2020 BMW X3 problems

UNKNOWN OR OTHER

I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.

NHTSA complaint #11756272 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.

NHTSA complaint #11756272 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.

NHTSA complaint #11756272 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 BMW X3. The contact stated that while driving 25 MPH, the message “Heat Management Module Malfunction” was displayed and the warning light was illuminated. The drive-train warning light was illuminated. Upon research, the contact became aware of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The vehicle was previously taken to the dealer to be diagnosed, and the contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided due to a prior good-faith repair being provided. The failure mileage was approximately 70,000.

NHTSA complaint #11754695 — an unverified report by a vehicle owner.

FUEL SYSTEM, DIESEL

The contact owns a 2020 BMW X3. The contact stated that while driving 25 MPH, the message “Heat Management Module Malfunction” was displayed and the warning light was illuminated. The drive-train warning light was illuminated. Upon research, the contact became aware of NHTSA Campaign Number: 21V586000 (Fuel System, Diesel). The vehicle was previously taken to the dealer to be diagnosed, and the contact was informed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no additional assistance was provided due to a prior good-faith repair being provided. The failure mileage was approximately 70,000.

NHTSA complaint #11754695 — an unverified report by a vehicle owner.

POWER TRAIN

Heat Management Module HMM is bad. BMW used a plastic part that is right up against the engine block. This HMM Heat Management Module resulted in STOPPING the vehicle completely in the middle of the freeway. I had no control. Then the car drove, then stopped again. I had NO CONTROL over the vehicle. Weeks later the Drivetrain Malfunction warning light appeared as i was driving home late at night from the ER. I took it to my BMW dealer. The diagnostic test was performed and was told the Heat Management Module HMM needed to be replaced at a cost to me of $3000. I contacted BMW USA, explained what transpired and they responded with a denial. I stopped driving the car completely after i found other complaints about BMW using an inferior part on the 3 series and the same issue about the car stopping in highway traffic without any control. I later got my BMW repaired, at the BMW dealer, as i could not afford to buy another car. I have the defective inferior part in my possession for inspection by NHTSA. BMW refuses to recall the Heat Management Module HMM and will not address the Drivetrain Malfunction warning light. I would like this to be escalated and investigated by NHTSA.gov so that others may be safe when driving please. Thank you.

NHTSA complaint #11749367 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

Heat Management Module HMM is bad. BMW used a plastic part that is right up against the engine block. This HMM Heat Management Module resulted in STOPPING the vehicle completely in the middle of the freeway. I had no control. Then the car drove, then stopped again. I had NO CONTROL over the vehicle. Weeks later the Drivetrain Malfunction warning light appeared as i was driving home late at night from the ER. I took it to my BMW dealer. The diagnostic test was performed and was told the Heat Management Module HMM needed to be replaced at a cost to me of $3000. I contacted BMW USA, explained what transpired and they responded with a denial. I stopped driving the car completely after i found other complaints about BMW using an inferior part on the 3 series and the same issue about the car stopping in highway traffic without any control. I later got my BMW repaired, at the BMW dealer, as i could not afford to buy another car. I have the defective inferior part in my possession for inspection by NHTSA. BMW refuses to recall the Heat Management Module HMM and will not address the Drivetrain Malfunction warning light. I would like this to be escalated and investigated by NHTSA.gov so that others may be safe when driving please. Thank you.

NHTSA complaint #11749367 — an unverified report by a vehicle owner.

ENGINE

Heat Management Module HMM is bad. BMW used a plastic part that is right up against the engine block. This HMM Heat Management Module resulted in STOPPING the vehicle completely in the middle of the freeway. I had no control. Then the car drove, then stopped again. I had NO CONTROL over the vehicle. Weeks later the Drivetrain Malfunction warning light appeared as i was driving home late at night from the ER. I took it to my BMW dealer. The diagnostic test was performed and was told the Heat Management Module HMM needed to be replaced at a cost to me of $3000. I contacted BMW USA, explained what transpired and they responded with a denial. I stopped driving the car completely after i found other complaints about BMW using an inferior part on the 3 series and the same issue about the car stopping in highway traffic without any control. I later got my BMW repaired, at the BMW dealer, as i could not afford to buy another car. I have the defective inferior part in my possession for inspection by NHTSA. BMW refuses to recall the Heat Management Module HMM and will not address the Drivetrain Malfunction warning light. I would like this to be escalated and investigated by NHTSA.gov so that others may be safe when driving please. Thank you.

NHTSA complaint #11749367 — an unverified report by a vehicle owner.

ENGINE

I own a 2020 BMW X3 M40i, VIN [XXX], manufactured November 2019, now at approximately 100,000 miles, equipped with the B58TU engine. My oil level sensor stopped completing measurements at approximately 45,000 miles, a known precursor to thermoplastic oil pump failure. For 55,000 miles I had no way to identify whether my vehicle contained the defective component because BMW removed the original thermoplastic part number from all dealer networks. VIN-based lookup now falsely returns updated metal component information regardless of what is physically present in the vehicle. This makes proactive identification impossible for both owners and dealers, meaning the defect cannot be remediated even by willing owners. I had no actionable path forward. On [XXX] I was driving on a Florida highway at 80 mph when a low oil pressure warning appeared. I pulled over immediately. A fault log pulled at 2:05PM showed code 1C3002. A second log pulled at 6:49PM after briefly running the engine showed three additional oil system faults including 1C2002 - engine oil pump pressure too low - indicating active progressive failure within hours. This failure occurred in 90 degree Florida summer heat, not cold weather. If NHTSA’s investigation is scoped around cold climate failures, my case demonstrates that scope is incomplete and the affected population is broader than currently documented. Carfax records confirm 18 total service records over 100,000+ miles, including 8 dealer visits between 18,000 and 50,000 miles under active CPO warranty. This vehicle has been consistently and properly maintained throughout its life. The vehicle became a safety hazard at highway speed without adequate warning. I will file a second complaint after physical inspection confirming which pump variant is actually present. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11745794 — an unverified report by a vehicle owner.

ENGINE

reporting a safety issue with BMW vehicles equipped with the B58TU engine, primarily 2019-2021 models. These vehicles have an oil pump with an internal plastic component that regulates oil pressure, and this part is fracturing in the field, causing sudden loss of oil pressure. The failure typically occurs during cold starts in low temperatures. When it fails, oil pressure becomes erratic or is lost entirely, often with little to no warning before engine damage or vehicle disablement. Warning signs, when present, include inability to measure oil level electronically, abnormal oil pressure, or sudden drivetrain malfunction warnings. These can rapidly progress to engine shutdown or severe damage from oil starvation. This creates a dangerous situation because the vehicle can become disabled without warning while driving or after startup. This is especially hazardous when cars become immobilized in traffic or during winter conditions when failures occur most frequently, leaving occupants exposed to freezing temperatures while awaiting assistance. Pump replacement requires extensive disassembly and commonly costs $6,000-$8,000, assuming no engine damage. A critical concern: owners cannot determine if their vehicle has the original plastic pump or the later metal revision. BMW's VIN-based parts lookup now shows updated components even when original plastic parts remain installed, and BMW has removed the original plastic part number from dealer networks entirely. Failures are reported across multiple production years, and the scope of affected vehicles remains unclear. Because this condition causes sudden vehicle disablement without adequate warning, especially in cold weather, I believe this warrants investigation as a potential safety-related defect.

NHTSA complaint #11744370 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 BMW X3. The contact stated that while driving at an undisclosed speed, the drivetrain warning light illuminated on the instrument panel, causing the vehicle to jerk and run rough. The vehicle was taken to the dealer, where it was diagnosed with a heat management module failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 53,404.

NHTSA complaint #11742323 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I am submitting this complaint regarding ongoing and potentially dangerous mechanical failures involving my vehicle that have repeatedly occurred despite numerous repair attempts by the dealership. Over the past year, I have taken my vehicle to the dealership more than 10 times for serious recurring issues. The problems have included: Drivetrain malfunction warnings Engine warning lights Oil leaks Smoke coming from the vehicle The vehicle unexpectedly shifting into neutral while driving Sudden loss of drivability requiring the vehicle to be towed The dealership has repeatedly stated that the issues were repaired, and at one point even provided a one-year warranty on the repair work. Despite this, the same problems have continued to occur. Most recently, the drivetrain malfunction warning and engine light returned again, smoke came from the vehicle, and the car shifted into neutral on its own, becoming completely undriveable and requiring towing. I have spent more than $10,000 on repairs related to these ongoing issues, yet the vehicle remains unreliable and unsafe. My primary concern is the safety risk posed by the drivetrain failure and the vehicle unexpectedly shifting into neutral while in operation. I am requesting that this matter be reviewed as a potential vehicle safety issue. I believe these repeated failures may present a serious risk not only to myself but potentially to other drivers as well. Thank you for your attention to this matter.

NHTSA complaint #11738436 — an unverified report by a vehicle owner.

ENGINE

I am submitting this complaint regarding ongoing and potentially dangerous mechanical failures involving my vehicle that have repeatedly occurred despite numerous repair attempts by the dealership. Over the past year, I have taken my vehicle to the dealership more than 10 times for serious recurring issues. The problems have included: Drivetrain malfunction warnings Engine warning lights Oil leaks Smoke coming from the vehicle The vehicle unexpectedly shifting into neutral while driving Sudden loss of drivability requiring the vehicle to be towed The dealership has repeatedly stated that the issues were repaired, and at one point even provided a one-year warranty on the repair work. Despite this, the same problems have continued to occur. Most recently, the drivetrain malfunction warning and engine light returned again, smoke came from the vehicle, and the car shifted into neutral on its own, becoming completely undriveable and requiring towing. I have spent more than $10,000 on repairs related to these ongoing issues, yet the vehicle remains unreliable and unsafe. My primary concern is the safety risk posed by the drivetrain failure and the vehicle unexpectedly shifting into neutral while in operation. I am requesting that this matter be reviewed as a potential vehicle safety issue. I believe these repeated failures may present a serious risk not only to myself but potentially to other drivers as well. Thank you for your attention to this matter.

NHTSA complaint #11738436 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I am submitting this complaint regarding ongoing and potentially dangerous mechanical failures involving my vehicle that have repeatedly occurred despite numerous repair attempts by the dealership. Over the past year, I have taken my vehicle to the dealership more than 10 times for serious recurring issues. The problems have included: Drivetrain malfunction warnings Engine warning lights Oil leaks Smoke coming from the vehicle The vehicle unexpectedly shifting into neutral while driving Sudden loss of drivability requiring the vehicle to be towed The dealership has repeatedly stated that the issues were repaired, and at one point even provided a one-year warranty on the repair work. Despite this, the same problems have continued to occur. Most recently, the drivetrain malfunction warning and engine light returned again, smoke came from the vehicle, and the car shifted into neutral on its own, becoming completely undriveable and requiring towing. I have spent more than $10,000 on repairs related to these ongoing issues, yet the vehicle remains unreliable and unsafe. My primary concern is the safety risk posed by the drivetrain failure and the vehicle unexpectedly shifting into neutral while in operation. I am requesting that this matter be reviewed as a potential vehicle safety issue. I believe these repeated failures may present a serious risk not only to myself but potentially to other drivers as well. Thank you for your attention to this matter.

NHTSA complaint #11738436 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 BMW X3. The contact stated while driving at an undisclosed speed, the brake pedal was released, the auto start feature failed to function as intended. The vehicle was taken to the dealer where it was diagnosed with a failed engine starter. The contact was informed that the engine starter needed to be replaced. The vehicle was not repaired. The contact referenced a recall, NHTSA Campaign Number: 25V636000 (Electrical System) however the contact's VIN was not associated. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 55,000.

NHTSA complaint #11737334 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

While stopped at a red light, my front sunroof panel exploded/shattered. My brother and I heard a loud bang. No object hit the sunroof. It was visible that the glass was bubbled outward. And, the 4 corners had cracking. Lucky the roof liner was closed and no glass hit us.

NHTSA complaint #11735763 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

It has come to my attention that liquid from the Positive Crankcase Ventilation (PCV) system may leak onto the water pump electrical connector. This condition can lead to an electrical short circuit and, in rare cases, may increase the risk of a vehicle fire. This issue presents a serious safety concern for vehicle owners and others on the road. A failure of this nature, especially one that carries a fire risk, warrants immediate review and corrective action. I respectfully request that NHTSA investigate this matter and determine whether a safety recall is necessary to address this defect. The dealership noticed the leak beginning at the weep hole of the waterpump. No incident occurred this is for preventive measures and review for recall and reimbursement

NHTSA complaint #11731565 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: WARNINGS

Due to a TSB (SIB 65 12 22) wherein the roof antennae leaks water and causes a short in the telemetry module, the car does not have pedestrian warning, navigation or backup camera / cross traffic warning. The car is drivable, but compromised from a safety perspective.

NHTSA complaint #11729946 — an unverified report by a vehicle owner.

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

Due to a TSB (SIB 65 12 22) wherein the roof antennae leaks water and causes a short in the telemetry module, the car does not have pedestrian warning, navigation or backup camera / cross traffic warning. The car is drivable, but compromised from a safety perspective.

NHTSA complaint #11729946 — an unverified report by a vehicle owner.

LANE DEPARTURE: WARNING

Due to a TSB (SIB 65 12 22) wherein the roof antennae leaks water and causes a short in the telemetry module, the car does not have pedestrian warning, navigation or backup camera / cross traffic warning. The car is drivable, but compromised from a safety perspective.

NHTSA complaint #11729946 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2020 BMW X3. The contact received notification of NHTSA Campaign Number: 25V636000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part to do the recall repair was not available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11729629 — an unverified report by a vehicle owner.