23 of the 624 complaints about the 1991 Plymouth Voyager are about the electrical system — 4% of everything reported for this model year.
23
Complaints
0
Crashes
3
Fires
0
Injuries
Filed with NHTSA, in their own words.
ELECTRICAL SYSTEM
VEHICLE DIED. ATTEMPT TO RESTART FAILED. FIRE BURST FROM UNDER HOOD. ENTIRE VEHICLE, INSIDE AND OUT, BECAME ENGULFED IN FLAMES. TOTALLY BURNED INSIDE AND OUT. FATHER ABLE TO GET THREE SMALL CHILDREN OUT OF VEHICLE WITHOUT INJURIES. RANGER STATED THAT FIRE STARTED UNDER DASH.
NHTSA complaint #10146102 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING
RUBBER PLASTIC MOUNTING IS MELTING AROUND AREA OF LICENSE PLATE. MELTING CAN CAUSE A POTENTIAL FIRE. DEALER STATES THAT MATERIAL IS TOO HEAT SENSITIVE. PROBLEM IS BEING REPAIRED FOR SECOND TIME. DEALER WAS NOTIFIED. *AK CONSUMER STATES THAT THE WIRING HARNESS TO LICENSE PLATE LIGHTS HAD MELTED AT BULB SOCKETS. SOCKETS NO LONGER ATTACHED TO TAILGATE.
NHTSA complaint #8006101 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
RUBBER PLASTIC MOUNTING IS MELTING AROUND AREA OF LICENSE PLATE. MELTING CAN CAUSE A POTENTIAL FIRE. DEALER STATES THAT MATERIAL IS TOO HEAT SENSITIVE. PROBLEM IS BEING REPAIRED FOR SECOND TIME. DEALER WAS NOTIFIED. *AK CONSUMER STATES THAT THE WIRING HARNESS TO LICENSE PLATE LIGHTS HAD MELTED AT BULB SOCKETS. SOCKETS NO LONGER ATTACHED TO TAILGATE.
NHTSA complaint #8006101 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
WHEN APPLYING BRAKES PEDAL WILL INTERMITTENTLY GO TO THE FLOOR, AND BRAKE LIGHT COMES ON. VEHICLE TAKEN TO DEALER 7 TIMES, REPLACED ACCUMULATER PUMP, WIRING HARNESS, AND MULTI- FUNCTION SWITCH. BUT, DID NOT REMEDY PROBLEM.ALSO, THERE WAS A RECALL ON THE ABS SYSTEM, BUT THIS VEHICLE WAS NOT AFFECTEDDUE TO VIN.
NHTSA complaint #897871 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
WHILE DRIVING VEHICLE CAUGHT ON FIRE UNDER THE HOOD WITHOUT ANY WARNING. DRIVER EXTINGUISHED THE FLAMES. LIFTED HOOD AND NOTICED ELECTRICAL WIRING HARNESS WAS BURNT. HAS NOT TAKEN VEHICLE TO DEALERSHIP.
NHTSA complaint #863537 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:HORN
VEHICLE EXPERIENCED HORN FAILURE. DEALER NOTIFIED AND INFORMED CONSUMER THAT RELAY NEEDS TO BE REPLACED. DEALER REPLACED RELAY BUT HORN STILL FAILS TO OPERATE. *AK
NHTSA complaint #857266 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING
WHILE DRIVING AT ANY SPEED THERE IS SOME TYPE OF NOISE WITHIN THE RUBBER BOOTS. ALSO,DOOR LOCKS/SPEEDOMETER ARE NOT WORKING, AND ELECTRICAL WIRES SHORTED OUT. DEALER CAN'T DETERMINE CAUSE OF THE THE PROBLEM.
NHTSA complaint #850120 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FRONT UNDERHOOD
CONSUMER STARTED ENGINE, TURNED HEATER ON, AND SAT FOR 10-15 MINUTES AND SMOKE CAME IN THROUGH VENTS. THEN FLAMES CAME OUT OF HOOD. VEHICLE BURNED TOTALLY. SMOKE WAS EXTREMELY THICK.
NHTSA complaint #836294 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
ENTIRE IGNITION LOCK CYLINDER FELL OUT.
NHTSA complaint #520772 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR
ALTERNATOR FAILED.
NHTSA complaint #520772 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
ELECTRICAL SYSTEM FAILURE, STALLING VEHICLE.
NHTSA complaint #603405 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
VEHICLE STALLS WITH NO WARNING AT ANY SPEED. PLEASE DESCRIBE.
NHTSA complaint #986874 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
VEHICLE WILL STALL WITHOUT WARNING WHILE DRIVING AT ANY SPEED.
NHTSA complaint #983718 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
VEHICLE WILL STALL WITHOUT WARNING WHILE DRIVING AT ANY SPEED.
NHTSA complaint #983718 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
ENGINE; WHILE DRIVING THE VEHICLE, THE VEHICLE STALLS/HESITATES/STUMBLES AND ALSO CUTS OFF.
NHTSA complaint #980844 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
FUSE BLEW, WHILE DRIVING, HEADLIGHTS/TAIL LIGHTS WENT OUT; REPLACED WITH NEW FUSE; WITHIN AN HOUR WENT OUT AGAIN; CAUSED VISION PROBLEM. TT
NHTSA complaint #978562 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
THE VEHICLE STARTS AND WILL RUN FOR AWHILE THEN DIE WHILE DRIVING. PLEASE DESCRIBE. TT
NHTSA complaint #973063 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
INTERMITTENT STALLING. *SKD
NHTSA complaint #481831 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
PICK UP COIL FAILED.
NHTSA complaint #489574 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
VEHICLE STALLS.
NHTSA complaint #489574 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING
ABS/BRAKE LIGHT CAME ON DUE TO SHORT IN ELECTRICAL HARNESS.
NHTSA complaint #967044 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:12V/24V/48V BATTERY
REPLACED BATTERY.
NHTSA complaint #963621 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
IGNITION SENSOR FAILED, CAUSING VEHICLE TO STALL.
NHTSA complaint #478340 — an unverified report by a vehicle owner.