Subaru Outback steering problems

STEERING

I bought a brand new 2025 subaru outback in April of 2025. At first service (oil change and tire rotation) in Jan 2026, I complained that the vehicle keeps swerving left and right and Subaru of Ann Arbor said they will diagnose the i-Sight vehicle system and correct it. But right after delivery , i realized the steering had to be held at ~5 degrees to the right (off centered) to get the car go straight. I complained and I was made to bring the car in 3 times to Subaru of Ann arbor - only to go without a fix. The car fishtailed, the traction control system malfunctioned in normal roads and highways due to the steering angle error. I was asked my Subaru of Ann Arbor to not come there anymore and take it to a different dealership. I complained to Subaru of America (Customer advocacy) and they asked me to pick a different dealer - Lafontaine Subaru. Even there the technicians argued that the car is good and just did an alignment without fixing the steering angle error issue. The steering angle sensor is tied to the vehicle safety software controls, traction control system and safety systems such as lane keep. I have to keep the steering tilted to keep the vehicle in lanes and I am struggling to keep it safely within lanes since January 2026. Subaru of America has not intervened even after the 6th repair in 3 months as the problem is not fixed. the lives of my family including a [XXX] infant for whom I got the car is being threatened on a daily basis. I keep telling the urgency and grave danger and the last response from the second subaru dealer was this is the maximum we can do. I am feeling threatened as I paid a fortune for a new car and wanted to secure my infant and my family. Our safety has been disregarded despite multiple complaints and repairs in the first year of ownership. Mileage now is 6100 miles total. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11748229 — an unverified report by a vehicle owner.

STEERING

On Monday [XXX] were driving on [XXX] going north up [XXX]. I was doing about 60-65 mph in traffic which was flowing in both directions. While ascending the pass, the car suddenly started to misfire, rapidly lost power, power steering failed and all dash lights lit up. With no shoulder to pull out this was a very scary experience. Eventually managed to limp to a spot where I could pull out off the pavement. Car was dead. Popping the hood showed significant battery corrosion. I had a toolkit with me. The voltmeter measured the battery voltage at 9.3V. Thinking maybe cleaning the battery terminals would allow the car to be restarted, I managed to get the cables off and cleaned everything with a wire brush. But still no power. After a while a state trooper passed by and hung on while I contacted a towing service. After another 1.5 hours, the tow truck arrived and towed the car the 60 miles or so to the dealership in Denver with my wife and I in the cab of the tow truck. Dealer repair invoice indicated Data Control Module (DCM) "causing excessive draw on electrical system." More significantly, the battery had drained below the the operating threshold voltage required for vehicle drivability (understood to be 10-10.5V). There was no mention of this by the dealer service adviser. Although dealer diagnostic was carried out, no computer codes were provided. Vehicle mileage at time of incident 73,456. I have owned the car since new and have all service records. Car was repaired and picked up from dealership on 06/10/26 with a replacement DCM. Battery was charged up but not replaced and left in corroded state. Battery will probably have been weakened by such a total discharge with reduced life expectancy. I have uploaded the dealer repair invoice. I have reported this incident to Subaru of America. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745736 — an unverified report by a vehicle owner.

STEERING

SUBJECT: Formal Safety Defect Complaint: 2016 Subaru Outback – Manufacturing Nondisclosure of Latent "Day 1" Design Flaw Causing Ignition Key Entrapment, Uncommanded Steering Column Lockout, and Severe Family Safety Risk I am writing to formally report a severe, unaddressed safety defect and a deceptive corporate practice by Subaru of America, Inc. affecting my 2016 Subaru Outback. This vehicle suffers from a "Day 1" latent engineering flaw that causes the physical ignition key to become permanently trapped in the ignition cylinder, triggering an uncommanded, rigid locking of the steering column assembly. Subaru has possessed documented knowledge of this failure for years, cataloging it under Technical Service Bulletin TSB 16-112-18R. Rather than fulfilling its statutory obligation to issue a comprehensive federal safety recall, Subaru deployed a voluntary, time-bound 8-year warranty extension. Subaru conveniently did not notify me of this warranty extension. By doing so, the manufacturer unconscionably ignored this defect, placing its customers at direct peril. They capitalized on asymmetric information to shift both the financial burden and the severe physical safety risks of a known factory flaw onto my family, the moment an arbitrary time threshold expired. My family and I have been at active, continuous risk in this vehicle since the day we purchased it due to an engineering error that was present when the car rolled off the assembly line. The root cause of this failure is a fundamental engineering defect within the Continuously Variable Transmission (CVT) shifter assembly, specifically, the premature degradation of the electrical contacts within the select lever park-range switch.

NHTSA complaint #11742958 — an unverified report by a vehicle owner.

STEERING

Ignition key not releasing after turning engine off. Put shifter in park, foot on brakeii, turn Ignition key off. Key will not release. Have to cycle multiple times to get key released.

NHTSA complaint #11737057 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2025 Subaru Outback. The contact stated while driving at an undisclosed speed, the wheels skidded and the steering wheel seized. In addition, the contact stated that the engine seized. No warning lights were illuminated. The contact stated that while attempting to start the vehicle, the vehicle started. The contact stated that the vehicles behind the contact's vehicle had to drive around the contact's vehicle. The vehicle was driven to the contact's residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 16,000.

NHTSA complaint #11736330 — an unverified report by a vehicle owner.

STEERING

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

NHTSA complaint #11735647 — an unverified report by a vehicle owner.

STEERING

April 3, 2026: my 2025 Subaru Outback Premium (VIN [XXX] , 2,052 miles) suffered simultaneous failure of multiple safety-critical systems due to corrosion on a CAN bus pin in the driver door wiring harness (Subaru part #XXX) at its dash harness connection, caused by water intrusion into the cabin. Trip start: EyeSight, collision avoidance, blind spot, and lane assist all offline; BRAKE indicator illuminated with no brake engagement. Minutes later, airbag warning activated. Dealer service advisor described the dash as "lit up like a Christmas tree." While reversing through a 3-point turn on a commercial drive used by heavy trucks, I LOST STEERING at single-digit speed. 60 seconds further would have placed me on an inclined high-traffic road near a freeway interchange. Vehicle was towed by Subaru from the failure location. Confirmed by authorized dealer Driveway Subaru of Moon Township (Invoice #680646, warranty claim). Subaru SSM4 scan recorded 17 unique DTCs across 10 control systems, including C1460 Brake Booster Abnormality; U1131 Lost Comm Power Steering Control Module; U0151 Restraints Control Module; U0122/U1122 VDC; U0126 Steering Angle Sensor; plus multiple EyeSight faults. Dealer documented moisture on both A-pillars, driver kick panel, standing water in cupholders and center console. Prior intermittent symptom: passenger seatbelt alarm on empty seat, two occasions in prior months, consistent with past-status U0151 on scan. Dealer cleaned the corroded pin but did NOT identify or seal the original water ingress point. Vehicle remains in dealer possession. Subaru of America Customer Advocacy Case #XXX-XXXhas declined repurchase/replacement, stating vehicle is "operating safely as designed." I dispute this conclusion: the ingress source is unremediated and recurrence risk has not been addressed. Repair invoice, full DTC scan, SOA correspondence, and owner statement available on request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11732342 — an unverified report by a vehicle owner.

STEERING

Brake light comes on while driving and power steering also locks up..

NHTSA complaint #11715920 — an unverified report by a vehicle owner.

STEERING

See attached document for complaint.

NHTSA complaint #11700418 — an unverified report by a vehicle owner.

STEERING

While the lane keeping assistance is on the car will follow the exit lane beside the lane I’m in and jerk over into it. There has been a car beside me when has happened but I caught the steering wheel before a crash. Also if a car is turning in front of me sometimes, not always, the brakes will jam on when I’m not even close to the car that is turning but I would be going around the car after it has turned almost all the way. There has been no crashes or injuries yet.

NHTSA complaint #11697314 — an unverified report by a vehicle owner.

STEERING

The clock spring (steering roll connector) component has failed, confirmed by the resulting complete loss of the horn function. SAFETY HAZARD: The component failure has resulted in the loss of the electrical connection to the Driver's Airbag System, rendering the primary airbag inoperable. This creates an unreasonable, life-threatening risk in the event of a collision. The problem has been diagnosed based on common failure patterns for this vehicle platform and confirmed via manufacturer correspondence. The problem first occurred on or about [Input Approximate Date] with the simultaneous failure of the horn and subsequent inoperability of the driver's airbag. The manufacturer, Subaru of America (SOA Case #251013-1700910), was contacted and acknowledged the concern but refused to cover the repair under a Goodwill Adjustment, citing an expired warranty, despite the component's direct link to the critical airbag safety system

NHTSA complaint #11693803 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2025 Subaru Outback. The contact stated that while driving on several occasions at various speeds, the vehicle oversteered, almost causing the contact to crash several times. The vehicle was taken to a dealer where it was diagnosed and determined that the alignment was out of spec, and an alignment was needed. The vehicle was repaired, but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 44.

NHTSA complaint #11668907 — an unverified report by a vehicle owner.

STEERING

Car will lane correct when it's not needed. And all warning lights will come on in car when it's very hot. Cannot access touchscreen - because it constantly glitches as if it's being touched passenger side window continues to roll up and down when you click auto control on window and will not stop. I am afraid to drive because of these Electrical issues.

NHTSA complaint #11655604 — an unverified report by a vehicle owner.

STEERING

The steering warning light came on and my steering wheel stiffened. Luckily I was able to make it home, but when I went back to crank it. The light was still on and it would only move forward of backwards; because I wasn't able at all to turn the steering wheel.

NHTSA complaint #11637733 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2014 Subaru Outback. The contact stated while driving 50 MPH or above, the front end and the steering wheel were shaking abnormally. While driving at various speeds, there was a metallic grinding sound coming from the passenger side of the vehicle. The contact stated that while depressing the brake pedal, the brake pedal went to the floorboard and the braking distance became extended. The contact stated that the brakes were squeaking while the brake pedal was depressed. The contact stated that the brakes, check engine, power steering, and engine overheating warning lights were illuminated. The vehicle was taken to the dealer seven times; however, the dealer was unable to determine the cause of the failures. The contact stated that the dealer replaced the passenger’s side rear wheel bearing. The manufacturer was not made aware of the failure. The failure mileage was 201,206.

NHTSA complaint #11635704 — an unverified report by a vehicle owner.

STEERING

The clock spring that controls the steering wheel, horn and other electrical accessories doesn’t work. This put my life and family’s lives at risk. This is a known issue for Subarus 2015-2019. There’s multiple videos online, I have spoken to multiple owners personally that have encountered the same issue. I spoke to the Subaru dealer and they said due to no recall has been issued for the vin number of my vehicle they can’t replace it and it cost about $1,000 dls. We need the NHTSA to step in and ask Subaru to issue a recall to start replacing the defective units at no cost to the owner.

NHTSA complaint #11632999 — an unverified report by a vehicle owner.

STEERING

To the CA Automotive Repair Bureau, [XXX] complaint, In 2022, I bought a new Outback at Albany Subaru. In October 2024, my car has 33,000 miles and I've had all of my 3,000-mile oil changes, inspections, and Warranty repairs done by Albany Subaru. I pay $100 for each repair that's covered under Subaru's extended Warranty. In 2023, the car's Dashboard Computer/Radio Head Unit was repaired, I drove the car for a few days, but the Head Unit was defective, so Subaru changed the Head Unit. This cost me (3) three trips to Subaru, which is 7.8 miles from my home, UBER costs, and three $100 Warranty payments. I'm a small business owner and had to pay employees extra to remain at work so I could drop off and pick up my car. Most times Subaru didn't give me a loaner car. Weeks later, I was driving up a hill and could not correctly steer my car, I thought I might crash, so I stopped driving my new car. I only drive on paved roads and I bought my Subaru because of Subaru's quality and safety reputation. I returned my car to Albany Subaru. My car's Steering or front end seemed loose and not right. Subaru told me I needed an alignment. I paid for an alignment. I drove my car home, but again, the Steering didn’t seem right, it was still loose and shaking. A day later, I returned my car to Subaru and they readjusted and tightened the Steering Box. Subaru called me at home and stated I needed an oil change, an alignment, and (4) four new tires, and brakes, which I agreed to the oil change. The next day, I picked the car up and spoke to the Service Managers about my concerns with the new car Steering, and stated to them that Subaru Bloggers are sharing that there should be a Recall on Subaru Steering Columns and other repair issues that could result in Lemon Law Lawsuits against Subaru. The Service Manager Nikki Ali and a Mechanic stated that Subaru has Steering Column issues but that Subaru has not yet issued a National Recall, but may replace Steering Columns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

NHTSA complaint #11619244 — an unverified report by a vehicle owner.