Owners have filed 234 complaints
about the 2020 RAM 2500 with NHTSA between 2020 and 2026.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 10 of 15 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 24
Against the median year of the RAM 2500. 50 means typical for this
model; 100 means roughly double.
Severity — 46
9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
77% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
1418.7%
1,000 – 9,999 miles
2330.7%
10,000 – 24,999 miles
1520.0%
25,000 – 49,999 miles
1216.0%
50,000 – 74,999 miles
45.3%
75,000 – 99,999 miles
11.3%
100,000 – 149,999 miles
45.3%
150,000+ miles
22.7%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2020 Ram 2500 Crew PU/CC 4WD
29.2% risk
2020 Ram 2500 Crew PU/CC 2WD
19.8% risk
2020 Ram 2500 Mega PU/EC 4WD
—
—
—
29.2% risk
2020 Ram 2500 Regular PU/RC 4WD
—
—
—
29.2% risk
2020 Ram 2500 Regular PU/RC 2WD
—
—
—
19.8% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2020peak 15Aug 2026
NHTSA investigations into the 2020 RAM 2500
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA23001Opened 17 Mar 2023Still openFUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
High pressure fuel pump failure
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021, to investigate incidents alleging a stall/loss of motive power as a result of high-pressure fuel pump failures in certain model year (MY) 2019-2020 Ram 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines. During the investigation, ODI sought to determine if the related defect allegation was limited in scope to the recalled population. After review of information request response materials from both FCA and BMW, NHTSA determined that sufficient information to identify a compreh...
PE21021Opened 14 Oct 2021Closed 14 Apr 2023FUEL SYSTEM, DIESEL:DELIVERY:FUEL PUMP
High pressure fuel pump failure
The Office of Defects Investigation (ODI) opened PE21-021 on October 14, 2021 to investigate allegations of stall/loss of motive power as a result of high pressure fuel pump failures in certain model year (MY) 2019-2020 RAM 2500, 3500, 4500, and 5500 heavy duty trucks equipped with 6.7L Cummins turbodiesel engines.On November 12, 2021, FCA filed vehicle recall 21V-880 and equipment recall 21E-094 on the subject population, identifying an `internally failed component? of the high pressure fuel pump equipped on the 6.7L Cummins Turbodiesel engine that introduced debris into the fuel system poten...
Recalls on the 2020 RAM 2500
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20250131,393 units in Canada
Airbag
Issue: On certain trucks, the side curtain airbag inflators may be defective. As a result, the driver and/or passenger side curtain airbag inflator(s) could rupture unexpectedly and metal fragments could be propelled toward vehicle occupants. Note: This recall also affects certain 2016 model year RAM 3500 chassis cab incomplete vehicles. Safety Risk: An airbag inflator that ruptures can create a risk of injury. Corrective Actions: FCA Canada will notify owners in writing and advise you to take your truck to a dealership to replace the affected side curtain airbag(s).
Recall 2024548314,717 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label does not list that there is no spare tire in both official languages. The label reads as "NONE" when it should read as "NONE / AUCUN". Canadian regulations require the information to be listed on the label in both English and French. Safety Risk: This error does not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the tire and loading information label for all new vehicles.
Recall 2022699120,706 units in Canada
Structure
Issue: On certain trucks, the tailgate could unlatch and open while driving. If this happens, cargo that is not secured could fall out of the truck bed and onto the road. Safety Risk: Cargo that falls from the truck bed could create a road hazard for others. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your truck to a dealership to inspect the alignment of the tailgate strikers, and adjust them if necessary.
Recall 202264417,606 units in Canada
Powertrain
Issue: On certain trucks, a buildup of heat and pressure inside the transmission could cause fluid to leak from the transmission dipstick tube. Note: This recall only affects trucks equipped with a Cummins 6.7 L diesel engine and a 68RFE automatic transmission. Safety Risk: A transmission fluid leak could create the risk of a fire. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealership to replace the transmission dipstick and vent assembly.
Recall 202210829,656 units in Canada
Brakes
Issue: On certain vehicles, the warning lamp for the electronic stability control (ESC) system may not turn on when there is a problem with the ESC system. Safety Risk: A driver that is not aware of a problem with the ESC system could have an increased risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to update the antilock brake system (ABS) control module software.
Recall 202202516,332 units in Canada
Visual System
Issue: On certain trucks, the nuts that attach the windshield wiper arms may not have been tightened properly. This could cause the wipers to slip and not clear the windshield properly. Safety Risk: Windshield wipers that do not work properly could affect a driver's visibility. This could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to tighten the nuts on the windshield wiper arms.
Recall 202169120,539 units in Canada
Fuel System
Issue: On certain vehicles equipped with a 6.7 L Cummins diesel engine, the high-pressure fuel pump could fail. If this happens, you may notice a change in engine performance, a fuel leak, or the check engine light may turn on. This could also result in a sudden loss of engine power while driving. Safety Risk: A sudden loss of engine power could increase the risk of a crash. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealership to replace the high-pressure fuel pump and update the powertrain control module software. Additional fuel system parts may be replaced, if necessary.
Recall 20204722,660 units in Canada
Visual System
Issue: On certain trucks, the driver side rearview mirror glass may not be properly attached. As a result, the mirror glass could fall off. Safety Risk: A missing mirror will reduce rear visibility and could increase the risk of a crash. Corrective Actions: Fiat Chrysler Automobiles Canada will notify owners by mail and instruct you to take your truck to a dealer to replace the driver side mirror glass.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 35,272 milesAragon, GA1 injured
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
The contact owns a 2020 Ram 2500. The contact stated that while standing directly behind the tailgate, the contact heard an audible "click", and the tailgate independently unlatched and opened, striking the contact's chest, and the contact was forcefully knocked to the ground. Due to the severity of the impact and injury, the contact was immobilized on the ground for 45 minutes while calling out for emergency assistance. The contact sustained a broken femur. The contact related the failure to NHTSA Campaign Number: 22V904000 (Structure), in which the vehicle did not have the recall remedy performed to prevent the failure. Prior to the failure, the vehicle was taken to the dealer for the recall repair; however, the dealer determined that no repair was needed and marked the recall as complete. The vehicle was taken back to the same dealer for a reinspection, with a diagnostic fee included, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact mentioned being concerned for their safety when driving the vehicle. The failure mileage was 35,272.
NHTSA complaint #11743463 — an unverified report by a vehicle owner.
at 35,272 milesAragon, GA1 injured
STRUCTURE
The contact owns a 2020 Ram 2500. The contact stated that while standing directly behind the tailgate, the contact heard an audible "click", and the tailgate independently unlatched and opened, striking the contact's chest, and the contact was forcefully knocked to the ground. Due to the severity of the impact and injury, the contact was immobilized on the ground for 45 minutes while calling out for emergency assistance. The contact sustained a broken femur. The contact related the failure to NHTSA Campaign Number: 22V904000 (Structure), in which the vehicle did not have the recall remedy performed to prevent the failure. Prior to the failure, the vehicle was taken to the dealer for the recall repair; however, the dealer determined that no repair was needed and marked the recall as complete. The vehicle was taken back to the same dealer for a reinspection, with a diagnostic fee included, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact mentioned being concerned for their safety when driving the vehicle. The failure mileage was 35,272.
NHTSA complaint #11743463 — an unverified report by a vehicle owner.
Elgin, SCFire
ELECTRICAL SYSTEM
As I was operating my vehicle on I95 northbound smoke began to pour out of my vents. I was able to pull over and was able to determine there was a fire behind the radio in my truck. I immediately grabbed the personal affects that I could grab and called 911. However within 5 minutes the cab of the truck.was engulfed im flames.
NHTSA complaint #11687105 — an unverified report by a vehicle owner.
at 67,000 milesGreenville, SCFire
ELECTRICAL SYSTEM
The contact owns a 2020 Ram 2500. The contact stated that after starting the engine, moments later the contact came back to discover fire coming from under the hood of the vehicle. The contact and co-workers used fire extinguishers to extinguish the flames. The vehicle was later towed away. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 67,000.
NHTSA complaint #11611450 — an unverified report by a vehicle owner.
at 67,000 milesGreenville, SCFire
ENGINE
The contact owns a 2020 Ram 2500. The contact stated that after starting the engine, moments later the contact came back to discover fire coming from under the hood of the vehicle. The contact and co-workers used fire extinguishers to extinguish the flames. The vehicle was later towed away. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure but no assistance was offered. The failure mileage was 67,000.
NHTSA complaint #11611450 — an unverified report by a vehicle owner.
at 115,000 milesWinston-Salem, NCCrash1 injured
SERVICE BRAKES, HYDRAULIC
The contact owns a 2020 Ram 2500. The contact stated while driving at approximately 45 MPH, the contact swerved to the left to avoid crashing into a deer. The contact stated that when he attempted to return the vehicle to the right lane the vehicle's front end continued to turn to the left as the rear end of the vehicle spun out to the right. The contact stated that the vehicle hit the shoulder of the road on the right side, rolled once, and stopped. The vehicle had rolled onto the passenger side of the vehicle. The contact stated that no air bags inflated. The contact stated that the right side of the vehicle was dented and heavily scratched, and the right front and rear passenger doors were crushed, and the glass of the rear cab window was broken. The contact had not noticed any warning lights. The contact stated that he had bruises on the left side of his forehead and an abrasion on his right ear. The contact was driven to a local ER by a friend and had a CT scan performed and was released. The contact stated that a state trooper had written a report and issued a citation. The contact had the vehicle towed to his residence. The vehicle had not been diagnosed and was not repaired. The contact had researched online and related the failure to NHTSA Campaign Number: 22V140000 (Service Brakes, Hydraulic, Electronic Stability Control). The manufacturer was informed of the failure. The failure mileage was approximately 115,000.
NHTSA complaint #11579705 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Chauvin, LA
POWER TRAIN
RAM COMPLIANCE RECALL PORTAL DROPPED (MOPAR Y78) VIN:[XXX] / Miles:110,862 Static 1.Driveway photo [XXX] proves 50PSI idle oil pressure, 0 warning lights on June 30. 2.Video [XXX] captures raw CP4 pump shards in filter housing. 3.Dealer faked portal closure July 7 without flush. Forced engine start thrashed valvetrain, gear indexes & rocker arms post-intake. Full 12-pg matrix brief sent under corporate Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755737 — an unverified report by a vehicle owner.
Chauvin, LA
ENGINE
RAM COMPLIANCE RECALL PORTAL DROPPED (MOPAR Y78) VIN:[XXX] / Miles:110,862 Static 1.Driveway photo [XXX] proves 50PSI idle oil pressure, 0 warning lights on June 30. 2.Video [XXX] captures raw CP4 pump shards in filter housing. 3.Dealer faked portal closure July 7 without flush. Forced engine start thrashed valvetrain, gear indexes & rocker arms post-intake. Full 12-pg matrix brief sent under corporate Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755737 — an unverified report by a vehicle owner.
Chauvin, LA
FUEL/PROPULSION SYSTEM
RAM COMPLIANCE RECALL PORTAL DROPPED (MOPAR Y78) VIN:[XXX] / Miles:110,862 Static 1.Driveway photo [XXX] proves 50PSI idle oil pressure, 0 warning lights on June 30. 2.Video [XXX] captures raw CP4 pump shards in filter housing. 3.Dealer faked portal closure July 7 without flush. Forced engine start thrashed valvetrain, gear indexes & rocker arms post-intake. Full 12-pg matrix brief sent under corporate Case #[XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755737 — an unverified report by a vehicle owner.
at 150,128 milesLower Lake, CA
ENGINE
The contact owns a 2020 RAM 2500. The contact stated while driving at an undisclosed speed, the contact noticed that the engine was running unusually rough and the engine seized. No warning lights were illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with a failed engine. The contact was informed that the heater intake bolt was detached and entered into the number 6 cylinder. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure was a known failure regarding the vehicle. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 150,128.
NHTSA complaint #11748863 — an unverified report by a vehicle owner.
at 46,000 milesHooks, TX
ENGINE
The contact owns a 2020 Ram 2500. The contact stated that while driving the vehicle at an undisclosed speed, a tapping sound was heard, which gradually grew louder. The next day, the vehicle was taken to a dealer where it was diagnosed with a piston 5 failure, and the dealer determined that the engine needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 46,000.
NHTSA complaint #11748901 — an unverified report by a vehicle owner.
at 35,272 milesAragon, GA1 injured
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
The contact owns a 2020 Ram 2500. The contact stated that while standing directly behind the tailgate, the contact heard an audible "click", and the tailgate independently unlatched and opened, striking the contact's chest, and the contact was forcefully knocked to the ground. Due to the severity of the impact and injury, the contact was immobilized on the ground for 45 minutes while calling out for emergency assistance. The contact sustained a broken femur. The contact related the failure to NHTSA Campaign Number: 22V904000 (Structure), in which the vehicle did not have the recall remedy performed to prevent the failure. Prior to the failure, the vehicle was taken to the dealer for the recall repair; however, the dealer determined that no repair was needed and marked the recall as complete. The vehicle was taken back to the same dealer for a reinspection, with a diagnostic fee included, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact mentioned being concerned for their safety when driving the vehicle. The failure mileage was 35,272.
NHTSA complaint #11743463 — an unverified report by a vehicle owner.
at 35,272 milesAragon, GA1 injured
STRUCTURE
The contact owns a 2020 Ram 2500. The contact stated that while standing directly behind the tailgate, the contact heard an audible "click", and the tailgate independently unlatched and opened, striking the contact's chest, and the contact was forcefully knocked to the ground. Due to the severity of the impact and injury, the contact was immobilized on the ground for 45 minutes while calling out for emergency assistance. The contact sustained a broken femur. The contact related the failure to NHTSA Campaign Number: 22V904000 (Structure), in which the vehicle did not have the recall remedy performed to prevent the failure. Prior to the failure, the vehicle was taken to the dealer for the recall repair; however, the dealer determined that no repair was needed and marked the recall as complete. The vehicle was taken back to the same dealer for a reinspection, with a diagnostic fee included, but the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact mentioned being concerned for their safety when driving the vehicle. The failure mileage was 35,272.
NHTSA complaint #11743463 — an unverified report by a vehicle owner.
Fleming Island, FL
AIR BAGS
My 2020 Ram 2500 Mega Cab truck Dash Leather Covering is coming loose from it base and may interfere with the passenger Air Bag deployment that is under the loose material. My truck has only 36,000 miles on it and has been garaged kept since I purchased it new. *I found this information online. Ram 2500 trucks (2019–2023) frequently experience dashboard leather bubbling or delamination, particularly over the passenger airbag area. This bulging can compromise airbag deployment and is caused by adhesive failure, often requiring a full dashboard replacement. I contacted my local Ram service center. They advised my to contact Ram corporate regarding this Safety Issue. Key Details Regarding the Issue: •Cause: The glue holding the leather/vinyl to the dash substrate fails, leading to bubbling and peeling, which can create a ridge over the passenger airbag deployment zone. •Safety Risk: A warped or bulging dashboard can interfere with the proper deployment of the passenger-side airbag.
NHTSA complaint #11728458 — an unverified report by a vehicle owner.
Mesa, AZ
ENGINE
Massive oil leak that everyone has issues with also has a grid heater bolt that fails and causes engine damage. The oil leaks are terrible for the environment and causing leaks all over every road
NHTSA complaint #11722748 — an unverified report by a vehicle owner.
Salt Lick, KY
UNKNOWN OR OTHER
The reverse went out while driving
NHTSA complaint #11717800 — an unverified report by a vehicle owner.
Salt Lick, KY
ENGINE
The reverse went out while driving
NHTSA complaint #11717800 — an unverified report by a vehicle owner.
Richmond, VA
UNKNOWN OR OTHER
Hood liner repeatedly drops down out of its mounting points on the edge near the engine firewall. This is a manufacturing engineering deficiency that relies on shaped material to hold the liner in place. The dealer has replaced it three times, and the same thing continues to happen. Chrysler refuses to address the issue. My concern is what happens if the liner completely drops down on the engine while in operation.
NHTSA complaint #11716542 — an unverified report by a vehicle owner.
West Valley City, UT
UNKNOWN OR OTHER
While towing, my trailer brakes and lights come off and on randomly. I've had the wiring repaired on my trailer and it did not fix the issue. I've almost been in several accidents while towing, It is very unsafe.
NHTSA complaint #11716032 — an unverified report by a vehicle owner.
Fort Wainwright, AK
ENGINE
Def pump failed twice with this vehicle and with that it does not allow the vehicle to run any faster than 5 mph after the countdown ends. Unknown how the exhaust being plugged and service was done to clean the exhaust ended up having the fuel pump and turbo charger needing replaced. Not sure if they went hand in hand and one causing the other. So far the vehicle only has almost 78,000 miles on it. Change oil and fuel filters at the vehicles scheduled computer system reports on the vehicle. I was having issues from service center having trouble resetting the exhaust system, which they said the system was not sealing properly. Took them a couple of days to get part from dealership to get it to seal and reprocessed the test which they said passed exhaust reset. That would explain the poor fuel rating of only getting 9 miles per gallon. If there was a complete fuel pump failure, not sure if that would compare to this being a safety issue. Not sure how engine would react, due to it completely failing or if the turbo would cause the vehicle to be unsafe. The vehicle is currently at dealership and only 1 out of the 3 are even available to fix this problem. Def pump is available, but unknown when the others will arrive. Service shop said it could be 3 weeks or 8 months for parts to come in. Due to being a back ordered item. Spent $70k for this vehicle, just to have it spend over 2 months in the shop. I do my own oil and fuel filter changes, due to it being faster and cheaper than any dealer or shop.
NHTSA complaint #11713822 — an unverified report by a vehicle owner.
Fort Wainwright, AK
FUEL/PROPULSION SYSTEM
Def pump failed twice with this vehicle and with that it does not allow the vehicle to run any faster than 5 mph after the countdown ends. Unknown how the exhaust being plugged and service was done to clean the exhaust ended up having the fuel pump and turbo charger needing replaced. Not sure if they went hand in hand and one causing the other. So far the vehicle only has almost 78,000 miles on it. Change oil and fuel filters at the vehicles scheduled computer system reports on the vehicle. I was having issues from service center having trouble resetting the exhaust system, which they said the system was not sealing properly. Took them a couple of days to get part from dealership to get it to seal and reprocessed the test which they said passed exhaust reset. That would explain the poor fuel rating of only getting 9 miles per gallon. If there was a complete fuel pump failure, not sure if that would compare to this being a safety issue. Not sure how engine would react, due to it completely failing or if the turbo would cause the vehicle to be unsafe. The vehicle is currently at dealership and only 1 out of the 3 are even available to fix this problem. Def pump is available, but unknown when the others will arrive. Service shop said it could be 3 weeks or 8 months for parts to come in. Due to being a back ordered item. Spent $70k for this vehicle, just to have it spend over 2 months in the shop. I do my own oil and fuel filter changes, due to it being faster and cheaper than any dealer or shop.
NHTSA complaint #11713822 — an unverified report by a vehicle owner.
at 41,000 milesColton, CA
POWER TRAIN
The contact owns a 2020 Ram 2500. The contact stated while driving 75 MPH, traffic started to slow down, and the vehicle failed to stop as intended while depressing the brake pedal. The contact depressed the brake pedal again, and the vehicle abruptly stopped and veered to the left. The contact was able regain control of the vehicle and pulled over to the shoulder. Several unknown warning lights were illuminated. The contact stated that the ABS, 4x4, and brakes warning lights were illuminated, and other unknown warning lights were illuminated. Additionally, a metallic burning odor was coming from the vehicle. The vehicle was towed to the residence. When the tow truck driver lowered the vehicle, the contact noticed that the front driver’s side wheel seemed bent. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 41,000.
NHTSA complaint #11703837 — an unverified report by a vehicle owner.
at 41,000 milesColton, CA
SERVICE BRAKES, HYDRAULIC
The contact owns a 2020 Ram 2500. The contact stated while driving 75 MPH, traffic started to slow down, and the vehicle failed to stop as intended while depressing the brake pedal. The contact depressed the brake pedal again, and the vehicle abruptly stopped and veered to the left. The contact was able regain control of the vehicle and pulled over to the shoulder. Several unknown warning lights were illuminated. The contact stated that the ABS, 4x4, and brakes warning lights were illuminated, and other unknown warning lights were illuminated. Additionally, a metallic burning odor was coming from the vehicle. The vehicle was towed to the residence. When the tow truck driver lowered the vehicle, the contact noticed that the front driver’s side wheel seemed bent. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 41,000.
NHTSA complaint #11703837 — an unverified report by a vehicle owner.
Frederick, MD
ELECTRICAL SYSTEM
2500 Truck randomly activates emergency braking for no reason. Occurs a couple times a month. Every occurrence has zero obstructions in front. I took it to the Tate Ram dealer (frederick MD) and they refused to update their software unless I pay them +$285.00. The Ram dealer is even aware of the software issue. I told them this is a life safety issue and not my fault. I requested the fix immediately but refused. I also have an active full MOPAR warranty, and they still said it's not covered. This is insane
NHTSA complaint #11694963 — an unverified report by a vehicle owner.
Frederick, MD
SERVICE BRAKES
2500 Truck randomly activates emergency braking for no reason. Occurs a couple times a month. Every occurrence has zero obstructions in front. I took it to the Tate Ram dealer (frederick MD) and they refused to update their software unless I pay them +$285.00. The Ram dealer is even aware of the software issue. I told them this is a life safety issue and not my fault. I requested the fix immediately but refused. I also have an active full MOPAR warranty, and they still said it's not covered. This is insane
NHTSA complaint #11694963 — an unverified report by a vehicle owner.
Frederick, MD
FORWARD COLLISION AVOIDANCE: WARNINGS
2500 Truck randomly activates emergency braking for no reason. Occurs a couple times a month. Every occurrence has zero obstructions in front. I took it to the Tate Ram dealer (frederick MD) and they refused to update their software unless I pay them +$285.00. The Ram dealer is even aware of the software issue. I told them this is a life safety issue and not my fault. I requested the fix immediately but refused. I also have an active full MOPAR warranty, and they still said it's not covered. This is insane
NHTSA complaint #11694963 — an unverified report by a vehicle owner.
Elgin, SCFire
ELECTRICAL SYSTEM
As I was operating my vehicle on I95 northbound smoke began to pour out of my vents. I was able to pull over and was able to determine there was a fire behind the radio in my truck. I immediately grabbed the personal affects that I could grab and called 911. However within 5 minutes the cab of the truck.was engulfed im flames.
NHTSA complaint #11687105 — an unverified report by a vehicle owner.
Owosso, MI
SERVICE BRAKES
I pushed my breaks and the hydro booster started spraying fluid inside the cab I lost my breaks I was backing up down my sister's drive way hit a telephone pole with the back of the truck it made a little dent
NHTSA complaint #11683879 — an unverified report by a vehicle owner.
Pioneer, CA
ENGINE
Subject: Fuel System Failure Resulting in Engine Damage – 2020 RAM 2500 Pickup VIN: [XXX] Complaint Summary: I am submitting this complaint to formally report a dangerous and costly fuel system defect in my 2020 Dodge Ram 2500 Pickup (VIN: [XXX] ) that has resulted in catastrophic engine damage. Although Chrysler has issued a recall for the high-pressure fuel pump (HPFP) in many 2020 Ram trucks equipped with the 6.7L Cummins engine, I was told that my vehicle was not included in the recall—even though it exhibits all the classic symptoms of HPFP failure. This is a safety hazard and a potential emissions violation. Details of the Incident: In June 2025, I brought my truck to Tracy Chrysler Dodge Jeep RAM after experiencing engine misfires, loss of power, and a knocking noise. The dealership diagnosed a P0303 cylinder misfire and noted a fuel smell in the engine oil, as documented in repair order #[XXX]. Despite extensive diagnostic work—including compression tests, leak-down, and injector swaps—the misfire remained unresolved, and a tapping noise persisted. The technician explicitly noted fuel contamination in the oil and suspected internal engine damage due to a fuel system issue. To further investigate, I submitted an oil sample to Blackstone Laboratories. The lab confirmed the engine oil was heavily diluted with diesel fuel—over 10% fuel contamination, which reduced the viscosity from 5W40 to the equivalent of 5W20. This is consistent with HPFP failure leaking fuel into the crankcase. The oil report also noted excessive steel wear and recommended immediate oil change and fuel system inspection. At no time was a check engine light present, nor was there a clear diagnostic code for HPFP failure. Chrysler continues to deny responsibility even though the evidence clearly points to a failed HPFP—a well-documented issue for this engine model and year. The cost of diagnosis and parts alone has exceeded $4,000, and the engine is likely destroy INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA
NHTSA complaint #11679223 — an unverified report by a vehicle owner.
Pioneer, CA
FUEL/PROPULSION SYSTEM
Subject: Fuel System Failure Resulting in Engine Damage – 2020 RAM 2500 Pickup VIN: [XXX] Complaint Summary: I am submitting this complaint to formally report a dangerous and costly fuel system defect in my 2020 Dodge Ram 2500 Pickup (VIN: [XXX] ) that has resulted in catastrophic engine damage. Although Chrysler has issued a recall for the high-pressure fuel pump (HPFP) in many 2020 Ram trucks equipped with the 6.7L Cummins engine, I was told that my vehicle was not included in the recall—even though it exhibits all the classic symptoms of HPFP failure. This is a safety hazard and a potential emissions violation. Details of the Incident: In June 2025, I brought my truck to Tracy Chrysler Dodge Jeep RAM after experiencing engine misfires, loss of power, and a knocking noise. The dealership diagnosed a P0303 cylinder misfire and noted a fuel smell in the engine oil, as documented in repair order #[XXX]. Despite extensive diagnostic work—including compression tests, leak-down, and injector swaps—the misfire remained unresolved, and a tapping noise persisted. The technician explicitly noted fuel contamination in the oil and suspected internal engine damage due to a fuel system issue. To further investigate, I submitted an oil sample to Blackstone Laboratories. The lab confirmed the engine oil was heavily diluted with diesel fuel—over 10% fuel contamination, which reduced the viscosity from 5W40 to the equivalent of 5W20. This is consistent with HPFP failure leaking fuel into the crankcase. The oil report also noted excessive steel wear and recommended immediate oil change and fuel system inspection. At no time was a check engine light present, nor was there a clear diagnostic code for HPFP failure. Chrysler continues to deny responsibility even though the evidence clearly points to a failed HPFP—a well-documented issue for this engine model and year. The cost of diagnosis and parts alone has exceeded $4,000, and the engine is likely destroy INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA
NHTSA complaint #11679223 — an unverified report by a vehicle owner.
Mt. Juliet, TN
SERVICE BRAKES
The parking brake will not operate. Upon inspection the teeth on the gear are broken causing it to lock at top position. Dealership would not warranty safety part at 30,059 miles on vehicle so now I am left with no parking brake to protect vehicle from rolling on hill. Keep in mind vehicle is always used for towing 12,000 pounds or more.
NHTSA complaint #11671827 — an unverified report by a vehicle owner.
