Owners have filed 261 complaints
about the 2011 Mercury Milan with NHTSA between 2012 and 2026.
The largest single group is the steering.
Across this model's run it ranks 6 of 6 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 24
Against the median year of the Mercury Milan. 50 means typical for this
model; 100 means roughly double.
Severity — 8
1.5% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 18
11% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
10.5%
10,000 – 24,999 miles
83.8%
25,000 – 49,999 miles
8439.6%
50,000 – 74,999 miles
4621.7%
75,000 – 99,999 miles
2411.3%
100,000 – 149,999 miles
2913.7%
150,000+ miles
209.4%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Configuration
Overall
Front
Side
Rollover
2011 Mercury Milan 4 DR AWD
9.2% risk
2011 Mercury Milan 4 DR FWD
10.5% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jun 2012peak 21Aug 2026
NHTSA investigations into the 2011 Mercury Milan
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE14030Opened 2 Oct 2014Closed 10 Sep 2015STEERING:ELECTRIC POWER ASSIST SYSTEM
Electric power steering failure
The Office of Defects Investigation (ODI) opened a preliminary evaluation to investigate complaints of the loss of power steering while driving. The subject vehicles are equipped with a rack mounted Electric Power Assisted Steering (EPAS) unit.Some of the complaints alleged that the steering assist failed and resulted in increased steering efforts that contributed to a loss of control and in some cases a crash.The EPAS system was manufactured by TRW Automotive for Ford and was designated as Generation I.These units were first produced and put into vehicle production in July 2008 beginning with...
PE13003Opened 21 Feb 2013Closed 28 Feb 2014ENGINE
Electronic Throttle Body Malfunction
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting...
EA12009Opened 12 Dec 2012Closed 12 Jun 2014VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Floor mat interference with accelerator
On May 27, 2014, Ford Motor Company submitted recall 14E-028 (Ford recall #14S07) to correct a safety-related problem with certain driver's side Ford optional all-weather floor mats sold for use in model year 2006 through 2011 model year Ford Fusion, Mercury Milan, Lincoln Zephyr, and Lincoln MKZ vehicles built at Hermosillo Assembly Plant (HAP) from November 9, 2007, to October 31 ,2010.NHTSA testing determined that the original accessory all-weather mat with a single retention clip (Figure 1), may interfere with accelerator pedal return to idle with the mat retained by the clip and rotated c...
Recalls on the 2011 Mercury Milan
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V158000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
21V081000
AIR BAGS:FRONTAL
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
21E013000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain air bag inflator and/or module replacement service parts that may have been used as part of a collision repair. The parts include certain driver-side air bag inflators and/or modules, designed to fit 2005-2014 Ford Mustang and Mustang GT500. It also includes certain passenger-side air bag inflators and/or modules designed to fit 2005-2014 Ford Mustang, 2010-2012 Lincoln MKZ, 2010-2012 Ford Fusion, 2010-2011 Mercury Milan, 2007-2011 Ford Ranger, and 2007-2010 Lincoln MKX vehicles. Please see Ford's recall report for the specific part numbers. These parts may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V001000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain 2014 Ford Mustang vehicles sold, or ever registered, in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Ford is recalling certain 2011 Ford Ranger and Mercury Milan vehicles, 2011-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles and 2011-2014 Ford Mustang vehicles sold, or ever registered, in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Ford is also recalling certain 2010 Ford Edge and Lincoln MKX vehicles, 2010-2011 Ford Ranger and Mercury Milan vehicles, 2010-2012 Ford Fusion and Lincoln Zephyr/MKZ vehicles, and 2010-2014 Ford Mustang vehicles sold, or ever registered, in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with air bag inflators a
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
16V384000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V793000
FUEL SYSTEM, GASOLINE:STORAGE:AUXILLARY TANK
Ford Motor Company (Ford) is recalling certain model year 2010-2011 Ford Fusion vehicles manufactured July 21, 2008, to March 4, 2011, and 2010-2011 Mercury Milan vehicles manufactured July 23, 2008, to December 10, 2010. The affected vehicles have fuel vapor canisters whose purge valves may not operate properly resulting in abnormal pressure changes in the fuel tank.
Risk: The pressure changes may cause the tank to crack and leak fuel. A fuel leak in the presence of an ignition source increases the risk of a fire.
15V340000
STEERING:ELECTRIC POWER ASSIST SYSTEM
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Risk: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
14E028000
EQUIPMENT
Ford Motor Company (Ford) is recalling certain all weather driver side accessory floor mats sold for use in model year 2006-2011 Ford Fusion and Mercury Milan, 2006 Lincoln Zephyr, and 2007-2011 Lincoln MKZ vehicles manufactured November 9, 2007, through October 31, 2010. The affected floor mats may move and possibly interfere with the accelerator pedal.
Risk: The floor mat could shift such that it could interfere with the accelerator pedal, preventing its return to an idle position, which could result in unintended vehicle speeds, increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2021029274,737 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: Ford will notify owners by mail. The corrective actions for this recall are under development. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 2019005300,898 units in Canada
Airbag
Issue: On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the passenger-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Actions: Owners will be notified by mail and instructed to take their vehicle to a dealer to have the passenger-front airbag inflator replaced. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected. Additional note: This recall supersedes recalls 2016-347 (Ford Safety Improvement Program 16S26), 2017-024 (Ford Recall 17S01) and 2018-035 (Ford Recall 18S01). Vehicles repaired under the previous recalls do not require repair under this recall.
Recall 20163475,867 units in Canada
Airbag
Ford Canada is conducting a voluntary Safety Improvement Program involving passenger airbag inflators in certain vehicles that were originally sold or ever registered in certain high humidity areas of the United States equipped with Takata airbags. Ford will replace the driver or passenger inflator on affected vehicles, depending on the vehicle involved. Owners who believe their vehicles may have been originally purchased or registered in the states of New Jersey, Delaware, District of Columbia, Maryland, Pennsylvania, Ohio, Indiana, Illinois, Virginia, West Virginia, Kentucky, Missouri, Nebraska, Kansas, Oklahoma, Arkansas, Tennessee, North Carolina, Nevada, Arizona, New Mexico, California, Texas, Louisiana, Mississippi, Alabama, Georgia, South Carolina, Florida, Hawaii, Puerto Rico or the U.S. Virgin Islands should contact a Ford dealer. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This Safety Improvement Program is superseded by recall 2019005 (Ford Recall 19S01). Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019005">recall 2019005</a> for more information.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 135,000 milesPlantation, FLCrashFire
AIR BAGS
I DID RECEIVE A LETTER ABOUT A YEAR AGO REQUESTING TO TAKE MY CAR INTO FORD CONCERNING THE DRIVER AIR BAG AND OTHER THINGS THAT NEEDED TO BE CORRECTED AS WELL. ALL THE RECALL WORK WAS COMPLETED EXCEPT FOR THE AIR BAGS. WE WERE TOLD THAT THEY DID NOT HAVE THE PARTS NEEDED IN STOCK THAT WE WOULD BE NOTIFIED. AS OF TODAY PLANTATION FORD HAS REACHED OUT TO US, NOR HAS FORD MOTOR COMPANY. THE ONLY REASON WHY THIS CAME TO MIND WAS THAT WE HAD AN HIT AND RUN YESTERDAY, AND THE AIRS BAGS DID NOT WORK. * (RECALL RELATED INCIDENT) TS
NHTSA complaint #11072648 — an unverified report by a vehicle owner.
at 82,000 milesNorth LAS Vegas, NVFire
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM
WHILE WE WERE DRIVING THE VEHICLE, THE BLOWER MOTOR FOR THE AIR CONDITIONER SHUT ITSELF OFF THEN CAME BACK ON AND IT WAS BLOWING WHITE SMOKE OUT OF ALL OF THE VENTS. WE HAD TO PULL OVER TO THE SHOULDER OF THE ROAD AND SHUT OFF THE CAR IN ORDER TO STOP THE WHITE SMOKE FROM COMING THROUGH THE VENTS. THE HVAC BLOWER CONTROL MOTOR UNIT HAD STARTED BURNING AND FAILED TO DISENGAGE THE BLOWER MOTOR WHILE IT WAS BURNING. ADDITIONALLY THE VEHICLES 40A FUSE AND 30A ISO RELAY DID NOT WORK PROPERLY, IF WE DID NOT SHUT OFF THE CAR IT WOULD HAVE CONTINUED TO BURN. THIS IS THE SECOND INSTANCE OF THIS HAPPENING TO OUR MERCURY, THE FIRST TIME WE WERE PARKED AND WHEN WE TURNED THE CAR ON IT STARTING BLOWING WHITE SMOKE AND SMELLED OF BURNT ELECTRONICS AND OZONE FROM AN ELECTRICAL FIRE IN THE CAB. WHEN WE HAD A FORD SERVICE CENTER LOOK AT THE VEHICLE, WE WERE TOLD THIS IS A COMMON PROBLEM WITH THIS TYPE OF VEHICLE. AND THAT THE CONTROL UNIT IS BEING USED LIKE A FUSE TO THE BLOWER MOTOR.
NHTSA complaint #10532364 — an unverified report by a vehicle owner.
at 82,000 milesNorth LAS Vegas, NVFire
ELECTRICAL SYSTEM
WHILE WE WERE DRIVING THE VEHICLE, THE BLOWER MOTOR FOR THE AIR CONDITIONER SHUT ITSELF OFF THEN CAME BACK ON AND IT WAS BLOWING WHITE SMOKE OUT OF ALL OF THE VENTS. WE HAD TO PULL OVER TO THE SHOULDER OF THE ROAD AND SHUT OFF THE CAR IN ORDER TO STOP THE WHITE SMOKE FROM COMING THROUGH THE VENTS. THE HVAC BLOWER CONTROL MOTOR UNIT HAD STARTED BURNING AND FAILED TO DISENGAGE THE BLOWER MOTOR WHILE IT WAS BURNING. ADDITIONALLY THE VEHICLES 40A FUSE AND 30A ISO RELAY DID NOT WORK PROPERLY, IF WE DID NOT SHUT OFF THE CAR IT WOULD HAVE CONTINUED TO BURN. THIS IS THE SECOND INSTANCE OF THIS HAPPENING TO OUR MERCURY, THE FIRST TIME WE WERE PARKED AND WHEN WE TURNED THE CAR ON IT STARTING BLOWING WHITE SMOKE AND SMELLED OF BURNT ELECTRONICS AND OZONE FROM AN ELECTRICAL FIRE IN THE CAB. WHEN WE HAD A FORD SERVICE CENTER LOOK AT THE VEHICLE, WE WERE TOLD THIS IS A COMMON PROBLEM WITH THIS TYPE OF VEHICLE. AND THAT THE CONTROL UNIT IS BEING USED LIKE A FUSE TO THE BLOWER MOTOR.
NHTSA complaint #10532364 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Grosse Pointe Woods, MI
FUEL/PROPULSION SYSTEM
Gas tank leak, fuel fumes. Part of safety recall for fuel pressure regulator causing fuel tank rupture!!!
NHTSA complaint #11754953 — an unverified report by a vehicle owner.
at 125,000 milesGrosse Pointe Woods, MI
FUEL SYSTEM, GASOLINE
The contact owns a 2011 Mercury Milan. The contact stated there was an abnormal fuel odor coming from the vehicle and there was fuel underneath the vehicle. The contact researched and became aware of NHTSA Campaign Number: 15V793000 (Fuel System, Gasoline); however, the VIN was not included in the recall. The dealer was contacted and confirmed that the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The vehicle was not repaired. The manufacturer was made aware of the issue and confirmed that the VIN was not under recall. The failure mileage was approximately 125,000.
NHTSA complaint #11754479 — an unverified report by a vehicle owner.
Ventura, CA
STEERING
On XXX My 2011 Milan, experienced a total loss of steering assist. Am original owner & have original invoice from former dealer (Vista Ford )dated XXX, Invoice #XXX shows the dealer only did a software patch under 15N01 because there were no error codes at the time. My physical defective steering gear was never replaced, and now suffers a total mechanical electrical failure. The manufacturers software recall patch failed to prevent the component from failing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11750411 — an unverified report by a vehicle owner.
at 91,430 milesVentura, CA
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving at an undisclosed speed, the electronic power steering failure warning light illuminated. Additionally, the steering wheel failed to turn in the intended direction. The contact's family member attached the ODS monitor to the vehicle, and fault codes: C1277 (Steering Wheel Angle Sensor), UL3000 (Power Steering Control Modular) and several other failure codes associated with the electronic power steering were retrieved. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The dealer was not made aware of the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 91,430.
NHTSA complaint #11743808 — an unverified report by a vehicle owner.
Indianapolis, IN
POWER TRAIN
1) The electric power steering system failed. The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working, making the steering extremely stiff. The vehicle also lost reverse gear, where the engine revs but the vehicle does not move when shifted into reverse. The vehicle is still in my possession and available for inspection upon request. 2) When the power steering assist failed, the steering wheel became extremely difficult to turn, which made the vehicle harder to control. This created a safety risk when attempting to turn or maneuver the vehicle in traffic or parking areas. Additionally, the inability to use reverse gear could create a hazardous situation if the driver cannot back out of traffic, parking spaces, or other areas. 3) The problem has not yet been inspected or confirmed by a dealership or independent service center. 4) No, the vehicle has not been inspected by the manufacturer, police, insurance representatives, or other parties. 5) The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working. The problem appeared suddenly when the vehicle was started. The steering immediately became extremely stiff, and the warning message appeared at that time. This failure created a serious safety hazard because the steering assist stopped working without warning, making the vehicle extremely difficult to control. A sudden loss of steering assist can increase the risk of a crash, especially when turning, parking, or driving in traffic. I am concerned that other drivers could experience the same sudden steering failure. The vehicle displayed the message “Service Power Steering Now,” and the steering immediately became extremely stiff. The vehicle is currently undriveable in reverse and difficult to steer safely.
NHTSA complaint #11722674 — an unverified report by a vehicle owner.
Indianapolis, IN
STEERING
1) The electric power steering system failed. The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working, making the steering extremely stiff. The vehicle also lost reverse gear, where the engine revs but the vehicle does not move when shifted into reverse. The vehicle is still in my possession and available for inspection upon request. 2) When the power steering assist failed, the steering wheel became extremely difficult to turn, which made the vehicle harder to control. This created a safety risk when attempting to turn or maneuver the vehicle in traffic or parking areas. Additionally, the inability to use reverse gear could create a hazardous situation if the driver cannot back out of traffic, parking spaces, or other areas. 3) The problem has not yet been inspected or confirmed by a dealership or independent service center. 4) No, the vehicle has not been inspected by the manufacturer, police, insurance representatives, or other parties. 5) The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working. The problem appeared suddenly when the vehicle was started. The steering immediately became extremely stiff, and the warning message appeared at that time. This failure created a serious safety hazard because the steering assist stopped working without warning, making the vehicle extremely difficult to control. A sudden loss of steering assist can increase the risk of a crash, especially when turning, parking, or driving in traffic. I am concerned that other drivers could experience the same sudden steering failure. The vehicle displayed the message “Service Power Steering Now,” and the steering immediately became extremely stiff. The vehicle is currently undriveable in reverse and difficult to steer safely.
NHTSA complaint #11722674 — an unverified report by a vehicle owner.
Indianapolis, IN
ELECTRICAL SYSTEM
1) The electric power steering system failed. The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working, making the steering extremely stiff. The vehicle also lost reverse gear, where the engine revs but the vehicle does not move when shifted into reverse. The vehicle is still in my possession and available for inspection upon request. 2) When the power steering assist failed, the steering wheel became extremely difficult to turn, which made the vehicle harder to control. This created a safety risk when attempting to turn or maneuver the vehicle in traffic or parking areas. Additionally, the inability to use reverse gear could create a hazardous situation if the driver cannot back out of traffic, parking spaces, or other areas. 3) The problem has not yet been inspected or confirmed by a dealership or independent service center. 4) No, the vehicle has not been inspected by the manufacturer, police, insurance representatives, or other parties. 5) The dashboard displayed the message “Service Power Steering Now,” and the steering assist stopped working. The problem appeared suddenly when the vehicle was started. The steering immediately became extremely stiff, and the warning message appeared at that time. This failure created a serious safety hazard because the steering assist stopped working without warning, making the vehicle extremely difficult to control. A sudden loss of steering assist can increase the risk of a crash, especially when turning, parking, or driving in traffic. I am concerned that other drivers could experience the same sudden steering failure. The vehicle displayed the message “Service Power Steering Now,” and the steering immediately became extremely stiff. The vehicle is currently undriveable in reverse and difficult to steer safely.
NHTSA complaint #11722674 — an unverified report by a vehicle owner.
Mokena, IL
STEERING
on 10/27/25 my son was driving car (2011 Mercury Milan) and light came on dash and car suddenly lost all power steering. Luckily car was able to be driven to side of the road when steering went out. I went to the Ford recalls website and it indicated "Epas steering efforts" was on the website as requiring free service. This recall is specifically for loss of power steering in car. Electronic Power Assisted Steering (EPAS) systems provide variable steering assistance but can experience issues leading to increased steering effort and loss of control. Upon checking with dealer, this was to be fixed under safety recall bulletin 15S18. This was initially repaired in 2015 under that recall bulletin. This did not fix the issue as the car requires a power steering gear replacement for same issue. Warranties on this recall are not being honored and this is deceptive as the final repair did not correct the problem. Federal law dicates warrenties do not expire on safety recalls. Upon checking the ford recall website, Ford is now indicating it can be fixed under a "Customer Satisfaction Program" to cover the original safety recall which has already expired. Now I am faced with almost a $3k repair on a safety recall which was never fixed and not being honored by Ford.
NHTSA complaint #11696096 — an unverified report by a vehicle owner.
Fort Collins, CO
EXTERIOR LIGHTING
Passenger side brake light assembly failed June 2025. I found it our at an oil change inspection. Ford discontinued manufacturing this LED brake light assembly, so it is difficult to replace this safety critical part. The part number is 9N7Z 13404 A.
NHTSA complaint #11675692 — an unverified report by a vehicle owner.
Wheeling, WV
SERVICE BRAKES, HYDRAULIC
The contact owns a 2011 Mercury Milan. The contact stated that while the vehicle was at the dealer for servicing, the contact was informed that the electronic brake control module had failed. The contact was informed that the electronic brake control module needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure, but no assistance was provided. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
NHTSA complaint #11662594 — an unverified report by a vehicle owner.
Vadnais Heights, MN
STEERING
My car was recalled for the steering control module issue in 2016, Recall 15S18 and 15N01. Brought it into my Ford dealer in 2016 and Ford declined to fix the steering control module repair. In 2016, car was well within the 10 year window and mileage restriction. Now, my car still is under 150K miles, is at 124,000. The power steering stopped working last week. The error message on dashboard states, power steering control error. Brought it into shop and mechanic diagnosed it as error with power steering control module and loss of power steering assist. Mechanic advised me to return to Ford as this problem was under recall 15V34. Ford refuses to repair my car as it is past the 10 year warranty window. If Ford would not have denied this repair in 2016, my car power steering control module would not have failed last week. Now my car is unsafe to drive. Ford should have fixed my car and now it is undrivable. They know that 2011 Mercury Milans have this issue and have abdicated responsibility for the safety of my car.
NHTSA complaint #11646548 — an unverified report by a vehicle owner.
at 124,000 milesSaint Paul, MN
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving at various speeds, the power steering assist intermittently failed to operate as needed. The contact stated that the "Service Power Steering Now" message was displayed. The vehicle was taken to an independent mechanic and the contact was informed that the vehicle was included in NHTSA Campaign Number: 15V340000 (Steering). The vehicle was then taken to the dealer and the contact was informed that the vehicle was not under recall or warranty. The contact was provided an estimate for the repair. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 124,000.
NHTSA complaint #11645325 — an unverified report by a vehicle owner.
Swainsboro, GA
STEERING
Steering went out on vehicle, very difficult to steer. Got it to the dealership, they say it is not in the recall. The power steering assist fault light came on and service advance trac. Is costing almost $1500 to fix.
NHTSA complaint #11637194 — an unverified report by a vehicle owner.
Keokuk, IA
AIR BAGS
I've been reading on all these recalls for my car and only one recall was fix which was when I took care of it but these past recalls on my car, and some of the recalls match up to the way my car is acting like and I bought this car used and I am concerned about the recalls and not being fix I would like to get my car checked for the past recalls on it bc I don't want to drive a car that has recalls that's not been fix and I do not want to put my life or anyone else in danger
NHTSA complaint #11629029 — an unverified report by a vehicle owner.
Keokuk, IA
WHEELS
I've been reading on all these recalls for my car and only one recall was fix which was when I took care of it but these past recalls on my car, and some of the recalls match up to the way my car is acting like and I bought this car used and I am concerned about the recalls and not being fix I would like to get my car checked for the past recalls on it bc I don't want to drive a car that has recalls that's not been fix and I do not want to put my life or anyone else in danger
NHTSA complaint #11629029 — an unverified report by a vehicle owner.
Keokuk, IA
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
I've been reading on all these recalls for my car and only one recall was fix which was when I took care of it but these past recalls on my car, and some of the recalls match up to the way my car is acting like and I bought this car used and I am concerned about the recalls and not being fix I would like to get my car checked for the past recalls on it bc I don't want to drive a car that has recalls that's not been fix and I do not want to put my life or anyone else in danger
NHTSA complaint #11629029 — an unverified report by a vehicle owner.
Decatur, IL
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving at various speeds, the vehicle experienced a loss of power steering functionality. A message indicating power steering failure was displayed. The vehicle was taken to several independent mechanics, where it was determined that the failure was related to NHTSA Campaign Number: 15V340000 (Steering). The vehicle was then taken to the dealer, where the contact was informed that the repair of Ford Campaign Number: 15N01 could not be completed due to the vehicle's mileage. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA complaint #11612496 — an unverified report by a vehicle owner.
at 147,000 milesEnnis, TX
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving 70 MPH, the steering wheel locked. The power steering assist warning light was illuminated, and the message "Service Advance Track" was displayed. The vehicle was driven to the contact's residence. The vehicle was not diagnosed or repaired. No further information was provided. The manufacturer was not notified of the failure. The failure mileage was approximately 147,000.
NHTSA complaint #11578411 — an unverified report by a vehicle owner.
at 147,000 milesEnnis, TX
STEERING:ELECTRIC POWER ASSIST SYSTEM
The contact owns a 2011 Mercury Milan. The contact stated while driving 70 MPH, the steering wheel locked. The power steering assist warning light was illuminated, and the message "Service Advance Track" was displayed. The vehicle was driven to the contact's residence. The vehicle was not diagnosed or repaired. No further information was provided. The manufacturer was not notified of the failure. The failure mileage was approximately 147,000.
NHTSA complaint #11578411 — an unverified report by a vehicle owner.
at 260,000 milesBartow, WV
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while starting the vehicle, the steering wheel was difficult to turn. The failure was more evident during the cold weather. The Service Power Steering warning light was illuminated. The vehicle was not taken to the local dealer to be diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 260,000.
NHTSA complaint #11566259 — an unverified report by a vehicle owner.
Decatur, GA
STEERING
Power steering service light came on, and the power steering on vehicle was impaired and almost impossible to turn the wheel while operating the vehicle .,after contacting Ford dealership, a recall is listed on that year of this make and model, but the Vin number is not included in the recall for maintenance repairs
NHTSA complaint #11565329 — an unverified report by a vehicle owner.
Fairborn, OH
STEERING
The first symptom was the steering wheels failure to return to center after going around a corner. That went on for about 3 weeks before the Service Advance Trac warning came on. The vehicle started to have a terrible noise when turning the wheel which can only be described as the sound of bones breaking. The sound is increasing louder at slow speeds. Then the Advance Trac System Failure message came on, and the vehicle lost all power steering assist. When turning a corner the steering wheel almost gets stuck at the 2,3,4,5 positions. There was a massive Ford recall for this make and model with the exact same failed part, but for some reason Ford decided to not include my vehicle in this recall, despite it having the failure. This is a very expensive repair, and at this point in the vehicles life basically renders it a total loss. This should be remedied by Ford for all vehicles with this part.
NHTSA complaint #11562701 — an unverified report by a vehicle owner.
at 101,000 milesRockwell, NC
STEERING
The contact owns a 2011 Mercury Milan. The contact stated that the vehicle had been experiencing power steering failure. The contact stated while reversing out of the driveway and attempting to make a turn, the vehicle lost power steering functionality. The messages "Power Steering Assist Fault" and "Service Advancetrac" were displayed. The contact stated that she was unable to turn the steering wheel. The dealer was not notified of the failure. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 101,000.
NHTSA complaint #11560914 — an unverified report by a vehicle owner.
at 186,000 milesLenoir, NC
STEERING
The contact owns a 2011 Mercury Milan. The contact stated while driving 25 MPH, she heard an abnormal sound coming from the front-end of the vehicle, and the contact became aware that the electronic power steering was not functioning properly. The "Service Power Steering Now" and "Service Advance Track" messages were displayed. Additionally, the traction control warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 15V34000 (Steering) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 186,000.
NHTSA complaint #11556225 — an unverified report by a vehicle owner.
Las Vegas, NV
STEERING
The power steering is out and the car is very hard to turn and control. The recall has been confirmed by the dealer but it appears that they cannot fix due to my vin number not showing a recall for the power steering control module.
NHTSA complaint #11530130 — an unverified report by a vehicle owner.