2012 Hyundai Genesis problems

SERVICE BRAKES

Brake pedal has been intermittently low/spongy and has progressively gotten worse. During these events, the brake pedal goes nearly to the floorboard, and braking power is weak but will typically function after pumping the pedal repeatedly. Stopping or slowing in an emergency situation may not be possible. There is no manual emergency brake. No trouble codes found, and no warning lamps illuminated related to the braking system. Dealer diagnosed faulty antilock braking system (ABS) hydraulic electronic control unit (HECU). This exact defect is addressed in Warranty Extension TXXP: Hydraulic Electronic Control Unit (HECU) [XXX] Hyundai rejected this under the warranty coverage because the vehicle build date is approximately 2 weeks beyond the date range in the TSB. Subsequent web searches revealed replacement parts were available for production in late XXX. The TSB's affected date range ends on XXX. This vehicle was produced on XXX and was not included in the recall notifications. It is not known if a complete stock purge was performed on the production line or if parts were continued to be installed until old stock was depleted. Other vehicles outside of the TSB stated production date range may also have this latent critical safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11749208 — an unverified report by a vehicle owner.

SERVICE BRAKES

I am submitting this letter as a formal safety defect complaint regarding my 2012 Hyundai Genesis 5.0 sedan, which is experiencing braking system behavior that directly mirrors the defect described in Hyundai Recall Campaign 114 (NHTSA Campaign 13V489000), despite my vehicle not being included by VIN. Although excluded by VIN, the functional failure mode matches recalled vehicles, indicating the defect population may extend beyond the original VIN range. The vehicle exhibits the following symptoms: 1.Excessive and inconsistent brake pedal travel 2. Soft and spongy brake pedal feel 3. Highly variable brake biting point 4. Requirement to pump the brake pedal to obtain normal braking 5. Unpredictable brake engagement during normal driving These symptoms are intermittent and occur without warning, significantly increasing stopping distance and reducing driver confidence. The behavior is consistent with internal hydraulic or HECU malfunction, which the original recall attributes to corrosion caused by improper brake fluid formulation. I am particularly concerned because I am a disabled driver, and any reduction in braking reliability presents an elevated safety risk. Unpredictable brake response materially affects my ability to operate the vehicle safely and to respond to emergency conditions. While Hyundai has limited the recall to certain VIN ranges, Model Years Affected: 2009–2012 Hyundai Genesis sedans built April 30, 2008 – March 28, 2012. The braking behavior is functionally identical to recalled vehicles. This suggests the defect may not be limited to the originally identified production range and warrants further investigation. I respectfully request that NHTSA: 1. Review this complaint in the context of the existing recall 2. Evaluate whether the defect population should be expanded 3. Initiate further inquiry into VIN-excluded vehicles exhibiting identical symptoms 4. This issue represents a clear safety concern with potential for serious injury

NHTSA complaint #11716198 — an unverified report by a vehicle owner.

SERVICE BRAKES

Brake line on driver rear rusted and leaking above brake hose. Cannot drive vehicle safely with this leak. Would leak brake fluid each time I step on brake pedal. Problem magnified when car is on and brake booster is working. Vehicle not at dealer or mechanic yet, but link to video of driver rear brake line leaking on 1-31-2026: [XXX] Service Campaign 991 [XXX] ) was completed less than two years ago on Feb 19, 2024 (today is 1/31/2026). See note about "dealer will apply an anti-corrosion treatment to certain parts, and *replace the brake lines if necessary*" Not told about any rust, nor any parts replaced. Link to service campaign quote: [XXX] No warning lamps, messages, or symptoms of the problem. Assumed wheel liner covered brake line from salt. Vehicle is located in [XXX] and I suspect other brake lines are also rusted out. Would like manufacturer to replace all brake lines under warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11714723 — an unverified report by a vehicle owner.

VISIBILITY

The contact owns a 2012 Hyundai Genesis. The contact had engaged the windshield wipers during a light rainstorm and noticed that the intermittent wiper function was not working as designed. The contact stated that gradually the wiper speeds were no longer functional, and only the high-speed option was operable. The contact had taken the vehicle to the local dealer who diagnosed that the gasket around the wiper motor had failed, and that water had entered the wiper motor and determined that the wiper motor needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred; however, the contact had taken the vehicle to a local dealer and was advised that the vehicle was no longer under warranty and had to be repaired out-of-pocket. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the gasket around the wiper motor had deteriorated, and water was leaking into the wiper motor's electrical circuits. The contact was advised by the mechanic that there was a recall, NHTSA Campaign Number: 16V117000 (Visibility); however, the VIN was not included. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 150,000.

NHTSA complaint #11640947 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2012 Hyundai Genesis. The contact stated that while driving at an undisclosed speed, there was an abnormal rattling sound emanating from the engine compartment, after which the vehicle lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the engine. The contact was informed that the engine needed to be replaced. The vehicle was repaired, but the failure reoccurred a week later. The vehicle was towed back to the independent mechanic, who again diagnosed a failure with the engine and informed the contact that the engine needed to be replaced a second time. The vehicle was repaired, but the failure reoccurred three additional times. The manufacturer was notified of the failure, and a case was opened. The failure mileage was unknown.

NHTSA complaint #11624199 — an unverified report by a vehicle owner.

POWER TRAIN

During normal driving conditions, the 8 speed automatic transmission will randomly hesitate to upshift from 2nd to 3rd and from 4th to 5th, causing an unpredictable loss of power. Symptoms will show up intermittently, and do not seem to be caused by certain events. This is unsafe because the unpredictability of the problem could cause power loss during moments where acceleration is needed to avoid an accident (moments which would otherwise be completely safe, i.e. merging onto a freeway, turning across incoming traffic, right turns into the direction of traffic, etc.) This problem already has a TSB issued by Hyundai. Problem has been reproduce by a technician. Component has been checked by a technician. There are no warning lights or other symptoms before failure.

NHTSA complaint #11605009 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2012 Hyundai Genesis. The contact stated while driving 10 MPH, the vehicle stalled in the middle of the road. There was no warning light illuminated. The contact shifted into park(P) and pressed the Push to Start button, and the vehicle restarted. The contact was able to continue driving. The contact stated that an OBD scanner was unable to retrieve any diagnostic trouble codes for the failure. The contact stated that the failure recurred while driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 85,000. The contact is requesting to be contacted via telephone in reference to this inquiry.

NHTSA complaint #11586620 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2012 Hyundai Genesis. The contact stated while driving 10 MPH, the vehicle stalled in the middle of the road. There was no warning light illuminated. The contact shifted into park(P) and pressed the Push to Start button, and the vehicle restarted. The contact was able to continue driving. The contact stated that an OBD scanner was unable to retrieve any diagnostic trouble codes for the failure. The contact stated that the failure recurred while driving. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 85,000. The contact is requesting to be contacted via telephone in reference to this inquiry.

NHTSA complaint #11586620 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2012 Hyundai Genesis. The contact stated while driving at approximately 35 MPH, the vehicle lost motive power, shut off but was able to coast off the highway. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic computer motherboard needed to be replaced. The vehicle was not repaired due to parts being on backorder. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 62,000.

NHTSA complaint #11581934 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2012 Hyundai Genesis. The contact stated while driving at approximately 35 MPH, the vehicle lost motive power, shut off but was able to coast off the highway. There were no warning lights illuminated. The vehicle was towed to the local dealer, where it was diagnosed that the electronic computer motherboard needed to be replaced. The vehicle was not repaired due to parts being on backorder. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 62,000.

NHTSA complaint #11581934 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2012 Hyundai Genesis. The contact stated that the vehicle hesitated to start and made a continuous clicking sound before starting. Additionally, while driving at approximately 40 MPH, the vehicle stalled. The contact stated that the ABS, and traction control warning lights were illuminated intermittently. The vehicle was taken to an independent mechanic where it was diagnosed with a drained battery. The vehicle was repaired; however, the failure recurred, and the vehicle was taken to the same independent mechanic where it was diagnosed with a faulty tensioner. The vehicle was repaired; however, the failure recurred, and the vehicle was taken to the same independent mechanic where it was diagnosed with an unknown failure. The mechanic stated that there was no available fix for the vehicle and referred the contact to the NHTSA Hotline. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 210,034. The VIN was not available.

NHTSA complaint #11581228 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

recall from 2014 under Hyundai genesis BH over brake corrosion and leading to HECU /electrical / wheel stability/electrical wire problems /fire Also immobilizer and safety I now have no dash or steering wheel controls Believe car was broken into shows signs of elapsed time/fob and controls inside no longer work Two fuses inside driver side panel spark even when car is not on Took to Springfield Hyundai They not only lied and stated my car isn’t under any recall but they stated online they did a safety inspection which is not true I just replaced rear brakes and after barely driving 1,000 miles the brakes are making a wearing metal noise and sound like they are bad again I even stated I had information for the immobilizer since Hyundai didn’t install on any of their vehicles until 2022 Now I enter my vin and it comes up under the 2 door coupe not the sedan (BH) Also found archived article from car and driver about the FBI suing Hyundai in 2014 over the exact model and make 2012 Hyundai Genesis BH over brake corrosion accidents and HECU issues causing accidents and other electrical issues Now I am scared worried and I am being ignored an neglected Driving a car that clearly is not safe and putting my life in danger if I have a tampered VIN from theft of no immobilizer this is Hyundai negligence and now my VIN isn’t showing correctly for my make and model I NEED help I have videos of fuses sparking and printed recall Info for my make and model under NHTSA safety investigations I have NEVER received one recall notice from Hyundai in the mail since I am the owner since 2019 I also show DMV records of many registration transactions for years I owned vehicle I only get one registration per year Some shows 2 & 3 prior owner of vehicle worked for a car dealership in Woodbury Even Vehicle History reports aren’t correct

NHTSA complaint #11576484 — an unverified report by a vehicle owner.

ENGINE

recall from 2014 under Hyundai genesis BH over brake corrosion and leading to HECU /electrical / wheel stability/electrical wire problems /fire Also immobilizer and safety I now have no dash or steering wheel controls Believe car was broken into shows signs of elapsed time/fob and controls inside no longer work Two fuses inside driver side panel spark even when car is not on Took to Springfield Hyundai They not only lied and stated my car isn’t under any recall but they stated online they did a safety inspection which is not true I just replaced rear brakes and after barely driving 1,000 miles the brakes are making a wearing metal noise and sound like they are bad again I even stated I had information for the immobilizer since Hyundai didn’t install on any of their vehicles until 2022 Now I enter my vin and it comes up under the 2 door coupe not the sedan (BH) Also found archived article from car and driver about the FBI suing Hyundai in 2014 over the exact model and make 2012 Hyundai Genesis BH over brake corrosion accidents and HECU issues causing accidents and other electrical issues Now I am scared worried and I am being ignored an neglected Driving a car that clearly is not safe and putting my life in danger if I have a tampered VIN from theft of no immobilizer this is Hyundai negligence and now my VIN isn’t showing correctly for my make and model I NEED help I have videos of fuses sparking and printed recall Info for my make and model under NHTSA safety investigations I have NEVER received one recall notice from Hyundai in the mail since I am the owner since 2019 I also show DMV records of many registration transactions for years I owned vehicle I only get one registration per year Some shows 2 & 3 prior owner of vehicle worked for a car dealership in Woodbury Even Vehicle History reports aren’t correct

NHTSA complaint #11576484 — an unverified report by a vehicle owner.

SERVICE BRAKES

recall from 2014 under Hyundai genesis BH over brake corrosion and leading to HECU /electrical / wheel stability/electrical wire problems /fire Also immobilizer and safety I now have no dash or steering wheel controls Believe car was broken into shows signs of elapsed time/fob and controls inside no longer work Two fuses inside driver side panel spark even when car is not on Took to Springfield Hyundai They not only lied and stated my car isn’t under any recall but they stated online they did a safety inspection which is not true I just replaced rear brakes and after barely driving 1,000 miles the brakes are making a wearing metal noise and sound like they are bad again I even stated I had information for the immobilizer since Hyundai didn’t install on any of their vehicles until 2022 Now I enter my vin and it comes up under the 2 door coupe not the sedan (BH) Also found archived article from car and driver about the FBI suing Hyundai in 2014 over the exact model and make 2012 Hyundai Genesis BH over brake corrosion accidents and HECU issues causing accidents and other electrical issues Now I am scared worried and I am being ignored an neglected Driving a car that clearly is not safe and putting my life in danger if I have a tampered VIN from theft of no immobilizer this is Hyundai negligence and now my VIN isn’t showing correctly for my make and model I NEED help I have videos of fuses sparking and printed recall Info for my make and model under NHTSA safety investigations I have NEVER received one recall notice from Hyundai in the mail since I am the owner since 2019 I also show DMV records of many registration transactions for years I owned vehicle I only get one registration per year Some shows 2 & 3 prior owner of vehicle worked for a car dealership in Woodbury Even Vehicle History reports aren’t correct

NHTSA complaint #11576484 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2012 Hyundai Genesis. The contact stated while driving at an undisclosed speed, the brake pedal was depressed and went to the floorboard, and the vehicle failed to immediately stop. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the brake booster and brake master cylinder. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 13V489000 (Service Brakes, Hydraulic) but the VIN was not included in the recall. The manufacturer was notified of the failure, and a case was opened. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 22,000.

NHTSA complaint #11567975 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Submitted complaint of unsafe fumes /gas smells emitting from engine and into cabin of car to site on 10/23/2023 for my vin the complaint I see is under Tires This should be under engine I said nothing about tires it's a 2012 Hyundai Genesis BH 4 door sedan battery wasn't holding charge engine idles high and low poor gas mileage and sluggish brake light always on even after repair

NHTSA complaint #11565430 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Submitted complaint of unsafe fumes /gas smells emitting from engine and into cabin of car to site on 10/23/2023 for my vin the complaint I see is under Tires This should be under engine I said nothing about tires it's a 2012 Hyundai Genesis BH 4 door sedan battery wasn't holding charge engine idles high and low poor gas mileage and sluggish brake light always on even after repair

NHTSA complaint #11565430 — an unverified report by a vehicle owner.

ENGINE

Submitted complaint of unsafe fumes /gas smells emitting from engine and into cabin of car to site on 10/23/2023 for my vin the complaint I see is under Tires This should be under engine I said nothing about tires it's a 2012 Hyundai Genesis BH 4 door sedan battery wasn't holding charge engine idles high and low poor gas mileage and sluggish brake light always on even after repair

NHTSA complaint #11565430 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

The contact owns a 2012 Hyundai Genesis. The contact stated upon starting the vehicle, an abnormal fuel odor was coming from the vehicle with heavy smoke coming from the exhaust pipe. The contact stated that the tire pressure and brake warning lights were illuminated. The vehicle was not serviced or diagnosed. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 170,000.

NHTSA complaint #11555690 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

The contact owns a 2012 Hyundai Genesis. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to an independent mechanic and diagnosed with transmission failure. The contact stated that the check engine light was later illuminated, and the vehicle was taken to a second independent mechanic. The mechanic retrieved a code for a defective pressure sensor. Upon investigation, the contact discovered Manufacturer Communication Number: 16-8at-011) which he linked to the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the Manufacturer Communication Number. The vehicle was not repaired. The failure mileage was approximately 155,620.

NHTSA complaint #11555225 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Hyundai Genesis. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. The vehicle was taken to an independent mechanic and diagnosed with transmission failure. The contact stated that the check engine light was later illuminated, and the vehicle was taken to a second independent mechanic. The mechanic retrieved a code for a defective pressure sensor. Upon investigation, the contact discovered Manufacturer Communication Number: 16-8at-011) which he linked to the failure. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under the Manufacturer Communication Number. The vehicle was not repaired. The failure mileage was approximately 155,620.

NHTSA complaint #11555225 — an unverified report by a vehicle owner.

ENGINE

Car shuts off while driving for no reason. Happens last time on the beltway. No check engine light or warning that it will cut off. Doesn’t happen at the mechanics. No one knows why it happens. I see this is an ongoing issue for Genesis

NHTSA complaint #11554903 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2012 Hyundai Genesis. The contact stated while driving 25-30 MPH, the vehicle stalled inadvertently. There was no warning light illuminated. The contact was able to veer to the side of the road. The contact was able to restart the vehicle and continue driving. The contact stated that the failure had been recurring while driving. The vehicle was taken to an unknown local dealer, and to an independent mechanic; however, the failure could not be duplicated. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

NHTSA complaint #11545881 — an unverified report by a vehicle owner.