49 of the
2,854 complaints filed about the Mini Cooper
are about the braking system —
2% of everything owners reported.
The worst model year for it is 2015.
Anytime the wipers are on and the speed is above 50 mph, this car periodically applies the brakes to keep the rotors dry. It's an automated system that BMW's and Mini's have. However, for some reason, the vehicle now pulls hard to the right, which veers the car into the other lane. The brake pads and rotors are all new. The tires are new and the alignment is good. The brake fluid was just changed and bled. There is literally nothing wrong except for this bizarre system which is now only applying some brake pressure to the front right rotor. The car slows and pulls right suddenly without applying the brake lights. I'm worried I will get rear ended or side swipe somebody. I've resorted to using Rainx and not using the wipers or simply avoiding driving in the rain. This is a serious issue that should be a recall. Thank you!
NHTSA complaint #11756726 — an unverified report by a vehicle owner.
While driving straight on an Interstate highway at approximately 65 mph, the right front and left rear brakes momentarily locked up after the windshield wipers were turned on due to light rain starting to fall. This happened multiple times, only when the wipers were turned on. There were no warning lights illuminated in the instrument cluster or dash displays. This nearly caused a loss of vehicle control on several occasions and nearly caused an accident as well. The car has been routinely serviced to factory schedules including brake fluid time based changes. There appeared to be some occasional delay in the release of the brakes when starting from a stop. The brakes were serviced after this incident and the service center recommended completing a few panic stops to operate the ABS system. They could not explain how the wiper system can cause one circuit of the braking system to operate momentarily. A search of web forums for the F56 series MINI shows that this random locking of the RF & LR brakes with teh wipers in operation has happened to quite a few other owners of similar Mini Coopers. This problem creates a very significant safety risk.
NHTSA complaint #11614123 — an unverified report by a vehicle owner.
The vehicle has been presenting issues with breaks, electrical issues, turning off while driving, misfires, air bags don't work, ADAS sometimes don't work, the vehicle chokes and has difficulty running at times, among other issues. There has been a recall since last year and I've tried contacting the manufacturer multiple times, but the issue has not been fixed yet. All of these problems are a great safety hazard for me and my family while on the road.
NHTSA complaint #11586940 — an unverified report by a vehicle owner.
Trailer brakes disconnected in 18k lb trailer while driving down mountain. This bulletin is the issue, should be a recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11585140 — an unverified report by a vehicle owner.
Received recall from MINI USA May 2023 “Safety Recall footwell control module 23V-337. Update May 2024 “remedy being developed”. I’m unable to have a mini dealership confirm safety of my veh as there are no dealerships in State of Maine, closest in Peabody MA 1.5 hrs away. It’s going on 1 yr & no remedy on the horizon? I called Mini USA hotline and they can’t help. This is unacceptable. Are they required to resolve in a timely manner? Should they be required to buy my veh back as it wouldn’t pass inspection & unable to drive?? Please provide next steps. Thank you
NHTSA complaint #11585025 — an unverified report by a vehicle owner.
Purchased the car new. On day two of having the vehicle and on a cold start in the morning, I noticed that the brake was very difficult to press in order to get the car started. Additionally, when applying the brake during driving it seemed to take a bit longer to slow down. I took the car into the dealer's service department and they confirmed that it was a bad brake booster. I am now waiting for the part to come in from Germany, which is backordered.
NHTSA complaint #11582529 — an unverified report by a vehicle owner.
Driver's side rear caliper appears to be rubbing into rotor...BMW claims that at 16,845 miles from new, that this is merely wear and tear...I believe it is a dangerous design flaw and should be properly vetted...
NHTSA complaint #11576560 — an unverified report by a vehicle owner.
Without any warning lamps,The vehicle started pulling left when the brakes were applied a certified mechanic looked at it and feels that is the due to a defective DSC/ABS control unit. The unit hasn't been otherwise inspected but is available for inspection
NHTSA complaint #11551994 — an unverified report by a vehicle owner.
1. (Lighting) The front lights of the car kept turning off and on. We would always go to the repair shop every time the lights began to malfunction. (Engine) the oil was sticky which was not normal and the water entered inside. (Brakes) When you turned on the car, noises came from the brakes which were concerning and risky to drive in. 2. This car was risky to drive due to the problems with the oil and brakes. 3. Yes, this problem has already been confirmed by a dealer. 4. No. 5. No.
NHTSA complaint #11516980 — an unverified report by a vehicle owner.
Left brake light continues to blow out with a loud pop through the speakers. Instrument at parts store shows ABS warning but not on dash. Bulb has been replaced approximately 5 times and continues to blow out after a day or two. No one can seem to find the problem.
NHTSA complaint #11512562 — an unverified report by a vehicle owner.
i Purchased the car in Dover Pa . INspection sticker had same milage as on car so i shoulda knew he slapped a sticker on . drove 150 miles dash lit ip like chrismas tree. 1st thing left window wont work , then left lock wont work had to lock from passenfger dide. then door wont open at all . have to get ou t passenger door . know that wont open have to put down passenger window pull handel to get out . car is possessed light work whren they want does all kinda crazt stuff . batter has problems . charge and still cant start it . and hatch locks so i cant get to battery. power steering leaking going bad . timing belt making noise . no power on hills .cracking noise in right front pulls to right had . hazard to me ive been locked inside three times could get out of car i coulda sat in heat and died or cold and froze . cant get out of car when it ts electric doors dont work . car sucks . this has been gradual thing these events from feb to may . now i just hate the car
NHTSA complaint #11493892 — an unverified report by a vehicle owner.
The proportioning value that controls brake function had a catastrophic failure and caused the brake calipers especially the left front to lock suddenly. The caused the left front wheel to lock and caused the car to pull hard to left and become difficult if not impossible to control. The car pulled hard left and risked the car moving uncontrollably into on coming traffic. The failed part was saved and is available for inspection. The safety of the driver(my wife) was put at risk during the loss of control of the car. Other cars in the area were also put at risk simply due to the loss of control of our car. The problem was confirmed by the independent service center. The vehicle was not drivable and was towed to the dealership. The dealership thought the root cause was the brake master cylinder. This turned out not to be the case. The root cause was the failed proportioning valve. This caused the calipers to lock. The discs, rotors, calipers and proportioning value were replaced. There were no warning lights and the car had been taken for regular service at the dealership which was included in the purchase of the car. We were told that there is no warning light for a failure of this part.
NHTSA complaint #11484820 — an unverified report by a vehicle owner.
I have made several attempts to reach out to dealer. The check engine light came on the same day I purchased car. I brought the car back, the dealer said they would replace it, but couldn't do the work that day. They provided me with a false inspection report. They never followed up with me after several months had gone by and several phone calls had been made with them refusing to return my call. The car turns off on its on while driving. The brakes are also not good on the car. I had to get an oil change, wiping blades after a month of having the car. The AC fan is also not functioning. I would like to escalate this issue, because I am unable to pass my state inspection as well as feeling unsafe to drive a car that can turn off anytime on the road while driving. I waited to take to inspection because I was waiting on the dealer to communicate when they will replace the part. after several months of refusing to respond to my phone calls and emails. I have decided to report their intentional negligence. I also purchased a warranty. through this company EPOVO auto group. I have not received a follow document certifying my warranty purchase through them. Uncertain of legitimacy of this warranty as well. I have filed a complaint with BBB and Federal Trade Commission. I have not received a response. The following failed inspection codes: P0014, P0015, MIL Command.
NHTSA complaint #11418450 — an unverified report by a vehicle owner.
WHEN PRESSING THE BREAK, THE ENGINE REVS. I TURNED ON THE CAR AND PRESSED THE BREAK. THE ENGINE REVVED. WHEN I PRESSED THE BRAKE AGAIN IT REVVED UP TO 7000 RPM. I TURNED OFF THE CAR. I DID THIS SEVERAL TIMES AND IT CONTINUED TO HAPPEN. I WAS AFRAID TO PUT THE CAR IN GEAR. WHILE DRIVING DOWN THE ROAD A MONTH AGO THE MINI ENGINE RPM RAISED AND THE CAR WENT FASTER EVEN THOUGH I WAS NOT PRESSING THE GAS. I WAS ABLE TO STOP IT.
NHTSA complaint #11396075 — an unverified report by a vehicle owner.
WHILE DRIVING, CARS AROUND ME WERE BEEPING WHEN I SWITCHED LANES AFTER SIGNALING AND STEPPED ON THE BRAKES. I WAS NEARLY REAR ENDED! COME TO FIND OUT ALL OF MY LIGHTING SYSTEMS WERE INOPERABLE. I HAD: *NO BRAKE LIGHTS *NO TURN SIGNALS *NO HAZARD LIGHTS *NO HEADLIGHTS *NO TAIL LIGHTS *WINDOWS WERE INOPERABLE. THE LIST GOES ON. THIS IS TERRIFYING TO HAVE HAPPEN WHILE DRIVING, AND EVEN WORSE, I DIDN'T REALIZE WHAT WAS HAPPENING UNTIL I HAD NEARLY BEEN HIT BY TWO DIFFERENT CARS. THIS WOULD HAVE BEEN EVEN WORSE HAD IT FAILED AT NIGHT. I HAD MY CAR TOWED TO THE DEALER TO BE DIAGNOSED. THE ISSUE IS THAT THE FOOTWELL MODULE (AKA FRM) HAD FAILED. THIS HAPPENED AT ONLY 41,000 MILES. APPARENTLY THIS IS EXTREMELY COMMON AND A LONG-KNOWN DEFECT ON MINI COOPERS. IN MY OPINION THERE NEEDS TO BE AN IMMEDIATE RECALL ON ALL AFFECTED FRMS. I LEARNED THAT MINI ISSUED A "SILENT RECALL" OF EXTENDED WARRANTIES, FROM 4 YEARS TO 8 YEARS, AND NOW TO 10 YEARS/156,000 MILES. I AM OUTSIDE OF WARRANTY 6 MONTHS BY TIME, BUT WITHIN WARRANTY BY 115,000 MILES. I CONTACTED MINI USA TO REQUEST THAT THEY COVER THE PART REPAIR, AS THIS IS A KNOWN DEFECTIVE PART IN MY CAR'S MODEL AND YEAR AND A CRITICAL SAFETY ISSUE. THEY HAVE REFUSED, DESPITE ME GETTING IN TOUCH THREE TIMES. I ALSO NOTIFIED CUSTOMER RELATIONS AT MINI USA THAT I NEVER RECEIVED NOTIFICATION OF THE WARRANTY EXTENSION ON THIS PART, OR ON ANY OTHER PART. ADDITIONALLY, I HAVE NOT RECEIVED ANY NOTIFICATION OF RECALLS THAT APPLY TO MY VEHICLE, THOUGH THROUGH MY RECENT RESEARCH I HAVE FOUND THAT SOME HAVE BEEN ISSUED. A QUICK GOOGLE SEARCH AS WELL AS DISCUSSIONS WITH MINI TECHS WILL REVEAL WIDESPREAD FRM FAILURE. MANY OTHER COMPLAINANTS ON THIS PAGE ARE REGARDING THE SAME ISSUE. HAS ANY INVESTIGATION TAKEN PLACE? IF NOT, I HOPE THERE WILL BE ONE.
NHTSA complaint #11353457 — an unverified report by a vehicle owner.
THE POWER STEERING ASSIST HAS ALL BUT STOPPED WORKING, WITH STEERING NOW DIFFICULT AT LOWER SPEED--ESPECIALLY WHEN I FIRST START THE ENGINE IN THE MORNING. THE CLUTCH DOESN'T RESPOND WELL AND THE VEHICLE NO LONGER GOES INTO SECOND GEAR. THE REAR LEFT BRAKE CALIPER SEIZED IN PLACE, NOT ALLOWING THE BRAKE PAD TO RETRACT COMPLETELY AND THEREFORE THE BRAKE PAD CONTINUOUSLY RUBBED AGAINST THE DISC, BUT WITHOUT NOISE. NOT UNTIL THE LEFT REAR BRAKE MADE NOISE BECAUSE OF THE METAL ON METAL BRAKING WAS THE SEIZED OEM CALIPER IDENTIFIED, WHEN I PUT ON A SET OF NEW BRAKE PADS. NONE OF THE OTHER THREE BRAKES HAD THE SEIZED OEM CALIPER.
NHTSA complaint #11311300 — an unverified report by a vehicle owner.
HANDBRAKE HARNESS NOT ROUTED AS DESIGNED. FROM THE PICTURE YOU CAN SEE THE HARNESS NOT INSIDE THE CLIP. THIS MAKES THE HANDBRAKE HARNESS SHORT FROM POINT TO POINT. WHICH WILL LEAD TO MY REAR PASSENGER SIDE BRAKE ALWAYS ON. AND ALSO, IT WILL CAUSE A SERIOUS SAFETY ISSUE IF I WANT TO USE MY HANDBRAKE TO STOP MY VEHICLE. THE FORCE APPLIED ON PASSENGER SIDE IS WAY MORE THAN DRIVE SIDE ( IT WAS INSTALLED CORRECTLY ) . AND IT MAY LEAD MY PASSENGER SIDE HANDBRAKE WIRING HARNESS BROKEN ( BECAUSE OF THE INCORRECT ROUTING ) I FOUND IT OUT WHEN MY BRAKE LIGHT IN ON. MY FRONT BRAKE STILL WORKING FOR ANOTHER 1100 MILES WHILE MY REAR BRAKE SENSOR TELL ME I NEED TO CHANGE MY BRAKE . WE CHANGE THE REAR PASSENGER BRAKE AND FOUND OUT ITS DIFFICULT TO CLIP THE HANDBRAKE WIRING HARNESS TO RIGHT HOLE. THEN WE TRACK THE WIRING DONE. IT'S SHOCKS ME . THE ROUTING IS 100% INCORRECT. YOU CAN SEE THE CORRECT HANDBRAKE HOLE IS EMPTY.
NHTSA complaint #11196221 — an unverified report by a vehicle owner.
FEBRUARY 21, 2019 I WAS PULLING INTO A PARKING SPACE AND THE BRAKES TEMPORARILY FAILED. WHEN I PUMPED THEM A SECOND TIME THEY CAME TO A STOP, HOWEVER BY THEN THE CAR AND I HAD GONE OVER A HEDGE AND SIDE SWIPED A TREE. BMW NORTH AMERICA COULD NOT FIND ANY WARNING ON MARCH 11, 2019 WHEN THEY REVIEWED THE SYSTEMS, NO WARNINGS AT ALL, NO AIR BAGS DEPLOYED. I WAS TURNING IN TO A FAMILIAR PARKING LOT AT A SLOW SPEED.
NHTSA complaint #11195306 — an unverified report by a vehicle owner.