981 of the
13,865 complaints filed about the Volkswagen Jetta
are about the braking system —
7% of everything owners reported.
The worst model year for it is 2009.
Brakes were replaced in 2025 after dealership said there was manufacturer issues with premature wear on the brakes. Same day brakes were replaced they started making grinding noises again. We called the dealership ship and they said it would stop with in a few days never did. Now a year later the the replacement brakes failed on us.
NHTSA complaint #11757575 — an unverified report by a vehicle owner.
The brake pads that are being used on Volkswagen are semi metallic and that causes the brakes to make a grinding noise which the dealer says is common on volkswagen. The problem you cannot tell if brakes need replacement. I have had my vehicle in service dept twice for the same problem. The noise is a grinding noise and that is a safety hazard. Now I have a warrantey on the entire car and I was told I have to pay 1100 dollars to have it repaired.
NHTSA complaint #11752734 — an unverified report by a vehicle owner.
While traveling at the posted speed limit and approaching a signalized intersection, I attempted to brake for stopped traffic ahead. The vehicle did not decelerate as expected, and the automatic emergency braking/forward collision mitigation system did not activate or provide any braking assistance. Additionally, no forward collision warning or audible/visual alert was provided prior to impact. A red warning indicator illuminated immediately before the collision; however, there was insufficient time to take additional evasive action. As a result, my vehicle rear-ended the vehicle stopped in front of me. The apparent failure of the braking assistance and forward collision warning systems placed both myself and the occupants of the other vehicle at risk, resulting in a motor vehicle collision. The vehicle is available for inspection upon request. The cause of the malfunction has not yet been confirmed by a dealer or independent repair facility (UNKNOWN). The vehicle has been inspected by law enforcement and insurance representatives as part of the accident investigation. Prior to the incident, I had not observed any warning lamps, messages, or symptoms indicating a problem with the braking or forward collision systems. The only warning observed was the red indicator light that appeared immediately before the collision.
NHTSA complaint #11750281 — an unverified report by a vehicle owner.
DRIVING ON WESTLAKE DRIVE IN WIMAUMA FL PREPARING TO TURN LEFT TOOK FOOT OFF GAS PUT FOOT ON CLUTCH PUT CAR IN 2ND GEAR WITH FOOT ABOVE BRAKE TO MASH DOWN, PCOULD WOULD NOT STOP OR SLOW DOWN HIT ELECTRIC POLE AIR BAGS DEPLOYED. CAR WAS IN SHOP PRIOR TO ACCIDDENT AT BOB BOAST VOLKSWAGEN IN BRADENTON FL.
NHTSA complaint #11746925 — an unverified report by a vehicle owner.
My 2024 Volkswagen Jetta has about 14,429 miles, driven almost entirely on the highway between two Texas cities, with little city traffic and no mountain driving. The rear brakes are wearing out far faster than normal. At a dealer inspection on June 15, 2026, the rear linings measured 1 mm and 2 mm, nearly gone, while the front linings still measured 10 mm. This is the reverse of normal wear, since the fronts do most of the braking and should wear first. The vehicle is available for inspection. This is not sudden. A prior dealer inspection on July 7, 2025 already showed the rear linings (9 mm) more worn than the fronts (11 mm). Between the two inspections the fronts lost about 1 mm while the rears lost about 7 to 8 mm, so the rears are wearing many times faster than the fronts. Both inspections were done and documented by an authorized Volkswagen dealer. Given the low mileage and highway-only use, this cannot be normal wear. The rears are approaching metal-to-metal at very low mileage, which compromises braking and is unsafe. The pattern points to a mechanical defect, such as a seized rear caliper or a dragging or malfunctioning electronic parking brake that keeps the rear brakes partially applied. Premature rear brake wear is widely reported on this model, and the manufacturer issued a rear brake pad warranty extension for affected vehicles, acknowledging excessive wear and possible workmanship issues. No crash, fire, or injury has occurred. I am reporting this so the defect can be investigated and other owners protected.
NHTSA complaint #11744699 — an unverified report by a vehicle owner.
the components that failed are the rear brakes and rotors. we no longer have the components as the vehicle would not pass inspection without having the work completed. The manufacturer sent a letter to customers affected by this issue as it is a known issue for this year/make/model. the inspection location advised that given the mileage on the vehicle there is no reason it should need this type of work performed, under 25k miles on vehicle. the only warning that was given was the letter sent by the manufacturer. we took our vehicle back to the dealership when the letter was received and were informed they would not complete the outlined work on our vehicle. now that the vehicle would not pass inspection, the brake work had to be performed so my daughter could get back and forth to work
NHTSA complaint #11741996 — an unverified report by a vehicle owner.
The rear service brake assembly—specifically the rear brake pads and rotors—suffered premature wear and catastrophic structural failure. The defective parts are not available for inspection, as they were discarded by Firestone during the emergency repair to restore the vehicle to a safe operating condition. The problem was first confirmed by an authorized manufacturer dealer, Larry H. Miller Volkswagen Tucson. It was subsequently confirmed, documented, and repaired by an independent service center (Firestone). The vehicle and the failing brake components were physically inspected by the manufacturer's authorized dealership service department at Larry H. Miller Volkswagen Tucson prior to the repair. No dashboard warning lamps or error messages illuminated. The symptoms appeared suddenly at approximately 33,200 miles in the form of severe metal-on-metal grinding noises, a vibrating brake pedal, and noticeably reduced stopping power during routine deceleration.
NHTSA complaint #11741183 — an unverified report by a vehicle owner.
At only 24,000 miles, the rear brakes are already showing significant wear. When checked by the dealer, they were 2mm, while the front brakes were 12mm. The service representatives at the dealership have said this is a known problem with this model year, and they have already seen several cars with the same issue of brakes wearing out way too quickly. If a driver wasn't getting regular inspections, they would assume that their brakes would still be in great condition with this mileage, and it could pose a large safety risk.
NHTSA complaint #11737730 — an unverified report by a vehicle owner.
Vehicle Information: Year: 2021 Make: Volkswagen Model: Jetta Date of Purchase: March 2022 Approximate Mileage at Time of Incident: 25,000 miles --- NATURE OF COMPLAINT: I am filing this complaint regarding premature and dangerous rear brake pad and rotor wear on my 2021 Volkswagen Jetta, purchased new in March 2022. At approximately 25,000 miles — well below any reasonable expectation of normal brake wear — I was informed by a service technician that my rear brake pads required immediate replacement due to excessive wear. The front brakes showed no comparable wear, which is inconsistent with normal braking patterns and strongly suggests a manufacturing or design defect. SAFETY CONCERN: Premature rear brake failure at such low mileage presents a serious safety hazard. Degraded braking performance increases stopping distances and reduces driver control, particularly in emergency situations. I was given no prior warning indicators or alerts from the vehicle's onboard systems before being advised the brakes were critically worn. This lack of advance warning compounds the safety risk. SUPPORTING EVIDENCE OF A KNOWN DEFECT: This is not an isolated incident. Volkswagen has already acknowledged premature rear brake pad wear as a systemic issue in 2020–2023 Jetta vehicles by issuing a Rear Brake Pad Limited Warranty Extension, extending coverage from the standard 1 year/12,000 miles to 2 years/24,000 miles. Despite this acknowledgment, Volkswagen has refused to provide adequate and lasting remedy to affected owners, and many consumers — including myself — have been denied reimbursement or further assistance after the extended warranty window expired. Notably, my vehicle reached 25,000 miles just outside the extended warranty coverage limit, yet exhibits the exact defect the warranty extension was designed to address. Multiple complaints filed with NHTSA and reported on consumer safety platforms describe the identical pattern.
NHTSA complaint #11736753 — an unverified report by a vehicle owner.
The vehicle experienced a complete loss of communication with the ABS control module, resulting in multiple warning lights and loss of ABS and related safety systems. The failure is consistent with Volkswagen Recall 45F2, which describes internal ground and solder failures in the ABS module. Prior to total failure, the vehicle exhibited intermittent warning lights and an ABS fault code (01130 – Implausible Signal) in 2021 but was told the car was not under recall by dealer. After the condition progressed, the module became non-communicative and no longer generated fault codes. This is consistent with internal failure preventing communication. The failure affects braking-related safety systems, including ABS and stability control, and creates a potential safety risk, particularly during emergency braking or low-traction conditions. The condition has been confirmed by both a Volkswagen dealership and an independent Volkswagen/Audi specialist. A dealership diagnosis in 2025 once again confirmed that the ABS pump and module had no communication and required full replacement. Independent electrical testing verified that all external wiring, power, and ground inputs were functioning properly, indicating the failure is internal to the ABS module. Despite this, the manufacturer denied recall repair based on the absence of diagnostic fault codes. However, the lack of communication prevents the module from generating fault codes, creating a situation where complete failure does not qualify for recall repair. The failed ABS module is still installed in the vehicle and is available for inspection upon request.
NHTSA complaint #11729349 — an unverified report by a vehicle owner.
I tried to stop my car and the brake pedal went completely to the floor and did not stop at all. There were no warning lights on, I keep my brakes and car well maintained. My car hit the rear of another car because the brakes failed to engage when I pushed the pedal down. My car which is the vw jetta was totaled in the accident. My insurance company GEICO has the car sitting at copart and it should be able to be inspected. I know the 2015-2016 vw Jetta had a recall for brake failure due to brake vacuum pump.But my 2016 doesn’t have any recalls on it. The police officer inspected the brakes at the scene.
NHTSA complaint #11728910 — an unverified report by a vehicle owner.
The contact owns a 2009 Volkswagen Jetta. The contact received notification of NHTSA Campaign Number: 16V913000 (Service Brakes, Hydraulic, Electronic Stability Control (ESC). The contact stated that while driving on several occasions at various speeds, there was a burning odor coming from outside the vehicle, and the odometer was inoperable. The ABS, Brake, DRL, and EPC warning lights were illuminated. During the failure, the vehicle drove like the parking brake was engaged. The contact stated that on two separate occasions, while driving and experiencing the failures, the vehicle was pulled over to the side of the road, and the contact exited the vehicle, and observed smoke coming from all four wheels. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the cylinder to the ABS module had failed to communicate with the computer and needed to be replaced. The vehicle was not repaired, but the contact was made aware of an associated recall. The vehicle was taken to a dealer where it was diagnosed, and determined that the ABS module was inoperable and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 177,000.
NHTSA complaint #11725252 — an unverified report by a vehicle owner.
I took my car into dealer at 20,000 miles. They told me rear brake pads and rotors needed to be replaced. At that time, they were replaced under warranty. I took my car into dealer at 34,000 miles for regular service and was told rear brake pads and rotors needed to be replaced. Pads were at 3%, service associate warned me about driving on the highway. I took my car to another location and mechanic for a second opinion and was told "rear brake pads approx. 2mm remaining friction material, and brake rotors are overheated & scored. Not knowing that my rear brakes had worn down to this level in 14,000 miles put myself and other drivers at risk. I had no warning nor did I experience any symptoms in my brakes until I took it in for regular service.
NHTSA complaint #11720536 — an unverified report by a vehicle owner.
Please copy the link. It is not a spam nor malware. It is the diagnostic report ran 9/12/2025. Please look under “airbag” tab and you will see the code related to brake system. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11686881 — an unverified report by a vehicle owner.
I just got this 2024 Jetta Sport 6 speed manual and tried getting up the drive that's slightly inclined and the brake assist would not disengage or the fuel was cut after it didn't progress then dies. It is possible to power through the brake assist but it will cause premature wear on the clutch, flywheel as well as the rear E brake with all this wireless tech on the brakes, throttle can't figure it out so take it back.
NHTSA complaint #11686138 — an unverified report by a vehicle owner.
The rear brake pads on my 2021 Volkswagen Jetta have worn out prematurely twice by 20,000 miles. The first replacement occurred at only 8,006 miles in April 2023. At that time, Volkswagen acknowledged the problem and provided “goodwill” coverage of 50% since my vehicle was only one month outside of the Rear Brake Pad Limited Warranty Extension. Now at approximately 20,846 miles in September 2025, the rear pads have worn out again and required replacement. Volkswagen has refused to provide any assistance this time. Normally, front brake pads wear faster than the rear. In this case, the rear pads are failing far earlier than expected, which creates a potential safety issue since brake performance is being compromised at very low mileage. Volkswagen has already acknowledged this defect by issuing the warranty extension for 2020–2023 Jettas, but coverage expired by time, not mileage, leaving owners like me with repeated failures and no support. When I raised the issue with my dealership, they suggested that the premature wear is due to the emergency brake always being engaged when the car is parked. This explanation does not make sense, since pads do not normally wear when the car is stationary. The fact that VW created a warranty extension for this exact problem shows this is a design defect, not a misuse issue. This issue has been confirmed by a Volkswagen dealer and independent service centers, and is well-documented among other owners. If the pads continue to wear this quickly, it poses a recurring safety risk and results in abnormally high repair costs for a critical safety component. I am reporting this so NHTSA is aware that the defect continues to affect owners even beyond the limited warranty extension and goodwill offers, and that a long-term solution is needed.
NHTSA complaint #11684685 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR
The contact owns a 2024 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear tires. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the rear rotors, and brake pads needed to be replaced. The vehicle was repaired at the consumer's expense. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.
NHTSA complaint #11684683 — an unverified report by a vehicle owner.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:PADS
The contact owns a 2024 Volkswagen Jetta. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the rear tires. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed and determined that the rear rotors, and brake pads needed to be replaced. The vehicle was repaired at the consumer's expense. The manufacturer was made aware of the failure. The failure mileage was approximately 15,000.
NHTSA complaint #11684683 — an unverified report by a vehicle owner.