Owners have filed 78 complaints
about the 2021 Volvo XC60 with NHTSA between 2021 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 4 of 16 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 66
Against the median year of the Volvo XC60. 50 means typical for this
model; 100 means roughly double.
Severity — 93
17.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — not reported
Too few complaints recorded a mileage to measure this.
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jul 2021peak 7Aug 2026
NHTSA investigations into the 2021 Volvo XC60
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Recalls on the 2021 Volvo XC60
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V179000
ELECTRICAL SYSTEM:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Risk: A short circuit in a high-voltage battery increases the risk of a fire.
23V001000
STEERING
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Risk: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
21V716000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 S90L, 2020-2021 XC60, and XC90 vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Risk: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
21V682000
SEAT BELTS:FRONT:RETRACTOR
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: An unsecured child restraint system can increase the risk of injury during a crash.
21V001000
AIR BAGS
Volvo Cars USA, LLC (Volvo Car) is recalling certain 2021 Volvo V60, V60 Cross Country, V90, V90 Cross Country, XC60, and XC90 vehicles. The Supplementary Restraint System (SRS) control unit may not have been properly attached to the car body and may detach during a crash.
Risk: A detached SRS control unit can decrease the performance of occupant protection systems such as air bags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2025147585 units in Canada
High Voltage
Issue: On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit. Note: This recall only affects certain plug-in hybrid (PHEV) models. Safety Risk: A short circuit in the high-voltage battery can create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, Volvo advises not to charge your vehicle until the recall repairs have been completed. Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the high-voltage battery module(s). The dealer will also install an advanced diagnostic software that will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the affected high-voltage battery module(s).
Recall 202259531,117 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing. Note: This recall only affects vehicles equipped with a 360-degree park assist camera. Safety Risk: A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
Recall 20215403,078 units in Canada
Seats And Restraints
Issue: On certain vehicles, the passenger seat belt assemblies may contain defective automatic locking retractors (ALR). As a result, the seat belts may not properly lock to secure a child seat. Note: The vehicle's lower universal anchorage system (UAS) is not affected by this defect and may still be used to secure a child seat. Safety Risk: A seat belt that is used to secure a child restraint but is not properly locked could increase the risk of injury in a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the seat belts. They will be replaced, if necessary.
Recall 202100339 units in Canada
Airbag
Issue: On certain vehicles, the screws that attach the control unit for the supplemental restraint system (SRS) may not have been properly tightened. As a result, the SRS control unit may not work properly and could come loose in a crash. If this happens, the seat belt pretensioner(s), airbag systems and high-voltage battery disconnect may not work correctly. Note: This problem may cause the SRS warning lamp to turn on and a "Service Urgent" message may display in the instrument cluster. Safety Risk: A seat belt pretensioner, airbag system or high-voltage battery disconnect that does not work properly in a crash could create an increased risk of injury. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the mounting screws for the SRS control unit. They will be tightened, if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Boca Raton, FLCrash
UNKNOWN OR OTHER
Exiting a parking lot, attempting to break. The plastic break pedal cover fell off and was unable to break in time to avoid a front end accident.
NHTSA complaint #11722722 — an unverified report by a vehicle owner.
Pantego, TXCrash1 injured
AIR BAGS
Side impact curtain air bags only deployed on right side (side of impact), causing head concussion from hitting driverside window on left side. Vehicle has been towed for repair, but may still be available for inspection for a short time. Fire department stated airbags tried but failed deployment. Contacted dealer. Dealer said contact Volvo North America. Volvo has yet to connect me to the right person or department.
NHTSA complaint #11475285 — an unverified report by a vehicle owner.
Brooklyn, NYCrash1 injured
ELECTRICAL SYSTEM
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
NHTSA complaint #11461792 — an unverified report by a vehicle owner.
Brooklyn, NYCrash1 injured
FORWARD COLLISION AVOIDANCE: WARNINGS
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
NHTSA complaint #11461792 — an unverified report by a vehicle owner.
The car started to move and accelerate with brake pressed. Accident prevention system did not activate itself. It did not display any warnings as it typically do during parking and being close to other cars. The car caused an accident with mild injuries to the driver of the other car, but could have hit a pedestrian or go to the intersection and involved with an accident with a car moving perpendicularly at a higher speed. I am waiting for an investigator from Volvo and Travelers Insurance. Prior to the accident the electronic display of the car started to malfunction. I have a video of the whole accident , but it is in mp4 format and thus i could not upload it. The dashboard camera's microphone picked some electromagnetic interference that increased as we got closer to the accident. Description of the accident: We pulled to a red light behind another car. After not moving for a few seconds, the car started to move on its own, accelerating and hitting the car in the front, continuing to move forward. I was able to put the shifter into the park, stopping it. The road conditions were good. Roads were dry. The sky were cloudy overhead. The vehicle is not drivable ( radiator leak ). The car behaved usually before the accident, except for some reason, for the first time, all the displays dimmed significantly ( it was hard to see anything, and I could not increase brightness ). The screens went back to normal brightness right before the accident. Also, the dashboard camera that recorded the incident, for some reason, picked up audio evidence of electromagnetic interference which was increasing as we were getting closer to the intersection.
NHTSA complaint #11461792 — an unverified report by a vehicle owner.
Staten Island, NYCrash1 injured
POWER TRAIN:AUTOMATIC TRANSMISSION
The contact owned a 2021 Volvo XC60. The contact stated that while driving approximately 25 mph, the vehicle suddenly began to accelerate and the brakes failed to stop. The vehicle crashed into a nearby fence causing the vehicle to flip. The air bags did deploy. The contact received injuries to their right shoulder and left knee. Medical attention was needed. A police report was filed. The vehicle was towed and had not been deemed totaled as of yet however, damage to the vehicle would be considered unrepairable. The dealer was informed of the incident however they were unable to assist. The manufacturer was not made aware of the failure. The approximate failure mileage was unknown.
NHTSA complaint #11433852 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Pleasant Hill, IA
ELECTRICAL SYSTEM
My SUV has a had the check engine light on from a failed battery cell for my 2021 grey Volvo XC60 recharge (VIN [XXX]). I have been without the electric functionality (to charge the hybrid car or use electric power) since mid December and waiting on a warranty part since Dec. 23, 2025. I have been told April 2026 and then August 2026 for this warranty issue that both the dealership and Volvo corporate have agreed is under warranty and needs replaced to make the car functional as intended. They claim the part as been backordered for the entire 8 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11756600 — an unverified report by a vehicle owner.
Bethesda, MD
UNKNOWN OR OTHER
After backing up out of a parking space, the side mirror on the drivers side moves to an unpredictable position and does not return to its original position. This is potentially dangerous because the driver is not aware of this change in position, and when changing lanes may rely on mirror that is in a faulty position. This appears to be some sort of flaw in the logic that tilts the mirror down when backing up and returns to original position when the car is put back in drive. Regardless of whether I turn this feature on or off, the same malfunction occurs.
NHTSA complaint #11753923 — an unverified report by a vehicle owner.
Princeton Jct, NJ
LANE DEPARTURE: BLIND SPOT DETECTION
The entire right ride of the car just stopped working. Back right door became permanently locked and could not open from outside or inside. When hitting lock/unlock buttons on key fob i) front passenger door would not lock/unlock and ii) right side mirror would not fold in/out. Blind spot monitor and TPMS said they needed service. Left side of car was fine and worked. Car would start normally. I checked all relevant fuses and none were blown. Then all of a sudden it all started working again. My fear is that in the heat of summer what if all doors became locked somehow and i did not have the key fob with the manual key? I have 2 children
NHTSA complaint #11747588 — an unverified report by a vehicle owner.
The entire right ride of the car just stopped working. Back right door became permanently locked and could not open from outside or inside. When hitting lock/unlock buttons on key fob i) front passenger door would not lock/unlock and ii) right side mirror would not fold in/out. Blind spot monitor and TPMS said they needed service. Left side of car was fine and worked. Car would start normally. I checked all relevant fuses and none were blown. Then all of a sudden it all started working again. My fear is that in the heat of summer what if all doors became locked somehow and i did not have the key fob with the manual key? I have 2 children
NHTSA complaint #11747588 — an unverified report by a vehicle owner.
Kennesaw, GA
ELECTRICAL SYSTEM
An intermittent electrical failure occurred to my wife causing my 2021 Volvo XC60 to stop and then later go into limp mode while driving. The service light went on immediately and was very startling to her and made it difficult for the drivers following as the car speed was significantly reduced/ I suspect limp mode though it was not on the dashboard. When I called Volvo and then brought the car in... it is a known issue to Volvo. They purposively produce a vehicle that is known for sunroof leaks which knowingly leads to electrical issues exposing their customers to harm. Volvo (Geely) inspected the car, found the electrical issues from the front interior to the battery compartment that had water over an inch deep. the VGM (Vehicle Gateway Module) was replaced and reloaded, all connectors were separate/dried and several had to be cut/spliced and rewired due to corrosion damage. Carpets were removed, the gasket was replaced, the front and rear sun roof drains were cleaned out. Aside from the safety concern the shrinking of the rubber gasket caused the issue. Not funny, but Volvo/Geely states that the repair now has a lifetime warranty after I was charged over $4,000 USD. The vehicle is only about 5 years old!!
NHTSA complaint #11743000 — an unverified report by a vehicle owner.
Mesa, AZ
FUEL/PROPULSION SYSTEM
My 2021 Volvo XC60 experienced a fuel system failure at approximately 53,500 miles. Prior to the failure, the vehicle displayed multiple warning messages and entered reduced-power (limp mode), including the turtle symbol on the instrument cluster. The vehicle unexpectedly would not start despite multiple attempts. The failure occurred while I was at a physical therapy appointment approximately 25 minutes from my home. After approximately 10 minutes, the vehicle started and was able to be driven. Because of the warning messages, limp mode, and failure-to-start condition, the vehicle was taken to a Volvo dealership for diagnosis. The Volvo dealership diagnosed the vehicle with ECM fault code P008A00 (Low Fuel Pressure). According to the repair invoice, testing confirmed that fuel pressure was intermittently low, and the dealership determined that the in-tank fuel pump was faulty. The fuel pump was replaced to correct the condition. This failure created a safety concern because the vehicle became unexpectedly inoperable and would not start when needed. Had the failure occurred in a remote location, during extreme weather conditions, at night, or in an emergency situation, it could have left the vehicle occupants stranded without reliable transportation. The inability to start the vehicle occurred without warning and could have resulted in a more serious safety risk under different circumstances. The issue was reproduced and confirmed by an authorized Volvo dealership, which inspected the vehicle, diagnosed the fault, and replaced the fuel pump. Repair records are available for inspection upon request. The failure occurred at approximately 53,500 miles, which is relatively low mileage for a major fuel system component. Because fuel pump failures can render a vehicle unexpectedly inoperable, I am submitting this complaint for review and investigation.
NHTSA complaint #11741045 — an unverified report by a vehicle owner.
Berlin, CT
STEERING
Multiple times, with the Pilot Assist system engaged, the vehicle has pulled me out of my intended travel lane when on a curve, near an on / off ramp, and generally tends to drift from the left to right of the intended lane of travel on straight sections of road. It will drift to the rumble strip and sometimes into the next lane with both hands firmly on the wheel. I find myself fighting the system at these times. When it gets confused, with corners or merges, and on / off ramps, it will abruptly change lanes which is very dangerous. Twice it almost caused an accident. I have had it looked at many times now by Gengras Volvo in East Hartford where I bought the car. I was provided a loaner each time but the car has been in their shop for close to a month over these visits. It happend on one test drive with their repair tech driving the car, so the issue has been verified and recorded by Gengras. Multiple components of the system have been changed out and Volvo has downloaded and reviewed the telemetry twice. Volvo's stance is that the system is functioning correctly, and in times if inclement weather it may not work as intended. Most of my incidents happened on dry roads. Upon researching this on the internet, there are many other owners of Volvos of my year and others complaining of the exact same issues and behavior of the car. I feel it may be a design flaw but in my opinion the system is not safe to use. Volvo went to a completely different system soon after 2021. This was a very expensive option to purchase on the vehicle. We have a similar system in our Acura that works flawlessly on the same roads in any weather condition. I bought this vehicle certified by Volvo with roughly 15K miles for my son to drive when he had just gotten his license as Volvo has an incredible reputation for safely. I do not feel safe with him driving this vehicle as was intended. Latest diagnosis attached, Remainder available from Gengras Volvo, East Hartford CT.
NHTSA complaint #11731535 — an unverified report by a vehicle owner.
Berlin, CT
LANE DEPARTURE: ASSIST
Multiple times, with the Pilot Assist system engaged, the vehicle has pulled me out of my intended travel lane when on a curve, near an on / off ramp, and generally tends to drift from the left to right of the intended lane of travel on straight sections of road. It will drift to the rumble strip and sometimes into the next lane with both hands firmly on the wheel. I find myself fighting the system at these times. When it gets confused, with corners or merges, and on / off ramps, it will abruptly change lanes which is very dangerous. Twice it almost caused an accident. I have had it looked at many times now by Gengras Volvo in East Hartford where I bought the car. I was provided a loaner each time but the car has been in their shop for close to a month over these visits. It happend on one test drive with their repair tech driving the car, so the issue has been verified and recorded by Gengras. Multiple components of the system have been changed out and Volvo has downloaded and reviewed the telemetry twice. Volvo's stance is that the system is functioning correctly, and in times if inclement weather it may not work as intended. Most of my incidents happened on dry roads. Upon researching this on the internet, there are many other owners of Volvos of my year and others complaining of the exact same issues and behavior of the car. I feel it may be a design flaw but in my opinion the system is not safe to use. Volvo went to a completely different system soon after 2021. This was a very expensive option to purchase on the vehicle. We have a similar system in our Acura that works flawlessly on the same roads in any weather condition. I bought this vehicle certified by Volvo with roughly 15K miles for my son to drive when he had just gotten his license as Volvo has an incredible reputation for safely. I do not feel safe with him driving this vehicle as was intended. Latest diagnosis attached, Remainder available from Gengras Volvo, East Hartford CT.
NHTSA complaint #11731535 — an unverified report by a vehicle owner.
Holland, MI
SERVICE BRAKES
After 5 times of phantom breaking at high speed I took the car to Betten Volvo. The did a system update to try to correct. The car has now 3 times in 2 weeks again triggered the break at highway speed. I have another appointment scheduled April 21, 2026. Having the brake applied for no reason at this speed is extremely jarring and dangerous.
NHTSA complaint #11730370 — an unverified report by a vehicle owner.
Portsmouth, VA
VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
The driver's side mirror repositions itself downward, upward, or outward when unlocking and opening a door. It infrequently repositions while driving as well. These occurrences put me and others at risk by increasing my blind spot when I need to change lanes. Two Volvo dealers have reproduced the mirror changing positions when unlocking and opening the door, but a few times they were not able to get the car to reproduce it. Technicians have performed software updates, deleted and reprogrammed the keys to the car, and performed a factory reset on the infotainment center to no avail.
NHTSA complaint #11724198 — an unverified report by a vehicle owner.
Boca Raton, FLCrash
UNKNOWN OR OTHER
Exiting a parking lot, attempting to break. The plastic break pedal cover fell off and was unable to break in time to avoid a front end accident.
NHTSA complaint #11722722 — an unverified report by a vehicle owner.
King George, VA
AIR BAGS
SRS warning light is on
NHTSA complaint #11709802 — an unverified report by a vehicle owner.
San Diego, CA
SEAT BELTS
The USB ports under the center console malfunction frequently. The main, top engine mount disintegrated and needed to be replaced under 50,000 miles. The rear seat seatbelts come loose and sag easily. They do not retract automatically. The rubber stripping, where the door jamb is, comes off. The handles to the air vent break off very easily, rendering the vents inoperable. **The software for the vehicle malfunctions constantly, displaying the incorrect readings for fuel economy, the gas gauge, and more. It is possibly affecting the catalytic converters and O2 sensors. **The vehicle turns itself on, in battery mode. **The blind spot indicators to not light up sometimes and do not make any noise indications of nearby cars.
NHTSA complaint #11707518 — an unverified report by a vehicle owner.
San Diego, CA
ELECTRICAL SYSTEM
The USB ports under the center console malfunction frequently. The main, top engine mount disintegrated and needed to be replaced under 50,000 miles. The rear seat seatbelts come loose and sag easily. They do not retract automatically. The rubber stripping, where the door jamb is, comes off. The handles to the air vent break off very easily, rendering the vents inoperable. **The software for the vehicle malfunctions constantly, displaying the incorrect readings for fuel economy, the gas gauge, and more. It is possibly affecting the catalytic converters and O2 sensors. **The vehicle turns itself on, in battery mode. **The blind spot indicators to not light up sometimes and do not make any noise indications of nearby cars.
NHTSA complaint #11707518 — an unverified report by a vehicle owner.
San Diego, CA
ENGINE
The USB ports under the center console malfunction frequently. The main, top engine mount disintegrated and needed to be replaced under 50,000 miles. The rear seat seatbelts come loose and sag easily. They do not retract automatically. The rubber stripping, where the door jamb is, comes off. The handles to the air vent break off very easily, rendering the vents inoperable. **The software for the vehicle malfunctions constantly, displaying the incorrect readings for fuel economy, the gas gauge, and more. It is possibly affecting the catalytic converters and O2 sensors. **The vehicle turns itself on, in battery mode. **The blind spot indicators to not light up sometimes and do not make any noise indications of nearby cars.
NHTSA complaint #11707518 — an unverified report by a vehicle owner.
Middletown, CT
POWER TRAIN
Serpentine belt failure at 70K miles. Was driving back home when I felt the traction misbehaving and the check engine light came on. Was able to get home safely and brought the car to the garage the next open day. During inspection, serpentine belt was found missing 1 rib and was caught in splash fan. Had to pay almost $1000 to replace it as insurance had run out a couple months prior. Volvo tech said it was almost surely a defect in the belt as these last typically ~150k miles and they had seen other such recent cases of early failure. I was not happy having to pay to replace a defective part which moreover was about to catastrophically fail, destroying my engine/traction and potentially hurting me. Thankfully the check engine light, which was apparently unrelated (oxygen sensor which needed to be replaced for another $1000) brought me to the garage before the accident happened.
NHTSA complaint #11705446 — an unverified report by a vehicle owner.
at 45,000 milesPedricktown, NJ
STEERING
The contact owns a 2021 Volvo XC60. The contact stated that while driving at undisclosed speeds and turning, the front end of the vehicle made an abnormal grinding sound. Additionally, the contact stated that the steering wheel seized after turning, which required the contact to jam the steering wheel for the steering wheel to return to the center. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the steering rack had failed internally and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V001000 (Steering); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,000.
NHTSA complaint #11688891 — an unverified report by a vehicle owner.
Temecula, CA
ELECTRICAL SYSTEM
My car was backed into July 4, 2024, unoccupied and had damage done to the hood and front light and bumper. The person who hit the car had insurance and I took it to a local collison company for the repairs In November 2024. (Insured would not return calls to insurance company so it took this long for repairs) I began taking it to Volvo OC in December because the sensors were constantly lighting up and beeping constantly with no one around me. I took it to Volvo many times from December to August 2025. They would have my car for a week or two and think they fixed it and it was not fixed. After Volvo sent me a note saying that Corporate was not going to pay to do anything and they were done with trying to fix the car I took it back to my collison company. When Volvo last had it they told me that the wiring harness was not the correct part number and that the collision company installed the wrong one. I called them back and they explained that they had to call Volvo Mission Viejo and gave them the VIN number and they installed what was sent. I took it back to the collision company and they called and ordered another harness and they received the exact same harness. They installed that one and the sensors still do not work correctly. They then called Volvo Mission Viego again and they were told there was a cable that was needed if a car was in an accident and 2 sensors needed to be attached to the cable and the other sensors to the harness. So they did that. And still the same issue. At that time Volvo told me that the sensors in my car were not the correct sensors and that they were not the sensors that came with the car. The collision company said they removed the sensors from the harness but attached the exact same sensors during the repair. So both Volvo and the collision company have left me hanging and this is a safety issue. If I am looking one way for traffic and the beeping goes off it is startling to think someone is coming from the other
NHTSA complaint #11685673 — an unverified report by a vehicle owner.
Temecula, CA
BACK OVER PREVENTION: WARNINGS
My car was backed into July 4, 2024, unoccupied and had damage done to the hood and front light and bumper. The person who hit the car had insurance and I took it to a local collison company for the repairs In November 2024. (Insured would not return calls to insurance company so it took this long for repairs) I began taking it to Volvo OC in December because the sensors were constantly lighting up and beeping constantly with no one around me. I took it to Volvo many times from December to August 2025. They would have my car for a week or two and think they fixed it and it was not fixed. After Volvo sent me a note saying that Corporate was not going to pay to do anything and they were done with trying to fix the car I took it back to my collison company. When Volvo last had it they told me that the wiring harness was not the correct part number and that the collision company installed the wrong one. I called them back and they explained that they had to call Volvo Mission Viejo and gave them the VIN number and they installed what was sent. I took it back to the collision company and they called and ordered another harness and they received the exact same harness. They installed that one and the sensors still do not work correctly. They then called Volvo Mission Viego again and they were told there was a cable that was needed if a car was in an accident and 2 sensors needed to be attached to the cable and the other sensors to the harness. So they did that. And still the same issue. At that time Volvo told me that the sensors in my car were not the correct sensors and that they were not the sensors that came with the car. The collision company said they removed the sensors from the harness but attached the exact same sensors during the repair. So both Volvo and the collision company have left me hanging and this is a safety issue. If I am looking one way for traffic and the beeping goes off it is startling to think someone is coming from the other
NHTSA complaint #11685673 — an unverified report by a vehicle owner.
Temecula, CA
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
My car was backed into July 4, 2024, unoccupied and had damage done to the hood and front light and bumper. The person who hit the car had insurance and I took it to a local collison company for the repairs In November 2024. (Insured would not return calls to insurance company so it took this long for repairs) I began taking it to Volvo OC in December because the sensors were constantly lighting up and beeping constantly with no one around me. I took it to Volvo many times from December to August 2025. They would have my car for a week or two and think they fixed it and it was not fixed. After Volvo sent me a note saying that Corporate was not going to pay to do anything and they were done with trying to fix the car I took it back to my collison company. When Volvo last had it they told me that the wiring harness was not the correct part number and that the collision company installed the wrong one. I called them back and they explained that they had to call Volvo Mission Viejo and gave them the VIN number and they installed what was sent. I took it back to the collision company and they called and ordered another harness and they received the exact same harness. They installed that one and the sensors still do not work correctly. They then called Volvo Mission Viego again and they were told there was a cable that was needed if a car was in an accident and 2 sensors needed to be attached to the cable and the other sensors to the harness. So they did that. And still the same issue. At that time Volvo told me that the sensors in my car were not the correct sensors and that they were not the sensors that came with the car. The collision company said they removed the sensors from the harness but attached the exact same sensors during the repair. So both Volvo and the collision company have left me hanging and this is a safety issue. If I am looking one way for traffic and the beeping goes off it is startling to think someone is coming from the other
NHTSA complaint #11685673 — an unverified report by a vehicle owner.
Sammamish, WA
STEERING
Rotor seems to have worn out much quicker than expected. When I break, I can feel certain vibration / bumps. When breaking while going down on a hill, front break also has made screeching noise. Steering feels stiff at times. generally, I have always been topping up gas more than the advertised mileage performance / EPA
NHTSA complaint #11684241 — an unverified report by a vehicle owner.
Sammamish, WA
SERVICE BRAKES
Rotor seems to have worn out much quicker than expected. When I break, I can feel certain vibration / bumps. When breaking while going down on a hill, front break also has made screeching noise. Steering feels stiff at times. generally, I have always been topping up gas more than the advertised mileage performance / EPA
NHTSA complaint #11684241 — an unverified report by a vehicle owner.
Sammamish, WA
FUEL/PROPULSION SYSTEM
Rotor seems to have worn out much quicker than expected. When I break, I can feel certain vibration / bumps. When breaking while going down on a hill, front break also has made screeching noise. Steering feels stiff at times. generally, I have always been topping up gas more than the advertised mileage performance / EPA
NHTSA complaint #11684241 — an unverified report by a vehicle owner.
Riverview, FL
SEAT BELTS
Rear Center Seat seatbelt buckle does not latch.
NHTSA complaint #11632886 — an unverified report by a vehicle owner.
Baltimore, MD
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
The passenger side rear door locked and could not be open from either the inside or the outside. The dealer concluded that the door lock failed in the locked position. It gained entry to the door panel with the door shut, removed the old lock, opened the door, installed a new lock assembly and reassembled the door. Because the car was slightly out of warranty, we had to pay for the repair. Until this was done, we felt very unsafe. In the event of an accident or emergency, the passenger on that side of the car would not be able to exit the car. There was no warning prior to this happening. It just stopped working.
NHTSA complaint #11631036 — an unverified report by a vehicle owner.