2022 Ford Bronco problems

FUEL/PROPULSION SYSTEM

Was driving on highway with cruise control set. Vehicle started slowing down, so pressed on gas pedal and no response from vehicle, had to navigate to shoulder and was unable to drive vehicle. No warning that there was any issue. Vehicle has been at dealership for a month. Low pressure fuel pump failure and no parts are available.

NHTSA complaint #11763513 — an unverified report by a vehicle owner.

POWER TRAIN

Clutch pedal went to floor and didn't return. The accumulator on part # MB3Z-7A512-A failed and broke apart causing a complete loss of brake fluid in the clutch hydraulic system rendering the clutch completely inoperable.

NHTSA complaint #11762643 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I am writing to formally complain about a serious and increasingly concerning problem with the hardtop on my 2022 Ford Bronce four-door. I began noticing cracks in the hardtop after becoming aware of numerous complaints from other Bronco owners regarding similar cracking problems. Once I knew what to look for, I inspected my Bronco and noticed cracks in the hardtop. I promptly brought the issue to the attention of my Ford dealership. Unfortunately, I was told that the vehicle had just passed the time limit of the factory warranty, even though it was well within the mileage limit of the warranty. I find it extremely frustrating that Ford’s position appears to be based on the calendar expiration of the warranty when this is a known problem (defect) that has been reported by numerous Bronco owners. More importantly, the condition of the hardtop has deteriorated significantly. Over the past several months, the cracks have become substantially worse, and I am now concerned that the hardtop could eventually fail completely. This is no longer simply a cosmetic concern. I purchased a new Ford Bronco with the expectation that the vehicle’s major structural components would remain reliable under normal use. I am requesting that Ford reconsider my case and provide full replacement of the defective hardtop at no cost to me, including parts and installation cost. I would also like Ford to consider the safety implications of allowing a hardtop with progressively worsening cracks to remain in service. I have legitimate concerns that the hardtop could fail at speed or during an accident creating hazard or injury.

NHTSA complaint #11762457 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Simply filing a complaint for the recall on the fuel pump that still has not been remedied over a year ago. I’m hearing stories of people having to replace their fuel pumps and ford not covering it even though it’s an open recall. Hoping to get more pressure on them to get a remedy. Thank you for all you do!

NHTSA complaint #11762209 — an unverified report by a vehicle owner.

SEATS

Headrest on rear passenger side will not stay up.

NHTSA complaint #11761959 — an unverified report by a vehicle owner.

SEATS

3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a used vehicle and I didn’t barrow money from to purchase this has been going on for more than a year it is ridiculous!!

NHTSA complaint #11760648 — an unverified report by a vehicle owner.

WHEELS

On August 26, 2026, my 2022 Ford Bronco experienced a serious safety related failure while I was driving. The vehicle displayed a sway bar disconnect system warning and became disabled, leaving me stranded on the side of the road. The Bronco had to be towed to a Ford dealership, where it is available for inspection. Ford previously claimed that it inspected my Bronco under a recall specifically pertaining to the sway bar system. Ford determined that the sway bar did not need to be replaced and closed the recall as completed. The vehicle has now experienced a failure involving the same system that Ford claims it previously inspected. I am concerned that the recall inspection may not have identified the problem or that the recall procedure or remedy was insufficient. The precise cause of the current failure is still being diagnosed. Approximately one and a half weeks before the incident, five replacement tires were installed by a mobile tire service. The replacement tires were the same type and size already used on the vehicle. There was no change in tire size and no tire related modification to the Bronco. Three lug nuts were also found loose following this incident. Approximately three months earlier, three lug nuts had come completely off the vehicle. Loose lug nuts were found again during a tire rotation approximately one month before this incident. I do not yet know whether the repeated loose lug nuts and the sway bar system failure are connected. This failure occurred while the vehicle was being driven, disabled the vehicle, and left me stranded. I am requesting that NHTSA document and investigate whether the sway bar recall inspection or remedy was inadequate, or whether another safety defect exists in my 2022 Ford Bronco.

NHTSA complaint #11760585 — an unverified report by a vehicle owner.

SUSPENSION

On August 26, 2026, my 2022 Ford Bronco experienced a serious safety related failure while I was driving. The vehicle displayed a sway bar disconnect system warning and became disabled, leaving me stranded on the side of the road. The Bronco had to be towed to a Ford dealership, where it is available for inspection. Ford previously claimed that it inspected my Bronco under a recall specifically pertaining to the sway bar system. Ford determined that the sway bar did not need to be replaced and closed the recall as completed. The vehicle has now experienced a failure involving the same system that Ford claims it previously inspected. I am concerned that the recall inspection may not have identified the problem or that the recall procedure or remedy was insufficient. The precise cause of the current failure is still being diagnosed. Approximately one and a half weeks before the incident, five replacement tires were installed by a mobile tire service. The replacement tires were the same type and size already used on the vehicle. There was no change in tire size and no tire related modification to the Bronco. Three lug nuts were also found loose following this incident. Approximately three months earlier, three lug nuts had come completely off the vehicle. Loose lug nuts were found again during a tire rotation approximately one month before this incident. I do not yet know whether the repeated loose lug nuts and the sway bar system failure are connected. This failure occurred while the vehicle was being driven, disabled the vehicle, and left me stranded. I am requesting that NHTSA document and investigate whether the sway bar recall inspection or remedy was inadequate, or whether another safety defect exists in my 2022 Ford Bronco.

NHTSA complaint #11760585 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a used vehicle and I didn’t barrow money from to purchase this has been going on for more than a year it is ridiculous!!

NHTSA complaint #11760648 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

3 different incidents have came up with recalls that have been going on for awhile this a working vehicle that makes my money to pay for the loans, which for over a year have not made me any money costing me to lose money out of my own pocket, ford has not been willing to work with because it’s a used vehicle and I didn’t barrow money from to purchase this has been going on for more than a year it is ridiculous!!

NHTSA complaint #11760648 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or cracks or chips while doing work they are not responsible to cover new windshield. please advise. They show on Ford recall website the recall complete, but my windshield was never removed, resealed and reinstalled. So that is a lie/fraud on All American Ford part. Please help. I have 2 other major issues with Bronco as well which are recalls that they made me pay for or did not resolve as of yet. I already paid for a middle roof panel and now front passenger roof panel must be replaced (recall 26S32) and they say it is not part of recall. And, the safety concern is the car just turned off on major highway 2 different episods one in May on NJ Turnpike I was almost hit from behind and the other was on Route 35 in Seaside Park, NJ in August. Same dealership said they can't experience it so they cannot diagnose and repair it. It is the fuel pump/loss of power issue #26V236000. the car has to be restarted and there is no warning. I am very worried about this.

NHTSA complaint #11759852 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Windshield is leaking water/rain inside vehicle. I have it at All American Ford Old Bridge,NJ, for 15 days now and they want to charge me portion $256.76 plus tax. BUt, the Bronco has recall 222c12 or 25C52. I was willing to pay not knowing that there as a recall but they said if it breaks or cracks or chips while doing work they are not responsible to cover new windshield. please advise. They show on Ford recall website the recall complete, but my windshield was never removed, resealed and reinstalled. So that is a lie/fraud on All American Ford part. Please help. I have 2 other major issues with Bronco as well which are recalls that they made me pay for or did not resolve as of yet. I already paid for a middle roof panel and now front passenger roof panel must be replaced (recall 26S32) and they say it is not part of recall. And, the safety concern is the car just turned off on major highway 2 different episods one in May on NJ Turnpike I was almost hit from behind and the other was on Route 35 in Seaside Park, NJ in August. Same dealership said they can't experience it so they cannot diagnose and repair it. It is the fuel pump/loss of power issue #26V236000. the car has to be restarted and there is no warning. I am very worried about this.

NHTSA complaint #11759852 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Fender flares (2) have detached. Flare 1: Passenger side, front wheel - it flew off while driving. Flare 2: Partially breaking / cracking off - on the drivers side, back wheel.

NHTSA complaint #11758670 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11758189 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11758189 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V455000 (FUEL SYSTEM, GASOLINE) and 26V468000 (ENGINE, ELECTRICAL SYSTEM); however, the parts to do the recall repairs were not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11758189 — an unverified report by a vehicle owner.

ENGINE

Loss of power or acceleration randomly, when pressing on the pedal. A recall was issued that it was a fuel pump failure June of 2025. One year and two months later there is still no solution to this recall. I am mostly submitting this covering all bases and am filing a complaint with Ford motor company as well. This is a serious safety concern as without warning the car basically dies so turning in front of oncoming traffic or pulling out onto a road poses great risk when the vehicle may cease functioning.

NHTSA complaint #11757928 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Loss of power or acceleration randomly, when pressing on the pedal. A recall was issued that it was a fuel pump failure June of 2025. One year and two months later there is still no solution to this recall. I am mostly submitting this covering all bases and am filing a complaint with Ford motor company as well. This is a serious safety concern as without warning the car basically dies so turning in front of oncoming traffic or pulling out onto a road poses great risk when the vehicle may cease functioning.

NHTSA complaint #11757928 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

There is a manufacture recall for the low pressure fuel pump malfunctioning #25S75/NHTSA#25V455. There has been no action by the manufacturer to remedy this issue in a timely manner. This issue has been ongoing for over 1 year now with no corrective measures.

NHTSA complaint #11756638 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford Bronco. The contact stated that while leaving the residence, the vehicle stalled on the highway. The driver was able to avoid a crash with a tractor-trailer. The check engine warning light illuminated intermittently, and a “Service Vehicle Soon” message was displayed. Additionally, there was a tool symbol displayed on the instrument panel. The vehicle was towed to a local dealer, and the contact was informed that the part needed to perform the recall repair of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); was not yet available. The manufacturer was not contacted. The failure mileage was approximately 75,000.

NHTSA complaint #11756185 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2022 Ford Bronco. The contact stated that while leaving the residence, the vehicle stalled on the highway. The driver was able to avoid a crash with a tractor-trailer. The check engine warning light illuminated intermittently, and a “Service Vehicle Soon” message was displayed. Additionally, there was a tool symbol displayed on the instrument panel. The vehicle was towed to a local dealer, and the contact was informed that the part needed to perform the recall repair of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); was not yet available. The manufacturer was not contacted. The failure mileage was approximately 75,000.

NHTSA complaint #11756185 — an unverified report by a vehicle owner.

STRUCTURE

The contact owns a 2022 Ford Bronco. The contact stated that the vehicle had experienced issues with hardtop roof panels. The hatch was cracked, and the forward removable panel had developed bubbles. The contact stated that the front driver’s side panel was chipped and detaching, and the underside of the roof was visible. The contact associated the failure with NHTSA Campaign Number: 26V299000 (Structure); however, the VIN was not included in the recall. The dealer was contacted regarding the failure, and the vehicle was repaired under warranty. The manufacturer was made aware of the failure and stated that the roof panel was not under warranty. The failure mileage was approximately 19,073.

NHTSA complaint #11755438 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11754752 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Safety Defect – Inadequate Warning and Insufficient Time to Respond to Alternator/Charging System Failure I am submitting this safety complaint regarding a dangerous condition in my 2022 Ford Bronco involving the charging system and alternator protection behavior. While driving, a warning related to the charging system/battery appeared. The message lacked sufficient clarity and urgency. The time from the warning until the 12-volt battery was fully depleted was extremely short—too brief to safely identify a location and pull completely out of traffic. Once the battery died: • The vehicle could not be placed in neutral, preventing it from being moved out of the travel lane. • There was insufficient power to operate the hazard lights. This occurred on a busy highway, leaving the vehicle disabled in traffic and creating a significant safety risk. I was fortunate it happened in daylight. Had it occurred at night without functioning hazard lights, the likelihood of a catastrophic accident would have been high. This aligns with known alternator/charging system issues on 2021-2022 Broncos addressed in Ford Technical Service Bulletin TSB 23-2238 (superseding TSB 22-2392). The combination of an unclear warning, inadequate response time, loss of neutral capability, and loss of hazard lights presents an unreasonable safety risk. I request that Ford investigate this condition, provide a permanent remedy, and improve the warning strategy so drivers receive clear, timely notice with enough opportunity to reach a safe location.

NHTSA complaint #11754647 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that while his wife was driving 70 MPH uphill, the vehicle lost drive power. Several unknown warning lights were illuminated. The driver was able to pull over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the main wiring harness had dislodged, sat across the exhaust, and was burned. The dealer determined that the main wiring harness needed to be replaced, which required the temporary removal of several components. The contact was provided a repair estimate and was advised that the failure was not covered under the recall and that the vehicle was out of warranty. The vehicle was not repaired. The contact obtained a rental vehicle out-of-pocket. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that partial assistance might be provided. The failure mileage was approximately 60,908.

NHTSA complaint #11754712 — an unverified report by a vehicle owner.