Owners have filed 205 complaints
about the 2015 RAM 3500 with NHTSA between 2015 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 9 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 46
Against the median year of the RAM 3500. 50 means typical for this
model; 100 means roughly double.
Severity — 48
9.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 93
55% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
74.7%
1,000 – 9,999 miles
3322.3%
10,000 – 24,999 miles
2718.2%
25,000 – 49,999 miles
2315.5%
50,000 – 74,999 miles
3221.6%
75,000 – 99,999 miles
64.1%
100,000 – 149,999 miles
117.4%
150,000+ miles
96.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2015peak 8Jun 2026
NHTSA investigations into the 2015 RAM 3500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
Post Recall Remedy Brake Transmission Shift Interlock (BTSI) Failure
The Office of Defects Investigation (ODI) has received 14 Vehicle Owner Questionnaire (VOQ) reports and 6 EWR Death & Injury (D&I) reports describing post recall remedy failures of the brake transmission shift interlock (BTSI) system in certain Model Year (MY) 2013-2018 RAM pickup trucks.The subject vehicle models include 1500, 2500, 3500, 4500, and 5500 trucks equipped with a column mounted shift lever.The failures of the BTSI described in the VOQs occurred on vehicles that had all previously been repaired under recall 17V-821 or 18V-100.Both recalls address a potential condition which can ca...
EA19004Opened 1 Dec 2019Closed 20 Nov 2025STEERING:LINKAGES:DRAG:LINK:CONNECTION
Steering loss due to linkage separation
On December 17, 2018, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18016 to investigate alleged drag link failures in the steering system on model year (MY) 2015 and 2016 Ram 2500 trucks manufactured by FCA US, LLC (FCA). The drag link failures were found to be due to a safety defect with the steering linkage where the drag link adjustable connector (used to adjust the steering system), held in position by two opposing jam nuts, can loosen. The loosening of this part can lead to wear and deterioration of the threads and eventual separation of the drag link,...
PE18016Opened 17 Dec 2018Closed 12 Dec 2019STEERING:LINKAGES:DRAG:LINK:CONNECTION
Steering loss due to linkage separation
On December 17, 2018, NHTSA's Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 18-016 to investigate the steering system on model year (MY) 2015 and 2016 Ram 2500 manufactured by FCA US, LLC (FCA). Four complaints were received alleging separation of the drag link, a steering linkage that connects between the right front steering knuckle and the pitman arm on the steering box output shaft. The failures were found to be at a threaded coupler within the drag link used for adjusting the length of the linkage during routine maintenance (alignment) of the steering system.Onc...
RQ15004Opened 24 Jul 2015Closed 5 Jan 2016ELECTRICAL SYSTEM:SOFTWARE
Software security vulnerability
On July 23, 2015, Fiat Chrysler Automobiles (FCA) launched Safety Recall 15V-461 to remedy security vulnerabilities in approximately 1.4 million model year (MY) 2013 through 2015 vehicles equipped with Uconnect head units (HU) 8.4A (RA3 radio) and 8.4AN (RA4 radio) manufactured by Harman International.On July 24, 2015, the Office of Defects Investigation (ODI) opened Recall Query, RQ 15-004, to investigate HU security vulnerabilities and remedy effectiveness in the recalled population and to determine whether similar units have been supplied for use in other FCA vehicles.In an August 11, 2015...
Recalls on the 2015 RAM 3500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
21V632000
AIR BAGS:SIDE/WINDOW:CURTAIN:INFLATOR
Chrysler (FCA US, LLC) is recalling certain 2015-2020 Ram 1500 Classic, 2015-2016 Ram 3500, and Ram 2500 vehicles, and 2016 Ram 3500 Cab Chassis with a gross vehicle weight rating less than 10,000 lbs. The side air bag inflatable curtain (SABIC) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.
Risk: A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.
21V398000
WHEELS:LUGS/NUTS/BOLTS/STUDS
Chrysler (FCA US, LLC) is recalling certain 2012-2021 RAM 3500, 3500 Cab Chassis, 4500 Cab Chassis, and 5500 Cab Chassis vehicles. Incorrect information in the Service and Owner's Manuals may cause the flanged lug nuts to be over-tightened, which could result in a broken wheel stud and possible wheel separation.
Risk: Wheel separation can cause a vehicle crash.
19V347000
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
Chrysler (FCA US LLC) is recalling certain 2015-2017 Ram 1500, 2500 and 3500 pickup trucks equipped with an 8 foot bed and a power locking tailgate. Chrysler is also recalling all 2013-2014 and 2018 Ram 1500, 2500 and 3500 pickup trucks built before April 1, 2018 with a 6 or 8 foot bed and a power locking tailgate. On August 29, 2019 Chrysler expanded the recall to include an additional 693,128 model year 2013-2014 Ram 1500, 2500 and 3500 pickup trucks. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Risk: If the tailgate opens while the vehicle is being driven, cargo may fall out the vehicle and create a road hazard, increasing the risk of crash.
19V021000
STEERING:LINKAGES:DRAG:LINK:CONNECTION
Chrysler (FCA US LLC) is recalling certain 2013-2018 Ram 3500 and 2014-2018 Ram 3500 Chassis Cab and Ram 2500 vehicles. The outboard steering linkage jam nut may loosen, allowing one end of the drag link to separate.
Risk: A drag link separation can cause a loss of steering control, increasing the risk of crash.
18E096000
STEERING:LINKAGES
Streetcar ORV LLC (Streetcar) is recalling certain American Expedition Vehicles (AEV) 3" Dualsport aftermarket suspension kits, part numbers N0436000 and N0436001, sold for installation on 2013-2018 RAM 2500 and 3500HD trucks. Improper installation and machining of the original equipment steering knuckle may weaken the joint between the steering drag link and knuckle.
Risk: The weakened connection may result in a fractured steering drag link, causing a loss of steering and increasing the risk of a crash.
18V486000
STRUCTURE:BODY:TAILGATE
Chrysler (FCA US LLC) is recalling certain 2015-2017 RAM 1500, 2500, and 3500 pickup trucks equipped with a power locking tailgate and either a 5 foot, 7 inch or 6 foot, 4 inch bed. The tailgate actuator limiter tab may fracture and cause the tailgate to unlatch and open while driving.
Risk: If the tailgate latch releases and the tailgate opens while driving, cargo may fall out, creating a road hazard and increasing the risk of a crash.
18V332000
ELECTRICAL SYSTEM:WIRING
Chrysler (FCA US LLC) is recalling certain 2014-2018 Dodge Journey, Charger and Durango, RAM 2500, 3500, 3500 Cab Chassis (more than 10,000lb), 4500 Cab Chassis and 5500 Cab Chassis, Jeep Cherokee and Grand Cherokee and Chrysler 300, 2014-2019 RAM 1500, 2015-2018 Dodge Challenger, 2015-2017 Chrysler 200, 2016-2018 RAM 3500 Cab Chassis (less than 10,000 lb), 2017-2018 Chrysler Pacifica and 2018 Jeep Wrangler vehicles. These vehicles are being recalled to address a defect that could prevent the cruise control system from disengaging. If, when using cruise control, there is a short circuit within the vehicle's wiring, the driver may not be able to shut off the cruise control either by depressing the brake pedal or manually turning the system off once it has been engaged, resulting in either the vehicle maintaining its current speed or possibly accelerating.
Risk: If the vehicle maintains its speed or accelerates despite attempts to deactivate the cruise control, there would be an increased risk of a crash.
17V824000
EQUIPMENT
Chrysler (FCA US LLC) is recalling various Dodge, Chrysler, and RAM vehicles equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers. A list of the affected trailer models is available at: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17V824-0103.pdf. These extinguishers may become clogged, preventing the extinguisher from discharging as expected or requiring excessive force to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Risk: If the fire extinguisher does not function properly, it can increase the risk of injury in the event of a fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2024548314,717 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 202151143,618 units in Canada
Airbag
Issue: On certain trucks, the side curtain airbag inflators could be defective. As a result, the driver and/or passenger side curtain airbag inflator(s) could rupture unexpectedly. If this happens, small pieces of metal could be propelled toward vehicle occupants or cause damage to the airbag and prevent it from inflating properly. Safety Risk: A side curtain airbag inflator that ruptures could create a risk of injury. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to inspect and replace the side curtain airbags, as necessary.
Recall 202133630,899 units in Canada
Wheels
Issue: On certain pickup and chassis-cab trucks, the owner's manual and service manual list the wrong torque specification for the wheel nuts. As a result, some trucks may have had the lug nuts over-tightened during servicing. This can damage the wheel studs and, over time, they could break. If this happens, a wheel could separate from the truck. Note: This recall only affects trucks equipped with dual rear wheels and flanged lug nuts. Safety Risk: A wheel separation could cause a loss of control and increase the risk of a crash. A wheel that separates could also hit another person or vehicle. Corrective Action: FCA Canada will contact owners by mail and instruct you to take your truck to a dealer to inspect and replace the wheel studs, as necessary. They will also provide an update for the torque specification listed in the owner's manual.
Recall 2020312
Steering
Issue: This recall is for certain replacement parts for use on Ram Heavy Duty trucks that were sold by dealer parts departments. This recall is not being conducted under the requirements of the Motor Vehicle Safety Act. If the outboard steering linkage jam nut is not welded according to the Dealer Service Instructions for safety recall V06, it could loosen and allow one end of the drag link to separate from the adjuster sleeve. A drag link separation can result in a loss of steering control. The following 4x4 style steering system parts are included in this recall: Drag Link Assembly (Part # 68369907AA) Jam Nut (Part # 06510749AA and Part # 06510750AA) Drag Link Outer (Part # 68111301AA) Drag Link Adjuster (Part #68111302AA) Drag Link Inner (Part # 68111304AA) Safety Risk: A loss of steering control could increase the risk of a crash. Corrective Actions: FCA Canada will notify potential owners using dealer sales records. Owners will be instructed to take their vehicle to a dealer to inspect the drag link assembly. If the drag link is not welded but the jam nuts are properly tightened, the nuts will be welded to the adjuster sleeve. If the nuts are not properly tightened, the drag link assembly will be assessed for replacement. If a component or assembly is returned, FCA will reimburse the customer.
Recall 2019441220,317 units in Canada
Structure
Issue: On certain trucks equipped with a power locking tailgate, the tailgate may open while driving. If this occurs, cargo that is not secured could fall out of the truck bed and onto the road. Note: This is an expansion of recall U74 (Transport Canada recall 2018-398). Safety Risk: Cargo that falls from the truck bed could create a road hazard for others. Corrective Actions: The company will notify owners by mail and instruct them to take their truck to a dealer to modify the tailgate locking mechanism. Note: This recall supersedes recall 2019-221
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Recall 201922163,753 units in Canada
Structure
Issue: Note: This recall is superseded by recall 2019441. Please see <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2019441">recall 2019441</a> for more information. On certain trucks equipped with a power locking tailgate, the tailgate may open while driving. If this occurs, cargo that is not secured could fall out of the truck bed and onto the road. Note: This is an expansion of recall U74 (Transport Canada recall 2018-398). Safety Risk: Cargo that falls from the truck bed could create a road hazard for others. Corrective Actions: The company will notify owners by mail and instruct them to take their truck to a dealer to modify the tailgate locking mechanism.
Recall 201903877,994 units in Canada
Steering
Issue: On certain trucks, a nut in the steering system could loosen and cause a loss of steering control. This problem affects trucks equipped with a 4x4 style steering system. Safety Risk: A loss of steering control would increase the risk of a crash. Corrective Actions: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to inspect the outboard steering linkage jam nut. If the nut is properly tightened, it will be welded to the adjuster sleeve. If the nut is not properly tightened, the drag link assembly will be replaced.
Reports where the owner recorded a crash, a fire, an injury or a death.
Spring Run, PAFire
AIR BAGS
Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.
NHTSA complaint #11496055 — an unverified report by a vehicle owner.
Spring Run, PAFire
STRUCTURE:BODY
Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.
NHTSA complaint #11496055 — an unverified report by a vehicle owner.
Spring Run, PAFire
ELECTRICAL SYSTEM
Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.
NHTSA complaint #11496055 — an unverified report by a vehicle owner.
Louisville, KYCrash
STEERING
TL* THE CONTACT WAS A LAWYER CALLING ON BEHALF OF HER CLIENT WHO OWNED A 2015 RAM 3500. THE LAWYER STATED WHILE HER CLIENT WAS HAULING HORSES AT AN UNKNOWN RATE OF SPEED, THE STEERING ROD BROKE UNEXPECTEDLY, CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE DRIVER DROVE DOWN AN EMBANKMENT AND HIT A SIGN, TOTALING THE VEHICLE. THE LAWYER WAS UNAWARE IF ANY WARNING LIGHTS WERE ILLUMINATED PRIOR TO THE FAILURE; THE LAWYER WAS ALSO UNAWARE IF THE AIR BAGS DEPLOYED UPON IMPACT. THE DRIVER NOR THE HORSES WERE INJURED DUE TO THE CRASH. THE POLICE WERE CALLED AND A POLICE REPORT WAS FILED. UPON INVESTIGATION, THE LAWYER DISCOVERED AN ACTIVE RECALL ON THE VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 19V021000 (STEERING); WHICH SHE LINKED TO HER CLIENT'S FAILURE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DEEMED A TOTAL LOSS. THE MANUFACTURER NOR THE DEALER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11323358 — an unverified report by a vehicle owner.
at 69,200 milesWoodbine, GAFire
POWER TRAIN
TL* THE CONTACT OWNS A 2015 RAM 3500. THE CONTACT STATED THAT WHILE DRIVING AT NIGHT, AN ORANGE GLOW COMING FROM UNDERNEATH THE VEHICLE AND THERE WAS ODOR OF SMOKE IN THE CABIN. THE CONTACT STOP IN THE MIDDLE OF THE ROAD BECAUSE THE VEHICLE WAS ON FIRE AND WAS ABLE TO EXIT THE VEHICLE WITH HIS WIFE SAFE BUT INHALED A LITTLE SMOKE. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT NOTICED UNDER THE HOOD WAS IN FLAME. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE AND FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO UMANSKY CHRYSLER DODGE JEEP RAM DEALER, (960 HILTON HEIGHTS RD, CHARLOTTESVILLE, VA 22901, (434) 326-0298) WHERE THE CONTACT WAS INFORMED WHAT CAUSE FIRE, WHICH WAS A FAULTY TRANSMISSION COOLING LINE CLIP. THE TRANSMISSION FLUID IGNITED THE EXHAUST CAUSING THE FIRE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE AWAITING ON A PART TO TEST EVERYTHING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE THREE TIMES AND PROVIDED A CASE NUMBER: 71744090-74426250. THE FAILURE MILEAGE WAS APPROXIMATELY 69,200.
NHTSA complaint #11299235 — an unverified report by a vehicle owner.
at 69,200 milesWoodbine, GAFire
ENGINE
TL* THE CONTACT OWNS A 2015 RAM 3500. THE CONTACT STATED THAT WHILE DRIVING AT NIGHT, AN ORANGE GLOW COMING FROM UNDERNEATH THE VEHICLE AND THERE WAS ODOR OF SMOKE IN THE CABIN. THE CONTACT STOP IN THE MIDDLE OF THE ROAD BECAUSE THE VEHICLE WAS ON FIRE AND WAS ABLE TO EXIT THE VEHICLE WITH HIS WIFE SAFE BUT INHALED A LITTLE SMOKE. MEDICAL ATTENTION WAS NOT REQUIRED. THE CONTACT NOTICED UNDER THE HOOD WAS IN FLAME. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE AND FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO UMANSKY CHRYSLER DODGE JEEP RAM DEALER, (960 HILTON HEIGHTS RD, CHARLOTTESVILLE, VA 22901, (434) 326-0298) WHERE THE CONTACT WAS INFORMED WHAT CAUSE FIRE, WHICH WAS A FAULTY TRANSMISSION COOLING LINE CLIP. THE TRANSMISSION FLUID IGNITED THE EXHAUST CAUSING THE FIRE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE AWAITING ON A PART TO TEST EVERYTHING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE THREE TIMES AND PROVIDED A CASE NUMBER: 71744090-74426250. THE FAILURE MILEAGE WAS APPROXIMATELY 69,200.
NHTSA complaint #11299235 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 193,000 milesParadise, TX
STEERING
The contact owns a 2015 Ram 3500. While attempting to have an alignment performed, the contact was informed that the steering drag link and the tie rod were both cracked. The failure caused rapid, premature wear on the tire. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 19V021000 (Steering); and believed that the welding that was performed in the recall repair had directly caused the current failure. The vehicle was taken to an authorized dealer, where the technicians diagnosed the vehicle and determined that the previous recall repair made it impossible to perform a proper wheel alignment. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 193,000.
NHTSA complaint #11742354 — an unverified report by a vehicle owner.
Klamath Falls, OR
STEERING
humming from the hydroboost pump, actual issue is the high pressure steering line has a nylon tube inside the hose that breaks apart and moves throughout the system. Dodge had one revision of the hose on the early model years but this issue has gone unresolved. I am afraid if i cant get it fixed it may possibly cause the brakes or steering assistance to fail.
NHTSA complaint #11721992 — an unverified report by a vehicle owner.
at 50,000 milesOcala, FL
ELECTRICAL SYSTEM
The contact owns a 2015 Ram 3500. The contact stated while driving approximately 70 MPH in the left lane, the check engine warning light illuminated, and the vehicle simultaneously went into LIMP Mode. The contact was able to pull over to the shoulder of the roadway. The contact was able to continue driving, but the vehicle failed to exceed 5 MPH. Upon arriving to the residence, the vehicle was scanned, and it was determined that the turbo charger actuator had failed and needed to be replaced. The contact purchased an aftermarket part and repaired the vehicle. The dealer was not contacted. The contact later became aware that the failure was related to Chrysler Extended Warranty Coverage Number: X99; however, the contact had not received a notification from the manufacturer. The contact requested reimbursement from the manufacturer; however, the reimbursement was denied because the vehicle was not repaired by a dealer. The failure mileage was approximately 50,000.
NHTSA complaint #11721925 — an unverified report by a vehicle owner.
Klamath Falls, OR
SERVICE BRAKES
humming from the hydroboost pump, actual issue is the high pressure steering line has a nylon tube inside the hose that breaks apart and moves throughout the system. Dodge had one revision of the hose on the early model years but this issue has gone unresolved. I am afraid if i cant get it fixed it may possibly cause the brakes or steering assistance to fail.
NHTSA complaint #11721992 — an unverified report by a vehicle owner.
Granada Hills, CA
SERVICE BRAKES
The output voltage to the Trailer Braking system is low, only 7.5 volts. Other owners have the same problem. From what I understand there is an issue with the computer that keeps the Original Equipment trailer brake controller from delivering full power at speeds below 30 MPH. This is a safety hazard in stop and go driving. There are many complaints about this same problem in the Ram Forumz. Ram should be able to do a software update to fix the problem. One of the posts in the forum stated that Ram has the software update available but will charge a lot of money for it. This is a safety issue and these trucks should be recalled to fix the problem.
NHTSA complaint #11722035 — an unverified report by a vehicle owner.
Ellington, CT
STEERING
There was a recall forced by the NTSB for a condition where the track bar adjustment nut would come loose and the truck would lose steering. The recall on the track bar was rectified by the dealer by welding the nut on the track bar. Now that the nut has been welded a proper alignment can not be preformed. There is no longer adjustment available due to the welded nut. The only way to properly fix this is to replace the track bar. I have had many communications with ram (stellantis) and they refuse to remedy this as they tell me they have complied with the NTSB’s resolution.
NHTSA complaint #11718592 — an unverified report by a vehicle owner.
Ellington, CT
SUSPENSION
There was a recall forced by the NTSB for a condition where the track bar adjustment nut would come loose and the truck would lose steering. The recall on the track bar was rectified by the dealer by welding the nut on the track bar. Now that the nut has been welded a proper alignment can not be preformed. There is no longer adjustment available due to the welded nut. The only way to properly fix this is to replace the track bar. I have had many communications with ram (stellantis) and they refuse to remedy this as they tell me they have complied with the NTSB’s resolution.
NHTSA complaint #11718592 — an unverified report by a vehicle owner.
Cookeville, TN
SERVICE BRAKES
At about 3,000 miles I noticed a periodical head light flicker and intermittent radio issues. Shortly after that the truck has presented with periodical brake issues. My front brakes parodically drag and get hot. Typically on one front side or the other. However on [XXX] my wife and I took the truck out for a drive and both front brakes began dragging and heated up. I had to be towed 40+ miles back home. Two of my neighbors can verify I've had issues with the brakes on multiple occasions for several years now. I've had to limp the truck home on several occasions while in town and in Feb. 2025 it put my wife and I in what a consider a dangerous situation by stranding us on the side of the highway. I don't remember any warning lamps coming on but I did a scan after I got the truck back home. B170-15, B210A-16, B222C, B2861-15, P2509 & P2560 were present. I used my scanner to delete the codes and reset the EMC but am a bit hesitant to take the truck out on the road. Note: The truck has experienced a weird and harsh vibration on back of truck as well. I stop, shut engine off - do a walk around but haven't been able to pinpoint anything. Crank engine back up and problem has seemingly resolved itself. I think it's possibly a brake issue as well. At present this truck has less than 11,000 miles on it. Yes, LOL, less than 11,000 miles. Calipers and pads are in excellent functioning order. Fluid is easily pushed back into reservoir with no restrictions and no apparent degradation of flexible lines. I considered the brake fluid might have moisture built up in the system so I had a complete fluid replacement done but problem has persisted.I did read there's a recall on the the HCU/ABS unit and my truck seems to be in that category but haven't received anything from FCA. [XXX] Your attention and assistance would be greatly appreciated. Thank You. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11658341 — an unverified report by a vehicle owner.
Ely, NV
ELECTRICAL SYSTEM
the instrument panel dash cluster went black and now I have no information like tire pressure, mph, engine oil temp, coolant temp, cruise control,parking sensor alert, ect. I have tried everything to reboot or see if there is loose connections and have come up with nothing. this could be a hazard.
NHTSA complaint #11630799 — an unverified report by a vehicle owner.
at 166,000 milesManito, IL
WHEELS:LUGS/NUTS/BOLTS/STUDS
The contact owns a 2015 Ram 3500. The contact stated while driving 60 MPH, the steering started shuddering and the vehicle made an abnormal popping sound. The contact then noticed that the front driver's side wheel was wobbling. The contact pulled over to the side of the road and inspected the wheel. The contact noticed that two of the wheel studs of the front driver's side wheel had fractured. The contact stated that the vehicle was previously taken to the dealer to be repaired under NHTSA Campaign Number: 21V398000 (Wheels); however, the dealer informed the contact that the wheel studs did not need to be replaced. The dealer was notified of the failure and informed the contact that the VIN was no longer included in the recall because the recall had been marked completed. The vehicle was not repaired and remained on the side of the road. The manufacturer was not notified of the failure. The failure mileage was approximately 166,000.
NHTSA complaint #11623871 — an unverified report by a vehicle owner.
Calabash, NC
UNKNOWN OR OTHER
I am filing this report to highlight ongoing safety and warranty issues with my 2015 Dodge Ram 3500, which is severely impacted by Recall 67A. This recall was intended to address emissions tampering, involving significant obligations for Stellantis/Cummins Inc. under the emissions extended warranty, termed the "Special Extended Warranty." Since the completion of the recall in January 2024, my vehicle has been inoperable for a total of 148 days due to significant defects. The vehicle has required six service visits to address these issues, with the most recent visit occurring on October 31, 2024, when it was towed back to the dealership. Throughout this process, I have encountered a lack of effective communication from both Cummins and FCA, and my attempts to resolve these issues were largely ignored until I escalated the matter to federal authorities, including Randall Stone from the U.S. DOJ. The ongoing failure to address these defects has not only violated warranty obligations but also poses a risk to safety, as the vehicle remains inoperable. Impact of the Problem: The inability to use my vehicle has caused considerable disruption to my daily life, preventing me from performing essential tasks, including towing a camper and transporting heavy items. This situation has also led to significant emotional distress, given the prolonged nature of the issues and the lack of adequate responses from the manufacturer. Action Requested: I seek the NHTSA's assistance in investigating these ongoing issues with my vehicle and holding the manufacturer accountable for their failure to uphold warranty obligations and address safety concerns related to emissions defects.
NHTSA complaint #11623214 — an unverified report by a vehicle owner.
Calabash, NC
ENGINE
I am filing this report to highlight ongoing safety and warranty issues with my 2015 Dodge Ram 3500, which is severely impacted by Recall 67A. This recall was intended to address emissions tampering, involving significant obligations for Stellantis/Cummins Inc. under the emissions extended warranty, termed the "Special Extended Warranty." Since the completion of the recall in January 2024, my vehicle has been inoperable for a total of 148 days due to significant defects. The vehicle has required six service visits to address these issues, with the most recent visit occurring on October 31, 2024, when it was towed back to the dealership. Throughout this process, I have encountered a lack of effective communication from both Cummins and FCA, and my attempts to resolve these issues were largely ignored until I escalated the matter to federal authorities, including Randall Stone from the U.S. DOJ. The ongoing failure to address these defects has not only violated warranty obligations but also poses a risk to safety, as the vehicle remains inoperable. Impact of the Problem: The inability to use my vehicle has caused considerable disruption to my daily life, preventing me from performing essential tasks, including towing a camper and transporting heavy items. This situation has also led to significant emotional distress, given the prolonged nature of the issues and the lack of adequate responses from the manufacturer. Action Requested: I seek the NHTSA's assistance in investigating these ongoing issues with my vehicle and holding the manufacturer accountable for their failure to uphold warranty obligations and address safety concerns related to emissions defects.
NHTSA complaint #11623214 — an unverified report by a vehicle owner.
Normangee, TX
VEHICLE SPEED CONTROL
ABS and Traction control warning lights are on display. Cruise control and 4x4 will not engage due to this issue. Also causing malfunction while towing a trailer.
NHTSA complaint #11613890 — an unverified report by a vehicle owner.
Normangee, TX
ELECTRICAL SYSTEM
ABS and Traction control warning lights are on display. Cruise control and 4x4 will not engage due to this issue. Also causing malfunction while towing a trailer.
NHTSA complaint #11613890 — an unverified report by a vehicle owner.
Normangee, TX
SERVICE BRAKES
ABS and Traction control warning lights are on display. Cruise control and 4x4 will not engage due to this issue. Also causing malfunction while towing a trailer.
NHTSA complaint #11613890 — an unverified report by a vehicle owner.
at 183,901 milesGranby, CO
WHEELS
The contact owns a 2015 Ram 3500. The contact stated while driving 35-40 MPH, the vehicle started wiggling and wobbling abnormally. The contact was able to pull to the side of the road, where he noticed that the outer rear wheel had separated from the vehicle. Additionally, the contact noticed that the inner rear wheel had separated and pinched the axle, causing the wheel to support the vehicle. The vehicle was towed to the dealer, where an assessment was made. The dealer determined that the wheel studs needed be replaced under NHTSA Campaign Number: 21V398000 (Wheels); however, the wheel replacement was not covered. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 183,901.
NHTSA complaint #11596921 — an unverified report by a vehicle owner.
Oakdale, PA
POWER TRAIN
The contact owns a 2015 Ram 3500. The contact received notification of NHTSA Campaign Number: 17V821000 (Power Train). The contact had experienced the failure and paid for the repair before receiving the recall notification. The contact stated he received the notification in January 2024 and took the vehicle, the notification, and the receipt for the repair to the dealer to be reimbursed. The contact stated the manufacturer was made aware of the issue however, the contact was not reimbursed for the repair. The failure mileage was unknown.
NHTSA complaint #11574562 — an unverified report by a vehicle owner.
at 37,000 milesTamassee, SC
TRAILER HITCHES
The contact owns a 2015 Ram 3500. The contact stated that the gooseneck ball hitch failed to remain secured. No warning light was illuminated. The vehicle was taken to dealer. The dealer confirmed the failure with the gooseneck ball hitch was related to the recall but did not replace the gooseneck ball hitch. The contact referenced NHTSA Campaign Number: 18E028000 (Trailer Hitches) as a possible solution however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was approximately 37,000.
NHTSA complaint #11569479 — an unverified report by a vehicle owner.
Randleman, NC
UNKNOWN OR OTHER
Backing up 11/20/23 in our driveway, the tailgate fell down, shut it and it occurred 2 more times before it could be re-parked.
NHTSA complaint #11556176 — an unverified report by a vehicle owner.
Mims, FL
SERVICE BRAKES
ABS Module / HCU (Hydraulic Control Unit Failure) causing abs MIL on. Fault code C0020
NHTSA complaint #11552694 — an unverified report by a vehicle owner.
at 112,000 milesMontrose, CO
POWER TRAIN
The contact owns a 2015 Ram 3500. The contact stated that after his wife started the vehicle, the transmission failed to shift into the intended gear because the gear shifter was loose. The vehicle was towed to the dealer, where the gear shifter bolt was tightened; however, after the repair was performed, the gear shifter detached while the contact was shifting into gear. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 17V821000 (Power Train); however, the failure occurred. The failure mileage was approximately 112,000.
NHTSA complaint #11552210 — an unverified report by a vehicle owner.
at 110,000 milesKalispell, MT
WHEELS
The contact owns a 2015 Ram 3500. The contact stated while driving at approximately 30 MPH, the driver's front and driver's side rear wheels detached from the vehicle. The contact became aware of nine broken wheel studs. There was no warning light illuminated. The contact referenced the failure to NHTSA Campaign Number: 21V398000 (Wheels) however, the VIN was not included in the recall. The contact made a local dealer aware of the failure and confirmed that the VIN was not included in the recall. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the wheel studs and lug nuts needed to be replaced. The vehicle remained with the independent mechanic awaiting parts for the repair. The manufacturer was made aware of the failure. The approximate failure mileage was 110,000.
NHTSA complaint #11499540 — an unverified report by a vehicle owner.
Sumner, WA
SERVICE BRAKES
ABS Module failed and is not reading rear wheel speed. Shop isolated issue to ABS module, and hydraulic control unit. Four safety components are no longer working as a result: ABS braking, traction control, 4wd, and rear back up sensors. This appears to be a common issue with Rams HD trucks as the parts are on back order causing me to drive my vehicle with no safety features.
NHTSA complaint #11497892 — an unverified report by a vehicle owner.
Spring Run, PAFire
AIR BAGS
Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.
NHTSA complaint #11496055 — an unverified report by a vehicle owner.
Spring Run, PAFire
STRUCTURE:BODY
Driving down turnpike my truck went up in flames, mopar sent investigator to determine cause of fire at dealership never called me to give me a report they emailed me to badly burnt to determine cause of fire.
NHTSA complaint #11496055 — an unverified report by a vehicle owner.