2000 Ford F-150 fuel system problems

FUEL SYSTEM, GASOLINE

The contact owns a 1991 Ford F-150. The contact stated that while attempting to accelerate from a complete stop, the vehicle was sluggish. The contact stated that the vehicle operated as needed after warming up. The contact stated upon refueling the vehicle, the gasoline would splash out of the fuel tank filler neck and onto the gas pump. There was no warning light illuminated. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 142,000.

NHTSA complaint #11662433 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BILL GRANT FORD LOCATED AT 3060 S SPRINGFIELD AVE, BOLIVAR, MO 65613, (417) 326-7671, WHERE THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). WHILE REPAIRING THE VEHICLE, THE CONTACT WAS INFORMED THAT THE FUEL TANK HAD A HOLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 207,000.

NHTSA complaint #11374873 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE THE VEHICLE WAS STATIONARY, THE FUEL TANK STRAP BECAME DETACHED FROM THE FUEL TANK AND CAUSED THE FUEL TANK TO STRIKE THE SKID PLATE OF THE VEHICLE. AS A RESULT, THE FUEL TANK WAS FRACTURED AND CAUSED FUEL TO SPILL OUT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 202,000.

NHTSA complaint #10926109 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. WHILE DRIVING APPROXIMATELY 50 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STRAPS AND FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNKNOWN.

NHTSA complaint #10919664 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE FUEL TANK STRAP FRACTURED AND SEPARATED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.

NHTSA complaint #10870370 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

WHILE SITTING STATIONARY WAITING FOR A TRAFFIC LIGHT. WHEN THE LIGHT CHANGED I BEGAN TO MOVE AND EJECTED A SPARK PLUG FROM MY 5.4L TRITON ENGINE. AFTER HEARING A LOUD POPPING NOISE AND THE CAB OF THE VEHICLE FILLED UP WITH GAS FUMES. LUCKLY I WAS CLOSE TO HOME. BUT I AM LUCKY THAT THE ENGINE COMPARTMENT DID NOT CATCH FIRE FROM GAS AND VAPORS IN THE ENGINE AREA.

NHTSA complaint #10810882 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THERE WAS A FUEL ODOR COMING FROM THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE VEHICLE WAS LEAKING FUEL FROM THE UNDERCARRIAGE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE'S FUEL TANK WAS RUSTED AND FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT WAS ALSO MADE AWARE OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) IN WHICH THE VEHICLE WAS INCLUDED, BUT THE CONTACT FAILED TO RECEIVE NOTIFICATION. THE CONTACT STATED THAT THE MANUFACTURER WOULD ONLY COVER THE REPAIR OF THE FUEL TANK STRAPS AND NOT THE FUEL TANK ITSELF. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

NHTSA complaint #10809458 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

HAVING A FUEL LEAK WHERE THE TANK IS STRAPPED TO THE VEHICLE. FORD HAS A RECALL ON THIS ISSUE, BUT UNFORTUNATELY NOT FOR MY VIN NUMBER. I EXPECT FORD TO MAKE THIS RIGHT. IT IS TOO COINCIDENTAL TO HAVE THE SAME PROBLEM BUT NOT BE COVERED FOR A RECALL. I CANNOT AFFORD IN ANY WAY THE COST OF THE REPAIRS FOR THIS PROBLEM. PLEASE ADVISE.

NHTSA complaint #10690953 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL*THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THERE WAS EXCESSIVE FUEL LEAKING FROM THE FUEL TANK. THE FAILURE OCCURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK WAS DAMAGED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 203,000.

NHTSA complaint #10690233 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH DOWN A SMALL HILL, THE FUEL TANK STRAPS FRACTURED AND CAUSED THE FUEL TANK TO DISLODGE FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL TANK STRAPS, THE FUEL TANK, AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000.

NHTSA complaint #10664568 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I REALIZE THIS IS NOT A NEW ISSUE, BUT IT NEEDS TO BE ADDRESSED. THE FIRST NOTIFICATION FROM FORD MOTOR CO. REGARDING THE 2011 RECALL FOR FAULTY GAS TANK STRAPS WAS RECEIVED THE WEEK OF OCTOBER 20TH 2014, ALTHOUGH I HAVE OWNED THE VEHICLE FOR OVER A YEAR. AN APPOINTMENT WAS MADE WITH BRONDES FORD IN MAUMEE, OHIO THE FOLLOWING WEEK. THE VEHICLE, WHICH WAS HAVING NO ISSUES AT ALL, WAS LEFT WITH ~$900 IN DAMAGE. THE FAULTY STRAPS HAD CORRODED THROUGH TO THE GAS TANK, AND SO WHEN THEY WERE REMOVED, LEFT HOLES IN THE GAS TANK. IN RESEARCHING THIS ISSUE, THIS CONSEQUENCE HAS BEEN RAMPANT AMONG THESE REPAIRS, YET NEITHER FORD NOR THEIR DEALERS' SERVICE DEPARTMENTS WILL COVER THE DAMAGE! SO A TRUCK THAT WAS IN PERFECT WORKING CONDITION WAS RENDERED USELESS. HOW CAN FORD BE RESPONSIBLE FOR THE STRAPS BUT NOT THE RESULTING DAMAGE THEY CAUSE? I GET THAT MY TRUCK IS OLD, BUT IF REPLACING THE STRAPS RUNS THE RISK OF CAUSING DAMAGE THE OWNER WILL BE LIABLE FOR, IT SHOULD BE CLEARLY OUTLINED! THE NOTION THAT ONLY THE FAULTY STRAPS ARE FORD'S LIABILITY IS NEGLIGENT. MY HOPE IS THIS ISSUE WILL BE READDRESSED WITH FORD AND THE OWNERS REIMBURSED FOR THE DAMAGES CAUSED BY FORD AND ITS AGENTS. THANK YOU.

NHTSA complaint #10661402 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT THE FUEL STRAPS AND THE FUEL TANK WERE RUSTED AND CORRODED WITH A POSSIBILITY OF FRACTURING. THE CONTACT NOTICED THAT THERE WAS FUEL LEAKING CAUSING THE FUEL LEVEL TO DECREASE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE FUEL TANK AND THE FUEL STRAPS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT DID NOT VERIFY IF THE VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA complaint #10654701 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT WHILE INSPECTING THE VEHICLE, SHE NOTICED THAT THE FUEL TANK STRAPS WERE CORRODED AND THE FUEL TANK WAS LEAKING GASOLINE DUE TO A HOLE ON THE FUEL TANK. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL TANK STRAPS NEEDED TO BE REPLACED AND WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE). HOWEVER, THE CONTACT WAS ADVISED THAT THE REPAIRS FOR THE HOLE IN THE FUEL TANK WERE NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 131,930. UPDATED 12/20/13*CN THE CONSUMER STATED THERE WAS A HOLE IN THE GAS TANK UNDER THE FUEL TANK STRAPS.

NHTSA complaint #10549959 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

FUEL TANK FELL OFF OF TRUCK WHILE DRIVING DOWN THE ROAD. CAUSING THE FUEL TANK TO HIT THE GROUND AND FUEL TO LEAK OUT OF TANK. FIRE DEPT. HAD TO COME CLEAN UP MESS. HAD TRUCK TOWED TO DEALER FOR SERVICE. FOUND OUT AFTER THAT STRAPS WHERE RECALLED BY FORD. FORD REFUSES TO PAY FOR THE TANK, THE CLEAN UP, OR THE TOW. THEY TOLD ME I HAD BEEN NOTIFIED AND THEY WOULD ONLY PAY FOR THE STRAPS. I FIND IT FUNNY THAT THEY DIDN'T HAVE ANY OF MY INFO BEFORE I GAVE IT TO THEM. SO HOW DID THEY NOTIFY ME.

NHTSA complaint #10541715 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT TOOK HIS VEHICLE TO THE DEALER TO HAVE NHTSA RECALL CAMPAIGN NUMBER 11V385000 (FUEL SYSTEM, GASOLINE) REPAIRED AND WAS INFORMED THAT THE FUEL TANK HAD CORRODED AND NEEDED TO BE REPLACED AT HIS EXPENSE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 156,816.

NHTSA complaint #10524865 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

5.4 TRITON V8. TODAY WHILE DRIVING, SPARK PLUG AND COIL BLEW OUT OF #7 CYLINDER HEAD. THIS ALSO OCCURRED SEVERAL MONTHS AGO ON CYLINDER #3. SOUNDED LIKE A SHOTGUN BLAST WHICH STARTLED ME TAKING MY ATTENTION AWAY FROM THE ROAD. GAS ALSO BLOWING OUT OF CYLINDER HOLE, AND LUCKILY NO FIRE STARTED. STRONG SMELL OF GAS WAS PRESENT IN CAB OF TRUCK. NAUSEATED FAMILY MEMBERS RIDING IN TRUCK. UPON INSPECTION FOUND PLUG AND COIL DAMAGED BY FUEL RAIL. ALSO FOUND SPARK PLUG THREADS STRIPPED OUT OF ALUMINUM CYLINDER HEAD. KNOWN TO BE A COMMON PROBLEM WITH FORD 5.4, AND IS ALSO AN ISSUE THAT IS KNOW TO BE IGNORED BY FORD. FORD ESTIMATES REPAIR BETWEEN 500.00 AND 3500.00 FOR A KNOWN MANUFACTURING DEFECT THAT THEY BLAME ON A SPARK PLUG MAINTENANCE ISSUE.

NHTSA complaint #10519899 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED HE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE) AND THE VEHICLE WAS TAKEN TO A DEALER FOR THE REPAIR. THE CONTACT WAS INFORMED THAT THE FUEL TANK HAD A LEAK AND WOULD NEED TO BE REPLACED BEFORE THE RECALL REPAIR COULD BE PERFORMED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND BOTH FAILURES WERE REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 115,000.

NHTSA complaint #10515197 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

THE STRAPS ON THE FUEL TANK COMPLETELY BROKE OFF AS I WAS DRIVING ON THE TURNPIKE AND THE FUEL TANK FELL DOWN; CAUSING IT TO DRAG ON THE ROAD LEAKING OUT GAS.

NHTSA complaint #10509751 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

REAR FUEL TANK STRAP CORRODED THROUGH AND BROKEN, APPROXIMATELY 6 INCHES OF DRIVER SIDE MISSING. REAR OF TANK WAS BEING SUPPORTED BY FILL AND VENT TUBES ONLY. FRONT STRAP WAS INTACT BUT CORRODED.

NHTSA complaint #10488928 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

I HAD AN APPOINTMENT AT DONLEY FORD IN ASHLAND, OHIO MON., 11-11-12 AT 6 PM., TO HAVE THE FUEL TANK STRAPS REPLACED ON MY F-150 PER THE RECALL. WHEN THE TECHNICIAN REMOVED THE STRAPS, THE TANK STARTED LEAKING. WHEN CONTACTING FORD, THEY DENY ANY RESPONSIBILITY FOR THIS PROBLEM. A QUICK SEARCH ON THE INTERNET SHOWS THAT MANY OTHERS HAVE HAD THE SAME EXPERIENCE. MY TRUCK WAS PREVIOUSLY OWNED MY BROTHER AND HAS BEEN TAKEN WELL CARE OFF. THE TECHNICIAN EVEN COMMENTED ON ITS CONDITION. THE TANK IS IN PERFECT CONDITION EXCEPT SOME RUSTING WHERE THE STRAPS WERE. AFTER SEARCHING THE INTERNET, I AM SURE THAT YOU HAVE HEARD THIS COMPLAINT BEFORE. I AM SIMPLY ADDING ONE MORE. NOT ONLY IS THERE A POTENTIAL FOR THE STRAPS TO BREAK, ALLOWING THE TANK TO FALL, THEY ALSO CORRODE THE TANK, CAUSING IT TO LEAK FUEL.

NHTSA complaint #10485079 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE FUEL TANK DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT HE PULLED OVER AND NOTICED THAT GASOLINE WAS LEAKING FROM A HOLE IN THE FUEL TANK. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FUEL TANK STRAPS WERE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT SHE SHOULD HAVE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE FAILURE MILEAGE WAS 130,000.

NHTSA complaint #10475867 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

AFTER DEALER COMPLETED SAFETY RECALL 11S21 FUEL TANK STRAPS, TANK BEGAN TO LEAK FUEL. FORD REFUSES TO ACKNOWLEDGE THAT THIS IS A SAFETY ISSUE TO FIX BROKEN FUEL TANK AFTER RECALL WORK. THERE RESPONSE TO ME WAS IF THE TANK FELL OFF THE TRUCK IT WOULD BE COVERED, THIS HAS HAPPENED TO MANY F150'S HENCE THE REASON FOR THE SAFETY STRAP RECALL.

NHTSA complaint #10472653 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

LIKE SO MANY, I HAD TO REPLACE MY FUEL TANK BECAUSE OF HOLES RUSTED IN IT ($500 COST TO ME). EVEN AFTER NHTSA "STUDIED" THE ISSUE FOR 10 MONTHS, THEY APPARENTLY DETERMINED THAT HAVING GASOLINE SPILL OUT ONTO THE ROAD IS NOT A SAFETY CONCERN FOR CONSUMERS. IF THIS IS TRUE, THEN THERE IS NO REASON TO CALL THE HAZ MAT TEAM IN TO CLEAN IT UP, BECAUSE RAY LAHOOD HAS DETERMINED THAT THERE IS NO RISK OF FIRE AND THE CONTAMINATION OF GROUND WATER IS OF NO PUBLIC CONCERN? THE TREAD ACT STATES THAT IF A DEFECT IS HIDDEN TO MISLEAD NHTSA, THE COMPANY IS SUBJECT TO A $15,000,000 FINE. IF THERE IS A DEATH OR GRIEVOUS INJURY AS A RESULT, THE PENALTY INCLUDES 15 YEARS IN PRISON (A RI WOMAN SUSTAINED SUCH AN INJURY) WHY IS RAY LAHOOD, DAVID STRICKLAND AND LARRY HERSHMAN SO RECKLESS WITH HUMAN LIFE AS TO NOT ENFORCE THIS LAW? WHY CAN THEY DECIDE WHICH CONSUMERS SHOULD BE COVERED BY CONSUMER PROTECTIONS UNDER THE LAW AND WHICH ONES SHOULD SOONER DIE IN A BALL OF FLAME? HOW CAN THE HR DEPARTMENT OF A COMPANY THREATEN EMPLOYEES WITH TERMINATION IF THEY REFUSE TO COVER UP A TREAD ACT CRIMINAL VIOLATION THAT COULD, AND I QUOTE (CHARR OCCUPANTS BEYOND RECOGNITION) ALL WITHOUT CONSEQUENCE IN SPITE OF THE LETTER AND SPIRIT OF THE LAW. THIS FAILURE TO CORROSION PROTECT IS THE SAME DECISION THAT KILLED A COAST GUARD VETERAN IN MASS WHEN THE AXEL BROKE ON HIS WINDSTAR. ANOTHER TREAD VIOLATION MERITING PRISON TIME, BUT NHTSA IS AGAIN EITHER TOO CORRUPT OR TOO INEPT TO ITS JOB. LIKEWISE, THE RECENT STRING OF BRAKE FAILURE DUE TO LINE CORROSION IS DUE TO THE SAME DECISION. HOW CAN ANYONE NOT KNOW THAT THESE PRESENT RISKS TO HUMAN LIFE? HOW CAN ANYONE HAVE SO LITTLE REGARD FOR HUMAN LIFE TO SEEMINGLY RUN A PROTECTION RACKET LIKE NHTSA SEEMS TO BE, YET CLAIM TO BE ACTING IN THE INTEREST OF THE PUBLIC AND CONSUMERS?

NHTSA complaint #10465581 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT AFTER PARKING, HE SMELLED GASOLINE FUEL COMING FROM THE VEHICLE AND THEN NOTICED A HOLE IN THE FUEL TANK. THE DEALER WAS NOTIFIED OF THE ISSUE WHO ADVISED THE CONTACT THAT THERE WERE NO RECALLS ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 139,000.

NHTSA complaint #10460110 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT BOTH FUEL TANK STRAPS WERE COMPLETELY RUSTED. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY: MOUNTING) AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER ADVISED THE CONTACT THAT THE RECALL REMEDY COULD NOT BE PERFORMED UNLESS THE DAMAGED FUEL LINES WERE REPLACED FIRST. THE VEHICLE WAS NOT REPAIRED. THE CONTACT EXPRESSED THAT THE FUEL TANK REPLACEMENT SHOULD HAVE BEEN INCLUDED IN THE RECALL CAMPAIGN. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.

NHTSA complaint #10459264 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2000 FORD F150. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER:11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). AFTER THE REPAIR, THE FUEL TANK BEGAN LEAKING. THE CONTACT CALLED THE DEALER AND THE DEALER INFORMED THE CONTACT THAT THEY COULD ONLY REPAIR THE FUEL TANK STRAPS AT NO COST ONLY ONCE UNDER THE RECALL. THE MANUFACTURER WAS ALSO CONTACTED AND ADVISED HIM THAT THE FUEL TANK WOULD NOT BE COVERED BY THE RECALL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 135,892.

NHTSA complaint #10454349 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

GOOD DAY, MY 2000 FORD F150 PICKUP TRUCK IS INVOLVED IN THE GAS TANK STRAPS RECALL. BECAUSE THE STRAPS BROKE IT CAUSED EXCESSIVE VIBRATION FROM THE TANK THAT ALSO DAMAGED THE TANK; NOW FORD HAS FIXED THE STRAPS BUT NOW THEY WANT $1600 TO FIX THE TANK WHICH BROKE BECAUSE OF THE DAMAGE STRAPS ORIGINALLY. I HAVE NEVER HAD A VEHICLE WITH SUCH A SEVERE RUST PROBLEM. I THINK THIS VEHICLE SHOULD HAVE A FUEL TANK RECALL ALSO. THE FUEL LINE ALL GOT RUSTED AND BROKE ON ME; I HAD TO CHANGE OUT ALL THE LINES. NOW THE GAS TANK AND STRAPS ARE ALL RUSTED OUT. THANKS,

NHTSA complaint #10452194 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

TL* THE CONTACT OWNS A 2000 FORD F-150. THE CONTACT STATED THAT BOTH OF THE FUEL TANK STRAPS FRACTURED AND AS A RESULT, THE FUEL TANK WAS SITTING ON TOP OF THE SKIT PLATES. THE CONTACT ALSO MENTIONED THAT THE FUEL TANK WAS LEAKING DUE TO THE CORROSION DAMAGE AROUND THE STRAPS. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) DID NOT INCLUDE THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 164,621.

NHTSA complaint #10449103 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

AS OF 12-10-2010 I WAS AT WORK AND WAS WALKING TOWARD THE TRUCK AND NOTICE THE GAS TANK WAS HANGING.I CALLED MY BOSS AND TOLD HIM THE SITUATION.SO I TOOK A RACHET STRAP AND STRAP IT UP.DROVE OVER SIXTY MILES HOME TO LOCAL AUTO STORE AND PICKED UP NEW STRAPS.AS I WAS REPLACING STRAPS I NOTICE A STRONG ODOR OF GAS.ALSO WHEN REPLACING THESE STRAPS THAT I NOTICE ALOT OF RUST ON GAS TANK WHERE GAS STRAPS WERE PLACED.WANTED TO TAKE A WIRE BRUSH TO IT BUT WAS AFRAID OF THE WIRE BRUSH PUTTING A HOLE THROUGH IT.ALSO MAYBE A SPARK AND KABOOM.BESIDES THAT TOOK THE TRUCK TO DEALERSHIP AND SERVICE ADVISOR CAME TO US AND TOLD US THAT GAS TANK HAS 3 HOLES IN TANK AROUND FRONT STRAP AND IS TO DANGEROUS TO DRIVE.HE SAID THAT HE WOULD GET AHOLD OF FORD AND MORE THAN LIKELY THEY WOULD PUT US IN A RENTAL AND FIX TANK.HE COMES BACK AND SAID THEY WOULD NOT FIX.HE TOLD US THAT WE HAVE A CASE.SO CALLED FORD AND THEY TOLD ME THAT THE ONLY WAY THEY WOULD FIX THE TANK IF IT WOULD DROP TO THE GROUND.I SEE THAT AS A PERSONAL SAFETY ISSUE FOR ME AND PEOPLE BEHIND ME.FORD SHOWED NO CONCERN AND THAT BOTHERED ME.BUT SINCE THE TANK DROPPED I HAVE SMELT GAS AND THE DEALERSHIP NOTICED THE CORROSION AND RUST UNDER THE STRAPS AND FORD STILL DID NOT CARE.

NHTSA complaint #10444458 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

I MAY BE POSSIBLE THAT IF YOUR VEHICLE IS OPERATED IN A HIGH CORROSION AREAS FOR AN EXTENDED PERIOD OF TIME, ONE OR BOTH FUEL TANK STRAPS COULD POTENTIALLY FRACTURE. STRAP FRACTURE MAY RESULT IN THE FUEL TANK CONTACTING THE GROUND. IF THE FUEL TANK CONTACTS THE GROUND AND DEVELOPS A LEAK WHILE DRIVING, THERE IS A POTENTIAL FOR FIRE. THE TIME FORD ESTIMATES FOR THIS REPAIR TO OCCUR IS ERRONEOUS. IT TAKES HALF A DAY IN THE SHOP TO DETERMINE IF THE STRAPS ARE IN GOOD OF BAD SHAPE. THEN THEY HAVE TO ORDER A REPAIR KIT. TO DO THE ACTUALLY REPAIR, CLOSE TO A DAY IN THE SHOP. I NEED MY VEHICLE FOR WORK AND FORD WILL NOT LOAN ME ONE FREE OF CHARGE.

NHTSA complaint #10441180 — an unverified report by a vehicle owner.