Owners have filed 240 complaints
about the 2005 Dodge RAM 3500 with NHTSA between 2004 and 2025.
The largest single group is the steering.
Across this model's run it ranks 4 of 20 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 60
Against the median year of the Dodge RAM 3500. 50 means typical for this
model; 100 means roughly double.
Severity — 100
25% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 40
24% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Automatic Transmission
2559.5%
Gear BOX (Other Than Rack AND Pinion)
49.5%
TIE ROD Assembly
49.5%
Diesel
24.8%
Column
24.8%
Engine
24.8%
Front
24.8%
Integrated Trailer Brake Control
12.4%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
179.8%
10,000 – 24,999 miles
1911.0%
25,000 – 49,999 miles
148.1%
50,000 – 74,999 miles
2011.6%
75,000 – 99,999 miles
3721.4%
100,000 – 149,999 miles
4224.3%
150,000+ miles
2413.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2004peak 9Dec 2025
NHTSA investigations into the 2005 Dodge RAM 3500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
AQ14003Opened 20 Oct 2014Closed 16 May 2016STEERING:LINKAGES:TIE ROD ASSEMBLY
Chrysler's execution of 13V-528 & 529
RMD opened this audit query (AQ) investigation in order to better understand and evaluate Chrysler's process(es) for timely and efficient execution of its safety recall campaigns, including its oversight and management of its parts division Mopar.Prior to opening this investigation, RMD had raised concerns with the company related to its execution of two safety recalls, 13V-528 and 13V-529, both of which involved safety defects that could cause the involved vehicles, FCA?s heavier Dodge Ram trucks, to lose steering control suddenly and without warning.Specifically, RMD inquired about the avail...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14013Opened 19 May 2014Closed 23 Dec 2014ELECTRICAL SYSTEM:IGNITION:SWITCH
Clutch Interlock Switch Malfunction
On December 16, 2104, Chrysler Group LLC submitted a Safety Recall Report to NHTSA describing a defect in the clutch ignition interlock switches in approximately 66,819 model year (MY) 2006 through early-2007 Dodge Ram Trucks, Dodge Dakota, and Mitsubishi Raider vehicles equipped with manual transmissions and built between July 1, 2005 and July 31, 2006 (NHTSA Recall No. 14V-795, Chrysler Recall No. P80), including 38,969 MY 2006 Dodge Ram 2500 and 3500 vehicles that are part of the subject vehicle population for PE14-013.Chrysler's Safety Report states that:1) the clutch ignition interlock sw...
EA05018Opened 2 Nov 2005Closed 29 Aug 2007POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
ENGINE STALL
ANALYSIS OF THE COMPLAINT, FIELD REPORT AND WARRANTY DATA SHOWS THAT THE MAJORITY OF STALLING INCIDENTS IN THE SUBJECT VEHICLES APPEAR TO BE RELATED TO THE ENGINE CALIBRATION CONCERNS THAT DAIMLERCHRYSLER ADDRESSED WITH SERVICE BULLETINS RELEASING REVISED PCM SOFTWARE.ANALYSIS OF THE COMPLAINTS AND ODI'S SURVEY OF OWNERS OF VEHICLES THAT RECEIVED ENGINE MANAGEMENT SOFTWARE UPDATES UNDER TSB #18-013-05 SHOW THAT THESE STALLING INCIDENTS HAVE THE FOLLOWING CHARACTERISTICS: - THEY OCCUR AT LOW SPEEDS, OFTEN DURING PARKING LOT ORDRIVEWAY MANEUVERS; - THEY OCCUR DURING DECELERATIONS, SUCH AS BRAKIN...
PE05027Opened 16 May 2005Closed 3 Nov 2005POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
ENGINE STALL
ON MAY 16, 2005,ODI OPENED PRELIMINARY EVALUATION PE05-027 TO INVESTIGATE COMPLAINTS OF ENGINE STALLING IN MODEL YEAR 2004-05 DODGE DURANGO SUVS AND RAM 1500 SERIES PICKUPS EQUIPPED WITH THE 5.7L V8 ENGINE.INFORMATION PROVIDED BY DAIMLERCHRYSLER DURING PE05-027 INDICATED THAT A LARGE PERCENTAGE OF THE COMPLAINTS ARE RELATED TO AN IDLE UNDERSHOOT CONDITION THAT MAY CAUSE THE ENGINE TO STALL DURING TURNING MANEUVERS.IN FEBRUARY 2005, DAIMLERCHRYSLER REVISED THE POWERTRAIN CONTROL MODULE SOFTWARE IN PRODUCTION VEHICLES AND ISSUED A TECHNICAL SERVICE BULLETIN (TSB 18-013-05) RELEASING THE NEW SOFT...
EA04025Opened 26 Aug 2004Closed 22 Dec 2005POWER TRAIN:AUTOMATIC TRANSMISSION
FALSE PARK
THE SUBJECT VEHICLES ARE HEAVY DUTY PICKUP TRUCKS WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS COMMONLY USED FOR COMMERCIAL AND WORK PURPOSES.A COLUMN MOUNTED SHIFT LEVER IS USED FOR GEAR SELECTION AND AN ELECTRONIC PRNDL ON THE INSTRUMENT PANEL PROVIDES GEAR POSITION INFORMATION TO THE DRIVER.THE SUBJECT VEHICLES ARE ALSO EQUIPPED WITH A BRAKE-TRANSMISSION SHIFT INTERLOCK THAT PREVENTS THE SHIFT LEVER FROM BEING MOVED FROM THE PARK POSITION (WHEN THE ENGINE IS ON) UNLESS THE BRAKE PEDAL IS DEPRESSED AND AN IGNITION-SHIFT INTERLOCK THAT PREVENTS KEY REMOVAL UNLESS THE TRANSMISSION IS IN THE...
Recalls on the 2005 Dodge RAM 3500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
14V770000
AIR BAGS
Chrysler Group LLC (Chrysler) is recalling certain model year 2004-2005 Dodge Ram 1500, 2500, and 3500, 2004-2005 Dodge Durango, 2005 Dodge Dakota, 2005 Dodge Magnum and 2005 Chrysler 300, 300C and 300 SRT8 vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
13V528000
STEERING:LINKAGES:TIE ROD ASSEMBLY
Chrysler Group LLC (Chrysler) is recalling certain model year 2003-2008 Dodge RAM 2500 4x4 and 3500 4x4, model year 2007-2008 Dodge RAM 3500 4x2 Cab Chassis and model year 2006-2008 Dodge RAM 1500 Mega Cab 4x4 trucks manufactured February 12, 2002, through February 13, 2008. The left tie rod assembly may break.
Risk: A failure of the tie rod assembly may result in a loss of steering control, increasing the risk of a crash.
11V350000
STEERING:LINKAGES:TIE ROD ASSEMBLY
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 2500/3500 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; MODEL YEAR 2008-2011 DODGE RAM 3500 CAB CHASSIS 4X2, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH MARCH 28, 2011; AND MODEL YEAR 2008 DODGE RAM 1500 MEGA CAB 4X4, MANUFACTURED FROM FEBRUARY 14, 2008, THROUGH AUGUST 15, 2008, BECAUSE THE LEFT TIE ROD BALL STUD MAY FRACTURE. THIS CONDITION TENDS TO OCCUR DURING LOW SPEED PARKING LOT TYPE MANEUVERS WHEN THE CUSTOMER IS MAKING A TIGHT TURN. ADDITIONALLY, MODEL YEAR 2003-2008 DODGE RAM 2500/3500 VEHICLES MAY HAVE RECEIVED THE AFFECTED TIE ROD ASSEMBLY AS A REPLACEMENT PART DURING NORMAL SERVICE.
Risk: THIS CONDITION COULD RESULT IN THE POTENTIAL LOSS OF DIRECTIONAL STABILITY IN THE LEFT HAND FRONT WHEEL, INCREASING THE RISK OF A CRASH.
10E013000
STEERING:GEAR BOX:SHAFT PITMAN
FABTECH IS RECALLING CERTAIN AFTERMARKET REPLACEMENT PITMAN ARMS, P/NOS. FTS93001 AND FT44039, INSTALLED FOR USE ON CERTAIN 2003 THROUGH 2008 DODGE 2500 4WD, 3500 4WD, AND 1500 4WD MEGA CAB VEHICLES. THE PITMAN ARM CAN FRACTURE AND BREAK AWAY FROM THE STEERING BOX CAUSING TOTAL LOSS OF STEERING CONTROL.
Risk: STEERING LOSS COULD RESULT IN A VEHICLE CRASH POSSIBLY RESULTING IN PROPERTY DAMAGE, INJURY OR DEATH.
07E104000
VISIBILITY:GLASS, SIDE/REAR
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
Risk: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
07E009000
SUSPENSION
CERTAIN LKI ENTERPRISES, INC., BRAND NAME SUPERLIFT SUSPENSION, PITMAN ARMS SOLD AS REPLACEMENT EQUIPMENT FOR 2003-2007 DODGE RAM 2500 AND 3500 4X4 LIGHT TRUCKS. DUE TO INADEQUATE HEAT TREATMENT DURING PRODUCTION, THE AFFECTED PITMAN ARMS MAY DEVELOP CRACKS IN THE UPPER SPLINED ATTACHMENT ATTACHMENT TO THE STEERING OUTPUT SHAFT. MOVEMENT BETWEEN THE PITMAN ARM AND THE OUTPUT SHAFT MAY DEFORM SPLINES, RESULTING IN PREMATURE WEAR AND FATIGUE FAILURE OF THE AFFECTED PITMAN ARM.
Risk: PITMAN ARM WEAR OR FAILURE MAY LEAD TO LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
05V462000
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
ON CERTAIN PICKUP TRUCKS EQUIPPED WITH DIESEL ENGINES AND AUTOMATIC TRANSMISSIONS, IN AN ATTEMPT TO EXIT THE VEHICLE QUICKLY WITHOUT SHUTTING OFF THE ENGINE AND REMOVING THE KEY, THE DRIVER MAY INADVERTENTLY LEAVE THE AUTOMATIC TRANSMISSION SHIFT CONTROL IN INDICATED REVERSE.
Risk: THIS ERROR IS AN UNINTENDED ACTION THAT MAY RESULT IN A LACK OF TRANSMISSION PARK PAWL ENGAGEMENT AND POSSIBLY DELAYED REARWARD MOVEMENT OF THE VEHICLE.
Reports where the owner recorded a crash, a fire, an injury or a death.
Flint, TXFire
ENGINE
Driver ran over tire rubber debris causing a thud under truck. Five minutes later a very loud thud noise occurred, no warning lights on dash, driver pulled off the highway immediately and exited truck. The grass was on fire underneath the truck. Explosion occurred. The entire inside of truck was gutted. Local fire department responded and put out the fire. Texas Department of Safety refused to respond since collision not involved. The truck is at a towing company awaiting salvage and has been inspected by a mechanic.
NHTSA complaint #11535177 — an unverified report by a vehicle owner.
Flint, TXFire
FUEL/PROPULSION SYSTEM
Driver ran over tire rubber debris causing a thud under truck. Five minutes later a very loud thud noise occurred, no warning lights on dash, driver pulled off the highway immediately and exited truck. The grass was on fire underneath the truck. Explosion occurred. The entire inside of truck was gutted. Local fire department responded and put out the fire. Texas Department of Safety refused to respond since collision not involved. The truck is at a towing company awaiting salvage and has been inspected by a mechanic.
NHTSA complaint #11535177 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
WHEELS
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
STEERING
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
SUSPENSION
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
at 86,891 milesHenry, VACrash1 injured
POWER TRAIN
TL* THE CONTACT OWNS A 2005 DODGE RAM 3500. THE CONTACT STATED THAT WHILE HER BOYFRIEND WAS DRIVING THE VEHICLE, HE HAD PLACED THE VEHICLE INTO PARK AND EXITED THE VEHICLE. WHILE HE WAS RETRIEVING ITEMS FROM THE TRUNK, HE HEARD AN ABNORMAL GRINDING SOUND EMITTING FROM THE VEHICLE AND THE VEHICLE BEGAN TO INDEPENDENTLY ROLL BACKWARDS. THE CONTACT'S BOYFRIEND ATTEMPTED OPEN THE DRIVER'S SIDE DOOR THROUGH THE WINDOW BUT FAILED TO ENTER THE VEHICLE. DUE TO THE VEHICLE BEING IN MOTION, HE DODGED OUT OF THE VEHICLE'S PATH. THE VEHICLE EVENTUALLY HIT TWO ROAD SIGNS BEFORE IT CAME TO A HALT. THE AIR BAGS DID NOT DEPLOY AS A RESULT OF THE ACCIDENT. THE CONTACT'S BOYFRIEND SUFFERED A ROAD RASH AS A RESULT OF DASHING OUT OF THE WAY OF THE VEHICLE. A POLICE REPORT WAS NOT FILED BUT A PARK RANGER ARRIVED AND TOOK PICTURES OF THE ACCIDENT. THE CONTACT'S BOYFRIEND WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE SCENE OF THE FAILURE. THE DEALER NOR THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE ACCIDENT. UPON INVESTIGATION, THE CONTACT DISCOVERED THAT THERE WAS A RECALL ON HER VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 05V462000 (POWER TRAIN). THE VEHICLE HAD YET TO BE SERVICED FOR THE RECALL. THE FAILURE MILEAGE WAS 86,891. *DT
NHTSA complaint #11353047 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 90,000 milesSaint Augustine, FL
POWER TRAIN
The contact owns a 2005 Dodge Ram 3500. The contact received notification of NHTSA Campaign Number: 05V462000 (POWER TRAIN). The vehicle was taken to a tire specialist to install larger tires on the vehicle. The contact was informed that the tires were too big and could not be installed on the vehicle. The contact stated that the employees switched the tires and added two low-drive tires on the front end and two larger tires in the rear. The contact stated that while driving 45 MPH back to the residence, the vehicle vibrated violently. The contact almost crashed three times. The contact stated that while the vehicle jerked, the steering wheel was difficult to control. In addition, the odometer failed to function as intended. The contact called the tire shop and asked the contact to drive the vehicle to the shop for an inspection. The contact had safety concerns about driving the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA complaint #11703233 — an unverified report by a vehicle owner.
at 90,000 milesSaint Augustine, FL
TIRES
The contact owns a 2005 Dodge Ram 3500. The contact received notification of NHTSA Campaign Number: 05V462000 (POWER TRAIN). The vehicle was taken to a tire specialist to install larger tires on the vehicle. The contact was informed that the tires were too big and could not be installed on the vehicle. The contact stated that the employees switched the tires and added two low-drive tires on the front end and two larger tires in the rear. The contact stated that while driving 45 MPH back to the residence, the vehicle vibrated violently. The contact almost crashed three times. The contact stated that while the vehicle jerked, the steering wheel was difficult to control. In addition, the odometer failed to function as intended. The contact called the tire shop and asked the contact to drive the vehicle to the shop for an inspection. The contact had safety concerns about driving the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA complaint #11703233 — an unverified report by a vehicle owner.
at 90,000 milesSaint Augustine, FL
ELECTRICAL SYSTEM
The contact owns a 2005 Dodge Ram 3500. The contact received notification of NHTSA Campaign Number: 05V462000 (POWER TRAIN). The vehicle was taken to a tire specialist to install larger tires on the vehicle. The contact was informed that the tires were too big and could not be installed on the vehicle. The contact stated that the employees switched the tires and added two low-drive tires on the front end and two larger tires in the rear. The contact stated that while driving 45 MPH back to the residence, the vehicle vibrated violently. The contact almost crashed three times. The contact stated that while the vehicle jerked, the steering wheel was difficult to control. In addition, the odometer failed to function as intended. The contact called the tire shop and asked the contact to drive the vehicle to the shop for an inspection. The contact had safety concerns about driving the vehicle. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.
NHTSA complaint #11703233 — an unverified report by a vehicle owner.
Spring Hill, FL
STEERING
Recall that the dealer would not fix
NHTSA complaint #11701036 — an unverified report by a vehicle owner.
Spring Hill, FL
UNKNOWN OR OTHER
Recall that the dealer would not fix
NHTSA complaint #11701037 — an unverified report by a vehicle owner.
at 18,000 milesWest Point, CA
TIRES
The contact owns a 2005 Dodge Ram 3500 equipped with Yokohama Tires, Tire Line: Geolander X A/T, Tire Size: 235/80/R17, DOT Number: XBA0PA01522. The contact stated that while exiting his driveway, the tires had trouble gaining stable traction. After a visual inspection of the tire tread, the contact became aware that the center tread on all four tires had excessive wear, potentially compromising vehicle safety. The vehicle was taken to the dealer, who informed the contact that the center tread did not provide an accurate measure of tread wear due to the step-up design, specific to the tire line. The tires were not replaced. The manufacturer was notified of the failure but provided no assistance. The tires were replacement tires. The failure mileage was 18,000.
NHTSA complaint #11555520 — an unverified report by a vehicle owner.
Flint, TXFire
ENGINE
Driver ran over tire rubber debris causing a thud under truck. Five minutes later a very loud thud noise occurred, no warning lights on dash, driver pulled off the highway immediately and exited truck. The grass was on fire underneath the truck. Explosion occurred. The entire inside of truck was gutted. Local fire department responded and put out the fire. Texas Department of Safety refused to respond since collision not involved. The truck is at a towing company awaiting salvage and has been inspected by a mechanic.
NHTSA complaint #11535177 — an unverified report by a vehicle owner.
Flint, TXFire
FUEL/PROPULSION SYSTEM
Driver ran over tire rubber debris causing a thud under truck. Five minutes later a very loud thud noise occurred, no warning lights on dash, driver pulled off the highway immediately and exited truck. The grass was on fire underneath the truck. Explosion occurred. The entire inside of truck was gutted. Local fire department responded and put out the fire. Texas Department of Safety refused to respond since collision not involved. The truck is at a towing company awaiting salvage and has been inspected by a mechanic.
NHTSA complaint #11535177 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
WHEELS
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
STEERING
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
Azle, TXCrash1 injured1 killed
SUSPENSION
May 13,2020. 11:32am Driving north, my drive side tire violently shook & suddenly gave way pulling me hard left. I struggling to keep truck in my lane but lost control of steering , the airbags also deployed. Blocking my view. The rode was a blind spot . I thought it was a tire failure. Be of the drop & hard pull to left. While the rode was curving right . I could not get truck to fallow curve. Causing truck to cross into oncoming lane. I never saw the other car . With air bags deployed. I thought I lost a tire and hit ditch was lifted up and hit ground hard. I was told I truck hit another car after crash . Hitting a car coming the other way. Causing a young women’s death. The tie rod had a clean break swing freely after break. In March 2020 had pulling or with extra movement off & on . Took to shop, they put a new sway bar on it. Seemed to help, no problems until this sudden catastrophic Paul and drop hard enough to deploy airbags. Truck is totaled but is here & available for inspection. Steve Erwin @ Scientific Analysis Inc. in Dallas TX 214 320-8686 has many pictures & Analysis. He mainly does accident recreations. He mentioned we need to find metals specialist to examine part failures.Due to failure being close to impact.
NHTSA complaint #11463292 — an unverified report by a vehicle owner.
Marysville, WA
WHEELS
This recall N62 13V-528 was never done by Duwanne Lanes Everett WA even though I was told by the dealership service team that they had done this recall as requested while they had my truck for over 3mo ths time. On April 3 ,2022 my vehicle had a cautostraphic failure of my steerwheell column & caused my front left tire to break totally off the front steering stabilizer front ball joint tie rod end pitman arm the wheel was free spinning .I had no steering control at all while driving 65 mph on I5 in the center lane. It is sheer luck that I was able to get truck off the freeway without being injured. I think Duanne Lanes of Everett, Wa (RECALL REMEDY INCIDENT) TS
NHTSA complaint #11460822 — an unverified report by a vehicle owner.
Marysville, WA
STEERING
This recall N62 13V-528 was never done by Duwanne Lanes Everett WA even though I was told by the dealership service team that they had done this recall as requested while they had my truck for over 3mo ths time. On April 3 ,2022 my vehicle had a cautostraphic failure of my steerwheell column & caused my front left tire to break totally off the front steering stabilizer front ball joint tie rod end pitman arm the wheel was free spinning .I had no steering control at all while driving 65 mph on I5 in the center lane. It is sheer luck that I was able to get truck off the freeway without being injured. I think Duanne Lanes of Everett, Wa (RECALL REMEDY INCIDENT) TS
NHTSA complaint #11460822 — an unverified report by a vehicle owner.
Marysville, WA
SUSPENSION
This recall N62 13V-528 was never done by Duwanne Lanes Everett WA even though I was told by the dealership service team that they had done this recall as requested while they had my truck for over 3mo ths time. On April 3 ,2022 my vehicle had a cautostraphic failure of my steerwheell column & caused my front left tire to break totally off the front steering stabilizer front ball joint tie rod end pitman arm the wheel was free spinning .I had no steering control at all while driving 65 mph on I5 in the center lane. It is sheer luck that I was able to get truck off the freeway without being injured. I think Duanne Lanes of Everett, Wa (RECALL REMEDY INCIDENT) TS
NHTSA complaint #11460822 — an unverified report by a vehicle owner.
Kettle Falls, WA
TIRES
LT 265 / 70 R 17 Driving at normal highway speed. No warning lamps, no messages, no other symptoms until heard a loud "bang" and steering became very difficult. Pulled over immediately to find a rear tire had exploded at edge of sidewall. The entire tread was blown off in one piece and caused damage to the vehicle. If I hadn't had a firm grip on the steering wheel before the tire blew up, I believe that I may have lost control of the truck, with possible injuries to occupants or bystanders nearby.
NHTSA complaint #11435228 — an unverified report by a vehicle owner.
at 205,000 milesNevada, IA
TIRES
The contact owns a 2005 Dodge Ram 3500 equipped with Cooper Discoverer A/T-3 tires, Tire Size: LT235/80/R17, DOT number: (UPAB1AU4513). While driving 65 MPH, the front passenger’s tire blew out. The blowout left a dent on the front passenger’s side door as well as damaged the front panel on the passenger’s side of the vehicle. The tire was then replaced with the spare. A few hours later while driving 50 mph, the front driver’s side tire also experienced a blowout. The blowout also damaged the driver’s side door as well as the front driver’s side panel. The manufacturer was notified of the failure and the contact was informed that the tires were not included in NHTSA Campaign Number: 21T002000 (Tires). The tires were not replaced. The tire failure mileage was approximately 6,000. The vehicle failure mileage was approximately 205,000.
NHTSA complaint #11426524 — an unverified report by a vehicle owner.
Bend, OR
VEHICLE SPEED CONTROL
A massive amount of people in forums have encountered the same problem. When you start the vehicle it will idle pretty rough with black smoke. If and when you press the accelerator pedal it will continue to throttle up on its own. In park or driving! FORUM POST: #1. While driving my 04 Dodge 3500 Cummins down the street, at a speed of around 45mph, all of a sudden it went to wide-open throttle. It completely caught me off guard and the first thing I did was hit the brake. It had very little effect on what was happening. In less than 1 block I was well over 70mph with the brake on in a 45mph zone. #2. I had the same exact thing happen, I was at 90 mph on a 40 mph road when I finally had to put it in neutral, the pedal had no effect on rpm as I coasted to a stop the engine sat pegged at the rev limiter, and stayed there until I shut the motor down. I did not have cruise control on or showing as ready to go into the cruise, ie cruise light on in the instrument panel. I had some codes, but not sure when. FUEL PRESSURE TOO HIGH and another I forget. It was scary with the family in the truck. waited a few minutes trying to see that all connections were tight and they were, restarted and all was back to normal. 2 complaints of 1000's. I've been in the mechanical world for 50 years. Everything from motorcycles to heavy equipment and this one took me over a year to figure out. Generally, there are no codes thrown as in mine. The fuel pressure regulator malfunctions and forces pressure on the fuel rail. This feeds the injectors too much fuel and the computer will not default and shut down. I was traveling at 55mph with a 45-foot king pin trailer on my truck. Went to accelerate a bit and took off. At 75 mph, loaded (45000 lbs) I turned the ignition off. How many people has this killed and the possible reason was driver error?
NHTSA complaint #11425292 — an unverified report by a vehicle owner.
at 86,891 milesHenry, VACrash1 injured
POWER TRAIN
TL* THE CONTACT OWNS A 2005 DODGE RAM 3500. THE CONTACT STATED THAT WHILE HER BOYFRIEND WAS DRIVING THE VEHICLE, HE HAD PLACED THE VEHICLE INTO PARK AND EXITED THE VEHICLE. WHILE HE WAS RETRIEVING ITEMS FROM THE TRUNK, HE HEARD AN ABNORMAL GRINDING SOUND EMITTING FROM THE VEHICLE AND THE VEHICLE BEGAN TO INDEPENDENTLY ROLL BACKWARDS. THE CONTACT'S BOYFRIEND ATTEMPTED OPEN THE DRIVER'S SIDE DOOR THROUGH THE WINDOW BUT FAILED TO ENTER THE VEHICLE. DUE TO THE VEHICLE BEING IN MOTION, HE DODGED OUT OF THE VEHICLE'S PATH. THE VEHICLE EVENTUALLY HIT TWO ROAD SIGNS BEFORE IT CAME TO A HALT. THE AIR BAGS DID NOT DEPLOY AS A RESULT OF THE ACCIDENT. THE CONTACT'S BOYFRIEND SUFFERED A ROAD RASH AS A RESULT OF DASHING OUT OF THE WAY OF THE VEHICLE. A POLICE REPORT WAS NOT FILED BUT A PARK RANGER ARRIVED AND TOOK PICTURES OF THE ACCIDENT. THE CONTACT'S BOYFRIEND WAS ABLE TO DRIVE THE VEHICLE AWAY FROM THE SCENE OF THE FAILURE. THE DEALER NOR THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE ACCIDENT. UPON INVESTIGATION, THE CONTACT DISCOVERED THAT THERE WAS A RECALL ON HER VEHICLE UNDER NHTSA CAMPAIGN NUMBER: 05V462000 (POWER TRAIN). THE VEHICLE HAD YET TO BE SERVICED FOR THE RECALL. THE FAILURE MILEAGE WAS 86,891. *DT
NHTSA complaint #11353047 — an unverified report by a vehicle owner.
at 178,000 milesColumbus, IN
FUEL/PROPULSION SYSTEM
AT 178,000 MILES (APPROXIMATELY), THE REAR SUSPENSION STRAP RUSTED THROUGH AND DROPPED THE REAR END OF THE DIESEL FUEL TANK TO THE PAVEMENT. THE PLASTIC TANK WAS GROUND DOWN BY MOVING OVER THE PAVEMENT AT HIGHWAY SPEEDS, BUT I WAS ABLE TO RECOGNIZE THE ISSUE BY THE UNUSUAL NOISE AND THUS STOP THE TRUCK BEFORE THE TANK RUPTURED. POTENTIAL HAZARDS INCLUDE FUEL SPILL, SMOKE, FIRE, AND VEHICLE STALL WHILE MOVING WITHOUT THE POSSIBILITY OF RESTART. FUEL TANK FIXATION TO THE VEHICLE SHOULD NOT RUST THROUGH AND FAIL DURING THE LIFETIME OF THE VEHICLE. THE FUEL TANK IS WITHIN 2 INCHES OF THE DRIVESHAFT AND WITHIN 18 INCHES OF THE EXHAUST SYSTEM.
NHTSA complaint #11350263 — an unverified report by a vehicle owner.
at 197,000 milesSouthbury, CT
VISIBILITY/WIPER
TL* THE CONTACT OWNS A 2005 DODGE RAM 3500. THE CONTACT STATED THAT WHILE DRIVING IN INCLEMENT WEATHER, THE WINDSHIELD WIPER WAS ACTIVATED BUT WAS INOPERABLE. THE CONTACT STATED THAT THE WINDSHIELD WIPERS WERE DEFECTIVE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 197,000.
NHTSA complaint #11322828 — an unverified report by a vehicle owner.
at 120,000 milesPomeroy, WA
SERVICE BRAKES
TL* THE CONTACT OWNS A 2005 DODGE RAM 3500. THE CONTACT STATED THAT THE ABS WARNING INDICATOR ILLUMINATED AND TWO PINS DETACHED FROM THE BRAKE CONTROL MODULE. THE VEHICLE WAS UNABLE TO BE DRIVEN SAFELY DUE TO THE BRAKE FAILURE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
NHTSA complaint #11228696 — an unverified report by a vehicle owner.
at 80,000 milesDayton, NV
SEATS
DRIVERS SIDE SEAT MOTOR THAT HOLDS THE SEAT FROM MOVING- SNAPPED- SO WHEN YOUY DRIVE YOU GO FORWARD OR BACKWARD AND THE TRUCK HAS 80000 MILES ON IT.
NHTSA complaint #11101627 — an unverified report by a vehicle owner.
at 112,000 milesSanta FE, TX
AIR BAGS
TAKATA RECALL. THE DEALERSHIP WANTS ME TO SIGN A WAIVER IF THEY BREAK MY DASH, THAT I AM RESPONSIBLE. I CALLED DODGE RECALL, ANF D THEY SAY THE SAME THING. WHY SHOULD I HAVE TO PAY FOR THEIR MISTAKES OR POOR WORKMANSHIP? THEY ARE TRYING TO DISCOURAGE PEOPLE FROM GETTING THE NECESSARY REPAIRS NONE TO PRESERVE CORPORATE PROFITS. I BOUGHT THIS TRUCK NEW.
NHTSA complaint #11057971 — an unverified report by a vehicle owner.
at 183,000 milesAndover, MAFire
ENGINE
ON JULY 20, 2017 FAMILY AND I WERE RIDING IN OUR METICULOUSLY MAINTAINED 2005 RAM 3500 AT HIGHWAY SPEED IN THE CAPE COD REGION OF MASSACHUSETTS. AFTER AN HOUR TRUCK RUNNING GREAT, OUTSIDE TEMP 92 DEGREES. 30 SECONDS LATER WE HAD A CATASTROPHIC EVENT WHICH PUT US ON THE SIDE OF THE ROAD.12 QUARTS OF OIL ON THE GROUND, FLAMES UNDER THE HOOD, AND A HOLE IN BLOCK. REMOVED WIFE AND DAUGHTER FROM VEHICLE, EXTINGUISHED FIRE THANKS TO A STATE TROOPER, FIRE AND POLICE APPARATUS. GIVEN THIS IS MY DAILY DRIVER AND A BUSINESS VEHICLE I WAS FORCED TO REPLACE MOTOR COSTING $18K. CUMMINS AND CHRYSLER INSPECTED VEHICLE. DID NOT INVESTIGATE CAUSE. REFUSED COPIES OF INSPECTION REPORTS. CUMMINS TIED UP VEHICLE FOR A MONTH. DELAYED REPAIR AND USE AS DAILY DRIVER AND CRITICAL BUSINESS NEED. ATTACHED CHRYSLER/CUMMINS RESPONSES SHOW NEGLIGENCE. RESEARCH HAS EXPOSED LATENT DEFECT WHEREBY DODGE APPLICATION OF CUMMINS DOES NOT USE ADEQUATE FUEL FILTRATION. RESULTS IN OVER FUELING OF THE INJECTORS THAT MELT OR HYDRO LOCK PISTONS, OVERLOADING RODS, DESTROYING BLOCK, SPILLING OF OIL, RESULTING IN FIRE. MANY ON LINE EXAMPLES OF SEVERELY DAMAGED ENGINES WELL BEFORE B50 LIFE OF 350K MILES. REPEATED REQUESTS TO ADDRESS SAFETY ISSUE THAT COULD RESULT IN SEVERE INJURY OR DEATH IGNORED. PERSONAL ENGINE INSPECTION SHOWED PUDDLED FUEL ON CRACKED PISTON 3 AND PISTON 4, INDICATING THE HYDRO LOCKED PISTON CAUSED THE ROD AND BLOCK FAILURE. REFER TO YOUTU LINK HTTPS://M.YOUTUBE.COM/WATCH?V=_BKDZXO6UNO THAT DEMONSTRATES CONSEQUENCES OF OVER FUELING. SUDDEN FAILURE ON WELL MAINTAINED VEHICLE RESULTING IN FIRE ON HIGHWAY WARRANTS ROOT CAUSE INVESTIGATION. CAUSE IS LIKELY INADEQUATE FUEL FILTRATION LATENT DEFECT.7 MICRON INSTEAD OF 3.THERE ARE NO CHRYSLER DIAGNOSTIC TOOLS OR MAINTENANCE PROCEDURES TO PROTECT THE CUSTOMER. LATENT DEFECT LIABILITY IS NOT LIMITED BY WARRANTY PERIOD. MUST ADDRESS SAFETY!
NHTSA complaint #11040197 — an unverified report by a vehicle owner.
at 237,400 milesPine Valley, CA
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 2005 DODGE RAM 3500. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A COMPLETE LOSS OF POWER WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTAKE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS REPLACED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 237,400.
NHTSA complaint #11031882 — an unverified report by a vehicle owner.