2024 RAM 2500 problems

EXTERIOR LIGHTING

The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the trailer braking system failed to operate, slow the vehicle, or stop the trailer while the brake pedal was depressed. The contact stated that the trailer brake disconnected warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 26V059000 (Exterior Lighting, Electrical System); however, the VIN was not included. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the trailer brake controller needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 12,000.

NHTSA complaint #11747148 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the trailer braking system failed to operate, slow the vehicle, or stop the trailer while the brake pedal was depressed. The contact stated that the trailer brake disconnected warning light was illuminated. The contact researched and was made aware of NHTSA Campaign Number: 26V059000 (Exterior Lighting, Electrical System); however, the VIN was not included. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the trailer brake controller needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 12,000.

NHTSA complaint #11747148 — an unverified report by a vehicle owner.

ENGINE

This is a brand new truck with 22,000 miles, a rod came loose in the engine when i was driving it, and blew a hole in the engine at 65 MPH, the rod then shot through my oil pan, I lost all drivability, no steering, no gas and I could not see due to black smoke. I almost died! I was able to pull over all the way to the left by the grace of God, not being able to see and having cars driving by at top speeds this is a catastrophic failure and the service Tech Ethan where the truck is says this happens 1 in every 1,000 trucks! The truck is at castle rock co dodge jeep ram

NHTSA complaint #11745646 — an unverified report by a vehicle owner.

SERVICE BRAKES

Brakes always collapse to the Floor. You cannot stick your toe in between the brake and the floorboard. But if you pump up the brakes like you used in the 1970''s the brake will rise and you can put a full foot underneath between the brake and the floorboard. Those making the brakes stop the truck 80%better. But if you put it in 4x4 mode there is almost no stopping power at all. You only have 10% of your brakes. Both issues can cause death and or injuries! If 4x4 is used on the road for rain or snow it will cause death and if your lucky just a major injury!!!!!!

NHTSA complaint #11743011 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The vehicle experienced repeated electrical and no-start issues believed to be related to the RF/electrical communication system. The truck has been returned to the dealership repeatedly for this issue and recently spent approximately two months at the dealership for diagnosis and repair. After finally being returned, the vehicle was completely dead the very next morning and would not start. The vehicle has also experienced dangerous electrical failures while being driven. During one incident at night, the headlights and interior electrical system became extremely dim and began flickering while an employee was operating the truck. Visibility was significantly reduced to the point the driver could barely see the roadway. During the same event, the brake pedal became abnormally hard to press intermittently, creating a serious safety concern while driving. The failure also occurred on our business lot where the truck was blocking multiple trailers needed for scheduled customer deliveries, creating operational disruption and safety concerns related to moving equipment and trailers around an inoperable heavy-duty truck. The dealership reportedly replaced or repaired an RF-related component/module during the repair process. However, the problem appears unresolved because the truck failed again immediately after being returned from service. Symptoms have included: * Complete battery drain/no-start condition * Flickering and dimming headlights/electrical systems * Intermittent hard brake pedal condition * Repeated electrical-related issues * Extended dealer downtime * Ongoing unresolved repair attempts The vehicle is available for inspection upon request. This truck is used daily for commercial/business operations. Reliability concerns are significant because unexpected electrical failure or no-start conditions can leave the vehicle stranded or create hazardous driving conditions. The issue has been reproduced after dealer repair attempts. Based on the symptoms and

NHTSA complaint #11735965 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The vehicle experienced repeated electrical and no-start issues believed to be related to the RF/electrical communication system. The truck has been returned to the dealership repeatedly for this issue and recently spent approximately two months at the dealership for diagnosis and repair. After finally being returned, the vehicle was completely dead the very next morning and would not start. The vehicle has also experienced dangerous electrical failures while being driven. During one incident at night, the headlights and interior electrical system became extremely dim and began flickering while an employee was operating the truck. Visibility was significantly reduced to the point the driver could barely see the roadway. During the same event, the brake pedal became abnormally hard to press intermittently, creating a serious safety concern while driving. The failure also occurred on our business lot where the truck was blocking multiple trailers needed for scheduled customer deliveries, creating operational disruption and safety concerns related to moving equipment and trailers around an inoperable heavy-duty truck. The dealership reportedly replaced or repaired an RF-related component/module during the repair process. However, the problem appears unresolved because the truck failed again immediately after being returned from service. Symptoms have included: * Complete battery drain/no-start condition * Flickering and dimming headlights/electrical systems * Intermittent hard brake pedal condition * Repeated electrical-related issues * Extended dealer downtime * Ongoing unresolved repair attempts The vehicle is available for inspection upon request. This truck is used daily for commercial/business operations. Reliability concerns are significant because unexpected electrical failure or no-start conditions can leave the vehicle stranded or create hazardous driving conditions. The issue has been reproduced after dealer repair attempts. Based on the symptoms and

NHTSA complaint #11735965 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL

The vehicle experienced repeated electrical and no-start issues believed to be related to the RF/electrical communication system. The truck has been returned to the dealership repeatedly for this issue and recently spent approximately two months at the dealership for diagnosis and repair. After finally being returned, the vehicle was completely dead the very next morning and would not start. The vehicle has also experienced dangerous electrical failures while being driven. During one incident at night, the headlights and interior electrical system became extremely dim and began flickering while an employee was operating the truck. Visibility was significantly reduced to the point the driver could barely see the roadway. During the same event, the brake pedal became abnormally hard to press intermittently, creating a serious safety concern while driving. The failure also occurred on our business lot where the truck was blocking multiple trailers needed for scheduled customer deliveries, creating operational disruption and safety concerns related to moving equipment and trailers around an inoperable heavy-duty truck. The dealership reportedly replaced or repaired an RF-related component/module during the repair process. However, the problem appears unresolved because the truck failed again immediately after being returned from service. Symptoms have included: * Complete battery drain/no-start condition * Flickering and dimming headlights/electrical systems * Intermittent hard brake pedal condition * Repeated electrical-related issues * Extended dealer downtime * Ongoing unresolved repair attempts The vehicle is available for inspection upon request. This truck is used daily for commercial/business operations. Reliability concerns are significant because unexpected electrical failure or no-start conditions can leave the vehicle stranded or create hazardous driving conditions. The issue has been reproduced after dealer repair attempts. Based on the symptoms and

NHTSA complaint #11735965 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

Description of the Issue: When full windshield defrost is selected—using either the infotainment system or physical HVAC controls—the system does not direct full airflow to the windshield. Instead, heated air is split between the windshield and floor vents, reducing airflow and heat at the windshield edges. As a result, ice forms and remains on the driver’s side windshield edge, beginning around the 11–12 o’clock steering wheel position and extending to the windshield edge. This occurs during cold conditions and restricts driver visibility, creating a safety hazard while driving. Safety Impact: The driver is unable to clear ice from the windshield edges, limiting visibility of adjacent lanes, pedestrians, and roadway conditions. When defrost is needed most, the system does not perform as required, preventing the driver from maintaining safe visibility. Inconsistent Operation: The HVAC/defrost system operates inconsistently under similar conditions. I have video evidence showing the system working correctly at times and failing at other times. In multiple cases, the only change was shutting the vehicle off and letting it sit. In one instance, the defrost later worked correctly the same day when ambient temperatures were warmer, suggesting a possible temperature-related or control issue. Videos documenting this behavior are available, including videos posted on YouTube. Additional HVAC Control Issue: The HVAC system will randomly set the temperature to 76°F and become unresponsive for approximately one minute. During this time, the driver cannot change any HVAC settings, creating distraction and preventing timely adjustment to address fogging or icing. This behavior is also documented on video. Repair Attempts: The vehicle has been taken to two RAM dealerships, and multiple parts have been replaced under warranty. The issue remains unresolved. A customer service case was also opened with RAM, but the HVAC and defrost issues have not been corrected.

NHTSA complaint #11734573 — an unverified report by a vehicle owner.

SERVICE BRAKES

When coming to a stop the truck has a very spongey pedal, in order to stop the vehicle you must allow for the stop by applying brake way in advance to be able to stop. When you applying pressure to the brake pedal the pedal is soft and goes almost to the carpet floor. When towing you feel extremely concerned if you can stop especially in an emergency braking situation. This is a problem that is ongoing and is happening every time you brake. The truck has 27k miles

NHTSA complaint #11733741 — an unverified report by a vehicle owner.

SEAT BELTS

The drivers side front seat belt stopped retracting. It was fixed when the warranty was good. I also reported the passenger side, later wasn't retracting. It retracted fine when the dealer had it so they didn't do anything with it. Now the warranty is up and it's hardly ever retracting but they want me to pay for it even thought I reported it when the warranty was good. Also, the driver's side seat belt doesn't always latch. You have to shove it in several times sometimes before it clicks. Sometimes you think it's in and it will unhook later while you're driving down the road.

NHTSA complaint #11732315 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

The contact owns a 2024 Ram 2500. The contact stated that while driving at an undisclosed speed, the brake pedal was depressed, but the vehicle failed to respond. The brake pedal was depressed to the floorboard. The brake pedal was soft, but after pumping it, the brake pedal became firm. The contact was unable to haul a trailer because the braking system was not operating properly. The contact stated that the ABS unintendedly engaged when not needed, but failed to function properly when needed. An independent mechanic bled the brake lines. The local dealer was contacted, but stated that the vehicle operated as designed. The vehicle was taken on two occasions to Don Franklin Somerset Chrysler Dodge Jeep RAM Service Center (1147 S. Hwy 27, Somerset, KY 42501), where the mechanic was able to duplicate the failure, but the vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 30,000. The VIN was not available.

NHTSA complaint #11731824 — an unverified report by a vehicle owner.

POWER TRAIN

At approximately 1750 miles the truck transmission began to shift in lower gears extremely violently. Every time that truck would shift in this manner, it would cause a startle effect and divert my attention away from driving to trying to determine what was going on. I immediately took the truck to my local Ram repair shop where they found metal shavings in the transmission oil pan. They told me I would need a completely new transmission. This is unacceptable with a truck with only 1750 miles on it. The dealership said they would need authorization to replace the transmission and not sure if one would be readily available. This is the fourth time this vehicle will have been at this repair facility. The first three times were for a fault code called Turbo under boost. Way too much downtime for a truck with only 1750 miles. We had to postpone our vacation since this is the only vehicle I own that’s capable of towing our boat and trailer. Because of all these issues, we have not been able to tow the trailer one time with our new truck!!!!!! When I asked the dealership what they thought the problem was they said quality control at the factory and a subpar designed for the product. If Ram doesn’t change the design of this transmission, even with a new transmission installed, I am scared this may happen again and then cause an accident.

NHTSA complaint #11724094 — an unverified report by a vehicle owner.

SEAT BELTS

The seatbelt retraction system on my truck has been replaced twice on the drivers side and once on the passenger side. The truck only has 40,000miles. The seatbelt retractors don't keep the shoulder strap tight when you move or get the belt first buckled. This can cause an issue if you are to get in an accident when the belt is not tight against your shoulder.

NHTSA complaint #11721807 — an unverified report by a vehicle owner.

SERVICE BRAKES

Spongy brakes, constant pumping of brakes to aid in stoping but check this out! In 4x4 mode Low 4x4 brake failure is almost 90%! I must mash the brakes as the brake peddle falls to the floor, then wait, brace and pray truck comes to come to a stop!!!!

NHTSA complaint #11719283 — an unverified report by a vehicle owner.

SERVICE BRAKES

Vehicle was purchased new with 29 miles on the odometer in December 2025. The brakes on the truck do not begin to engage until the brake pedal is depressed greater than 50% of its travel. The initial feedback of the brake pedal within the first 50% of travel is numb with virtually no resistance. While driving the truck from the purchasing dealer in Warrenton, VA to Chicago, IL, I encountered several instanced during medium to heavy traffic where I expected the truck to stop, but the significant vagueness in the pedal turned a routine slow down situation into an emergency/panic stop. After putting ~600 miles on the truck, it has not gotten better and the truck is currently at a local dealership in the Chicagoland area. There are no warning lights on and, as of now, the dealership has had the truck for almost 2 2 weeks with no resolution currently available from the service department, nor the manufacturer.

NHTSA complaint #11712348 — an unverified report by a vehicle owner.

SERVICE BRAKES

Vehicle was purchased new with 45 miles on the odometer in December 2025. The brakes on the truck do not begin to engage until the brake pedal is depressed greater than 50% of its travel. The initial feedback of the brake pedal within the first 50% of travel is numb with virtually no resistance. While driving the truck from the purchasing dealer in Warrenton, VA to Chicago, IL, I encountered several instanced during medium to heavy traffic where I expected the truck to stop, but the significant vagueness in the pedal turned a routine slow down situation into an emergency/panic stop. After putting ~1200 miles on the truck, it has not gotten better. I am currently waiting to see the results of our other "twin" truck (XXX) that is currently at a local dealership in the [XXX] area. There are no warning lights on and, as of now, the dealership has had the truck for almost 2 weeks with no resolution currently available from the service department, nor the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11712351 — an unverified report by a vehicle owner.

SERVICE BRAKES

When the brakes are applied during normal driving the pedal travels 2-3 inches before the brakes start to apply. During a panic stop and a strong force on the pedal it will travel almost to the floor. ABS never applies except on loose surfaces, i. e., snow, gravel and sand. I have had the vehicle to the dealer on three different occasion's for this problem. The dealer and the service technicians said it was normal, as they all do this. they bleed the brakes and it was marginally better for about 200 miles of driving, then back to the same low feel. One of those occasions there was an ABS fault and they had to reset the ABS system. After they did the reset the brakes felt a little better for a short time then back marginal again. If you tap the pedal twice in rapid succession the pedal feel is normal, as compared to other vehicles, and at the top of the pedal travel. Although with sustained foot pressure on the pedal you can push it to the floor. Again the dealer says it's normal. I tow regularly with this vehicle and because of the brake feel I travel slower and allow a much greater distance than normal.

NHTSA complaint #11711854 — an unverified report by a vehicle owner.