51 of the 4,040 complaints filed about the Dodge RAM 3500 are about the wheels — 1% of everything owners reported. The worst model year for it is 2012.
51
Complaints
1%
Share of all complaints
3
Crashes
0
Fires
WHEELS
Drivers side rear wheel broke loose from hub and bounced into the opposing lane of traffic.
NHTSA complaint #11687970 — an unverified report by a vehicle owner.
WHEELS:LUGS/NUTS/BOLTS/STUDS
The contact owns a 2012 Ram 3500. The contact stated that after driving at an undisclosed speed, he stopped at the gas station and went inside to pay for fuel; however, when the contact returned to the vehicle, he became aware that the rear passenger’s side wheel was missing five studs. The contact stated that he was able to safely drive the vehicle to the dealer, where the wheel was inspected and the dealer was able to diagnose the failure; however, the vehicle was not repaired. The contact stated that there was a previous safety recall for the vehicle, but when the vehicle was taken for the recall repair, the recall repair was not completed; the wheels were only inspected. The manufacturer was made aware of the failure; however, the contact stated that the manufacturer originally approved completing the repair as a recall repair and then declined the approval. The failure mileage was approximately 307,000.
NHTSA complaint #11536453 — an unverified report by a vehicle owner.
WHEELS:LUGS/NUTS/BOLTS/STUDS
The contact owns a 2012 Ram 3500. The contact stated while driving 60 MPH, there was an abnormally roaring sound coming from the vehicle. The contact stated that while slowing down, the rear wheels detached from the wheel studs with the lug nuts. The vehicle was towed to the dealer and the contact was informed that the lug nuts were torqued too tight on the studs. The contact referenced NHTSA Campaign Number: 21V398000 (Wheels). The vehicle was repaired. The contact stated that he also noticed that the lug nuts on the front wheels were missing. The dealer and the manufacturer were notified of the failure. The contact was informed that the repair would be an out-of-pocket expense. The failure mileage was 247,000.
NHTSA complaint #11475949 — an unverified report by a vehicle owner.
WHEELS
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
WHEELS
This recall N62 13V-528 was never done by Duwanne Lanes Everett WA even though I was told by the dealership service team that they had done this recall as requested while they had my truck for over 3mo ths time. On April 3 ,2022 my vehicle had a cautostraphic failure of my steerwheell column & caused my front left tire to break totally off the front steering stabilizer front ball joint tie rod end pitman arm the wheel was free spinning .I had no steering control at all while driving 65 mph on I5 in the center lane. It is sheer luck that I was able to get truck off the freeway without being injured. I think Duanne Lanes of Everett, Wa (RECALL REMEDY INCIDENT) TS
NHTSA complaint #11460822 — an unverified report by a vehicle owner.
WHEELS
The contact owns a 2012 Ram 3500. The contact received notification for NHTSA Campaign Number: 21V398000 (Wheels) however, the part to do the recall repair was unavailable. The dealer was made aware of the issue and it was confirmed that the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11428084 — an unverified report by a vehicle owner.
WHEELS
While driving down the highway, 7 of 8 lug studs of the right front wheel spontaneously broke off. Vehicle became difficult to control and steer. The one remaining lug stud kept the wheel on long enough to pull onto the shoulder of the road. This was a heavily travelled interstate highway. My safety and the safety of other motorists was at high risk. Broken lug studs are available for inspection. All of them broke at the location where the threads end at the shoulder of the bolt. I had recently performed brake service and the wheels were mounted and properly torqued to manufacturer specifications. No police report or dealer inspection. I made the repairs. No prior warning of the problem. This is identical to the problem a friend had with his Ram dually, that is now in a recall. Part number is 6509866AA. I have owned this vehicle since it was new.
NHTSA complaint #11420179 — an unverified report by a vehicle owner.
WHEELS
TL* THE CONTACT OWNS A 2008 DODGE RAM 3500. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD AND RESUMED DRIVING TO HIS RESIDENCE. IN ADDITION, EACH TIME THE VEHICLE DROVE OVER A BUMP, THE FRONT END SHOOK VIOLENTLY AND THE TIRES WOBBLED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.
NHTSA complaint #11076672 — an unverified report by a vehicle owner.
WHEELS
RELEASED THE EMERGENCY BRAKE WHEN GETTING READY TO START ROLLING WAS TOWING A TRAILER. HEARD A SNAP AFTER ROLLING A FEW FEET, THE EMERGENCY BRAKE DID NOT DISENGAGE WHEN RELEASED AND THE BACKING PLATE ON THE CALIPER SNAPPED OFF. I BELIEVE THE COLD FREEZING TEMPS TIRED OUTSIDE AFFECTED THE ENGAGEMENT MECHANISM AND PREVENTED IT FROM ACTUALLY RELEASING THE EMERGENCY BRAKE .
NHTSA complaint #11074873 — an unverified report by a vehicle owner.
WHEELS
TL-CONTACT OWNS A 2011 DODGE RAM 3500..... COMPLAINT...TIRES...GENERAL AMERITRAX TIRES.... TREADING SPLIT APART ON FRON DRIVERS SIDE TIRE AND TIRE BLEW OUT CAUSING MAJOR DAMAGE TO VEHICLE ON MAIN INTERSTATE AT 70MPH.... NO RECALL ON AMERITRAC TIRES AT THIS TIME. DECEMBER 11TH 2017 TIRE BLEW OUT ON MAIN INTERSTATE.
NHTSA complaint #11054869 — an unverified report by a vehicle owner.
WHEELS
ALCOA 17" RIMS CRACKED IN 4 PLACES ON DRIVER SIDE STEER. OTHER RIMS BEGINNING TO CRACK. HAD TO REPLACE ALL 4 ALCOA RIMS.
NHTSA complaint #11024269 — an unverified report by a vehicle owner.
WHEELS:HUB
TL* THE CONTACT OWNS A 2012 RAM 3500. WHILE DRIVING APPROXIMATELY 70 MPH AND TOWING A 2017 WOOD DECK TRAILER FMCW-11000-20S, THE CONTACT HEARD A BANGING NOISE UNDERNEATH THE FLOORBOARD. SUDDENLY, THE FRONT DRIVE SHAFT AND TRANSFER CASE SEPARATED AND BLEW UP. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT PULLED OVER TO INSPECT THE VEHICLE AND WAS INFORMED THAT HIS HUBCAP FELL OFF. WHILE ATTEMPTING TO SHIFT THE GEAR INTO DRIVE, THE GEAR SHIFTER FAILED. UPON FURTHER INSPECTION OF THE VEHICLE, THE CONTACT NOTICED THAT FLUID LEAKED ONTO THE GROUND FROM UNDERNEATH THE VEHICLE AND THAT THE TRANSFER CASE AND DRIVE SHAFT WERE GONE. THE VEHICLE WAS TOWED TO KING CITY CHRYSLER CENTER (1603 BROADWAY ST, MT VERNON, IL 62864 (618) 242-6600) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS CRACKED, THE AXLE WAS COMPROMISED, AND THE TRANSMISSION, FRONT DRIVE SHAFT, TRANSFER CASE, ENTIRE FRONT AXLE, FUEL LINES, TRANSMISSION WIRING HARNESS, SHIFT CABLE, AND TRANSMISSION COOLER LINES ALL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 127,900.
NHTSA complaint #11023296 — an unverified report by a vehicle owner.
WHEELS
HAPPENED ON BOTH SIDES 2 MONTH APART. LOUD BANG AND RUMBLE. INSIDE TIRE, TREAD CAME OFF OF TIRE. DAMAGED INSIDE OF WHEEL WELL, RUNNING LIGHTS, FENDERS ON THE DUALLY, METAL SUPPORTS ON FENDER. NEVER HAD THIS HAPPEN IN 30+ YEARS OF TOWING AND DRIVING TRUCKS.
NHTSA complaint #11013392 — an unverified report by a vehicle owner.
WHEELS
TL* THE CONTACT OWNS A 2010 DODGE RAM 3500. WHILE DRIVING APPROXIMATELY 60 MPH IN THE LEFT LANE, THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE FRONT TIRES. THE FRONT DRIVER'S SIDE TIRE BLEW OUT AND, WHILE COASTING OVER TO THE SIDE OF THE ROAD, THE SUSPENSION BECAME DAMAGED FROM THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE COSMETIC DAMAGES WERE REPAIRED. THE VEHICLE WAS NOT INSPECTED AND DIAGNOSED BY AN AUTHORIZED DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 28,000.
NHTSA complaint #11001998 — an unverified report by a vehicle owner.
WHEELS
ON FREEWAY GOING OVER EXPANSION JOINTS ENCOUNTERED FOUR SEPARATE TIMES SEVERE STEERING WHEEL SHAKING AND BOUNCING, I HAD TO BRING THE TRUCK TO AN ALMOST COMPLETE STOP TO GET IT TO QUIT! TRAVELING AT 75 MPH AND 60 ON THE FREEWAY ITS SOME THING THATS VERY UNSAFE TO HAVE HAPPEN.
NHTSA complaint #10991778 — an unverified report by a vehicle owner.
WHEELS
WHILE DRIVING HOME FROM WORK ONE EVENING MY TRUCK STARTED MAKING THE MOST AWFUL GRINDING SOUND COMING FROM THE FRONT PASSENGER TIRE. THEN MY ABS LIGHT AND SERV 4WD LIGHT CAME ON THE DASH. A FEW SECONDS LATER THE TUCKED BOBBLED AND WEAVED AND I COULD NO LONGER STEER IT. WHEN I GOT OUT TO LOOK AT THE PROBLEM THE WHEEL ITSELF WAS RESTING ON THE HUB ASSEMBLY. PREVIOUS TO THIS I'VE HAD TO REPLACE FRONT END PARTS LIKE CRAZY. NEW BALL JOINTS AND I JOINTS ANNUALLY. BRAKES TWICE A YEAR, AND IT WILL EAT UP TIRES ON THE FRONT. ALSO THE TRUCK WILL NOT STAY ALIGNED. I'VE CONTACTED CHRYSLER AND FIRST THEY WERE VERY HELPFUL, BUT THEN THEY STARTED TO GIVE ME THE RUN AROUND. I'VE HAD TO HAVE THEIR TIE ROD END RECALL FIXED SEVERAL TIMES AS WELL.
NHTSA complaint #10970837 — an unverified report by a vehicle owner.
WHEELS
ALUMIMUM WHEEL CRACKING CRACKED IN MAY OR JUNE 2016 AND IN NOV. 2016
NHTSA complaint #10926675 — an unverified report by a vehicle owner.
WHEELS
WHILE DRIVING AT SPEEDS BETWEEN 50-70 MPH I HAVE RUN ACROSS SMALL BUMPS OR HOLES THAT CAUSE EITHER FRONT WHEEL TO SHAKE UNCONTROLLABLY CAUSING ME TO HAVE TO REDUCE SPEED DRAMATICALLY OR EVEN STOP TO GET IT BACK UNDER CONTROL. I UNDERSTAND THIS IS CALLED THE "DODGE DEATH WOBBLE".
NHTSA complaint #10908755 — an unverified report by a vehicle owner.
WHEELS
DRIVING DOWN THE FRWY AT REQUIRED SPEED WHEN RT REAR PASS TIRE BLEW CAUSING EXTENSIVE DAMAGE TO THE WHEEL, RT REAR PANEL & TAILPIPE. THIS TIRE HAD 3,000 MI. ON IT & WE HAD CHKD PSIG ON ALL TIRES JUST PREVIOUS TO THE BLOWOUT. THIS TIRE WAS A LT265/70R-17/10 TERRAMAX HT ALL POSITION OWL MADE BY DYNAMIC TIRE. LES SCHWAB REPLACED IT WITH ONE JUST LIKE IT. WE HAD A 4,000LB ARCTIC FOX CAB OVER CAMPER ON THE TRUCK AT THE TIME. DYNAMIC STATES THERE IS NOT ENOUGH EVIDENCE OF POOR QUALITY OR ANYTHING ELSE THAT WOULD NAME THEM AS THE RESPONSIBLE PARTY.
NHTSA complaint #10903373 — an unverified report by a vehicle owner.
WHEELS
THE WHEEL STUDS BREAK WHENEVER I'M CHANGING TIRES, I'VE REPLACED 7 TOTAL. I HAVE TO PUT THEM ON VERY GENTLY THEN I TORQUE DOWN BY HAND. I RUN A FLEET OF TRUCKS AND DO MECHANIC WORK. THIS IS THE FIRST VEHICLE I'VE HAD TO DO THIS ON. RIGHT NOW I'M SITTIN ON THE SIDE OF THE ROAD BECAUSE MY RIGHT/REAR TIRE FELL OFF DUE TO ALL MY STUDS BREAKING. I HAVE HEARD OF OTHER RAM OWNERS HAVING ISSUES, THE DEALER SAID THAT THEY AND I'M OVER TIGHTENING BUT I'VE NEVER HAD THIS BEFORE. THESE ARE LUG NUTS... COME ON RAM, GET IT TOGETHER AND DO A RECALL. THIS IS A SAFETY CONCERN. IF I WERE ON THE HIGHWAY WITH A MOTORCYCLIST NEXT TO ME HE/SHE COULD HAVE DIED. I WAS MOVING 57MPH WHEN IT FELT LIKE I WAS GOING INTO A DIP AND THEN I SAW SPARKS FROM MY ROTOR, AND SAW MY TIRE/RIM GO FLYING OUT OF THE DITCH. IT PASSED ME AND NOW IS SITTING IN THE FIELD. IF I WERE HAULING A TRAILER IT WOULD HAVE BEEN TERRIBLE ALSO.
NHTSA complaint #10839346 — an unverified report by a vehicle owner.