13 of the 362 complaints about the 1999 Plymouth Voyager are about the fuel system — 4% of everything reported for this model year. Half of the failures with a mileage on record happened before 86,100 miles.
13
Complaints
0
Crashes
2
Fires
1
Injuries
Filed with NHTSA, in their own words.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1999 PLYMOUTH VOYAGER. THE CONTACT STATED THAT FUEL FUMES EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,200.
NHTSA complaint #10722607 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
THE CONSUMER SMELLED GAS FUMES INSIDE THE VEHICLE. PLEASE PROVIDE MORE INFORMATION.
NHTSA complaint #10101495 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
WHILE DRIVING ON THE INTERSTATE CONSUMER NOTICED SMOKE. THEN, VEHICLE ACCELERATED BY ITSELF AND JERKED FORWARD. CONSUMER EXITED OFF THE INTER STATE. SMOKE WAS COMING OUT FROM UNDER THE HOOD. VEHICLE WAS IN FLAMES WITHIN SECONDS. THE CAUSE OF THE FIRE WAS DUE TO A FUEL LEAK.
NHTSA complaint #10055666 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
WHILE DRIVING AT 55 MPH CONSUMER NOTICED SMOKE THROUGH THE REAR VIEW MIRROR COMING FROM THE REAR OF VEHICLE. WHEN THIS OCCURRED VEHICLE HESITATED TO ACCELERATE. WITHIN SECONDS OF THE CONSUMER PULLING OVER AND EXISTING THE VEHICLE, IT EXPLODED. THE FIRE INSPECTOR INDICATED THAT THE CAUSE OF THE FIRE WAS DUE TO A FUEL TANK LEAK. *AK THE VEHICLE ACCELERATED FROM 55 MPH TO 85 MPH ON ITS OWN.
NHTSA complaint #10037655 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY
IF THE VEHICLE WAS ON HALF A TANK IT WOULD SHUT OFF. *NLM
NHTSA complaint #10020465 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
I PURCHASED A USED 1999 PLYMOUTH VOYAGER. WHEN I TOOK IT TO A DEALER IN CARLSBAD, CA. BOB BAKER, I ASKED ABOUT TWO PROBLEMS I HAVE WITH IT. THE HORN DOESN'T HONK, AND THE AIR BAY LIGHT STAYS ON ALL THE TIME. I WAS TOLD THEY'D BE FIXED FREE. WHEN THEY CALLED REGARDING OTHER REPAIRS, THEY SAID THE ITEMS WOULDN'T BE FIXED FREE, THAT MY PARTICULAR 1999 PLYMOUTH VOYAGER WASN'T INCLUDED IN A RECALL. I OBJECTED AND ALSO FOUND THE REPAIR COSTS EXPENSIVE FOR ME, AND I WAS TOLD TO GO AHEAD AND PAY TO HAVE IT FIXED, THAT "THERE WILL BE A RECALL COMING UP AND WHEN IT DOES I CAN SHOW THE RECEIPTS AND GET A REFUND." WHY ARE SOME 1999 INCLUDED AND OTHERS NOT, WHEN THEY HAVE THE SAME PROBLEMS OTHERS ARE FIXED FOR UNDER RECALL? ALSO THE LOW FUEL BELL RINGS AFTER YOU FILL THE TANK UNTIL THE TANK LEVEL GETS DOWN TO ABOUT 3/4 TANK. ( IT DOES RING WHEN THE FUEL IS LOW, TOO). I WANT MY HORN FIXED, IT'S AN IMPORTANT SAFETY FEATURE. ALSO THE LIGHT "SERVICE ENGINE SOON" CAME ON, AND I JUST HAD A TUNE UP, ETC. I TOOK THE VEHICLE IN TO A REPAIR SHOP BECAUSE THE DEALERSHIP COSTS SO MUCH AND IT COST ME $58.00 TO FIND OUT THAT THE GAS CAP WASN'T SEALING PROPERLY. THE NEW CAP I BOUGHT IS IMPRINTED WITH INFORMATION ABOUT IT HAVING TO BE PLACED ON PROPERLY. THIS NEW CAP I BELIEVE IS IMPRINTED THIS WAY BECAUSE OF A PROBLEM THAT CAME UP. I AM DISGUSTED AND "BROKE" AFTER HAVING TO PAY FOR SUCH A DIAGNOSIS AND THEN 15.65 FOR THE NEW CAP.
NHTSA complaint #10018771 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP
I PURCHASED A USED 1999 PLYMOUTH VOYAGER. WHEN I TOOK IT TO A DEALER IN CARLSBAD, CA. BOB BAKER, I ASKED ABOUT TWO PROBLEMS I HAVE WITH IT. THE HORN DOESN'T HONK, AND THE AIR BAY LIGHT STAYS ON ALL THE TIME. I WAS TOLD THEY'D BE FIXED FREE. WHEN THEY CALLED REGARDING OTHER REPAIRS, THEY SAID THE ITEMS WOULDN'T BE FIXED FREE, THAT MY PARTICULAR 1999 PLYMOUTH VOYAGER WASN'T INCLUDED IN A RECALL. I OBJECTED AND ALSO FOUND THE REPAIR COSTS EXPENSIVE FOR ME, AND I WAS TOLD TO GO AHEAD AND PAY TO HAVE IT FIXED, THAT "THERE WILL BE A RECALL COMING UP AND WHEN IT DOES I CAN SHOW THE RECEIPTS AND GET A REFUND." WHY ARE SOME 1999 INCLUDED AND OTHERS NOT, WHEN THEY HAVE THE SAME PROBLEMS OTHERS ARE FIXED FOR UNDER RECALL? ALSO THE LOW FUEL BELL RINGS AFTER YOU FILL THE TANK UNTIL THE TANK LEVEL GETS DOWN TO ABOUT 3/4 TANK. ( IT DOES RING WHEN THE FUEL IS LOW, TOO). I WANT MY HORN FIXED, IT'S AN IMPORTANT SAFETY FEATURE. ALSO THE LIGHT "SERVICE ENGINE SOON" CAME ON, AND I JUST HAD A TUNE UP, ETC. I TOOK THE VEHICLE IN TO A REPAIR SHOP BECAUSE THE DEALERSHIP COSTS SO MUCH AND IT COST ME $58.00 TO FIND OUT THAT THE GAS CAP WASN'T SEALING PROPERLY. THE NEW CAP I BOUGHT IS IMPRINTED WITH INFORMATION ABOUT IT HAVING TO BE PLACED ON PROPERLY. THIS NEW CAP I BELIEVE IS IMPRINTED THIS WAY BECAUSE OF A PROBLEM THAT CAME UP. I AM DISGUSTED AND "BROKE" AFTER HAVING TO PAY FOR SUCH A DIAGNOSIS AND THEN 15.65 FOR THE NEW CAP.
NHTSA complaint #10018771 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
WHILE DRIVING VEHICLE, GAS FUMES WOULD ENTER THE INTERIOR OF VEHICLE. HAD TAKEN VEHICLE TO DEALERSHIP AND WAS INFORMED BY MECHANIC THE "O" RINGS WERE DEFECTIVE AND WOULD NEED TO BE REPLACE. NOTICED RECALL THRU CAR FAX AND CONTACTED MANUFACTURER FOR REIMBURSEMENT. INFORMED NOT TYPE OF MOTOR UNDER RECALL WITH SAME PROBLEM. TS
NHTSA complaint #8024074 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
THE AIRBAG ILLUMINATED, WHICH CAUSED THE HORN AND CRUSIE CONTROL TO NOT TO WORK, ALSO THE FUEL SENSOR WAS DEFECTIVE WHICH CAUSED THE VEHICLE TO RUN OUT OF GAS. TS
NHTSA complaint #8023279 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
CONSUMER TOOK VEHICLE INTO DEALERSHIP FOR RECALL 00V268 000 REPAIRS. DEALER DID NOT WANT TO HONOR RECALL LETTER. CONSUMER HAS TO MAKE DEALERSHIP HONOR RECALL LETTER. PLEASE PROVIDE ANY FURTHER INFORMATION.
NHTSA complaint #8009933 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
WHILE DRIVING ABOUT 55 MPH RAN OVER SOME SMALL DEBRIS ON ROAD. SHORTLY AFTER SHE SMELLED FUEL. PULLED OVER, AND NOTICED A FUEL LEAK. DEALER WAS REPLACING RUPTURED FUEL TANK.
NHTSA complaint #896857 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE
WHENEVER FILLING UP GAS TANK GAS MILEAGE STARTES TO DETERIORATE SLOWLY. CONSUMER NOTICES A DROP IN MILEAGE.
NHTSA complaint #879587 — an unverified report by a vehicle owner.
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
THREE TIMES I WAS DRIVING ABOUT 70 MILES AN HOUR AND MY CAR COMPLETELY SHUT DOWN WITHOUT WARNING. THE FIRST TIME I TOOK IT BACK TO THE DEALER AND THE COMPUTER CODES SAID THERE WAS LOOSE RELAY WIRE TO THE FUEL PUMP. ABOUT 1 WEEK LATER IT HAPPENED AGAIN AT 70 MILES AN HOUR ON THE FREEWAY AND IT QUIT ON ME AGAIN. I USED ANOTHER VEHICLE FOR WORK AND THE 2ND DAY AFTER THE 2ND INCIDENT I TOOK IT TO THE DEALER. THEY KEPT IT FOR 3 DAYS AND THEY STATED NO COMPUTER CODES CAME UP. IT HAPPENED AGAIN FOR THE 3RD TIME ON 9-30-99 AND I DROVE STRAIGHT TO DEALERSHIP. THEY ARE CLOSED FOR 4/5 DAYS FOR EXTERMINATING. I TOLD THE GUY THIS IS THE 3RD TIME IT HAPPENED. SORRY BUT EVERYTHING IS CLOSED UNTIL NEXT TUESDAY. I ONLY DRIVE IN THE FAST LANE OR THE COMPLETE RIGHT LANE IN FEAR THIS WILL HAPPEN AGAIN. WHEN IT SHUTS OFF I HAVE TO SIT THERE FOR ABOUT 5 MIN, PUMP THE GAS PEDAL AND THEN IT STARTS. WITH OR WITHOUT THE AIR CONDITIONER ON IT DOES IT. IT CONSTANTLY FEELS LIKE IT IS GOING TO DIE OUT ON ME. IT IS SCARY DRIVING OUT HERE ON THE FREEWAYS WITH A SEMI-TRUCK ON YOUR BACK AND A CAR STALLS OUT ON YOU. I TOLD THEM THAT BUT THEY SAY THEY CAN'T.
NHTSA complaint #712739 — an unverified report by a vehicle owner.