2000 Toyota Sienna body problems

STRUCTURE:BODY

WITHIN A TWO MINUTE PERIOD, BOTH SLIDING DOORS THAT WERE PREVIOUSLY FUNCTIONING, SUDDENLY FAILED IN A CLOSED POSITION. THEY COULD NOT BE OPENED MANUALLY USING THE DOOR HANDLES FROM BOTH INSIDE AND OUTSIDE THE VEHICLE, OR BY ATTEMPTING TO ACTUATE THE RIGHT SIDE POWER DOOR. THE POWER DOOR LOCKS HAD NO EFFECT. THERE WAS NO DAMAGE TO THE VEHICLE THAT COULD HAVE CAUSED MECHANICAL DOOR FAILURE, OR OTHERWISE. NON FUNCTIONING OR JAMMED DOORS SHOULD CONSTITUTE A SAFETY ISSUE AND SHOULD BE RECALLED. IF THE VEHICLES FRONT DOORS WERE COMPROMISED IN A COLLISION, PASSENGERS SHOULD BE ABLE TO EXIT THROUGH THE REAR DOORS, BUT WOULD NOT BE ABLE TO WITH THIS MECHANICAL DEFECT. THE FACT THAT THE DOORS CANNOT ALSO BE OPENED USING EXTERIOR HANDLES INCREASES THE RISK OF ENTRAPPING PASSENGERS. TOYOTA SHOULD CONSIDER THIS A SAFETY RECALL AND REPAIR ALL FAULTY DOORS, OF WHICH THERE ARE MANY COMPLAINTS FILED HERE AND ON ONLINE FORUMS. I AM CURRENTLY HAVING TO PAY FOR THIS REPAIR MYSELF, AS TOYOTA HAS INFORMED ME THAT THERE ARE NO CURRENT RECALLS. THANK YOU FOR YOUR CONSIDERATION.

NHTSA complaint #10637033 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

TL* THE CONTACT OWNS A 2000 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER'S SIDE DOOR HANDLE DETACHED. THE CONTACT MENTIONED THAT THE PASSENGER'S SIDE DOOR COULD NOT BE OPENED OR CLOSED FROM THE OUTSIDE OR INSIDE OF THE VEHICLE. THE VEHICLE WAS DIAGNOSED AND NEEDED THE PLASTIC ASSEMBLY DOOR HANDLE REPLACED WITH A METAL INSERT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 37,700.00.

NHTSA complaint #10620673 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

WITHOUT WARNING, PLASTIC DOOR HANDLES BREAK, RENDERING ABILITY TO OPEN, CLOSE HATCH OR DOOR IMPOSSIBLE. HATCH DOOR BROKE FIRST APPROXIMATELY JANUARY 2013, THEN REAR SLIDING DOOR, AND THEN TODAY, PASSENGER FRONT DOOR. HATCH HAS NO INSIDE DOOR HANDLE, SO WITHOUT WARNING DOOR IMMEDIATELY INOPERABLE. REAR DRIVERS SIDE SLIDING DOOR BROKE ON OUTSIDE FIRST, THEN INSIDE WITHIN A DAY, SO THAT EMERGENCY EXIT IMPOSSIBLE. TODAY, FRONT PASSENGER DOOR OUTSIDE BROKE.

NHTSA complaint #10593901 — an unverified report by a vehicle owner.

STRUCTURE:BODY

TL* THE CONTACT OWNS A 2000 TOYOTA SIENNA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE WINDSHIELD BECAME UNLATCHED AND OPENED UPWARD, SHATTERING THE WINDSHIELD. THE VEHICLE WAS TAKEN TO A BODY SHOP WHERE THE CONTACT WAS INFORMED THAT THE HOOD LATCH WOULD NOT ENGAGE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

NHTSA complaint #10520610 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

THE POWER DOOR WILL NOT OPEN/CLOSE CAUSING SERIOUS SAFTEY ISSUES.

NHTSA complaint #10428023 — an unverified report by a vehicle owner.

STRUCTURE:BODY

SLIDING DOOR WILL NOT OPEN ELECTRICALLY AND/OR MANUALLY. CLICKS WHEN ACTIVATED BUT DOESN'T OPEN EITHER WAY. DISCONNECTED BATTERY AS SUGGESTED BY DEALER, TO RESET THE MECHANISM, BUT TO NO AVAIL; STILL DOESN'T WORK AND IS A LARGE PAIN TO DEAL WITH! IT FORCES ENTRY ON THE DRIVERS SIDE ONLY AND THAT IS NOT SAFE WHEN THERE IS SPEEDING BY ONLY A FEW FEET AWAY WITH TRAFFIC! THERE ARE THOUSANDS OF COMPLAINTS IN ALL THE TOYOTA FORUMS ON THE NET. I THINK IT IS PAST TIME FOR A FACTORY RECALL ON THESE AUTOMATIC SLIDING DOORS!!!!

NHTSA complaint #10424055 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

POWER PASSENGER BACK DOOR HAS CEASED TO FUNCTION. THEE IS A WAY TO TURN OFF THE POWER DOOR, BUT THE MANUAL DOOR IS TOO DIFFICULT FOR THE CHILDREN TO OPERATE, THEY MUST ENTER AND EXIT ON THE DRIVERS SIDE REAR DOOR...TOYOTA WANTS 2300 TO REPAIR! I HAD PREVIOUSLY PAID 800 TO REPAIR, BUT THEY CLAIM THAT IT'S A DIFFERENT SET OF PARTS...AND DID NOT FIX THE PROBLEM.

NHTSA complaint #10392231 — an unverified report by a vehicle owner.

STRUCTURE:BODY

2000 TOYOTA SIENNA PASSENGER SLIDING DOOR QUIT WORKING. WILL NOT OPEN AT ALL. I FEEL IT IS A DANGEROUS SITUATION, DUE TO DELAYED EXITS IN CASE OF EMERGENCY, AND CAN NO LET KIDS OUT CURB SIDE AT ALL. VERY DISAPPOINTED TOYOTA WON'T FIX IT. $1200 REPAIR. WHO HAS THAT? WON'T EVEN OPEN MANUALLY. I LOVE MY VAN! BUT THIS IS A HUGE SET BACK!

NHTSA complaint #10384582 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

2000 TOYOTA SIENNA. THIS IS THE 3RD TIME MY POWER DOOR HAS GONE OUT. I HAVE PAID BOTH TIMES TO HAVE IT FIXED. RIGHT NOW IF YOU OPEN THE DOOR, YOU HAVE TO MANUALLY CLOSE THE DOOR WITH IT TRYING TO OPEN (LOTS OF EFFORT). ONCE YOU GET IT CLOSED, THE DASH LIGHT INDICATES THAT THE DOOR IS OPEN.

NHTSA complaint #10376891 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

TOYTA SIENNA VAN DOOR WILL NOT OPERATE WITH THE MOTOR. DOOR HANDLE BROKE OFF DUE TO TRYING TO OPEN THE DOOR.

NHTSA complaint #10372727 — an unverified report by a vehicle owner.

STRUCTURE

GAVE A VEHICLE A BOOST ONE DAY PREVIOUS. CLOSED HOOD ON 2000 SIENNA, BUT APPARENTLY NOT COMPLETELY. I BELIEVE ONLY SAFETY LATCH SECURING HOOD RATHER THAN FULL HOOD LATCH. DRIVING ON BUSY FREEWAY TO WORK FINE BUT RETURNING HOME ON FREEWAY, THE SAFETY LATCH ON HOOD FAILED CAUSING THE HOOD TO FLIP UP AND SMASH INTO WINDSHIELD, DENTING HOOD AND ROOF OF VAN ALSO. PULLED OVER TO SIDE OF FREEWAY SAFELY. CALLED TOW TRUCK TO HAUL CAR HOME. SAFETY LATCH AND FULL HOOD LATCH NOW SEEM FINE, BUT WILL BE REPLACING SHORTLY. CURRENTLY ONLY REPLACED WINDSHIELD AND SECURED HOOD AS GOOD AS POSSIBLE. GETTING QUOTES FROM BODYSHOPS FOR REPAIRS AND HAVE CONTACTED TOYOTA AS I FEEL THIS IS A SAFETY ISSUE. AFTER 6 DAYS, YET TO HAVE TOYOTA CALL ME BACK. THIS COULD HAVE BEEN A CATASTROPHIC CRASH, BUT THANKFULLY WASN'T.

NHTSA complaint #10368673 — an unverified report by a vehicle owner.

STRUCTURE

NHTSA RECALL 10V160000 RESULTED IN MY SPARE TIRE ASSEMBLY BEING PLACED IN THE REAR AREA OF MY VAN, MY DEALER TOLD ME IT WAS A TEMPORARY FIX UNTIL REMEDY PARTS WERE AVAILABLE, A WEEK OR SO. THAT WAS AUGUST 17, 2010 AND THEY STILL CLAIM THAT THE PARTS ARE NOT AVAILABLE (OCTOBER 18). I AM CONCERNED THAT THE WHEEL ASSEMBLY COULD FLY FORWARD IN AN EMERGENCY STOP FROM HIGHWAY SPEED AND CAUSE INJURY TO THE CAR OCCUPANTS. NO SUCH INCIDENT HAS HAPPENED YET BUT MY CONCERN IS INCREASING. NEITHER THE DEALER OR TOYOTA SEEM CONCERNED.

NHTSA complaint #10361065 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

2000 TOYOTA SIENNA -- PASSENGER SIDE AUTOMATIC SLIDING DOOR FAILED. THE PROBLEM WAS INTERMITTENT WHEN THE CAR WAS NEW AND THE DOOR FINALLY STOPPED WORKING COMPLETELY 5 YEARS AGO. THE VEHICLE NOW HAS APPROX. 60,000 MILES. THE DEALER THINKS THAT ALL COMPONENTS (MOTOR, CONTROLLER, ETC) NEED TO BE REPLACED AND WOULD COST OVER $2,200. AFTER READING ONLINE FORUMS AND OTHER PEOPLE HAVING THE SLIDING DOOR PROBLEMS AND THE FACT THAT IT WAS STILL NOT WORKING AFTER SPENDING THOUSANDS OF DOLLARS, I DECIDED AGAINST SPENDING THE MONEY. I BELIEVE THIS SLIDING DOOR PROBLEM HAS ALWAYS BEEN A DEFECT WITH THIS MODEL. AT FIRST DOOR WOULD AUTOMATICALLY OPEN AS ONE WAS DRIVING, A DANGEROUS SITUATION. MY WIFE DISABLED THE DOOR FROM THE CONSOLE SWITCH. ONLINE FORUMS HAVE LOT OF PEOPLE COMPLAINING OF THE SAME PROBLEM. I HAVE AT LEAST TWO OTHER FRIENDS. WE BOUGHT THE MINIVAN AT THE SAME TIME AND WE ALL HAD THE EXACT SAME PROBLEMS (SLIDING DOOR AND THE TIRE PRESSURE SENSORS). TOYOTA HAS AGAIN TRIED TO AVOID ANY RECALLS AND FIXED THE PROBLEMS ONLY WHEN PEOPLE COMPLAINED A LOT. UNFORTUNATELY THE MANUAL OVERRIDE AND RESETTING THE OPERATION DOES NOT WORK EITHER.

NHTSA complaint #10331825 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

THE POWER SLIDING PASSENGER DOOR ON MY 2000 TOYOTA SIENNA WILL OPEN BUT WILL NOT CLOSE. IT TOOK ME SEVERAL MINUTES OF VERY FIRM PRESSURE TO OVERCOME THE DOORS AUTOMATIC MECHANISM TO FORCE THE DOOR CLOSED. AS I USE THIS TO DROP MY CHILD OFF AT DAYCARE, I CAN NO LONGER LET HER OUT ON THE CURB SIDE OF THE VAN.

NHTSA complaint #10315870 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

SLIDING DOOR GETS STUCK. VERY DIFFICULT TO OPEN FROM OUTSIDE AND UNABLE TO OPEN FROM INSIDE. TRIED WD40 LUBRICATION BUT THIS DID NOT HELP.

NHTSA complaint #10285897 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

POWER SLIDING DOOR WILL NOT CLOSE.

NHTSA complaint #10279786 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

2000 TOYOTA SIENNA 2 ITEMS: 1. SEAT BELT LIGHT ALWAYS ON (RESEARCH REVEALS DEIGN FLAW) 2. AUTOMATIC SLIDING DOOR HAS NEVER WORKED CORRECTLY.

NHTSA complaint #10267929 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

THE DRIVERS SIDE SLIDING DOOR WAS STICKING AND VERY HARD TO OPEN. AFTER YANKING ON IT FOR WEEKS-TOTALLY BROKE OFF THE OUTSIDE HANDLE. THE ENTIRE MECHANISM WAS REPLACED. TWO WEEKS LATER-IT'S BEGINNING TO STICK AGAIN. I THINK IT MAY BE DUE TO THE SEAL AROUND THE DOOR. NOW THE PASSENGER SIDE AUTOMATIC DOOR HAS QUIT WORKING AND WE HAVE GREAT DIFFICULTY MANUALLY OPENING THE DOOR.

NHTSA complaint #10256847 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

REGULAR USAGE OF OUR VAN HAS CAUSED THE DOORS ON BOTH SIDES TO BREAK. ON ONE SIDE, THE HANDLE COMPLETELY BROKE OFF AND THE OTHER WILL ONLY PARTIALLY OPEN.

NHTSA complaint #10250157 — an unverified report by a vehicle owner.

STRUCTURE:BODY:HOOD

TL*THE CONTACT OWNS A 2000 TOYOTA SIENNA. WHILE DRIVING APPROXIMATELY 60 MPH, THE HOOD UNEXPECTEDLY RELEASED, FLIPPED UPWARD, AND DAMAGED THE WINDSHIELD. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 140,000.

NHTSA complaint #10249666 — an unverified report by a vehicle owner.

STRUCTURE

HANDLE TO THE POWER SLIDING DOOR OF MY TOYOTA SIENNA 2000 HAS BROKEN OFF. IT HAS BEEN BROKEN FOR OVER 4 MONTHS. THE DOOR WILL ALSO NOT CLOSE FOR NO REASON AND OPENS EASILY FROM JUST A BRUSH ON THE REMOTE ON THE KEY CHAIN.

NHTSA complaint #10242305 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

2000 TOYOTA SIENNA XLE PASSENGER POWER SLIDING DOOR FAILURE. SEEMS TO BE A VERY COMMON PROBLEM AFTER RESEARCHING ON THE WEB. COST TO REPAIR IS IN EXCESS OF $1500 WHICH CAN BE ON THE VERY LOW SIDE. TOYOTA SHOULD BE REQUIRED TO RECALL ALL VEHICLES WITH THESE DOORS.

NHTSA complaint #10240970 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

2000 TOYOTA SIENNA SLIDING POWER PASSENGER DOOR ACTS LIKE SOMETHING IS IN THE WAY WILL NOT TOTALLY CLOSE WITH POWER, SHUTS THEN IMMEDIATELY OPENS. LIGHT IN DASH IS ON, FOR SECOND TIME, MECHANICS FOUND NOTHING JUST RESET IT. TOYOTA MECHANICS.

NHTSA complaint #10240961 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

HANDLE BROKE OFF THE SIDE DOOR, NOW MUST CLOSE FROM INSIDE. BACK HANDLE SHEARED OFF HAD TO REPAIR.

NHTSA complaint #10238565 — an unverified report by a vehicle owner.

STRUCTURE

THE HANDLE LEVER FOR THE BACK HATCH BROKE FROM NORMAL USE AND THE HATCH CANNOT BE OPENED. ALSO, THE PASSENGER SIDE SLIDING DOOR HANDLE BROKE DUE TO NORMAL USE AND IT CAN ONLY BE OPENED FROM THE INSIDE. BOTH THESE PROBLEM CAN BE A POTENTIAL HAZARD IN CASE OF AN ACCIDENT WHERE THE DOORS/HATCH WILL NOT PERMIT QUICK OPENING DURING AN EMERGENCY. TOYOTA SHOULD FIX THESE DOOR/HATCH PROBLEMS AT NO COST TO THE CONSUMER......IMMEDIATELY!

NHTSA complaint #10236403 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

ENGINE LIGHT WENT ON , CHECKED WATER AND OIL, BOTH LEVELS WERE FINE, ENGINE JUST QUIT, VAN WAS TOWED TO REPAIR SHOP, I THE OWNER WAS TOLD THAT DUE TO SLUDGE IN THE ENGINE THE OIL COULD NOT PASS THROUGH SO ENGINE SEIZED UP, IT WAS A 2000 SIENNA VAN, THE OIL WAS CHANGED EVERY 3000-4000 MILES FAITHFULLY, THE ENGINE ONLY HAD 107,000. ORIGINAL MILES ON IT, A NEW ENGINE WOULD BE 6,200.00 PLUS LABOR AND A USED ENGINE WOULD BE 4,200.00 PLUS LABOR, SO NOW MY VAN HAD TO BE JUNKED.

NHTSA complaint #10216962 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

SINCE WE PURCHASED THE TOYOTA SIENNA XLE ABOUT 3 YEARS AGO WE HAVE HAD NOTHING BUT TROUBLE. OUR BIGGEST PROBLEMS HAVE OCCURRED ONLY RECENTLY. THE AUTOMATIC DOOR WAS NOT WORKING AND THE MECHANIC HAD TO TAKE OFF THE AUTOMATIC PART SO IT HAD TO BE OPENED MANUALLY. WELL AFTER ABOUT A WEEK OF MANUALLY OPENING AND PULLING OUT MY SHOULDER EVERY TIME, THE DOOR KNOB CAME OFF. WE HAVE ALSO HAD IN THE PAST A VERY LOUD SQUEALING NOISE EVERY TIME WE STARTED THE CAR. WE HAD THE BELTS TIGHTENED AND EVEN HAD THE BATTERY CHANGED AND THEN SUDDENLY IT STOPPED. ONE OF OUR CAPTAINS CHAIRS WILL NOT GO BACK INTO THE UPRIGHT POSITION. AND LASTLY THE BAR THAT HOLDS OPEN THE HOOD HAS COME OFF AND DOES NOT GO BACK INTO PLACE.

NHTSA complaint #10184006 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

DT: CONTACT STATES THE SLIDING DOORS WILL NOT OPEN FROM INSIDE OF THE VEHICLE. THE CONSUMER HAS CHECKED TO SEE IF THE CHILD SAFETY LOCK WAS ENGAGED, BUT IT WAS NOT. THE CONSUMER STATED HER SIX YEAR OLD CHILD BROKE THE HANDLE FROM THE OUTSIDE OF THE PASSENGER'S SIDE SLIDING DOOR. THE CONSUMER HAS NOT HAD THE VEHICLE TO A SERVICE DEALER YET.

NHTSA complaint #10133802 — an unverified report by a vehicle owner.

STRUCTURE:BODY:HATCHBACK/LIFTGATE

MY VAN HAD 66,000 MILES ON IT AND ONE DAY I OPENED THE BACK HATCH, WHICH IS RARELY USED, AND THE HATCH HANDLE BROKE-OFF IN MY HAND. I HAVE NEVER HAD A BACK HATCH HANDLE BREAK ON ANY OF MY VANS. I TOOK AND TO DEALER AND IT QUITE A WHILE FOR THEM TO REPAIR IT BECAUSE OF HOW THE HANDLE IS POSITION IN REAR DOOR.

NHTSA complaint #10131481 — an unverified report by a vehicle owner.