1997 Mercury Grand Marquis steering problems

STEERING

I AM AN AUTOMOTIVE TECHNICIAN AND I SERVICE MANY VEHICLES DAILY. I CURRENTLY OWN A 97 MERCURY GRAND MARQUIS LS AND HAVE NOTICED THAT PRACTICALLY MOST STEERING COMPONENTS ON MY VEHICLE ARE IN NEED OF REPLACING. SPECIFICALLY THE TIE ROD ENDS, CONTROL ARMS, BALL JOINS ALL HAVE BLOWN BUSHINGS AND A PITMAN ARM.... THE STEERING SWAYS SO HARD ON THIS VEHICLE. I HAVE NOTICED THAT CUSTOMER'S VEHICLES THAT I HAVE WORKED ON THAT ARE SIMILAR TO THE CROWN VIC, AND THE MARQUIS ARE SHOWING SIGNS OF STEERING COMPONENT CONCERN AS WELL. I SEE MORE FORDS WITH STEERING ISSUES THAN ANY OTHER VEHICLE THAT I SERVICE. THE VEHICLES ALSO SEEM TO HAVE ISSUES WITH ANYONE SITTING IN THE BACK THAT THE BODY WILL SCRAPE THE TIRES AND THERE ARE MULTIPLE ELECTRICAL ISSUES. I HAVE HAD TO RIG MY VENT DOOR ACTUATOR AND I HAVE HAD TO INSTALL A SHUT OFF SWITCH DUE TO A PARASITIC DRAW THAT I CAN NOT LOCATE EVEN WITH A VOLT METER. AFTER RESEARCHING ON FORUMS AND WATCHING COUNTLESS YOUTUBE VIDEOS OF OWNERS STATING THESE KNOWN ISSUES I BELIEVE THAT IT IS BEYOND MAINTENANCE STANDARDS FOR THESE PARTS ALL TO BE FAULTY FROM THIS CAR MANUFACTURER.

NHTSA complaint #11254228 — an unverified report by a vehicle owner.

STEERING

RECALL WHILE DRIVING THE STEERING WHEEL SEEMS VERY LOOSE AS IF ITS ABOUT TO COME OFF

NHTSA complaint #10907042 — an unverified report by a vehicle owner.

STEERING

I HAVE TO PUT IT ON NEUTRAL MOST OF THE TIME WITH EMG BRAKE ON. BECAUSE THE GEARSHIFT IS HARD TO PUT IN PARK. MY CAR ONLY HAS 92,000 MILES.

NHTSA complaint #10870613 — an unverified report by a vehicle owner.

STEERING:LINKAGES:TIE ROD ASSEMBLY

DT: THE CONSUMER OWNS A 1997 MERCURY GRAND MARQUIS. WHILE DRIVING AND USING THE STEERING WHEEL THERE WAS A SQUEAKING NOISE. THE CONSUMER HAD TAKEN THE VEHICLE TO THE MECHANIC WHO SUGGESTED THAT THERE WAS NO LUBRICATION ON THE BALL JOINTS NOR WAS THERE ANY WAY TO LUBRICATED THEM DUE TO THE DESIGN. THE MECHANIC SAID THAT THE BALL JOINTS SHOULD BE ALRIGHT FOR A WHILE. NO REPAIRS OR CORRECTIONS WERE MADE AT THAT TIME. ON ANOTHER OCCASION WHILE DRIVING 29 MPH UPHILL, THE LEFT FRONT BALL JOINT CRACKED AND DROPPED TO THE GROUND DAMAGING THE TIE ROD AND BALL JOINT ASSEMBLY AND THE LEFT FRONT TIRE. THE VEHICLE CONTINUED TO TRAVEL FOR APPROXIMATELY 20 TO 30 FEET AFTER THE VEHICLE DROPPED TO THE GROUND AND THE DRIVER LOST DIRECTIONAL CONTROL OF THE VEHICLE. THIS HAPPENED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALERSHIP. THE DEALER SAID THAT THE OTHER SIDE WAS AFFECTED AS WELL. THE DEALER REPAIRED BOTH FRONT BALL JOINTS ALONG WITH THE TIE ROD ASSEMBLY. *AK NOTE: FAILED COMPONENTS ARE AVAILABLE FOR INSPECTION UPON REQUEST. *MJJ (11/211/05) THE CONSUMER FOUND THE COOLANT CROSSOVER CRACKED ON INTAKE. *SC

NHTSA complaint #10139329 — an unverified report by a vehicle owner.

STEERING:LINKAGES:TIE ROD ASSEMBLY

DT: CONTACT STATES THE TIE ROD ON THE DRIVERS SIDE OF 1997 GRAND MARQUIS FELL OFF JUST BEFORE MEMORIAL DAY. IT HAPPENED BECAUSE THERE WERE NO GREASE FITTINGS ON THE TIE RODS . THE CAR ONLY HAD 63,000 MILES ON IT. HE HAD NOT BEEN HAVING ANY PROBLEMS WITH THE CAR PRIOR TO THIS PROBLEM. HAD THEM BOTH REPLACED. HE WENT TO A MERCURY DEALER AND THEY TOLD HIM THERE WAS NOTHING THEY COULD DO ABOUT IT. HE HAS NOT TALKED TO THE MANUFACTURER.*AK

NHTSA complaint #10128920 — an unverified report by a vehicle owner.

STEERING:LINKAGES

SUDDEN FAILURES OF BALL JOINTS AND STEERING LINKAGES.

NHTSA complaint #10095856 — an unverified report by a vehicle owner.

STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT

CONSUMER DISMAYED TO NOTICE THE SMELL OF FUEL AS SHE DROVE AND PARKED THE VEHICLE. *PH THE SMELL WOULD BE PRESENT WHEN THE VEHICLE WAS PARKED AS WELL. THE FUEL WAS LEAKING INTO THE BRAKE LINE. *SC THE IDLER AND PITMAN ARMS WERE REPLACED.

NHTSA complaint #10071863 — an unverified report by a vehicle owner.

STEERING:COLUMN

THE STEERING WHEEL BECAME VERY HOT, WHILE DRIVING.

NHTSA complaint #10011911 — an unverified report by a vehicle owner.

STEERING

VEHICLE HANDLES WITH DIFFICULTY, NOT MAINTAINING STEERING CONTROL, AND CHANGING DIRECTIONS UPON WIND GUST. OWNER HAS TAKEN VEHICLE TO A DEALERSHIP, WHICH WAS NOT ABLE TO DETECT CAUSE OF ERRATICAL STEERING. PLEASE DESCRIBE DETAILS.

NHTSA complaint #8018837 — an unverified report by a vehicle owner.

STEERING: STEERING WHEEL/HANDLE BAR

IN STEERING COLUMN BOLTS TO THE SHIFT INDICATOR FELL OUT. VEHICLE WAS HARD TO MANEUVER AND THERE WAS NO CONTROL OF WHICH GEAR VEHICLE WAS BEING SHIFTED TO. DEALER WAS NOTIFIED.

NHTSA complaint #8003519 — an unverified report by a vehicle owner.

STEERING:RACK AND PINION

CONSUMER STATES STEERING GEAR WAS EXCESSIVELY WORN, WHEN DRIVING AND STEERING WHEEL IS BEING TURNED IN EITHER DIRECTION, THERE IS A GRINDING NOISE.

NHTSA complaint #561869 — an unverified report by a vehicle owner.

STEERING

A LOUD CLUNCKING NOISE WILL OCCUR WHEN TURNING STEERING WHEEL TO LEFT OR TO RIGHT. DEALER CANNOT DETERMINE CAUSE OF DEFECT.

NHTSA complaint #862450 — an unverified report by a vehicle owner.

STEERING: STEERING WHEEL/HANDLE BAR

WHILE DRIVING DOWN MAIN STREET TRAVELING 10MPH, TRAFFIC WAS SLOWING DOWN UP AHEAD. WENT OVER A HUMP IN ROAD, AND ALL OF A SUDDEN STEERING WHEEL WOULD JUST SPIN. LOST CONTROL, AND WENT OFF TO THE SIDE OF ROAD. TOWED TO THE DEALER. DEALER LOCATED THE PROBLEM, AND REPLACED STEERING COLUMN COUPLING BOLT.

NHTSA complaint #858746 — an unverified report by a vehicle owner.

STEERING:RACK AND PINION

EXCESSIVE ROAD SHOCK FELT IN STEERING SINCE CAR WAS NEW. 2 DEALERS SAID NOT A PROBLEM BUT SEEMS TO BE GETTING WORSE WITH AGE OF CAR. ALSO WHEEL SKIP ON MODERATELY BUMPY ROADS IE ASPHALT STRIPS IN PAVEMENT.

NHTSA complaint #715434 — an unverified report by a vehicle owner.

STEERING:HYDRAULIC POWER ASSIST:PUMP

POWER STEERING PUMP WENT OUT. LIGHTS WERE BLINKING ON AND OFF FOR THREE DAYS.

NHTSA complaint #609708 — an unverified report by a vehicle owner.

STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS

POWER STEERING PRESSURE HOSE REPLACED DUE TO VIBRATION IN STEERING WHEEL PER SERVICE BULLETIN.

NHTSA complaint #543667 — an unverified report by a vehicle owner.

STEERING:GEAR BOX (OTHER THAN RACK AND PINION)

STEERING GEAR ASSEMBLY REPLACED DUE TO HOT LINE NOTICE, CAUSING VIBRATION.

NHTSA complaint #543667 — an unverified report by a vehicle owner.

STEERING

VIBRATION IN STEERING WHEN TRAVELING OVER BUMPS.

NHTSA complaint #539098 — an unverified report by a vehicle owner.

STEERING

STEERING WHEEL VIBRATES EXCESSIVELY AND JUMPS OVER ROAD WHEN HITTING A BUMP OR MANHOLE.

NHTSA complaint #539037 — an unverified report by a vehicle owner.

STEERING: STEERING WHEEL/HANDLE BAR

WHILE DRIVING THE IGNITION SWITCH AND STEERING COLUMN BECOME EXTREMELY HOT . THE DEALER HAS BEEN NOTIFIED.

NHTSA complaint #826722 — an unverified report by a vehicle owner.

STEERING

STEERING DURING CROSS WINDS CAUSES VEHICLE TO WANDER, DOES NOT STAY IN LANE. PLEASE DESCRIBE.

NHTSA complaint #812132 — an unverified report by a vehicle owner.