404 of the 8,415 complaints filed about the Dodge RAM 2500 are about the fuel system — 5% of everything owners reported. The worst model year for it is 1999.
404
Complaints
5%
Share of all complaints
13
Crashes
9
Fires
FUEL/PROPULSION SYSTEM
In the past 6 months my steering and suspension components failed causing me to wreck and also somehow my engine bay deteriorated in turn having started a fire
NHTSA complaint #11756595 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
My passenger headlights keeps going in and out. The wiring harness has been replaced twice and it still does it. My check engine light keeps coming on for the evap system even though its been replaced.
NHTSA complaint #11708616 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Our 2012 RAM 2500 truck with 135k miles, had it's fuel tank fail. The dealership in Oak Ridge, TN tested the vehicle and found that the gas tank tubes were broken causing us to not be able to fill the tank. The dealership recommended "NEED TO REPLACE GAS TANK". Mopar aka Stellantis does not make the fuel tank anymore, the "replacement" fuel tank does not work (completely wrong configuration), there is not an aftermarket tank. We have a Million Mile bumper to bumper warranty with MOPAR. "Customer Care" does not care.
NHTSA complaint #11697955 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Some electrical components became inoperative in the quick minute. Fuel pump was running continuedly till the battery was drained. Mechanic, I had used before told me that the TIPM Module was defective and needed replaced. Truck just before the battery died was that not all Eletronic's were working. Interior lights, horn, cruise control, FOBs not responding to the vehicle. Mechanic stated that the TPIM did need to be replaced. Contacted dealership were purchased and they told me that there have been recalls out on this particular part. I know that from 2009 to 2017 there have been several models that were impacted by this part being defective. I do have the invoice from the mechanic that took care of replacing the TIPM module.
NHTSA complaint #11491994 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
While the NHTSA is looking at the later Dodge diesel pickups, the 5.9 engines commonly fail at low mileage (mine was at 100,000 miles) by the intank pump failing. Mine shut off at 45mph in traffic on State 33 in Idaho without warning.. My truck was towed to repair facility and waited 4 weeks for a substitute pump to be installed. The Turbo Diesel Register magazine commonly has articles of the hundreds of Doidge Ram owners who have been stranded and sometimes lives endangered by the pump failure. Dealers are aware of the problem, give a wink and a nod and as the part is not available, I paid nearly $1400 for a r & r fuel tank, labor, and a FASS brand pump/filter to get back on the road. This happened in August 2020 and didn't run till Sept 2020. Work order available. Truck has had 3,000 mile service it's existance, at Dodge 5 Star Dealer
NHTSA complaint #11437265 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
Fuel pump failed with no warning. Best One of Indy confirmed and replaced. It was parked and would not start.
NHTSA complaint #11437231 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FUEL TANK STRAPS CORRODED AND BROKE OFF WHICH CAUSED FUEL TANK TO FALL OUT OF VEHICLE WHILE DRIVING DOWN THE ROAD.
NHTSA complaint #11412767 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I RECEIVED A VE5 LATE LIFE EMISSION PERFORMANCE DEGRADATION RECALL IN JANUARY 2021. I HAD THE RECALL PERFORMED ON 1.27/2021 AT RAZZARI DODGE, MERCED. THEY INSTALLED A NEW CAT CONVERTER AND EXHAUST MANIFOLD. WHEN I GOT MY TRUCK BACK, I HAD AN CEL ERROR CODE P2271 O2 SENSOR. I HAD TO PAY $707.74 AND $978.98 TO GET THE TRUCK RUNNING. I HAD NO PREVIOUS CEL. I THINK THEY BROKE THE WIRING HARNESS OR O2 SENSORS WHEN THEY PERFORMED THE RECALL. . I THINK THE VE5 RECALL REPAIR, SHOULD MAKE THE ENTIRE EMISSIONS SYSTEM FUNCTION, INCLUDING THE CONTROL ELECTRONICS.
NHTSA complaint #11408550 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
ON A 35MPH STREET, TRUCK SUDDENLY BUCKING AS IF IT WAS GOING TO STALL, AND THE RPM'S WERE ERRATIC. I PUT IT IN N PULLED OVER AND SHUT IT OFF. IT RESTARTED WITH NO ISSUES. I DROVE ABOUT 9 MILES, PULLED INTO MY DRIVEWAY AND WAS COASTING UP IT, WHEN SUDDENLY THE TRUCK ACCELERATED. I DEPRESSED THE BRAKE, NOTHING. I SLAMMED IT IN PARK AND SHUT IT OFF. IT HAPPENED A FEW TIMES WHILE IDLING, OR MOVING AT A SLOW RATE. I WAS STOPPED AT A LIGHT WHEN IT SUDDENLY ACCELERATED INTO A 50MPH, 4 LANE MAIN THOROUGHFARE. I STEPPED ON PARKING BRAKE, TURNED IT OFF AND THANKED GOD THAT I WAS UNHARMED. I STARTED BACK UP, PUT IT IN D, DEPRESSED THE GAS PEDAL (LIGHT TURNED GREEN) AND IT WOULD NOT ACCELERATE. I TOOK MY FOOT OFF THE GAS, THEN IT BUCKED A FEW TIMES AND ACCELERATED ON IT'S OWN. I DEPRESSED THE BRAKE PEDAL, BUT IT KEPT REVVING UP AND ACCELERATING. AGAIN, I DEPRESSED THE EMERGENCY BRAKE AND SHUT IT OFF. IT JUST HAPPENED AGAIN AS I WAS COMING UP MY SUBURBAN 35MPH STREET. I GOT TO APPROXIMATELY 20MPH WHEN IT WOULDN'T ACCELERATE FURTHER. I BUCKED AND CHOKED, RPM'S JUMPING UP AND DOWN THE LAST 100 YARDS. I TURNED INTO MY DRIVEWAY AT AN IDLING RATE AND IT TOOK OFF LIKE A SHOT. I PRESSED THE BRAKE AND IT STILL KEPT ACCELERATING. IF I HADN'T TURNED THE WHEEL, I WOULD HAVE DRIVEN THROUGH MY GARAGE. THIS IS NOT AN ISOLATED INCIDENT. I SUFFER FROM IDIOPATHIC CARDIOMYOPATHY AND CKD, THESE INCIDENTS HAVE CAUSED ME TO BE UNABLE TO BREATHE AS MY HEART WAS BEATING SO FAST. THIS MUST BE ADDRESSED IMMEDIATELY!
NHTSA complaint #11390758 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING ON NORMAL PAVED ROAD, NO EXCESSIVE BUMPS) AT AROUND 40 MPH, THE FUEL TANK BRACKETS (STRAPS) BROKE AND THE FUEL TANK FELL TO THE GROUND. I HEARD IT RIGHT AWAY AND ONLY DROVE AN ADDITIONAL FEW SECONDS TO A SAFE PLACE TO PULL OFF THE ROAD (NOT KNOW WHAT INITIAL HAPPENED - THOUGHT SOMETHING WAS CAUGHT IN THE WHEEL WELL). WHEN I NOTICED THE PROBLEM, I IMMEDIATELY TURNED OFF THE VEHICLE AND CALLED FOR A TOW TRUCK. WHILE WAITING, I CLEARLY NOTICED THE TANK STRAPS WERE RUSTED AND FAILED. ALSO WHILE WAITING FOR THE TOW TRUCK, I SEARCHED TO SEE IF OTHERS HAD A SIMILAR ISSUE. I FOUND THAT RAM DOES HAVE A RECALL FOR THIS EXACT ISSUE, BUT IT DOESN'T COVER THE YEAR OF MY TRUCK. CLEARLY THE YEARS AFFECTED NEED TO BE EXPANDED AS MY VEHICLE HAD THE EXACT FAILURE THAT THE RECALL ADDRESSED. THIS INCIDENT OCCURRED ON OCTOBER 4, 2020 AT APPROXIMATELY 12:15 IN THE AFTERNOON ON RTE 122 IN BLACKSTONE MA JUST SOUTH OF THE MILLVILLE BORDER. NO POLICE EVER PASSED OR STOPPED BY. NO OTHER VEHICLES WERE INVOLVED.
NHTSA complaint #11362964 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THERE ARE TWO ISSUES AT HAND HERE. ONE IS THE FUEL PUMP FUSE/RELAY. IT WENT OUT BUT CANT BE FIXED WITHOUT REPLACING THE ENTIRE FUSE BOX AS IT IS INTERNALLY WITHIN FUSE BOX. I DID A BYPASS AND REPLACED FUEL PUMP, BUT I STILL HAVE CODES RELATED TO FUEL SYSTEM HAVING A LEAK. WHEN THIS ISSUE HAPPENED, MY WIFE WAS LEFT STRANDED AS THE TRUCK WOULDN'T TURN ON. ALSO, ON A DIFFERENT NOTE, I NOTICED MY TRAILER BRAKE LIGHT COMING ON SAYING IT IS DISABLE AND FLASHES ON AND OFF AS I AM DRIVING. NOT SURE IF THIS IS RELATED TO THE ELECTRICAL ASPECT OF IT. THE OTHER WAS ON ENGINE. I HAVE A 2011 RAM 2500 5.7 4X4. IT STARTED WITH HAVING A CYLINDER 1 MISFIRE. I REPLACED SPARK PLUGS AND COILS. STILL HAD ISSUE AND AFTER SOME RESEARCH, I FOUND OUT THAT THE VALVE STEM/SPRING IN ENGINE HEAD BREAK AND CAUSE THE LIFTERS AND CAMSHAFT TO RUB AND RELEASE METAL SHAVINGS THROUGH OUT ENGINE. WHILE THIS WAS MESSED UP, I WOULD NOTICE THE TRUCK WOULD SHAKE VERY HARD AS I APPROACHED A CERTAIN SPEED LIMIT. I TOOK TRUCK TO DODGE DEALERSHIP TO VERIFY RESEARCH AND IT WAS CONFIRMED. I WAS TOLD I NEEDED A NEW ENGINE. SO I REPLACED ENGINE. TOTAL BILL WAS OVER 7500 FOR PARTS AND LABOR.
NHTSA complaint #11342669 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
DRIVING DOWN THE ROAD WONT ACCELATE THEN LOOSE POWER , THEN AFEW A FEW MINUTES DRIVES GREAT THEN NEVER KNOW WHEN IT WILL NOT ACCELATE DRANGE LOSING POWER LIKE THAT
NHTSA complaint #11340058 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2007 DODGE RAM 2500. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE ODOR OF DIESEL FUEL WAS PRESENT INSIDE THE CABIN WHICH HAD CAUSED RESPIRATORY PROBLEMS FOR THE DRIVER. THE CONTACT INDICATED THAT THE ODOR WAS MORE PRESENT WHILE THE ENGINE WAS IDLING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER LENOIR CITY CHRYSLER (1206 EAST BROADWAY, LENOIR CITY, TN.) WHO REPLACED THE BOLTS ON THE EGR COOLER BUT THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 35,000.
NHTSA complaint #11319910 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
MY TRUCK IS ONLY USED FOR TOWING A FIFTH WHEEL, THUS THE LOW MILEAGE. ON A TRIP, THE TRUCK STALLED WITH NO WARNING ON THE FREEWAY, LOST POWER, POWER BRAKES AND POWER STEERING IN THE 2ND FROM RIGHT LANE. I WAS BARELY ABLE TO PULL IT OVER AND STOP, IN AN UNSAFE AREA. 4 HRS LATER A TOW FOR TRUCK AND 5TH WHEEL WAS ARRANGED. THE TACOMA DODGE DEALER REPLACED THE LIFT FUEL PUMP WITH AN IN TANK LIFT FUEL PUMP. APPARENTLY THE BLOCK MOUNTED PUMP "ALWAYS FAILS AROUND 70K MILES", WHICH IS WHAT MY TRUCK HAS LOGGED. THE HEAT KILLS THE PUMP. I PAID $2106.47 FOR THE REPAIR. THE NEW PUMP FAILED IN LESS THAN 6 MONTHS OR 2K MILES. THE EVERETT DWAYNE LANE DEALER HAS THE TRUCK NOW FOR TWO WEEKS, AND CANNOT GET THE WARRANTED PUMP REPLACED FOR ANOTHER 2 WEEKS DUE TO BACK ORDER FROM MOPAR. I BELIEVE THE PUMP TO BE A DEFECT CAUSING EXTREME SAFETY HAZARD, AS NO WARNING LOSS OF POWER STEERING AND BRAKES ARE AFFECTED. SENIORS OFTEN DRIVE RV'S, MANY WOULD NOT BE ABLE PHYSICALLY TO HANDLE THE RIG WITH THIS FAILURE. EVENTUALLY A DEATH WILL OCCUR, AND PROBABLY MANY ALREADY HAVE THAT I AM UNWARE OF. RECALL SHOULD BE IMMEDIATE. SINCERELY, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CW
NHTSA complaint #11170035 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
THE EMISSIONS CHECK ENGINE LIGHT CAME ON AND WAS DIAGNOSED AS A OVERLAY WIRING HARNESS THAT WAS FAULTY AND NEEDED TO BE UPGRADED. THIS VEHICLE ONLY HAS 67000 MILES ON IT AND THIS ITEM HELPS CONTROL THE DIESELS EMISIONES. IT SHOULD BE COVERED BY THE FACTORY FOR THE 100,000 MILES AS STATED. UPON CONTACTING FCA THEY REFUSED TO HELP IN ANY WAY TO COVER COST OF REPAIRS. THIS REPAIR IS HAPPENING ON MULTIPLE DIESEL RAMS . I ONLY ASK THAT FCA BE HELD RESPONSIBILITY FOR VEHICLES THAT PRODUCE AND SELL
NHTSA complaint #11169967 — an unverified report by a vehicle owner.
FUEL SYSTEM, DIESEL
TL* THE CONTACT OWNS A 2012 RAM 2500. THE CONTACT STATED THAT ALL THE WARNING INDICATORS ILLUMINATED AND THE GEAR SHIFTER FAILED TO SHIFT INTO PARK. THE CONTACT USED THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO LANDERS CHEVROLET OF NORMAN (1221 ED NOBLE PKWY, NORMAN, OK 73072, 405-321-7021), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT SHE WAS UNAWARE OF NHTSA CAMPAIGN NUMBERS: 14V635000 (ENGINE AND ENGINE COOLING, FUEL SYSTEM, DIESEL), 15V459000 (AIR BAGS) ,AND 17V821000 (POWER TRAIN). THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #11119573 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
WHILE DRIVING DOWN HIGHWAY GASOLINE STARTED SPEWING UNDER PRESSURE FROM TOP OF FUEL PUMP, PULLED INTO PARKING LOT AWAY FROM OTHER VEHICLES AND WAITED FIVE TO TEN MINUTES BEFORE GASOLINE STOPPED SPRAYING OUT. I HAD TO HAVE IT TOWED HOME WHERE I COULD CHECK TO FIND OUT IF IT WAS ONLY A RUBBER HOSE AS I EXPECTED OR SOMETHING ELSE. I FOUND OUT IT WAS A FITTING AT TOP OF THE FUEL PUMP WHICH LOOKS LIKE METAL CONNECTOR WHERE THE GASOLINE WAS SPRAYING OUT OF A PIN HOLE, I LOST ABOUT 5 GALLONS OF GAS IN 14 MILES OF HIGHWAY DRIVING.
NHTSA complaint #11110708 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TRUCK DIES WHILE DRIVING AND MAKES IT EXTREMELY HARD TO STEER ! SEEMS TO BE SOME SORT OF FUEL PROBLEM ! THIS HAS BEEN ONGOING FOR SEVERAL YEARS AND I DON'T TRUST IT TO ATTEMPT TO DRIVE IN TRAFFIC TO A DEALER FOR REPAIRS ! THE TRUCK CURRENTLY HAS APPROX. 87,000 ORIGINAL MILES ON IT ! PROBLEM SEEM TO START SHORTLY AFTER LAST DEALER VISIT IN 2008 FOR REPLACEMENT OF A/C DUCTING UNDER DASH ! DEALER SHUT DOWN RIGHT AFTER OUR PRESIDENT TOOK OFFICE, AS DID MANY OF THE LOCAL DODGE DEALERS ! TO ME, IT ACTS AS IF THE FUEL JUST SHUTS OFF. HARD TO RESTART OR STEER - DEFINITELY A SAFETY HAZARD ! WHILE SURFING THE INTERNET FOR LIKE COMPLAINTS, MOST ALL COMPLAINTS OF THE SAME NATURE, SAY THAT DODGE IS AWARE OF THE PROBLEM AND WILL DO NOTHING ! I'M A 100 % SERVICE CONNECTED DOUBLE AMPUTEE, AND NEED THIS VEHICLE FOR TRANSPORTATION AND TRAVEL TO THE VA HOSPITAL 45 MILES AWAY FROM WHERE I LIVE ! I CAN'T AFFORD ANOTHER VEHICLE AT THIS TIME.
NHTSA complaint #11074695 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1992 DODGE RAM 2500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 93E034000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. WHILE DRIVING, THE THROTTLE WAS RELEASED, BUT THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT CALLED TURLOCK CHRYSLER DODGE JEEP RAM AT (209) 250-5800 (LOCATED AT 1600 AUTO MALL DR, TURLOCK, CA 95380) AND WAS INFORMED THAT THE PARTS WERE TOO EXPENSIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS UNAVAILABLE. PARTS DISTRIBUTION DISCONNECT.
NHTSA complaint #11064871 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
I STOPPED AT A GAS STATION AND WAS FILLING MY VEH. WITH GAS AND IT BEGAN TO VIGOROUSLY SPRAY OUT OF THE FILLER NECK WHERE THE GAS CAP FITS AND THE STATION'S FILLER NOZZLE, ALL OVER MY SKIN, CLOTHS, THE SIDE OF THE VEH. AND THE GROUND. THIS WAS A GUSHER OF GAS SPRAYING OUT WITH FORCE AND WOULD NOT LET ME FILL THE VEH.! THIS HAS HAPPENED ON SEVERAL OF THE DODGE RAM TRUCKS AND IS COVERED ON ALL MODELS EXCEPT MINE. THE DEALER TELLS ME IT IS RECALL# X49 ON OTHER TRUCKS ALL AROUND MY VIN # AND AGE BUT NOT MINE. THIS A BIG FIRE ISSUE AND IF OTHER TRUCKS DO IT AND GET FIXED WHY IS MINE LESS LIKELY TO CATCH FIRE THIS HAS HAPPENED TO ME SEVERAL TIMES AND I HAVE HAD TO FILL IT FROM A CAN WITH A FUNNEL TO BE ABLE TO DRIVE. THIS NEGATES ANY EVAPORATIVE EMISSION CONTROLS I HAVE. PLEASE HELP ME!
NHTSA complaint #11064742 — an unverified report by a vehicle owner.