Owners have filed 181 complaints
about the 2011 Lincoln MKZ with NHTSA between 2011 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 4 of 13 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 58
Against the median year of the Lincoln MKZ. 50 means typical for this
model; 100 means roughly double.
Severity — 100
21.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 43
25% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
32.9%
10,000 – 24,999 miles
109.7%
25,000 – 49,999 miles
2524.3%
50,000 – 74,999 miles
2524.3%
75,000 – 99,999 miles
1312.6%
100,000 – 149,999 miles
2726.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2011peak 9Aug 2026
NHTSA investigations into the 2011 Lincoln MKZ
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE14030Opened 2 Oct 2014Closed 10 Sep 2015STEERING:ELECTRIC POWER ASSIST SYSTEM
Electric power steering failure
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with...
EA12009Opened 12 Dec 2012Closed 12 Jun 2014VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated c...
Recalls on the 2011 Lincoln MKZ
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V158000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
21E013000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V001000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators a
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
18V775000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2010 Ford Fusion, Mercury Milan and 2010-2012 Lincoln MKZ vehicles that previously received a replacement passenger air bag under recall 16V-384, 17V-024 or 18V-046. In the event of a crash requiring deployment of the passenger air bag, the bracket that secures the air bag inflator to the module housing may deform, allowing the gas that inflates the air bag to leak out.
Risk: If the air bag does not inflate as intended, there is an increased risk of injury in the event of a crash.
16V384000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V340000
STEERING:ELECTRIC POWER ASSIST SYSTEM
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
14E028000
EQUIPMENT
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
Risk: The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2021029274,737 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Ford will notify owners by mail. The corrective actions for this recall are under development. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 2019005300,898 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Actions: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recalls 2016-347 (Ford Safety Improvement Program 16S26), 2017-024 (Ford Recall 17S01) and 2018-035 (Ford Recall 18S01). Vehicles repaired under the previous recalls do not require repair under this recall.
Recall 20163475,867 units in Canada
Airbag
Ford Canada is conducting a voluntary Safety Improvement Program involving passenger airbag inflators in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States equipped with Takata airbags. Ford will replace the driver or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in the states of New Jersey, Delaware, District of Columbia, Maryland, Pennsylvania, Ohio, Indiana, Illinois, Virginia, West Virginia, Kentucky, Missouri, Nebraska, Kansas, Oklahoma, Arkansas, Tennessee, North Carolina, Nevada, Arizona, New Mexico, California, Texas, Louisiana, Mississippi, Alabama, Georgia, South Carolina, Florida, Hawaii, Puerto Rico or the U.S. Virgin Islands should contact a Ford dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Program is superseded by recall 2019005 (Ford Recall 19S01). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019005">recall 2019005</a> for more information.
Recall 201522425,195 units in Canada
Steering
On certain vehicles, a fault in the Electric Power Steering (EPS) system could result in an immediate loss of power steering assist without warning to the driver. This would unexpectedly increase the steering effort force necessary to steer the vehicle at lower vehicle speeds, which could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will affect repairs as necessary and will reprogram the EPS controller with updated software. In the event that an EPS fault occurs, this updated software would allow for continued EPS function while displaying visual and audible warnings to the driver until the end of the drive cycle.
Recall 20141952,810 units in Canada
Accessories
A safety defect may exist in Ford aftermarket all-weather floor mats sold as accessories or service replacement parts for 2006-2011 Ford Fusion, Lincoln Zephyr, and Lincoln MKZ vehicles. The floor mats are secured by a single retention device, which could allow the driver's floor mat to move out of position and interfere with the accelerator pedal. If this occurs, the accelerator pedal could fail to return to idle. This could result in a crash causing injury and/or property damage. Correction: Dealers will replace Ford aftermarket all-weather floor mats with an updated design having two retention devices.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 100,000 milesWayne Scott, NYFire
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11680701 — an unverified report by a vehicle owner.
at 100,000 milesWayne Scott, NYFire
ELECTRICAL SYSTEM
The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11680701 — an unverified report by a vehicle owner.
at 120,000 milesDecatur, GACrash2 injured
AIR BAGS
TL* THE CONTACT OWNS A 2011 LINCOLN MKZ HYBRID. THE CONTACT STATED WHILE MAKING A TURN FROM A STOP SIGN, THE STEERING WHEEL BECAME HARD TO MANEUVER. AS A RESULT, THE VEHICLE WAS HIT ON THE FRONT PASSENGER SIDE BY ANOTHER VEHICLE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG DEPLOYED INJURING HIS GIRLFRIEND. HIS GIRLFRIEND SUSTAINED CUTS TO THE STOMACH AS THE CONTACT STATED IT SEEMED THAT METAL SHRAPNEL HAD DEPLOYED FROM THE AIR BAG. THE PASSENGER IN THE REAR MIDDLE ALSO SUSTAINED INJURIES TO THE HIP. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE CONTACT STATED PRIOR TO THE COLLISION, HE CONTACTED ST AUTO SALES INC (4545 GLENWOOD RD, DECATUR, GA) TO MAKE THEM AWARE OF THE STEERING WHEEL FAILURE. THE CONTACT STATED THAT THEY ADVISED HIM TO ADD STEERING FLUID TO THE RESERVOIR. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSIS AFTER THE COLLISION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11395560 — an unverified report by a vehicle owner.
at 120,000 milesDecatur, GACrash2 injured
STEERING
TL* THE CONTACT OWNS A 2011 LINCOLN MKZ HYBRID. THE CONTACT STATED WHILE MAKING A TURN FROM A STOP SIGN, THE STEERING WHEEL BECAME HARD TO MANEUVER. AS A RESULT, THE VEHICLE WAS HIT ON THE FRONT PASSENGER SIDE BY ANOTHER VEHICLE. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE AIR BAG DEPLOYED INJURING HIS GIRLFRIEND. HIS GIRLFRIEND SUSTAINED CUTS TO THE STOMACH AS THE CONTACT STATED IT SEEMED THAT METAL SHRAPNEL HAD DEPLOYED FROM THE AIR BAG. THE PASSENGER IN THE REAR MIDDLE ALSO SUSTAINED INJURIES TO THE HIP. MEDICAL ATTENTION WAS REQUIRED. A POLICE REPORT WAS FILED. THE CONTACT STATED PRIOR TO THE COLLISION, HE CONTACTED ST AUTO SALES INC (4545 GLENWOOD RD, DECATUR, GA) TO MAKE THEM AWARE OF THE STEERING WHEEL FAILURE. THE CONTACT STATED THAT THEY ADVISED HIM TO ADD STEERING FLUID TO THE RESERVOIR. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSIS AFTER THE COLLISION. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11395560 — an unverified report by a vehicle owner.
at 40,000 milesVentura, CACrash1 injured
SERVICE BRAKES
TL* THE CONTACT OWNS A 2011 LINCOLN MKZ. WHILE THE CONTACT'S WIFE WAS DRIVING AND ATTEMPTING TO APPLY THE BRAKES, THE BRAKE PEDAL LOWERED SLOWLY. THE CONTACT STATED THAT HIS WIFE STRUCK A FLOWER POT ON A NEARBY LAWN AND HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TOWED. THE CONTACT TOOK THE VEHICLE TO A CERTIFIED MECHANIC WHO REPAIRED THE MASTER CYLINDER, BUT THE FAILURE RECURRED. THE CONTACT RETURNED THE VEHICLE TO THE CERTIFIED MECHANIC WHO DISCOVERED A MECHANISM UNDER THE BRAKE PEDAL THAT PROHIBITED THE BRAKE PEDAL FROM BEING ABLE TO BE DEPRESSED APPROPRIATELY. THE MECHANISM WAS REMOVED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE; HOWEVER, THE CONTACT HAD NOT YET RECEIVED A RESPONSE. THE FAILURE MILEAGE WAS 40,000. THE CONSUMER STATED THERE WAS AN OBSTRUCTION ABOVE THE GAS AND BRAKE PEDALS. THE OBSTRUCTION PREVENT THE DRIVER FROM APPLYING THE NECESSARY PRESSURE TO THE PEDALS. A MECHANIC STATED THE FAILURE WAS DUE TO POOR RESPONSE TIMING OF THE VEHICLE'S MASTER CYLINDER. THE MASTER CYLINDER WAS REPLACED, BUT THE FAILURE RECURRED SEVERAL MORE TIMES. THE VEHICLE WAS INVOLVED IN 2 ACCIDENTS DUE TO THE FAILURE.*JS *JS
NHTSA complaint #11282314 — an unverified report by a vehicle owner.
at 28,273 milesDetroit, MICrash
POWER TRAIN
TL* THE CONTACT OWNS A 2011 LINCOLN MKZ. THE CONTACT STATED THAT THE VEHICLE UNINTENTIONALLY ACCELERATED. ALSO, WHEN THE BRAKE AND THE ACCELERATOR PEDAL WAS DEPRESSED AT THE SAME TIME, THE PEDAL TRAVELED TO THE FLOORBOARD. AS A RESULT, THE VEHICLE CRASHED INTO A BRICK WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS TOWED TO JACK DEMMER LINCOLN (21531 MICHIGAN AVE, DEARBORN, MI 48124, (313) 274-8800) WHERE THE CONTACT WAS INFORMED THAT THE ONLY WAY THE VEHICLE COULD BE DIAGNOSED WAS IF THE FAILURE OCCURRED WHILE AT THE DEALER. THE FRONT END OF THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 28,273 AT THE TIME OF THE CRASH. *TT
NHTSA complaint #11176467 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Middletown, NY
POWER TRAIN
2011 Lincoln MKZ AWD, 25000 miles. The plastic sheath that covers the transmission shift cable split in two. The split is located on the cable between the engine and firewall. preventing the driver from being able to shift the automatic transmission into Park and then later could no longer shift into any gear position. The metal cable and braid remained intact.
NHTSA complaint #11758814 — an unverified report by a vehicle owner.
at 100,000 milesWayne Scott, NYFire
STRUCTURE:FRAME AND MEMBERS
The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11680701 — an unverified report by a vehicle owner.
at 100,000 milesWayne Scott, NYFire
ELECTRICAL SYSTEM
The contact owns a 2011 Lincoln MKZ. The contact's spouse stated that while the vehicle was parked, the contact's spouse started the vehicle and noticed flames coming from the interior seal of the driver's door, located by the rocker panel. The contact's spouse stated that the flames were not severe. The contact’s spouse was able to extinguish the fire. The contact stated that after inspecting the vehicle, the contact noticed moisture leaking into the rocker panel wiring. The vehicle was taken to an independent mechanic for brake and rotor repair. The contact and the mechanic noticed that the whole rear of the vehicle was severely corroded. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
NHTSA complaint #11680701 — an unverified report by a vehicle owner.
Powder Springs, GA
UNKNOWN OR OTHER
While traveling on interstate at70 mph a red triangle appears on dash engine turns off warning on dash to stop asap. All you have is electrical power which is not much. Car needs to be turned off and restarted. This may occur again in a few minutes or not. Took to dealer they said they replaced an O2 sensor. It still turns off. Back to dealer. They can’t reproduce. Has happened to me at least 8 times on surface streets and highways. Extremely dangerous to loose power on highways. This started about 6 months ago. Still happening. Last incident was today
NHTSA complaint #11642912 — an unverified report by a vehicle owner.
Powder Springs, GA
ENGINE
While traveling on interstate at70 mph a red triangle appears on dash engine turns off warning on dash to stop asap. All you have is electrical power which is not much. Car needs to be turned off and restarted. This may occur again in a few minutes or not. Took to dealer they said they replaced an O2 sensor. It still turns off. Back to dealer. They can’t reproduce. Has happened to me at least 8 times on surface streets and highways. Extremely dangerous to loose power on highways. This started about 6 months ago. Still happening. Last incident was today
NHTSA complaint #11642912 — an unverified report by a vehicle owner.
Powder Springs, GA
FUEL/PROPULSION SYSTEM
While traveling on interstate at70 mph a red triangle appears on dash engine turns off warning on dash to stop asap. All you have is electrical power which is not much. Car needs to be turned off and restarted. This may occur again in a few minutes or not. Took to dealer they said they replaced an O2 sensor. It still turns off. Back to dealer. They can’t reproduce. Has happened to me at least 8 times on surface streets and highways. Extremely dangerous to loose power on highways. This started about 6 months ago. Still happening. Last incident was today
NHTSA complaint #11642912 — an unverified report by a vehicle owner.
Fayetteville, GA
ENGINE
As I was traveling home from work, I noticed the car jerk slightly and immediately decelerate. The engine temperature gauge light came on the dash and the temperature gauge immediately moved to the “H” position on the dash. Due to the fact that I was in rush hour traffic on the highway, I was worried I wouldn’t have enough speed to get to the median. I turned on my hazards and coasted safely to the side of the road but was nearly ran over by other vehicles not realizing the issue I was having. I was unable to accelerate out of the way and at the mercy of other drivers being courteous and give me space to move. I turned the car off and looked under the hood locating the coolant reservoir. It appeared empty. I was able to get a ride to the nearest auto parts store and buy coolant. When I returned to my car, I emptied coolant into the reservoir and cranked the vehicle. Within a minute the gauge returned to normal temp and carefully got back in flow of traffic but stayed close to the emergency lane. Within a couple hundred yards of driving again, the lights and gauges indicated another overheating issue. At the next stop, I pulled into a gas station. And parked the car to have it towed. My mechanic informed me that the coolant was leaking from the coolant pump into my oil pan. Now the engine is flooded with a mixture of oil and coolant and I will need a new engine. He said this issue has been reported before but wasn’t sure what Ford/Lincoln may be doing about it. I’m lucky I didn’t have an engine fire or some sort of collision while driving along a highway during rush hour traffic.
NHTSA complaint #11609001 — an unverified report by a vehicle owner.
at 70,000 milesGlenville, NY
ENGINE AND ENGINE COOLING
The contact owns a 2011 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the front of the vehicle. The contact stated on another occasion while driving at an undisclosed speed, the engine overheated. The vehicle was taken to the dealer where it was diagnosed; however, the cause of the failure was not yet determined. The contact was informed that it might have been an axle leak. The contact then took the vehicle to an independent mechanic who in turn advised her to take the vehicle to a dealer. The contact had the vehicle towed to the dealer, where it was diagnosed with water pump failure. The contact was informed that the water pump needed to be replaced. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.
NHTSA complaint #11607300 — an unverified report by a vehicle owner.
Jessup, MD
UNKNOWN OR OTHER
I was stopping at a stop sign and was unable to stop immediately, instead I coasted a little bit before stopping. Then the brake warning lights and ABS and traction lights came on. I pulled over to a parking lot and turned the car off and turned it back on: all the lights came back on. I put on my flashers and very carefully and slowly drove my car to Jiffy Lube. They did an $108 oil change and checked the brake pads and brake fluid levels and said everything was fine and I would need to take it to a larger shop. I contacted the Apple Ford dealer near me and had my family follow me as I dropped it off. They said it would be a total of $310 for diagnostic and brake flush. I did the flush and it didn’t work. They said it would cost just shy of $3k to replace the entire hydraulic system. I took the car home because that is too much for a 2011 vehicle. I ended up having to get a new car because I need transportation for me and my two young children. My neighbor took a look at the car (he works on trucks) and the battery wouldn’t work. I bought a new battery for the car at $238.14. The lights are still on. I would like to have this car fixed or be able to trade it in. I am now being recommended to run a computer test on it to reset the codes. I would like to have this fixed as this seems to be a known issue with this car and I could have crashed if I wasn’t already driving slowly.
NHTSA complaint #11595694 — an unverified report by a vehicle owner.
Jessup, MD
SERVICE BRAKES
I was stopping at a stop sign and was unable to stop immediately, instead I coasted a little bit before stopping. Then the brake warning lights and ABS and traction lights came on. I pulled over to a parking lot and turned the car off and turned it back on: all the lights came back on. I put on my flashers and very carefully and slowly drove my car to Jiffy Lube. They did an $108 oil change and checked the brake pads and brake fluid levels and said everything was fine and I would need to take it to a larger shop. I contacted the Apple Ford dealer near me and had my family follow me as I dropped it off. They said it would be a total of $310 for diagnostic and brake flush. I did the flush and it didn’t work. They said it would cost just shy of $3k to replace the entire hydraulic system. I took the car home because that is too much for a 2011 vehicle. I ended up having to get a new car because I need transportation for me and my two young children. My neighbor took a look at the car (he works on trucks) and the battery wouldn’t work. I bought a new battery for the car at $238.14. The lights are still on. I would like to have this car fixed or be able to trade it in. I am now being recommended to run a computer test on it to reset the codes. I would like to have this fixed as this seems to be a known issue with this car and I could have crashed if I wasn’t already driving slowly.
NHTSA complaint #11595694 — an unverified report by a vehicle owner.
Benton, AR
SERVICE BRAKES
I was driving home in rush hour traffic at approximately 50 mph. I tried to brake but the pedal went to the floor and I had no brakes at all. Turns out this was a recall issue for the same issue for the previous four years MKZs. Replacing the fluid did not fix the problem and the 2,000 dollars charged for just the module that controls this is disgraceful. That doesn't include the other thousand for a mechanic to install the part. I managed to avoid hitting anyone, but not by much. This is extremely dangerous and should be addressed
NHTSA complaint #11576429 — an unverified report by a vehicle owner.
Marshall, VA
TIRES:SIDEWALL
The tire is a NEXEN 225/45R18 After driving at highway speed on an out-of-town trip for several hours, got off the highway on the way to the hotel using suburban roads. About a mile later, a noise suddenly started at the driver's side front. The "slapping noise" got worse as the car went faster. I pulled off into a parking lot and found a steel bead from the tire had come loose and was hitting the inside fender well. I also noticed there were cracks in the side wall. I changed the tire using the spare tire and drove to the hotel. The next day, I went to a local tire dealer to buy replacement tires. Since the car is an All Wheel Drive vehicle, I had to replace all four tires. And, it is a good thing I did since when I inspected the old tires, the other front tire (the passenger side) had side wall cracks worse than the driver's side tire that had the bead separation. The two rear tires showed no evident side wall cracks. I kept the two front tires with the failures and one of the rear tires that did not have any evident cracks. There was not enough room in the car to bring all four tires back home. Attached are photographs of the two failed tires. NOTE: I am a former Director of the Office of Defects Investigation [XXX] ) and this is my wife's car. I brought the tires back with me since I believe ODI may want to have the tires in the event it believes a PE is appropriate. The tires are in my garage in Northern Virginia. The email and phone number are mine, not my wife's. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11541366 — an unverified report by a vehicle owner.
Marshall, VA
TIRES:BEAD
The tire is a NEXEN 225/45R18 After driving at highway speed on an out-of-town trip for several hours, got off the highway on the way to the hotel using suburban roads. About a mile later, a noise suddenly started at the driver's side front. The "slapping noise" got worse as the car went faster. I pulled off into a parking lot and found a steel bead from the tire had come loose and was hitting the inside fender well. I also noticed there were cracks in the side wall. I changed the tire using the spare tire and drove to the hotel. The next day, I went to a local tire dealer to buy replacement tires. Since the car is an All Wheel Drive vehicle, I had to replace all four tires. And, it is a good thing I did since when I inspected the old tires, the other front tire (the passenger side) had side wall cracks worse than the driver's side tire that had the bead separation. The two rear tires showed no evident side wall cracks. I kept the two front tires with the failures and one of the rear tires that did not have any evident cracks. There was not enough room in the car to bring all four tires back home. Attached are photographs of the two failed tires. NOTE: I am a former Director of the Office of Defects Investigation [XXX] ) and this is my wife's car. I brought the tires back with me since I believe ODI may want to have the tires in the event it believes a PE is appropriate. The tires are in my garage in Northern Virginia. The email and phone number are mine, not my wife's. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11541366 — an unverified report by a vehicle owner.
Freehold, NJ
SERVICE BRAKES
There have been several occasions where I am cruising at a steady spread and when I try to brake, the pedal just goes down to the floor. It's as if I don't have any brakes at all. I've had my brakes and fluid checked and all is good. This is a very scary and dangerous situation. Doing my research I see that this is a common problem. How is there not a recall on this? This could be a fatal situation. Please advise.
NHTSA complaint #11530068 — an unverified report by a vehicle owner.
San Antonio, TX
SERVICE BRAKES
Recently I have experienced a "soft brake pedal" on my 2011 Lincoln MKZ. I investigated online and here's what I found. So far there is no recall on this vehicle but SHOULD BE. NHTSA believes the hydraulic control valves can become corroded and stuck, causing soft brake pedals and longer stopping distances. In some cases, braking returns to normal when the valves subsequently become unstuck, causing an intermittent condition that makes a correct diagnosis difficult. On Ford's side, engineers discovered a gelatinous material that prevented control valves from properly returning to the closed positions after actuation. The automaker also found the gelatinous material likely occurred when brake fluid hit the valve coating. Federal investigators were able to recover affected brake components in some of the vehicles that were involved in crashes, and engineers confirmed stuck valves and corrosion of the zinc control valves. This problem has just recently evolved and it is very scary when applying the brakes and they go down to the floor. The car stops if you pump the brake pedal. My mileage is 150000 on my Lincoln MKZ but the car looks like new and is excellent shape.
NHTSA complaint #11524892 — an unverified report by a vehicle owner.
Mcpherson, KS
STEERING
While making a right turn into Walmart parking lot, car was suddenly very difficult to turn. We almost hit the car in the lane next to us. We had to back up into the main road and risked a collision there as well just to pull into the parking lot. Like the power steering went out. Just a mile before that turn we made a turn and had no issue. Highway driving is okay, it is just difficult to steer in low speed city driving conditions. I had a mechanic look at it. he could not find anything wrong so we flushed the power steering with fresh fluid. It did not seam to help. He concluded that the electric assist is probably what failed. We looked this up, and it is a common problem with this model year MKZ and a recall has been out for this. But, for some reason my car does not pull up this recall.
NHTSA complaint #11502687 — an unverified report by a vehicle owner.
Benton, AZ
SERVICE BRAKES
Brakes worked perfectly until I had to stop suddenly. Brake pedal went almost to the floor before brakes engaged, and then only slightly. I made it home with them in that same condition. When I took it to the shop, the brakes worked perfectly again. At no time was any code shown. So far the shop can't get the brakes to do it again, but I can't trust the car I paid for. The NHTSA had a recall for the Lincoln MKZ up to 2010, but my 2011 has the same ABS module issue. Please expand the recall before someone else gets injured or killed.
NHTSA complaint #11500983 — an unverified report by a vehicle owner.
Portage, IN
AIR BAGS
Takata recall. The contact owns a 2011 Lincoln MKZ. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) however, the part to do the recall repair was unavailable. The dealer was made aware of the issue and confirmed that parts were not yet available. The contact recently received a recall notice stating that parts were available; however, the contact was informed by the dealer that the parts were still not available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA complaint #11486097 — an unverified report by a vehicle owner.
Slippery Rock, PA
AIR BAGS
The contact owns a 2011 Lincoln MKZ. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. An unknown dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11479825 — an unverified report by a vehicle owner.
Lake Mary, FL
SERVICE BRAKES
Driving down the road all of a sudden Accutrac warning came up and then check brake system. The brakes were like a sponge and stopping was very difficult and required using emergency brake. Shut car off for a few minutes and then problem went away. Then it did it again. This is the same exact issue a recall was issued for the 2006-2010 model of Lincoln MKZ hybrid. Mine is a 2011 but built in the same plant. This car now has an unrepaired air bag from another recall that they still cannot fix and now no brakes and can't be driven. I feel this model should be included in the other model years recall.
NHTSA complaint #11474898 — an unverified report by a vehicle owner.
Pueblo, CO
AIR BAGS
Takata recall. The contact owns a 2011 Lincoln MKZ. The contact received notification of NHTSA Campaign Number: 21V158000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11471627 — an unverified report by a vehicle owner.
at 115,000 milesWoodbine, MS
ENGINE
The contact owns a 2011 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The vehicle was taken to the local dealer where it was diagnosed the water pump needed to be replaced. The contact was informed that water had leaked into the engine. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 115,000. The VIN was not available.
NHTSA complaint #11464857 — an unverified report by a vehicle owner.
at 115,000 milesWoodville, MS
ENGINE AND ENGINE COOLING
The contact owns a 2011 Lincoln MKZ. The contact stated that while driving at an undisclosed speed, there was an abnormal knocking noise detected and the vehicle stalled without warning. The vehicle was towed to the local dealer where it was diagnosed that water had entered the engine and the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but no additional assistance was provided. The approximate failure mileage was 115,000.
NHTSA complaint #11463184 — an unverified report by a vehicle owner.
Brecksville, OH
AIR BAGS
My vehicle has a safety recall for a possible exploding driver airbag, recall number 21V158. This recall was issued 3/25/21, about 10 months ago, and the manufacturer still does not have a fix for it. This is unacceptable given the severity of the recall. The NHTSA website states that if the manufacturer has not remedied a recall in a reasonable amount of time, then a vehicle complaint should be submitted. In my mind, 10 months is an unreasonable amount of time. I hope that the NHTSA can put additional pressure on Ford/Lincoln to remedy this recall ASAP.
NHTSA complaint #11448056 — an unverified report by a vehicle owner.
Waterford, MI
SERVICE BRAKES
During a braking event that caused my ABS to activate, my brake pedal traveled almost all the way to the floor. I was able to stop the car without accident but feel unsafe driving it. After much research I located Ford safety recall 19S54 which describes my issue exactly, unfortunately Ford has decided to only issue the recall for model years 2006 to 2010.
NHTSA complaint #11441895 — an unverified report by a vehicle owner.