70 of the
7,124 complaints filed about the Toyota Highlander
are about the suspension —
1% of everything owners reported.
The worst model year for it is 2003.
The contact’s daughter owns a 2018 Toyota Highlander. The contact stated that while operating the vehicle, there was a clunking sound coming from the front driver’s side of the vehicle. The vehicle was taken to the local dealer, and the owner was informed that the struts needed to be replaced. The vehicle was not repaired. The vehicle was later driven to a local tire and battery service center who inspected the vehicle and informed the owner that the front control arms were rusted and needed to be replaced, and that the front axle was cracked. The vehicle was not yet repaired. The daughter was informed that the vehicle was unsafe to drive. The manufacturer was not yet contacted. The failure mileage was 101,000.
NHTSA complaint #11746490 — an unverified report by a vehicle owner.
Around Halloween 2025 my Toyota’s Transmission started slipping. I called a few places and no one except Toyota would address the issue except a local shop in [XXX] , Ridge Auto Repair who after checking out the vehicle said they can’t repair it because the parts are not available November 6th, 2025, The Shop LAG LLC was recommended to me by a family member, and they came to check out the Toyota, and they were convinced it was the Torque Converter and wanted $1300 to fix it. I paid them and after a few weeks they claimed it was the Transmission and wanted more money which they were paid. Weeks went by and no updates from them and they weren’t responding to my messages. When they finally responded they started saying the starter was bad, the differential, the fly wheel, etc, Again, we paid them more money, and again weeks went by without any updates. We paid a total of $9000.00 Their last attempt to fix the vehicle also failed and I’m left with a vehicle with no transmission, the entire front end taken apart and scattered all over my property and this was their last response. “Oh lord. So the original place we got the transmission from denied the warranty, but at the time it wasnt a problem we have insurance. So we summited a claim and thats why it was going to be shipped from another place. Well they kept telling me that it was coming this day then that day. I got a letter denying the claim Instead. I have tried to fight it, but they ended up dropping us after that. We are willing to install one in for free if your able to get your hands on one, because this whole ordeal has been a nightmare, but we got denied due to mileage with the claim. There was a difference in our timestamped pictures and the adress of where it went once it left. So they said it was driven on with a problem, because it was moved to there with a problem thats what they are denying my claims to fight it. I didn't want to say anything until it was final and we kne INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMA
NHTSA complaint #11735861 — an unverified report by a vehicle owner.
Early failure of front struts on a 2021 Toyota Highlander XLE, leaking fluid at 29,000 miles. Manufacturer does not seem to have any reported issues with these components. Issue discovered just one month after warranty expiration. Given the low daily use and time, this might be a manufacturer defect/concern. Could potentially be a safety concern affecting the vehicle handling and maneuverability.
NHTSA complaint #11735102 — an unverified report by a vehicle owner.
This vehicle safety complaint is regarding my 2019 Toyota Highlander XLE, VIN [XXX] . A Toyota-authorized dealership, Sansone Toyota in Avenel, New Jersey, documented that the front driver axle is prone to freezing in the differential. This is a serious safety concern because if the axle seizes while the vehicle is in motion, it could cause sudden loss of control. This vehicle is used regularly as our family vehicle, including to transport our family of 6 with our young children. I am extremely concerned about continued operation of the vehicle while this documented condition remains unresolved. In addition to this safety-related axle issue, this vehicle has a broader history of serious mechanical problems. On May 13, 2022, after a recent service visit at DCH Brunswick Toyota, I reported that when I pressed the gas the vehicle was making an unusual noise like an old car, that the car delayed to speed when I pressed the gas, that I had to press the gas all the way in order for the car to move faster, and that it was not like this prior to service. At approximately 25,000 miles, I also asked that the brakes be checked because when we drove the vehicle and used the brakes, the car made a startling sound. In 2023, I also reported hard/heavy steering and jerking while driving. I reported transmission-related abnormal noises and drivability concerns while the vehicle was still within Toyota’s powertrain warranty period, but the condition was not properly diagnosed at that time. The transmission has since been confirmed by authorized Toyota dealerships to require full replacement. The vehicle also has a documented engine oil leak, leaking shock absorber, and prior recall history involving a stalling condition. I've filed this complaint with NHTSA due to the axle-related safety risk. Toyota is now on written notice of that condition. Mileage: approximately 101,000 Documenting safety issue: Sansone Toyota, Avenel, NJ Please review this potential safety defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION
NHTSA complaint #11734722 — an unverified report by a vehicle owner.
•The transmission malfunctioned and developed an abnormal internal noise at approximately 67,000 miles, which is an unexpected failure at low mileage. The vehicle had been properly maintained and had no prior mechanical issues. Atlanta Toyota inspected the vehicle and confirmed the transmission had failed and required full replacement. The dealer also stated that as a result of the transmission failure, other related components showed excessive and abnormal wear. A second independent service center inspected the vehicle and confirmed the same diagnosis. The vehicle is available for inspection upon request. • This unexpected transmission failure created a serious safety risk due to the possibility of sudden loss of power, inability to accelerate, or complete transmission failure while driving. I rely on this vehicle daily to transport my child to school and to commute to work. A sudden failure while in traffic could result in becoming stranded or involved in a collision. • The vehicle was inspected by an authorized Toyota dealer and an independent service center. Both stated that the failure was unusual given the low mileage and normal use of the vehicle. • There were no warning lights, messages, or diagnostic trouble codes prior to the failure and afterward. The only symptom was an abnormal internal noise from the transmission, which began suddenly at approximately 66,000 miles. • The vehicle has received regular maintenance and is used for normal daily driving. There was no abuse, heavy towing, or unusual use that would explain a transmission failure at this mileage.
NHTSA complaint #11717006 — an unverified report by a vehicle owner.
The contact owns a 2012 Toyota Highlander. The contact stated that 5,000 miles after purchasing the vehicle, the contact noticed an oil leak. The contact performed the oil changes and had noticed that engine oil had leaked down onto the weather seal in the vehicle. The contact noticed several oil stains on the ground during rainy weather. The contact noticed that the new tires that the dealer installed at the time of the vehicle sale were worn out. The contact checked the tires and noticed that the plastic rubber on the front strut was severely damaged. The vehicle was taken to an independent mechanic who diagnosed that the timing cover had a leak, and that the timing cover area was smeared with an unknown silicone patch. The struts were replaced. The contact stated that the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 160,000.
NHTSA complaint #11707520 — an unverified report by a vehicle owner.
UNKNOWN - 2024 Toyota Highlander makes a drumming or hooting sound when driving over normal to slightly rough roads. It is not related to expansion joints in the road. 1st dealer said it was a rt. wheel bearing, changed it and it did not work. He then said it was in all Toyota's with 20" wheels. I paid to change tires and wheel to no avail. 2nd dealer said it was normal even though mechanic heard the noise. His supervisor said it was fine and they would do nothing to try to isolate the noise. Noise is very obvious.
NHTSA complaint #11694379 — an unverified report by a vehicle owner.
Both front struts and bearing plates failed at 75k miles. They were leaking oil before that mileage. Approximate date of failure was 1/5/24. No parts were available until now. Parts were on back-order for upwards of a year for this model of Highlander in the FWD configuration, with 18” wheels. Prematurely failure causes a lot of bouncing in the car, therefore making the vehicle unresponsive to quick steering maneuvers. The bounce also made it so that typical driving within the city is dangerous as the bounce makes the car difficult to control. This is an issue that is documented on Toyota forums for FWD models. An accident has not been caused by this failure as of yet. Vehicle will be repaired soon. Mechanic was finally able to get two factory struts and bearing plates. Each strut is $200 and mounting plates are about $150 each. Parts + labor are expensive, but at least now it will be fixed.
NHTSA complaint #11670793 — an unverified report by a vehicle owner.
It’s been a known issue that Toyota Highlander has transmission problems under 100k miles from 2016-2021 or later (social media sites confirmed such). My vehicle require a trans axle replacement as well as the struts are leaking oil and my vehicle has less than 62k miles and is only 5 years old. This is being covered under my extended warranty but parts are on back order After doing research many owners complain about a whining noise showing acceleration of vehicle . If left unfixed this leads to transmission gears slipping and eventually needing an entire replacement Some owners also complain about leaky struts. My car has an issue with leaky struts and is being fixed under warranty Some owners say they need an entire new transmission and after that is replaced the rear transaxle goes and needs replacement Toyota is not putting a recall on this but it’s a known issue. Owners are asking to have this put out as a recall by toy. All parts are on back order and takes several months before transmission can be repaired or replaced. This tells me there are hundreds if not thousands of Highlander’s having the same issue This is a Toyota problem and is related to building transmission in the factory..recall the older vehicles and do better in the factory
NHTSA complaint #11666679 — an unverified report by a vehicle owner.
Had cv boot and control arm work at 30k miles caught it in time in 2021 and dealer fixed it. 2 years later same issue if i had bot taken it to dealer and just did oil changes myself cv boot and control arm would break during operation. Seems like they have serious issues with cv boots and control arms at low miles. I only have 50k miles to have a second replacement.
NHTSA complaint #11552727 — an unverified report by a vehicle owner.
3 wheel alignments in same vehicle needed in less than 30 months: <5,000, 30,000 and 35,000 odometer readings It’s not from pot holes; I have owned about 14 cars in family fleet and have never had 1 vehicle need more than 1 alignment during it’s time of ownership of over 1,000,000 miles driven Something is wrong with vehicle design or mechanical components to go out of alignment so frequently
NHTSA complaint #11527245 — an unverified report by a vehicle owner.
The contact owns a 2017 Toyota Highlander. The contact stated that upon purchasing the vehicle, there was an abnormal clicking sound coming from the front passenger’s side tire. There was no warning light illuminated. The vehicle was taken to a dealer and the contact was informed that the wheel bearings needed to be replaced. The vehicle was then taken to the dealer where it was purchased, Norm Reeves Honda Superstore Huntington Beach (19131 Beach Blvd, Huntington Beach, CA 92648), and the contact was informed that no fault was found with the vehicle. The contact stated that the vehicle stalled while attempting to make a U-turn with an unknown message on the instrument panel. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 20V682000 (Fuel System, Gasoline). The vehicle was taken back to the dealer where it was purchased; however, the mechanic was unable to duplicate the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 67,500.
NHTSA complaint #11513602 — an unverified report by a vehicle owner.
on 26/Jan/2022 i driving on highway suddendly the front wheel passanger side lock, luckily i quickly get off drive land to emergency land. The Brake Malfuntion light come up, i so scare, do not what happen. But i should do complaint about brake system on this vehicle. Thanks. Vu Dam.
NHTSA complaint #11449529 — an unverified report by a vehicle owner.
When the vehicle was ~1.5 years old following its 10,000 mile maintenance, substantial thumping generated from the rear of the vehicle. Each time, the dealership attempted to resolve the problem finding issues with struts; however, it only went away in late March after having the vehicle in the shop for weeks at a time on 5 different occasions Nov 2018 - Mar 2019. I engaged Toyota HQ (800-331-4331) - filing report #1901092572 - requesting an exchange of the vehicle. This was denied and I was offered a 8 year warranty. *Due to COVID, I rarely drove this vehicle through 2020 and most of 2021, where to date, I have only ~34,000 miles on the vehicle. -On 21 Oct 2021, my wife was stopped at a gas station and attempted to start the vehicle. The vehicle would not start and the following lights came on without previous warning: 1)Braking Power Low, 2)Maintenance needed soon, & 3)Orange yellow triangle lit up with exclamation mark. My wife was stranded for 3 hours and the vehicle had to be towed. The dealership informed me that Toyota installed a generic battery into the vehicle (when being sold) that was only to have 4-5 years of life; however, my concern was that this vehicle had just completed maintenance and there was no warning of this upcoming issue. When repaired, I had to pay for the name brand (True Start) battery. -On 16 Jan 2022, after having driven the Highlander for 25 minutes, I started the engine while in a parking lot. While moving forward and the engine still going, the brakes and power steering went out. On the dashboard, the same lights that came on in Oct 2021, did so again. I had to let the vehicle coast (having no control) with my wife and child in the car through the parking lot. It came to a stop at the concrete parking curb stop at a store front. Toyota stated that since there was no check engine light that there was no code and they could not duplicate the problem. The vehicle was sent back to me with no resolution or explanation.
NHTSA complaint #11447818 — an unverified report by a vehicle owner.
While entering a business park's parking lot, my vehicle suddenly and immediately stopped all forward movement. I was thrown against the steering wheel, injuring the right side of my chest and scraping the skin off my right forearm which was covered with the sleeve of my shirt. I was dazed, had no idea what happened, and thought that I had hit something but yet no airbags had deployed. When the vehicle stopped it was near a light post which I assumed I had hit. Upon exiting the vehicle I noticed the front tire was blown and the wheel was sitting on the ground at an odd angle. Walking around the vehicle showed no other body damage other that a few small strips of yellow paint from the base of the light post. When the tow truck driver was placing the chains to load it onto the flatbed, he called my attention to the fact that the drivers side control arm had failed. See the attached pictures for further detail. I am very grateful that I was not in traffic on a major highway as this would have been a horrific accident. Pictures show the control arm had a crack with exposed rust on edges of a fracture in the control arm. This vehicle has only been serviced at Toyota authorized dealerships and has undergone their multipoint inspections during these visits that include the front and rear suspension. I will not feel comfortable driving this vehicle again!
NHTSA complaint #11435470 — an unverified report by a vehicle owner.
I was forced to change lanes quickly from the left lane to the left shoulder of an interstate when a double tandem tractor trailer moved into my lane of traffic. The interstate was dry and the left shoulder was in excellent condition and wide enough to accommodate my vehicle easily. All lane assist options were turned off, the driving mode was set to “economy” and the cruise control was turned to “off”. A few seconds after entering the left shoulder of the interstate, I felt the rear end of my vehicle sway from side to side for a few seconds. After the swaying ended, I thought there was a brief loss of vehicle control after which the vehicle returned completely to my control. My vehicle is a Toyota Highlander Limited AWD gas engine SUV with about 2700 miles when this occurred. I drove my vehicle without any emergency steering maneuvers 2700 miles prior to and 500 miles after this incident without any problems. I had my Toyota dealer examine the suspension, steering and event recorder of the vehicle and test drive it. They found the vehicle to be performing within manufacturers specifications and without any defect in the steering or suspension and found no codes found in the event recorder.
NHTSA complaint #11431183 — an unverified report by a vehicle owner.
THE VEHICLE WAS TAKEN FOR SERVICE ON 1/8/21 AT TOYOTA OF SCRANTON FOR REAR SUSPENSION PROBLEMS. THEY HAD REPLACED ARM AWAY, TRAILING. WE CALLED AGAIN FOR DEVICE IN FEBRUARY 2021 FOR PROBLEMS WITH THE CAR. IT WAS SCHEDULED FOR SERVICE ON MARCH 20,2021, WHICH TOYOTA OF SCRANTON DID NOT HAVE THE PARTS. IN JANUARY 2021, TOYOTA MENTIONED NOTHING OF THE PENDING FUEL PUMP RECALL. WE RECEIVED NO CALLS FROM TOYOTA AT ANY TIME FOR A RECALL. WE BECAME AWARE OF THE RECALL AFTER WE EXPERIENCED PROBLEMS WITH THE CAR IN FEBRUARY. TOYOTA HAS STILL NOT RESOLVED THE FULL PUMP RECALL.
NHTSA complaint #11405110 — an unverified report by a vehicle owner.