Dodge RAM 2500 electrical problems

ELECTRICAL SYSTEM

The switch to start the vehicle has to be pushed down and turned at the same time. Vehicle starts but shuts the engine down when the key returns sometimes. On one occasion vehicle shut down while driving.

NHTSA complaint #11753537 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM:INSTRUMENT PANEL:SPEEDOMETER/ODOMETER

Odometer Fraud. The contact purchased a 2006 Dodge Ram 2500. It was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 133,000. The contact discovered that the mileage was 209,000 from an independent mechanic. The contact reported the issue to the local authorities.

NHTSA complaint #11733975 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Approximatly 6 years ago My TIPM failed on my 2011 dodge ram 2500. It was not under warrenty so I replaced it myself not knowing this was an ongoing problem with dodge products. My TIPM is again failing. What can be done with it? [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11665348 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2010 Ram 2500. The contact stated while driving approximately 70 MPH, the vehicle was driven over uneven pavement, causing the ignition key to fall out of the ignition. The contact coasted to the side of the road and placed the key back in the ignition and continued driving; however, the failure reoccurred several more times. The contact found information of NHTSA Campaign Number: 10V200000 (Electrical System). The contact called the dealer about the failure and confirmed that the VIN was not included in the recall. The contact called another dealer, R C Bliss Inc (901 Lyndale Ave N, Faribault, MN 55021) and it was confirmed that the VIN was not included. The vehicle was not repaired. The vehicle was taken to a certified mechanic however, the vehicle was not diagnosed or repaired. The manufacturer was informed of the failure and confirmed that VIN was not included in the recall. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

NHTSA complaint #11664513 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Headlights- the passenger side headlight would come on then go off whenever it wants to and now the low beam does not work. I have tested the connection and replaced the bulb several times and still does not work. When driving at night it makes it difficult to see. And is also against the law to not having working headlights. Trailer lights- the drivers side brake light/blinker on any trailer that’s hooked to my truck does not work. I have taken it the a local shop (street dynamics which is out of business now) several times over the last 5 years to see if they can fix the issue. The fix was to put a jumper wire from the truck brake light to the trailer connector. I still do not have a blinker on the driver side of the trailer. Windshield wipers- the windshield wipers will come on and off whenever they want. Some times when it is raining they will turn on with the switch then will turn off while driving or will stay on after the switch is turned off. The switch has been replaced and did not change anything. It is dangerous to drive the truck during inclement weather. I am a Police officer and have been for 17 years. In the last 12 plus years I have owned the truck which is a 2006 Dodge 2500 I have been told by several dodge technicians and mechanics that the issues I’m having is being caused by the TIPM. While researching the tipm I have found out all of my trucks issues are similar to a lot of other people’s 2006 dodge 2500s. I have had issues with the trailer brake lights since I bought it.

NHTSA complaint #11654389 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

driving down the highway at 70 mph and the drivers door came opened it was caused by a faulty door lock actuator

NHTSA complaint #11630223 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2009 Dodge Ram 2500. The contact stated while operating the vehicle, the check engine warning light remained illuminated, the headlights flashed off and on, and the battery failed to remain charged. The contact diagnosed an electrical ground short, a low voltage to the intake air heater relay, and the engine grid heater was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the Extended Warranty coverage for the failure. The failure mileage was 162,000.

NHTSA complaint #11615213 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have a 2001 Dodge Ram 2500. In 2003, I noticed parts of the dash, starting to break apart. In 2004, I had a major head on collision, and the airbag, did NOT deploy. The damage was extensive, with bent frame. The damage was $17,000 in 2004. I was told by the Chrysler Dealership, that did the repairs, that they could not check the condition of the airbag wiring, because the dashboard was broken. I wonder how many others out there, that have the same issue, with the dashboard, and don't have a working airbag. The other issue I have, is the seatbelt tensioner, has caused the seatbelt, to get chewed up. The belt, is now, no more than an inch wide.

NHTSA complaint #11580749 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2012 Ram 2500. The contact stated the vehicle failed to start intermittently. The contact also stated that the air bag warning light was illuminated. The vehicle was taken to the local dealer and the dealer was made aware of the failure. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 168,000.

NHTSA complaint #11532307 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

After driving in heavy rain. During the following day started having electrical issues the parking lights would stay on even when the switch was turned off the driver's side headlight would also come on. and the parking lights would either turn off or flash when the high beams were turned on this happened with front and back parking lights the only way to fully get them to stay off was to pull the relay or disconnect the battery. The problem is with the power distribution center and front control module the poor design allows them to corrode damaging the copper tracing and causing shorts in the system this is a common problem as there are several online forums dedicated to these problems with a lot of people having the same issues so I'm not sure why there hasn't been a recall for this since it is a major safety problem when it affects lights, windshield wipers and several other things that could cause accidents. my brother's truck is also having sign's of the pdc and fcm being bad. and at over $1000 to replace both for a manufacturing defect it's not right that dodge customer's should have to pay that bill. I'll be attaching a picture of another board but the damage is the same and in the same spot

NHTSA complaint #11516199 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving, my dodge shut off and it was hard to control my vehicle and come to a safe stop, out of the way of other motorists. Lost all power, as if I turned the key off while driving. Turns out that there is a weak/loss of connection in the WIN module. while the vehicle is running at idle, the truck will shut off as if I turned the key to the off position. This is dangerous and scary. There was no warning or heads up or any issues prior to this incident.

NHTSA complaint #11504080 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Some electrical components became inoperative in the quick minute. Fuel pump was running continuedly till the battery was drained. Mechanic, I had used before told me that the TIPM Module was defective and needed replaced. Truck just before the battery died was that not all Eletronic's were working. Interior lights, horn, cruise control, FOBs not responding to the vehicle. Mechanic stated that the TPIM did need to be replaced. Contacted dealership were purchased and they told me that there have been recalls out on this particular part. I know that from 2009 to 2017 there have been several models that were impacted by this part being defective. I do have the invoice from the mechanic that took care of replacing the TIPM module.

NHTSA complaint #11491994 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Driving on the highway doing about 100km per hour and the truck shut off. No noise or anything it just died, no steering etc. luckily I was able to slow down and safely get to the side of the road. Put in park and it started up again fine. A few weeks later the same thing happened while drive 60km per hour. I took it home and appears the key is able to shake loose while in the run position; if you hit a bump etc it’s enough to cause the truck to shut off. I brought it to the dealer and told them and they knew exactly what the issue was; have to replace the ignition and get new keys- approximately a $1000 repair im told. They also said they do 4-5 of these repairs a week. I asked if it’s a recall item and they said no. I was shocked as it was very frightening when the truck shut off on the highway and not having full control of the vehicle. It was dangerous and I have not driven the truck since; have been 5 weeks waiting on the new ignition to come in. I also have a 2012 dodge 3500 diesel and it did the same thing this week. While driving it shut off. So I have 2 of these truck with the same issue; I’m told it’s a common issue with the trucks, but it’s not a recall? Seems like a huge safety concern to me. If I had been involved in an accident due to this issue I’m Sure we would be looking at a whole other issue.

NHTSA complaint #11453936 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

While driving the vehicle suddenly lost engine power and turned off. When this happened the steering column locked. It did not just loose power steering. The column itself entirely locked up. At this point the vehicle had no steering and limited breaking and went off the road. Thankfully it just went into a ditch and no damage was done. The vehicle turned right back on. The next day I recreated the problem on some friends property. I gave the keys in the ignition a small tug and the engine would stop and the steering column would lock. The ignition never rotated out of the on position and the key remained in the ignition. I recreated this probably 5 times and it did the same thing every time. I then brought it to the dealer but they didn't have the parts to repair it so I didn't have them look at it. I had to use the vehicle sooner then they could repair it to pull a camper about 1200 miles. I diagnosed the problem to be the ignition switch. I replaced the switch myself and the vehicle has not had the same problem since. I have given the keys in the ignition the same kind of tug and it is no longer a problem. I do have the switch available for inspection. I personally can totally understand the engine turning off due to an ignition switch failure but I believe the actual steering column locking is unacceptable.

NHTSA complaint #11446616 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

This has happened to me two times in 2014 and This has happened to me twice in 2014 and Oct/09/21 The windshield washer starts spraying all of a sudden blinding me then was able to get wiper to work. Windows wouldnt go down so i could see out. luck i was going about 25 miles an hour. I was about to gett on interstate going about 70 mph.that would have been bad . then the pickup died and i was able to pull over off the road with no power steering or brakes. I got out and disctmpionteed the battery to stop horn and windowwasher and wiper and the engine kept trying to star all the while smoke was coming from the tpmi fuse box

NHTSA complaint #11436269 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The TIPM module is bad. This part controls quite a bit of electrical current to various areas of the vehicle. It stalls when stopped at a traffic light, it is not sending the brake light information to an attached trailer (left side only), gauges inside the vehicle have stopped working (to name a few of the items being affected by this control). This part can be inspected as it is currently still on the vehicle. Safety is a concern due to either not being able to move out of the roadway, and also when pulling a trailer as no one will see turn signals or brake lights on the tow vehicle as the power isn't going to the trailer lights. I was informed of the malfunction at a trailer dealership. The problems have been getting worse over the last 4 years of ownership of this vehicle. The check engine light is currently on, even though what the computer read out gave has now been repaired. There has currently been no accident that this vehicle has been involved in.

NHTSA complaint #11428151 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The room fcm power distribution module corrodes and causes electrical problems. Headlights can go out while driving, taillights, break lights etc. There is many complaints on the web about this issue and dodge has not fixed the problem. I was driving at night and my headlights went completely out. Luckily I was able to avoid any accident and come to a controlled stop. If I had been on a curve I would have lost sight of the road. This is a well known issue among dodge trucks. This is a safety recall as it can cause an accident and death.

NHTSA complaint #11421213 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2012 Ram 2500. The contact stated while driving approximately 40-60 mph, on several occasions after driving over a bump in the roadway, the vehicle loss steering and braking functionality before the vehicle loss motive power. The vehicle was taken to an independent mechanic who diagnosed that the wireless ignition node module was faulty. The mechanic retrieved a fault code. The vehicle was not repaired. The dealer and the manufacturer were made aware of the failure however, no assistance was offered. The contact was relating the failure to NHTSA Campaign Number: 10V200000 (Electrical System). The failure mileage was 216,000.

NHTSA complaint #11420109 — an unverified report by a vehicle owner.