10,000 – 24,999 miles
410.0%
25,000 – 49,999 miles
1127.5%
50,000 – 74,999 miles
37.5%
75,000 – 99,999 miles
615.0%
100,000 – 149,999 miles
12.5%
150,000+ miles
820.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2018peak 4Aug 2026
Recalls on the 2018 Ford Transit
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2025449122,125 units in Canada
Visual System
Issue: On certain vehicles, there could be a problem with the connections inside the rearview camera. As a result, the rearview camera image may not display correctly or at all when the transmission is shifted into reverse. Note: For certain models, this recall also affects incomplete vehicles. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the rearview camera.
Recall 202139636,496 units in Canada
Visual System
Issue: On certain vans, the pivot points for the side mirrors could rust. If this happens, the mirrors could become loose or fall down. Note: This recall only affects vans equipped with short arm, manual fold, power-adjustable outside rearview mirrors. The recall applies to vehicles originally sold or currently registered in areas of heavy road salt usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador). Safety Risk: A side mirror that loosens or separates could reduce rear visibility and increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealer to replace the side mirrors.
Recall 2018216753 units in Canada
Electrical
On certain vehicles equipped with a trailer lighting control module, or that had a trailer lighting control module installed as an aftermarket accessory, water may enter the module and connector, and could cause wiring corrosion and damage to the module. This could result in an electrical short to ground, which could cause an uncommanded seat belt pretensioner deployment, a burning smell and/or an increased risk of fire, even when the vehicle is parked and the ignition is off. This may also cause turn signals to flash rapidly as well as cause a loss of the instrument cluster display, heater and air conditioning controls, and multimedia system (radio, screens, SYNC). An electrical short could increase the risk of injury and/or damage to property. Correction: Dealers will add a drainage hole to the driver’s door stepwell and incorporate a fuse into the vehicle wiring harness. Note: This recall is an expansion of recall 2017-516.
Reports where the owner recorded a crash, a fire, an injury or a death.
Bloomington, INCrash2 injured
VEHICLE SPEED CONTROL
The contact owns a 2018 Ford Transit. The contact stated that while slowly driving into a parking space, the vehicle suddenly experienced unintended acceleration and crashed into another parked vehicle. During the incident, the brake pedal was pressed, but the vehicle did not stop. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. No injuries were reported and a police report was taken at the scene. Also, the vehicle later experienced the same failure. While attempting to park the vehicle again experienced unintended acceleration and drove forward, crashing into a second vehicle. During the crash, the two front occupants of the second vehicle had sustained undisclosed injuries that later required medical treatment. No further information was available. A police report was taken at the scene. The vehicle was towed to the local dealer, who was unable to determine the cause of the second failure. The contact indicated that the failure had recently reoccurred for the third time. The cause of the failures was not determined. The manufacturer was not contacted regarding the failures. The failure mileage was unknown.
NHTSA complaint #11666727 — an unverified report by a vehicle owner.
at 110,000 milesLeonard, TX7 injured
ENGINE
The contact owns a 2018 Ford Transit. The contact stated while driving at various speeds, the vehicle made an abnormal whistling sound. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where an unknown sensor was replaced, and the check engine warning light was no longer illuminated. Additionally, the contact stated while driving 60 MPH with her husband and 5 children in the vehicle, they all started having severe headaches, were dizzy and her daughter 's ears were ringing. The contact stated that she pulled to the side of the road for a moment. Then she rolled down the windows and drove to the residence. The contact stated that her 5 years old and 8 years old vomited upon arriving at the residence. The contact and her family did not seek medical assistance. The contact stated that they were able to recover after 24 hours. The vehicle was taken to an independent mechanic, where it was diagnosed that the exhaust manifold bolts were fractured, causing carbon monoxide to leak inside the cabin of the vehicle. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and informed the contact that they aware of the failure and that an improved part had been made. The manufacturer referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 110,000.
NHTSA complaint #11577564 — an unverified report by a vehicle owner.
Charlotte, NCFire
ELECTRICAL SYSTEM
On March 7, 2023, at approximately 1:45 PM, Bus 437 had caught fire in the engine compartment of the vehicle while sitting in the parking lot. The bus had just came off of a route minutes before & the driver had reported the dash tell tale (warning) lights had come on. The Operator switched the engine off and then noticed smoke coming from the engine compartment area prior to the thermal event. The fire caused significant damage & the vehicle is a total loss; the engine compartment, bus body, interior as well as exterior and top cap of the bus were affected. An independent firm was hire to conduct the fire investigation ( EFI Global, Inc.) & determined the source of the fire to be a power supply from the vehicles jump box; however our history with alternator failures & consumption of these components combined with my mechanical experience leads me to believe that the root cause of this has been overlooked and the alternator failures need to be further investigated for public safety reasons. I have engage the dealer principal (Creative Bus Sales, Inc.) who we purchased the vehicle from whom is working with Ford on this matter. The Alternator is the component that I want investigated & the one in question has not been removed from the vehicle however we did break down 3 alternators from our inventory of failed cores & the findings support my theory as the alternator (diodes) being the culprit of the failures. The cause of the fire is believed to be a situation created when the single alternator overheated causing the diode bridge to fail & alternator to ignite. We have experienced alternator failures on this group of buses since the vehicles inception into the fleet going back to 2018. 38 of these model buses were purchased & placed into service in 2018 & we have replaced 283 alternators since they were placed into service (very high consumption/failure rates).
NHTSA complaint #11519262 — an unverified report by a vehicle owner.
at 32,000 milesHOT Springs, AR2 injured
SEAT BELTS
1. RAIN SENSING WIPERS WORK INTERMITTENTLY BARELY WHEN DRIVING. TOLD BY SALES MANAGER THAT "THEY WORK BUT IT ISN'T A PERFECT SYSTEM" 2. A.M. LIMITED RECEPTION IN WIDE OPEN AREAS IN MULTIPLE LARGE POPULATION AREAS. SITTING OR DRIVING BOTH. TRIED TO USE FOR 530 A.M. ROAD INFORMATION & WOULDN'T WORK. 3. BODY ROOF SEAL CAME LOOSE FROM ROOF DRIVING HOME IN COLD WEATHER. 4. TIRE PRESSURE SENSOR FAULT GOES OFF AND ON WHILE DRIVING. 5. SEAT BELT HEIGHT ADJUSTMENT TAB ON FRONT PASSENGER SIDE FELL OFF. NOT COVERED BY FORD BECAUSE IT IS PLASTIC. 6. CUSTOMER CONNECTION POWER POINT ON DRIVERS SEAT PEDESTAL MISSING A MOUNTING NUT FROM FACTORY. WE HAVE BEEN TOLD THAT THE POWER POINT IS NOT FACTORY BECAUSE WE CONNECTED INTO THE PORT AS IT WAS DESIGNED FOR. STUD THREADS ARE STILL UNMARKED (NEW). THIS ALLOWS THE LOWER SECTION OF CCP TO BE SLIGHTLY LOOSE. 7. AC VENTS ON MAX BLOWING OUT 65-70 DEGREE AIR AT IDLE IN 80 DEGREE OUTSIDE AMBIENT TEMP. (KNOWN ISSUE) 8. OVERHEAD A/C LOUVERED VENTS ARE BREAKING INTERNALLY WHEN ADJUSTED. ONE ENTIRE VENT FELL OUT WHILE DRIVING DOWN THE ROAD ONTO MY CHILD'S HEAD WHO COULDN'T TOUCH IT. NOT COVERED BECAUSE THEY BROKE BUT THEY AREN'T A MECHANICAL FAILURE. DAUGHTER HAD SCRATCH ON HER FOREHEAD WHERE IT HIT HER. 10. OPENED UP HEADLAMP LENS TO UPGRADE THE LIGHTS AND THE LOW BEAM PIG TAIL ON BOTH LIGHTS ARE ALREADY DETERIORATING FROM THE LENS HEAT. LIGHTLY TOUCHED EACH OF THE LOCKING CLIPS AND WITHOUT LIFTING EITHER ONE AND THEY FELL OFF. HIGH BEAM WHICH ARE USED MUCH LESS HAVE PERFECT LOCKING TABS STILL. REQUIRED TO MAINTAIN CONTINUITY TO THESE LIGHTS. 11. LAST WEEK A PLUG IN THE DRIVERS DOOR THRESHOLD OVER FRAME BOLT TRIPPED ME WHEN IT CAME UP AS I WAS STEPPING OUT. SECOND TO FALL OUT. ALL THIS TOLD TO US UNDER THE 36K BUMPER TO BUMPER YET DEALER IS WILLING TO CHARGE ME FOR THE DEFECTIVE PARTS.
NHTSA complaint #11208107 — an unverified report by a vehicle owner.
at 32,000 milesHOT Springs, AR2 injured
WHEELS
1. RAIN SENSING WIPERS WORK INTERMITTENTLY BARELY WHEN DRIVING. TOLD BY SALES MANAGER THAT "THEY WORK BUT IT ISN'T A PERFECT SYSTEM" 2. A.M. LIMITED RECEPTION IN WIDE OPEN AREAS IN MULTIPLE LARGE POPULATION AREAS. SITTING OR DRIVING BOTH. TRIED TO USE FOR 530 A.M. ROAD INFORMATION & WOULDN'T WORK. 3. BODY ROOF SEAL CAME LOOSE FROM ROOF DRIVING HOME IN COLD WEATHER. 4. TIRE PRESSURE SENSOR FAULT GOES OFF AND ON WHILE DRIVING. 5. SEAT BELT HEIGHT ADJUSTMENT TAB ON FRONT PASSENGER SIDE FELL OFF. NOT COVERED BY FORD BECAUSE IT IS PLASTIC. 6. CUSTOMER CONNECTION POWER POINT ON DRIVERS SEAT PEDESTAL MISSING A MOUNTING NUT FROM FACTORY. WE HAVE BEEN TOLD THAT THE POWER POINT IS NOT FACTORY BECAUSE WE CONNECTED INTO THE PORT AS IT WAS DESIGNED FOR. STUD THREADS ARE STILL UNMARKED (NEW). THIS ALLOWS THE LOWER SECTION OF CCP TO BE SLIGHTLY LOOSE. 7. AC VENTS ON MAX BLOWING OUT 65-70 DEGREE AIR AT IDLE IN 80 DEGREE OUTSIDE AMBIENT TEMP. (KNOWN ISSUE) 8. OVERHEAD A/C LOUVERED VENTS ARE BREAKING INTERNALLY WHEN ADJUSTED. ONE ENTIRE VENT FELL OUT WHILE DRIVING DOWN THE ROAD ONTO MY CHILD'S HEAD WHO COULDN'T TOUCH IT. NOT COVERED BECAUSE THEY BROKE BUT THEY AREN'T A MECHANICAL FAILURE. DAUGHTER HAD SCRATCH ON HER FOREHEAD WHERE IT HIT HER. 10. OPENED UP HEADLAMP LENS TO UPGRADE THE LIGHTS AND THE LOW BEAM PIG TAIL ON BOTH LIGHTS ARE ALREADY DETERIORATING FROM THE LENS HEAT. LIGHTLY TOUCHED EACH OF THE LOCKING CLIPS AND WITHOUT LIFTING EITHER ONE AND THEY FELL OFF. HIGH BEAM WHICH ARE USED MUCH LESS HAVE PERFECT LOCKING TABS STILL. REQUIRED TO MAINTAIN CONTINUITY TO THESE LIGHTS. 11. LAST WEEK A PLUG IN THE DRIVERS DOOR THRESHOLD OVER FRAME BOLT TRIPPED ME WHEN IT CAME UP AS I WAS STEPPING OUT. SECOND TO FALL OUT. ALL THIS TOLD TO US UNDER THE 36K BUMPER TO BUMPER YET DEALER IS WILLING TO CHARGE ME FOR THE DEFECTIVE PARTS.
NHTSA complaint #11208107 — an unverified report by a vehicle owner.
at 32,000 milesHOT Springs, AR2 injured
VISIBILITY/WIPER
1. RAIN SENSING WIPERS WORK INTERMITTENTLY BARELY WHEN DRIVING. TOLD BY SALES MANAGER THAT "THEY WORK BUT IT ISN'T A PERFECT SYSTEM" 2. A.M. LIMITED RECEPTION IN WIDE OPEN AREAS IN MULTIPLE LARGE POPULATION AREAS. SITTING OR DRIVING BOTH. TRIED TO USE FOR 530 A.M. ROAD INFORMATION & WOULDN'T WORK. 3. BODY ROOF SEAL CAME LOOSE FROM ROOF DRIVING HOME IN COLD WEATHER. 4. TIRE PRESSURE SENSOR FAULT GOES OFF AND ON WHILE DRIVING. 5. SEAT BELT HEIGHT ADJUSTMENT TAB ON FRONT PASSENGER SIDE FELL OFF. NOT COVERED BY FORD BECAUSE IT IS PLASTIC. 6. CUSTOMER CONNECTION POWER POINT ON DRIVERS SEAT PEDESTAL MISSING A MOUNTING NUT FROM FACTORY. WE HAVE BEEN TOLD THAT THE POWER POINT IS NOT FACTORY BECAUSE WE CONNECTED INTO THE PORT AS IT WAS DESIGNED FOR. STUD THREADS ARE STILL UNMARKED (NEW). THIS ALLOWS THE LOWER SECTION OF CCP TO BE SLIGHTLY LOOSE. 7. AC VENTS ON MAX BLOWING OUT 65-70 DEGREE AIR AT IDLE IN 80 DEGREE OUTSIDE AMBIENT TEMP. (KNOWN ISSUE) 8. OVERHEAD A/C LOUVERED VENTS ARE BREAKING INTERNALLY WHEN ADJUSTED. ONE ENTIRE VENT FELL OUT WHILE DRIVING DOWN THE ROAD ONTO MY CHILD'S HEAD WHO COULDN'T TOUCH IT. NOT COVERED BECAUSE THEY BROKE BUT THEY AREN'T A MECHANICAL FAILURE. DAUGHTER HAD SCRATCH ON HER FOREHEAD WHERE IT HIT HER. 10. OPENED UP HEADLAMP LENS TO UPGRADE THE LIGHTS AND THE LOW BEAM PIG TAIL ON BOTH LIGHTS ARE ALREADY DETERIORATING FROM THE LENS HEAT. LIGHTLY TOUCHED EACH OF THE LOCKING CLIPS AND WITHOUT LIFTING EITHER ONE AND THEY FELL OFF. HIGH BEAM WHICH ARE USED MUCH LESS HAVE PERFECT LOCKING TABS STILL. REQUIRED TO MAINTAIN CONTINUITY TO THESE LIGHTS. 11. LAST WEEK A PLUG IN THE DRIVERS DOOR THRESHOLD OVER FRAME BOLT TRIPPED ME WHEN IT CAME UP AS I WAS STEPPING OUT. SECOND TO FALL OUT. ALL THIS TOLD TO US UNDER THE 36K BUMPER TO BUMPER YET DEALER IS WILLING TO CHARGE ME FOR THE DEFECTIVE PARTS.
NHTSA complaint #11208107 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Newfield, NY
STEERING
I took my vehicle on for am oil change and the mechanic brought to my attention that the front subframe of the vehicle had serious rot and rust. This lower subframe ties the front control arms together and other structural components, which is concerning with how fast this component has degraded. When researching this online, this appears to be a common issue on 2015 and later Transit vans, to the point that an investigation was started towards a class action lawsuit. My vehicle is only 8 years and has 95,000 miles, quite young for this serious of an issue to be found. Ford should be held responsible and a safety recall should be issued as other manufacturers have had similar ones in recent years.
NHTSA complaint #11755008 — an unverified report by a vehicle owner.
Newfield, NY
UNKNOWN OR OTHER
I took my vehicle on for am oil change and the mechanic brought to my attention that the front subframe of the vehicle had serious rot and rust. This lower subframe ties the front control arms together and other structural components, which is concerning with how fast this component has degraded. When researching this online, this appears to be a common issue on 2015 and later Transit vans, to the point that an investigation was started towards a class action lawsuit. My vehicle is only 8 years and has 95,000 miles, quite young for this serious of an issue to be found. Ford should be held responsible and a safety recall should be issued as other manufacturers have had similar ones in recent years.
NHTSA complaint #11755008 — an unverified report by a vehicle owner.
Newfield, NY
SUSPENSION
I took my vehicle on for am oil change and the mechanic brought to my attention that the front subframe of the vehicle had serious rot and rust. This lower subframe ties the front control arms together and other structural components, which is concerning with how fast this component has degraded. When researching this online, this appears to be a common issue on 2015 and later Transit vans, to the point that an investigation was started towards a class action lawsuit. My vehicle is only 8 years and has 95,000 miles, quite young for this serious of an issue to be found. Ford should be held responsible and a safety recall should be issued as other manufacturers have had similar ones in recent years.
NHTSA complaint #11755008 — an unverified report by a vehicle owner.
Sulphur, OK
UNKNOWN OR OTHER
Back up camera works only intermittently.
NHTSA complaint #11739640 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2018 Ford Transit. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of the purchase the mileage was 64,000 and at the time when the fraud was discovered the mileage was 364,00.
NHTSA complaint #11736268 — an unverified report by a vehicle owner.
at 90,000 milesEdmonds, WA
ENGINE AND ENGINE COOLING
The contact owns a 2018 Ford Transit. The contact stated that while driving at an undisclosed speed, there was a misfire coming from the engine with the check engine warning light illuminated. The vehicle was taken to several independent mechanics, where it was diagnosed with coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA complaint #11720498 — an unverified report by a vehicle owner.
at 90,000 milesEdmonds, WA
ENGINE
The contact owns a 2018 Ford Transit. The contact stated that while driving at an undisclosed speed, there was a misfire coming from the engine with the check engine warning light illuminated. The vehicle was taken to several independent mechanics, where it was diagnosed with coolant intrusion into the engine, causing engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA complaint #11720498 — an unverified report by a vehicle owner.
Durango, CO
POWER TRAIN
1- THE TURBO HAS FAILED TWICE 2- CURRENTLY The torque converter has failed. The mechanic has claimed this is a common problem and recommends a complete transmission replacement. This is available for inspection right now. The problem was suspected by Dealer but independent center diagnosed. The vehicle made a terrible hum as if it was going to explode. We had it cleaned and it made it stop for 10 miles, then it resumed.
NHTSA complaint #11703242 — an unverified report by a vehicle owner.
Durango, CO
ENGINE
1- THE TURBO HAS FAILED TWICE 2- CURRENTLY The torque converter has failed. The mechanic has claimed this is a common problem and recommends a complete transmission replacement. This is available for inspection right now. The problem was suspected by Dealer but independent center diagnosed. The vehicle made a terrible hum as if it was going to explode. We had it cleaned and it made it stop for 10 miles, then it resumed.
NHTSA complaint #11703242 — an unverified report by a vehicle owner.
Sarasota, FL
UNKNOWN OR OTHER
Rear-view camera displayed on rear-view mirror quit working, creating a blind spot behind the vehicle. No accident has yet occurred, but the danger is there. The vehicle is available for inspection. Ford has issued a recall for this problem for this year, make, and model vehicle, but Ford says that the recall is not extended to vehicles like mine that were manufactured in a plant not covered by the initial recall #25V270, which has recently been extended. My vehicle has not been inspected by any third party, nor has the problem been confirmed by any local dealer, althought I have spoken to my local dealer, Sarasota Ford, twice about this issue. No warning lamps or messages have been displayed in my vehicle. The camera just goes to a blue screen, especially when the weather is warm or in the heat of the day.
NHTSA complaint #11693073 — an unverified report by a vehicle owner.
Marquette, MI
ELECTRICAL SYSTEM
In hot or humid conditions, the 8 inch center display flashes on and off intermittently. This failure makes the backup camera unusable, which is a safety problem. It also makes controlling the navigation or radio very difficult. The dealer has looked at this vehicle problem a few times in the last five years and has been unable to duplicate the problem. I cannot force this to occur at the dealership service department. Because the weather condition needed to duplicate this problem rarely occur near my home getting service for this is very difficult. Once the heat or humidity has subsided via using the air conditioning, the problem goes away after an hour or so.
NHTSA complaint #11692745 — an unverified report by a vehicle owner.
at 480,000 milesEast Stroudsburg, PA
POWER TRAIN
The contact owns a 2018 Ford Transit. The contact stated that while driving approximately 40-60 MPH, the vehicle started vibrating abnormally and was almost uncontrollable. The contact held the steering wheel tightly. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the driveshaft coupling had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was approximately 480,000.
NHTSA complaint #11690253 — an unverified report by a vehicle owner.
Grants Pass, OR
UNKNOWN OR OTHER
09/18/25 As per conversation with Ford Customer Service; while the vehicle falls within the Mfg Date (Oct 19 2017) and Mfg Place (Kansas) listed on recall notice 25S89 AKA 25V572000, 25V270, the issue description -"rear view camera distorted or blank" is still not eligible because it falls outside of Fords approved/listed VIN numbers. Ford Customer Support recommended having the issue repaired at local dealer and pay out-of-pocket and 'hope' that Ford acknowledges this VIN as part of a 'possible' future recall. How can I/we/you be assured that Ford will review this particular issue and consider it for recall? Are there other vehicles like mine that have this ongoing issue that Ford has deliberately excluded?
NHTSA complaint #11688220 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2018 Ford Transit. The contact stated that upon taking the vehicle to the Ford dealer for service, the contact was informed that the vehicle was a Lemon vehicle, and that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 33,135; however, upon retrieving the Carfax history report of the vehicle, the Ford dealer informed the contact that the vehicle mileage was 240,000.
NHTSA complaint #11684566 — an unverified report by a vehicle owner.
Sparks, NV
POWER TRAIN
My 2018 Ford Transit 250 experienced a failure of the Input/Turbine Speed Sensor in the 6R80 transmission’s mechatronic lead frame at approximately 60,000 miles. The failure was confirmed by an authorized Ford service department, which retrieved DTC codes P0715-00 and P0717-00. These codes indicate that the turbine speed sensor signal is lost, forcing the transmission into limp mode, causing loss of power and erratic shifting. This is a serious safety concern, it can occur suddenly while driving and results in loss of proper gear control. Relation to Recall 19S07 Ford has already acknowledged this same defect in other vehicles using the 6R80 transmission. In Safety Recall 19S07, Ford recalled certain 2011–2013 F-150, Expedition, and Navigator models due to failure of the Output Shaft Speed (OSS) sensor in the 6R80 lead frame. The failure mode, symptoms, and remedy (lead frame replacement and PCM update) are identical. In my case, the failure is of the Input/Turbine Speed Sensor rather than the OSS sensor, but both are housed in the same lead frame assembly and both result in sudden sensor failure, limp mode, and unsafe driving conditions. Why Action Is Needed Despite the identical defect, Ford has refused coverage because my VIN is not included in Recall 19S07 and my vehicle is just outside the 5 year / 60,000 mile powertrain warranty. This exclusion leaves Transit owners unprotected even though we are experiencing the same premature failure Ford already acknowledged. Given the safety implications, I am requesting NHTSA to investigate whether Recall 19S07 should be expanded to include Ford Transit vehicles equipped with the 6R80 transmission. Summary Vehicle: 2018 Ford Transit 250, 60,000 miles DTCs: P0715-00, P0717-00 (Input/Turbine Speed Sensor failure) Component: 6R80 mechatronic lead frame (same part as in Recall 19S07) Symptoms: Limp mode, loss of shifting, unsafe drivability Ford refuses coverage despite identical failure acknowledged in other model
NHTSA complaint #11681679 — an unverified report by a vehicle owner.
Bloomington, INCrash2 injured
VEHICLE SPEED CONTROL
The contact owns a 2018 Ford Transit. The contact stated that while slowly driving into a parking space, the vehicle suddenly experienced unintended acceleration and crashed into another parked vehicle. During the incident, the brake pedal was pressed, but the vehicle did not stop. The vehicle was towed to the local dealer, who was unable to determine the cause of the failure. No injuries were reported and a police report was taken at the scene. Also, the vehicle later experienced the same failure. While attempting to park the vehicle again experienced unintended acceleration and drove forward, crashing into a second vehicle. During the crash, the two front occupants of the second vehicle had sustained undisclosed injuries that later required medical treatment. No further information was available. A police report was taken at the scene. The vehicle was towed to the local dealer, who was unable to determine the cause of the second failure. The contact indicated that the failure had recently reoccurred for the third time. The cause of the failures was not determined. The manufacturer was not contacted regarding the failures. The failure mileage was unknown.
NHTSA complaint #11666727 — an unverified report by a vehicle owner.
at 156,206 milesBroad Brook, CT
ENGINE
The contact owns a 2018 Ford Transit. The contact stated while driving at 55 MPH, the vehicle suddenly started losing power, after driving over 200 yards, the vehicle became inoperable. The check engine and service engine warning lights were illuminated. The contact merged to the side of the road as a ramp was coming up and called AAA. The vehicle was towed to the dealer and was diagnosed with a timing chain and engine failure. The contact was informed by the dealer of an extended warranty; however, the warranty had expired two days prior to the failure. The vehicle was taken to an independent mechanic. The engine was replaced with a used engine, new timing chain, new gaskets, engine oil, water pump, rear sealant, coolant, and spark plugs. The vehicle was replaced. The manufacturer was made aware of the failure. The failure mileage was approximately 156,206.
NHTSA complaint #11654711 — an unverified report by a vehicle owner.
New York, NY
WHEELS
I finance this car 10/ 25/24. I found some papers inside the car that says the car was 300.0 miles. But i purchased to the dealer with 77.0miles, how can I know is was a fraud?
NHTSA complaint #11623348 — an unverified report by a vehicle owner.
Marengo, IA
WHEELS
I was driving on a rural highway 55 mph when I heard a pop! I lost control and veered into oncoming traffic! I slowed down by tapping brakes and ended up back on the right side in the shoulder/ditch. The shoulder had new gravel so it slowed me down and grabbed a hold of what was left. Found the wheel out in the ditch a good ways from the car and also three lug nuts with bolts still attached and broken at the base in the stretch from the turn off to where the car stopped. Also found my brake pad near a lug nut in the median! Bolts completely broken at the base with lug nuts still attached. Wheel completely fine just not on car. Inside rim gouged out from riding on it after the bolts broke. Found a recall on Ford Transit for the 2019 version of this vehicle for the exact same problem. But since this is a 2018 Ford will not honor it. Cause appears to be a weakness in the alloy used which warps over time and then without warning causing the bolts to brake at the base and separate wheel from vehicle.
NHTSA complaint #11622254 — an unverified report by a vehicle owner.
Marengo, IA
UNKNOWN OR OTHER
I was driving on a rural highway 55 mph when I heard a pop! I lost control and veered into oncoming traffic! I slowed down by tapping brakes and ended up back on the right side in the shoulder/ditch. The shoulder had new gravel so it slowed me down and grabbed a hold of what was left. Found the wheel out in the ditch a good ways from the car and also three lug nuts with bolts still attached and broken at the base in the stretch from the turn off to where the car stopped. Also found my brake pad near a lug nut in the median! Bolts completely broken at the base with lug nuts still attached. Wheel completely fine just not on car. Inside rim gouged out from riding on it after the bolts broke. Found a recall on Ford Transit for the 2019 version of this vehicle for the exact same problem. But since this is a 2018 Ford will not honor it. Cause appears to be a weakness in the alloy used which warps over time and then without warning causing the bolts to brake at the base and separate wheel from vehicle.
NHTSA complaint #11622254 — an unverified report by a vehicle owner.
NHTSA complaint #11619378 — an unverified report by a vehicle owner.
Ronkonkoma, NY
POWER TRAIN
Randomly down shifts on its own while driving
NHTSA complaint #11596493 — an unverified report by a vehicle owner.
at 160,000 milesApollo, PA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2018 Ford Transit. The contact stated that while driving at various speeds, an abnormal squeaking sound would be emitted from the vehicle without warning. The contact stated that the sound went away upon the depression of the brake pedal. Since owning the vehicle, the contact had taken the vehicle to the dealer for an oil change, each time, the contact was informed that both the brake pads and rotors needed to be replaced. The contact stated that the clips needed to keep the brake pads in place fractured approximately 20-50 miles after being replaced. The contact stated that the brake pads and rotors had been replaced several times due to the failure. The manufacturer was notified of the failure and acknowledged the failure; however, no assistance was provided. The vehicle was not repaired. The failure mileage was approximately 160,000.
NHTSA complaint #11593003 — an unverified report by a vehicle owner.
at 200,593 milesCaryville, TN
POWER TRAIN
With this vehicle when driving on highway or interstate once you go past about 40 miles the transmission begins to overheat and when it reaches a temperature of approximately 245° it will kick down into limp mode causing the vehicle to suddenly slow down in front of other traffic. You have to get over to the side of the road and let the transmission cool down before you can continue at a safe pace. This vehicle has been taken multiple times the transmission has been replaced twice. They have replaced the transmission cooler, they have an auxiliary cooler, and the problems still persist. This is very dangerous to be operating when it kicks down tent mode and gears down suddenly. It has been in Fords service shop for over seven months now and we just got it back with the new auxiliary cooler on it and it is still having the same problem.
NHTSA complaint #11579477 — an unverified report by a vehicle owner.
at 200,593 milesCaryville, TN
VEHICLE SPEED CONTROL
With this vehicle when driving on highway or interstate once you go past about 40 miles the transmission begins to overheat and when it reaches a temperature of approximately 245° it will kick down into limp mode causing the vehicle to suddenly slow down in front of other traffic. You have to get over to the side of the road and let the transmission cool down before you can continue at a safe pace. This vehicle has been taken multiple times the transmission has been replaced twice. They have replaced the transmission cooler, they have an auxiliary cooler, and the problems still persist. This is very dangerous to be operating when it kicks down tent mode and gears down suddenly. It has been in Fords service shop for over seven months now and we just got it back with the new auxiliary cooler on it and it is still having the same problem.
NHTSA complaint #11579477 — an unverified report by a vehicle owner.