Owners have filed 4,981 complaints
about the 2012 Ford Focus with NHTSA between 2011 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 4 of 20 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Ford Focus. 50 means typical for this
model; 100 means roughly double.
Severity — 33
6.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 43
25% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
29561.7%
Latch
9018.8%
Control Module (Tcm/Pcm/Tecm)
265.4%
Automatic Transmission
224.6%
Door
204.2%
Clutch Assembly
132.7%
Power Window Devices AND Controls
71.5%
Lugs/Nuts/Bolts/Studs
51.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
1974.8%
1,000 – 9,999 miles
2506.2%
10,000 – 24,999 miles
2646.5%
25,000 – 49,999 miles
78119.2%
50,000 – 74,999 miles
85120.9%
75,000 – 99,999 miles
79219.5%
100,000 – 149,999 miles
72817.9%
150,000+ miles
2004.9%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2012 Ford Focus 5 DR FWD
11.7% risk
2012 Ford Focus 4 DR FWD
11.7% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2011peak 151Aug 2026
NHTSA investigations into the 2012 Ford Focus
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
RQ23006Opened 15 Sep 2023Closed 20 Dec 2024FUEL SYSTEM, GASOLINE:STORAGE:EVAPORATIVE EMISSIONS:CANISTER
Loss of Motive Power
On September 15, 2023, the Office of Defect Investigation (ODI) opened this Recall Query (RQ) after receiving 98 consumer complaints alleging loss of motive power in model year (MY) 2012-2018 Ford Focus vehicles. The RQ focused on the effectiveness of the remedies of Recall 18V-735 and 19V-515. In October 2018, Ford issued Recall 18V-735, which updated Powertrain Control Module (PCM) software in MY 2012-2018 Ford Focus vehicles equipped with 2.0L GDI engines built prior to April 13, 2017, and those with 2.0L GTDI engines built prior to February 2, 2018. The recall addressed vehicles experienci...
RQ19005Opened 19 Dec 2019Closed 7 Feb 2022LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Door Latch Failures
In December 2019, the Office of Defects Investigation (ODI) opened this investigation based on 235 Vehicle Owner Questionnaires (VOQs) alleging doors failed to latch when closed, and/or inadvertently opened while driving, on model year (MY) 2012-2014 Ford Fiesta, and 2013-2014 Fusion and Lincoln MKZ. Some VOQs reported the failure occurred after the latch had been remedied under a prior recall which involved fracture of the latch pawl spring tab due to thermally induced cyclic fatigue. Other VOQs alleged a similar failure in vehicles not previously recalled. A latch with a fractured pawl sprin...
PE16001Opened 16 Jan 2016Closed 29 Oct 2016LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Door Latch Failure
In January, the Office of Defects Investigation (ODI) opened this Preliminary Evaluation based on consumers' allegations of doors failing to latch and/or inadvertently opening on model year (MY) 2012-2013 Ford Focus vehicles (subject vehicles).ODI has received 464 unique reports related to the alleged problem, with over 200 claiming that the door(s) opened inadvertently while the vehicle was in motion.One consumer alleged an injury that occurred while driving when a door inadvertently opened and then closed on a child's arm.Another alleged that a door that inadvertently opened struck a parked...
Recalls on the 2012 Ford Focus
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Ford Motor Company (Ford) is recalling certain 2012-2018 Focus vehicles previously repaired incorrectly under recall number 18V735. The Canister Purge Valve (CPV) may malfunction, causing the engine to stall unexpectedly while driving.
Risk: An engine that stalls while driving increases the risk of a crash.
20V331000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Ford Motor Company (Ford) is recalling certain 2011-2014 Fiesta, 2013-2014 Fusion, 2015 Mustang, 2013-2015 Escape and C-Max, 2012-2015 Focus, 2014-2016 Transit Connect, 2013-2014 Lincoln MKZ, and 2015 MKC vehicles. These vehicles were previously recalled and repaired under recalls 15V-246, 16V-643 or 17V-210, however the repair may not have been completed properly. A component within the door latches may break making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
19V515000
FUEL SYSTEM, GASOLINE:STORAGE
Ford Motor Company (Ford) is recalling certain 2012 and 2017 Focus vehicles equipped with 2.0L GDI gasoline engines and 2013-2014 Focus ST vehicles equipped with 2.0L GTDI engines, previously recalled under 18V-735. The affected vehicles did not have the Powertrain Control Module (PCM) updated as intended. Therefore, the Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in the fuel vapor management system.
Risk: The excessive vacuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
18V735000
FUEL SYSTEM, GASOLINE:STORAGE
Ford Motor Company (Ford) is recalling certain 2012-2018 Ford Focus vehicles with a 2.0L GDI or 2.0L GTDI engine. The Canister Purge Valve (CPV) may malfunction, possibly causing excessive vacuum in fuel vapor management system.
Risk: The excessive vaccuum may result in an engine stall while driving, without warning and without the ability to restart the vehicle, increasing the risk of a crash.
16V643000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
Ford Motor Company (Ford) is recalling certain model year 2012-2015 Ford Focus, 2013-2015 Ford Escape and Ford C-MAX, 2015 Lincoln MKC and Ford Mustang, and 2014-2016 Ford Transit Connect vehicles. A component within the door latches may break, preventing the doors from latching and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Risk: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
13V335000
EXTERIOR LIGHTING
Ford is recalling certain model year 2012-2013 Focus BEV vehicles equipped with High Intensity Discharge (HID) headlights, manufactured September 15, 2011, through May 6, 2013; and model year 2013 Focus ST vehicles equipped with High Intensity Discharge (HID) headlights, manufactured February 16, 2012, through May 7, 2013. Due to a wiring incompatability, the front side marker lamps may not function. Thus, these vehicles fail to comply to the requirements of Federal Motor Vehicle Safety Standard (FMVSS) No. 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: Without the proper illumination of the side maker lamps, the vehicle may be less visible in night time conditions, increasing the risk of a crash.
12E035000
EQUIPMENT
This recall involves aftermarket parts sold by Yakima Products, Inc. for use on model year 2012 and 2013 Ford Focus vehicles. This recall is being conducted by Yakima, not by Ford. Certain combined Q-Tower and Q128 Clip rooftop rack systems, part numbers 8000124 and 8000728, do not fully contact the door frame.
Risk: Without proper contact of the rooftop rack clip to the door frame, there is insufficient clamping pressure and friction. The system may slide off the vehicle when loaded with accessories, possibly becoming a road hazard to other vehicles or causing injury to pedestrians.
12V149000
VISIBILITY:WINDSHIELD WIPER/WASHER:SWITCH/WIRING
FORD IS RECALLING CERTAIN MODEL YEAR 2012 FOCUS VEHICLES MANUFACTURED FROM AUGUST 1, 2010, THROUGH OCTOBER 18, 2011. A SEAL IN THE WIRING HARNESS CONNECTOR TO THE PASSENGER SIDE WIPER MOTOR MAY BE MISSING.
Risk: WATER OR OTHER CONTAMINANTS MAY ACCUMULATE IN THE CONNECTOR, RESULTING IN AN INTERMITTENT OR INOPERATIVE PASSENGER SIDE WIPER MOTOR, REDUCING VISIBILITY AND INCREASING THE RISK OF A CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2026338110,138 units in Canada
Fuel System
Issue: On certain vehicles the recall repairs completed by a Ford dealer during recall 18S32 (Transport Canada recall no. 2018-577) may not have been done correctly. As a result, a another repair is required. On certain vehicles, the canister purge valve (CPV) may stick open and cause the fuel tank to deform. If this happens, the fuel gauge could read incorrectly and there could be a loss of power to the wheels. Note: This recall is an expansion of Transport Canada recall no. 2018-577. Vehicles repaired under that recall also require this repair. Safety Risk: A sudden loss of power to the wheels could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the powertrain control module (PCM) software and, if necessary, replace the CPV. If the CPV is replaced, the dealer will inspect and replace the carbon canister, fuel tank and fuel delivery module, as necessary. In the interim, owners are advised to maintain at least 1/2 tank of fuel until the recall repair is performed.
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Recall 2019338408 units in Canada
Fuel System
Issue: On certain vehicles repaired under recall 2018-577 (Ford Recall #18S32), the software for the Powertrain Control Module (PCM) was not properly updated. As a result, a second repair is required. The software allows the PCM to detect a Canister Purge Valve (CPV) that is not working properly. A CPV that is not working properly could cause a malfunction indicator light (MIL) to turn on in the instrument cluster, erratic readings on the fuel gauge, and/or the engine may stall. Note: Owners are advised to keep their fuel level above half-full until the recall repairs are completed. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and instruct them to take their vehicle to a dealer to update the Powertrain Control Module (PCM) software.
Recall 2018577136,272 units in Canada
Fuel System
On certain vehicles, the Canister Purge Valve (CPV) may stick open and cause excessive vacuum in the fuel system that could deform the fuel tank. If this were to occur, it could cause: a malfunction indicator light (MIL) to illuminate, erratic readings on the fuel gauge, and/or the engine may stall. This could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will reprogram the Powertrain Control Module (PCM) with new software and replace the CPV as necessary. If the CPV is replaced, dealers will inspect and replace the carbon canister, fuel tank and fuel delivery module as necessary. Note: In the interim, owners are advised to maintain at least 1/2 tank of fuel until the recall repair is performed.
Recall 20184431,324 units in Canada
Electrical
Certain plug-in hybrid and electric vehicles were supplied with a 120V convenience charge cord that may be susceptible to overheating if there is a poor connection at the electrical outlet. This could result in increased cord temperatures, melting, and an increased risk of fire causing injury and/or damage to property. Correction: Dealers will replace the factory supplied 120V convenience cord with the latest version of the cord that includes thermal protection.
Recall 2016432233,034 units in Canada
Structure
On certain vehicles, the pawl spring tab in the side door latch could break. This condition typically will prevent the door from latching. In certain situations where the door is able to be closed, the door may be partially latched and could unlatch while driving. This could increase the risk of injury to a vehicle occupant seated next to the door, or result in damage to property. Correction: If a door will not latch, dealers will replace all four door latches with a more robust part. Note: A door that is partially latched can cause the courtesy light to remain on, set a door ajar message in the instrument cluster and sound a door ajar chime to alert the driver that there is a door latch problem.
Recall 2013371162 units in Canada
Powertrain
Certain Focus Electric vehicles may experience a sudden loss of motive power while driving, which could increase the risk of a crash causing injury and/or damage to property. Correction: Dealers will reprogram the powertrain control module. Note: If this condition occurs, a red triangle and "stop safely now" message will be displayed in the instrument cluster. Power steering and brakes will continue to operate normally and the vehicle can often be restarted after going through a shutdown process.
Recall 2013340929 units in Canada
Electrical
Certain vehicles may not comply with the requirements of Canada Motor Vehicle Safety Standard 114 - Theft Protection and Rollaway Prevention. No audible chime is provided when the door is opened and the electronic key code remains in the ignition. This could increase the risk of injury and/or damage to property. Correction: Dealers will update vehicle software.
Reports where the owner recorded a crash, a fire, an injury or a death.
Niles, OH1 injured
STEERING
During some Christmas shopping within the past few weeks, my cars power steering went out completely with no warning or sounds to repair or seek assistance. Not only was my life in danger, but the safety of others in the vehicles surrounding me. I couldn't even turn my wheel if I tried. There have been other instances in other cars where I could strong arm the wheel and be ok, but there was absolutely nothing I could do about turning the wheel whatsoever! When my dad came with power steering fluid, we discovered that these cars don't even have a reservoir for power steering fluid and that this was more than likely a battery or module issue or worse the power steering pump. This is ridiculous that there is no service light or warning that the power steering is going out or losing power. Ford should fix this because it seems like this is an ongoing issue with Fords in general
NHTSA complaint #11633582 — an unverified report by a vehicle owner.
Niles, OH1 injured
ELECTRICAL SYSTEM
During some Christmas shopping within the past few weeks, my cars power steering went out completely with no warning or sounds to repair or seek assistance. Not only was my life in danger, but the safety of others in the vehicles surrounding me. I couldn't even turn my wheel if I tried. There have been other instances in other cars where I could strong arm the wheel and be ok, but there was absolutely nothing I could do about turning the wheel whatsoever! When my dad came with power steering fluid, we discovered that these cars don't even have a reservoir for power steering fluid and that this was more than likely a battery or module issue or worse the power steering pump. This is ridiculous that there is no service light or warning that the power steering is going out or losing power. Ford should fix this because it seems like this is an ongoing issue with Fords in general
NHTSA complaint #11633582 — an unverified report by a vehicle owner.
Huntington, WVCrash
STEERING
I was traveling on a Highway on my way home and as I was turning in a curve at around 40 mph all of a sudden a message came up on my dash that steering assist fault which I didn’t know at the time I was to busy trying not to wreck my steering wheel locked In place coming out of the curve which put me in to the other lane of travel and eventually into a ditch and and thank god not into another vehicle, if there is not some kind of safety recall or major issue that should be a recall the governor or someone should address this immediately I was lucky I did not die. 1. So the system that failed is steering assist fault & yes it is available for inspection. 2 my safety and anyone else that was traveling in oncoming lanes life was in serious risk. 3 the problem is still there can’t get the steering to move to take it anywhere safely. 4 No it has not been inspected by anyone other than my brother to tow it home for me. 5 There was no warning lamps or malfunctions or symptoms at all until the incident happened the steering locked up I heard a tone and when I finally came to a stop these words where on the center dash display. Steering Assist Fault Service required.
NHTSA complaint #11593347 — an unverified report by a vehicle owner.
Sacramento, CACrash
EXTERIOR LIGHTING
Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi
NHTSA complaint #11576328 — an unverified report by a vehicle owner.
Sacramento, CACrash
ENGINE
Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi
NHTSA complaint #11576328 — an unverified report by a vehicle owner.
Sacramento, CACrash
FUEL/PROPULSION SYSTEM
Se acelera y desacelera repentinamente Quiero acelerar para llegar a la mismas velocidad del trafico y no lo hace y eso hase que ponga en peligro la vidad mia y de mi familia por que otro carro puede chocarme. Cuando sucedio eso se activo el CHECK, lo apago por completo y los parabrisas se activan repentinamente , todo esto es muy raro y no es bueno para mi
NHTSA complaint #11576328 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
St. Paul, MN
FUEL/PROPULSION SYSTEM
SAFETY DEFECT AND RECALL REMEDY REFUSAL REPORT: My 2012 Ford Focus is actively experiencing severe safety failures matching the known defects in Ford Recall Campaign 26S40 (NHTSA Campaign Number 26V369) for the canister purge valve. While operating the vehicle, the engine suddenly stalled, creating an immediate highway safety hazard. Diagnostic scans show critical low fuel pressure. A physical inspection reveals that the fuel tank and the attached heat shield are severely warped and deformed. This structural damage is a direct result of the defective purge valve sticking open, creating an excessive internal vacuum that collapsed the fuel delivery module and tank assembly. I had the vehicle towed to an authorized Ford dealership (Apple Ford in White Bear Lake, MN). The dealership service department is actively refusing to honor or perform the mandated remedy under NHTSA Campaign 26V369. The technician stated that because a previous, legacy software update was noted in their system, "nothing more can be done." This directly violates the June 2026 re-recall mandate, which was issued precisely because previous software fixes were incomplete or improperly performed. Furthermore, the dealership is attempting to charge me an unauthorized diagnostic fee for an open safety recall inspection, refusing to inspect the physically collapsed gas tank, and making verbal, undocumented claims about frame rust to avoid performing the safety remedy. The vehicle is currently stranded at the dealership, unrepaired, and remains an active safety hazard. I am requesting that the NHTSA investigate this dealership's refusal to comply with a federal safety recall mandate and force Ford Motor Company to replace the damaged fuel system components as required by law.
NHTSA complaint #11758411 — an unverified report by a vehicle owner.
El Paso, TX
UNKNOWN OR OTHER
My complaint is for serious safety concerns on my 2012 Ford Focus and the handling of recall 18S32 and 26S40 by Ford Motor Company. My fuel tank is visibly deformed in the exact strap area described in the recall, and I have physical proof and photographs confirming this. On XXX, a Ford technician found deformation during dispatch by local dealer to complete Recall 26S40. When I brought the vehicle to Viva Ford in [XXX], service manager and his master tech confirmed problem. They began avoiding the repair of course. Called Ford and they gave the same horrible customer service. Insistent that there were no recalls. Escalated to BBB and Ford had the audacity to simply reply that because there were no open recalls they would not be moving forward with a repair. Ford issued recall because many Focus vehicles were incorrectly marked as “repaired” by recall 18S32 years ago and they were actually never even repaired at all. Ford has publicly acknowledged these “phantom fixes.” While 26S40 is only a software patch, it does not eliminate eligibility for a tank replacement. In fact, in the service manager at the dealership even sent me official Ford literature which I will attach that states a claim can be made for related repairs needed that stemmed from these original recalls. Because the original software fix was never properly applied, my canister purge valve likely stuck open for years, causing the tank deformation that falls directly under recall 18S32 and the subsequent 26S40 where the Service Manager and Master Technician have confirmed my problem. I have never received a fuel‑tank recall repair, yet my tank is deformed and unsafe because it can fall off from my vehicle while in motion and cause me to stall abruptly. This is the safety issue at hand. Both Ford and Viva Ford dealership are refusing to repair it despite evidence and recall criteria that match my vehicle’s condition. I am appalled at their avoidance to fix my problem. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
NHTSA complaint #11757897 — an unverified report by a vehicle owner.
El Paso, TX
FUEL/PROPULSION SYSTEM
My complaint is for serious safety concerns on my 2012 Ford Focus and the handling of recall 18S32 and 26S40 by Ford Motor Company. My fuel tank is visibly deformed in the exact strap area described in the recall, and I have physical proof and photographs confirming this. On XXX, a Ford technician found deformation during dispatch by local dealer to complete Recall 26S40. When I brought the vehicle to Viva Ford in [XXX], service manager and his master tech confirmed problem. They began avoiding the repair of course. Called Ford and they gave the same horrible customer service. Insistent that there were no recalls. Escalated to BBB and Ford had the audacity to simply reply that because there were no open recalls they would not be moving forward with a repair. Ford issued recall because many Focus vehicles were incorrectly marked as “repaired” by recall 18S32 years ago and they were actually never even repaired at all. Ford has publicly acknowledged these “phantom fixes.” While 26S40 is only a software patch, it does not eliminate eligibility for a tank replacement. In fact, in the service manager at the dealership even sent me official Ford literature which I will attach that states a claim can be made for related repairs needed that stemmed from these original recalls. Because the original software fix was never properly applied, my canister purge valve likely stuck open for years, causing the tank deformation that falls directly under recall 18S32 and the subsequent 26S40 where the Service Manager and Master Technician have confirmed my problem. I have never received a fuel‑tank recall repair, yet my tank is deformed and unsafe because it can fall off from my vehicle while in motion and cause me to stall abruptly. This is the safety issue at hand. Both Ford and Viva Ford dealership are refusing to repair it despite evidence and recall criteria that match my vehicle’s condition. I am appalled at their avoidance to fix my problem. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION AC
NHTSA complaint #11757897 — an unverified report by a vehicle owner.
Standish, ME
POWER TRAIN
"I am reporting a dealer safety recall refusal under Campaign 26S40 / NHTSA 26V369. My 2012 Ford Focus is completely immobilized in my driveway in [XXX] with a total transmission software lockout and zero fuel. Yankee Ford in [XXX] operates an active Mobile Service van program but explicitly refused to dispatch a technician to flash my PCM. They falsely claimed local town ordinances prevent them from operating, completely ignoring that my vehicle is located outside their jurisdiction in [XXX]. They are using false administrative excuses to deny a free, federally mandated safety repair on a stranded vehicle." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11756962 — an unverified report by a vehicle owner.
at 130,000 milesHouston, TX
FUEL SYSTEM, GASOLINE
The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.
NHTSA complaint #11756307 — an unverified report by a vehicle owner.
at 130,000 milesHouston, TX
ENGINE
The contact owns a 2012 Ford Focus. The contact stated that the vehicle previously failed the vehicle state inspection due to the check engine warning light being illuminated. Additionally, the vehicle stalled intermittently while driving. The contact had to pull over, wait, and then restart the vehicle. The vehicle was taken to the dealer, who performed an unknown recall repair for the canister purge valve, but the failure persisted. The vehicle was then taken to the second dealer, Group 1 Ford of Southwest Houston (6445 Southwest Fwy, Houston, TX 77074), who performed another unknown recall repair for the canister purge valve, but the failure reoccurred. The contact later received notification of NHTSA Campaign Number: 26V369000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealers were made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 130,000.
NHTSA complaint #11756307 — an unverified report by a vehicle owner.
Dickinson, TX
STRUCTURE:BODY
Started July 2026, my drivers side door handle keeps getting stuck open
NHTSA complaint #11754278 — an unverified report by a vehicle owner.
Huron, CA
STRUCTURE:BODY
My driver side door was working perfect until one day i went into my car and tryed closing my door but it wont close so i had to go to work while holding the door so it dosent open i favent talked to ford itself bucause om scared they will charge me a lot
NHTSA complaint #11752964 — an unverified report by a vehicle owner.
Rogers, AR
VEHICLE SPEED CONTROL
The TCU/TCM has been going in and out of control. Sometimes it will work then others it will shut off. Speedometer won’t work, power steering won’t work, cruise control won’t work, etc. and when you do the transmission reset for it, it won’t work at all.
NHTSA complaint #11752841 — an unverified report by a vehicle owner.
Rogers, AR
STEERING
The TCU/TCM has been going in and out of control. Sometimes it will work then others it will shut off. Speedometer won’t work, power steering won’t work, cruise control won’t work, etc. and when you do the transmission reset for it, it won’t work at all.
NHTSA complaint #11752841 — an unverified report by a vehicle owner.
Rogers, AR
UNKNOWN OR OTHER
The TCU/TCM has been going in and out of control. Sometimes it will work then others it will shut off. Speedometer won’t work, power steering won’t work, cruise control won’t work, etc. and when you do the transmission reset for it, it won’t work at all.
NHTSA complaint #11752841 — an unverified report by a vehicle owner.
Pearl City, HI
UNKNOWN OR OTHER
On XXX I received email from CARFAX regarding my vehicle recall "26S40 PCM REPROGRAMMING FOR FUEL TANK DEFORMATION”. I contacted Ford Cutter Hawaii answering spoke with [XXX] over the phone regarding the recall, she asked me to forward the email then she after she read the email she dismissed the information as not reliable as it came from Carfax. She will only follow up if I got recall notice in the mail. XXX my car stalled in the middle of freeway and got towed. At the time the reading of fuel is low but not empty. The car started and only run for 1-2 seconds before it died again. That is very similar symptoms described in the recall information: "Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART AND CAN INCREASE THE RISK OF A CRASH.” End of complain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11749771 — an unverified report by a vehicle owner.
Pearl City, HI
ENGINE
On XXX I received email from CARFAX regarding my vehicle recall "26S40 PCM REPROGRAMMING FOR FUEL TANK DEFORMATION”. I contacted Ford Cutter Hawaii answering spoke with [XXX] over the phone regarding the recall, she asked me to forward the email then she after she read the email she dismissed the information as not reliable as it came from Carfax. She will only follow up if I got recall notice in the mail. XXX my car stalled in the middle of freeway and got towed. At the time the reading of fuel is low but not empty. The car started and only run for 1-2 seconds before it died again. That is very similar symptoms described in the recall information: "Safety Risk THIS MAY RESULT IN AN ENGINE STALL WHILE DRIVING WITHOUT WARNING OR WITHOUT THE ABILITY TO RESTART AND CAN INCREASE THE RISK OF A CRASH.” End of complain. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11749771 — an unverified report by a vehicle owner.
Apache Junction, AZ
FUEL/PROPULSION SYSTEM
Days after changing the purge valve on my car, because it had failed. I was driving on the freeway confident because my screen said 15 m left before running out of gas, then the engine stalled and lose power. The lights were on but the engine stopped running while driving on the freeway. Turned out I had runned out of gas but the computer was misreading it.
NHTSA complaint #11748105 — an unverified report by a vehicle owner.
Bee Cave, TX
UNKNOWN OR OTHER
Group 1 Ford of South Austin, TX refused to perform door latch recall unless we purchased additional parts and service out of pocket. The door will not latch and flies open even at slow speeds.
NHTSA complaint #11745330 — an unverified report by a vehicle owner.
Delray Beach, FL
ENGINE
I just recently got my fuel pump fixed and a new radiator fixed that was the knot problem wrong with my car now all of a sudden I get my car back from the shop with NO OIL I put oil even though I already just had a oil changed and my engine light is now blinking but when I bought the car it was just on [XXX] to Tallahassee and I live in eestpalm beach with no problem now my car smokes so much and auto shop Firestone says it’s my engine . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11745327 — an unverified report by a vehicle owner.
Federal Way, WA
VISIBILITY/WIPER
While driving back window spontaneously imploded
NHTSA complaint #11744999 — an unverified report by a vehicle owner.
Meridian, ID
UNKNOWN OR OTHER
Vehicle stalls while driving at low speeds and during acceleration. The engine loses power unexpectedly in traffic and may shut off completely while in motion. RPMs increase without corresponding acceleration and the vehicle fails to shift or respond normally. Check engine light is on with fuel/emissions-related codes. Fuel gauge is inaccurate and vehicle has unexpectedly run out of fuel even when gauge showed remaining fuel. The vehicle also hesitates, jerks, and feels unstable when stopping or turning. These issues have been present since shortly after purchase and have continued for approximately one year. Vehicle is unsafe to operate due to risk of stalling in traffic.
NHTSA complaint #11744465 — an unverified report by a vehicle owner.
San Jose, CA
UNKNOWN OR OTHER
For months in 2025 the car fan would continue to run for several minutes after the engine was turned off. I took the car in a two times to diagnose and couldn’t replicate . I sent video of the fan running even after short trips and in cold weather. Finally after catastrophic cooling system failure was the faulty fan module diagnosed. It was a safety issue because cooling failure causes car to stop operating properly. I was returning from the airport so the engine was cold. After a massive bill did the cooling fan module get diagnosed and replaced on May 16. There were not any safety recalls for faulty fan module. Hopefully this is reimbursable and others can have a safety recall.
NHTSA complaint #11743763 — an unverified report by a vehicle owner.
San Jose, CA
FUEL/PROPULSION SYSTEM
For months in early 2025, I was unable to fill gas tank without gas pump stopping ( so gas dispensers work to prevent gas from leaking?) Got progressively worse so less fuel could be put in gas tank. I took car into dealership to diagnose and fixed on April 25, 2025. I was at risk because the car can’t be filled and then unable to operate. Fuel filler neck was broken. I meant to report earlier and hopefully others can avoid the fix. No recall listed.
NHTSA complaint #11743754 — an unverified report by a vehicle owner.
Christiansburg, VA
STRUCTURE:BODY
While driving on the highway the sunroof suddenly blew off. The sunroof had not been opened prior. The frame bent upwards from the front, and the glass completely flew out onto the highway.
NHTSA complaint #11736311 — an unverified report by a vehicle owner.
Leander, TX
STEERING
Electric power steering failed at 65,000 miles. No power assist in the steering. Trying to steer the car with no power assist is very difficult and not safe.
NHTSA complaint #11735104 — an unverified report by a vehicle owner.
Mcdonough, GA
POWER TRAIN
Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.
NHTSA complaint #11734286 — an unverified report by a vehicle owner.
Mcdonough, GA
ELECTRICAL SYSTEM
Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.
NHTSA complaint #11734286 — an unverified report by a vehicle owner.
Mcdonough, GA
ENGINE
Beginning in approximately May 2025, the vehicle began displaying diagnostic trouble codes identified by independent auto parts retailers and service providers. These codes indicated potential issues within the engine, electrical, and powertrain systems. The vehicle was subsequently brought to a dealership for diagnostic evaluation and remained there from approximately May 15 through May 19, 2025. During this time, the dealership reported that no diagnostic codes were present and did not resolve the reported issue. However, the vehicle had recently exhibited repeatable symptoms, including entering “limp mode” and triggering diagnostic trouble codes, prior to being delivered to the dealership. Similar codes and issues were again identified after the dealership visit. The vehicle has experienced multiple incidents of entering “limp mode,” resulting in sudden loss of power and reduced drivability while in operation. This condition occurred without reliable warning and created unsafe driving situations, including the inability to maintain normal traffic flow. Due to safety concerns, the vehicle has not been driven under normal conditions since approximately May 2025 and has been limited to short, local movements only. The issue poses a safety risk to the driver, passengers, and surrounding traffic due to unexpected loss of power and inconsistent system diagnostics. The problem appears to be ongoing and unresolved. Independent diagnostic records and service visit documentation are available upon request.
NHTSA complaint #11734286 — an unverified report by a vehicle owner.
