Owners have filed 128 complaints
about the 2022 Volvo XC60 with NHTSA between 2022 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 1 of 16 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 100
Against the median year of the Volvo XC60. 50 means typical for this
model; 100 means roughly double.
Severity — 44
8.6% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
63% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Warnings
719.4%
Automatic Emergency Braking
616.7%
Camera
513.9%
Rearview System Braking
411.1%
Warnings
411.1%
Assist
411.1%
Warning
38.3%
Adaptive Cruise Control
38.3%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
112.5%
10,000 – 24,999 miles
225.0%
25,000 – 49,999 miles
450.0%
50,000 – 74,999 miles
112.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2022peak 9Sep 2026
NHTSA investigations into the 2022 Volvo XC60
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP22005Opened 27 Jan 2023Closed 7 Aug 2023ELECTRICAL SYSTEM:PROPULSION SYSTEM
Pedestrian alert sounds
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after Marc...
Recalls on the 2022 Volvo XC60
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V908000
BACK OVER PREVENTION:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2024 C40BEV, 2022-2025 S90, V90CC, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40, and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Risk: A rearview camera image that does not display reduces the driver's view behind the vehicle, increasing the risk of a crash.
25V282000
BACK OVER PREVENTION:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021-2025 XC40, 2022 V90, 2022-2025 S90, V90CC, C40, XC60, 2023-2025 S60, V60, V60CC, XC90, and 2025 EC40 and EX40 vehicles. The rearview camera image may not display when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Risk: A rearview camera image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
25V179000
ELECTRICAL SYSTEM:SOFTWARE
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Risk: A short circuit in a high-voltage battery increases the risk of a fire.
23V001000
STEERING
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2022 V60CC, XC60, and XC90 vehicles. During steering gear assembly, double screws may have been assembled on top of each other, which can cause a screw to fall into the gearbox housing.
Risk: A screw inside the gearbox housing can cause the steering wheel to lock up and increase the risk of a crash.
22V793000
ENGINE AND ENGINE COOLING:ENGINE:ENGINE CONTROL MODULE (ECU/ECM)
Volvo Car USA, LLC (Volvo Car) is recalling certain 2022-2023 S60, V60, S90L, XC60, and XC90 vehicles. An electronic control module (ECM) software error may prevent the combustion engine from starting, causing a loss of drive power.
Risk: The vehicle may lose drive power as the high voltage battery is depleted, increasing the risk of a crash.
21V682000
SEAT BELTS:FRONT:RETRACTOR
Volvo Car USA, LLC (Volvo Car) is recalling certain 2021 XC40, XC 40 Recharge, V60CC, V90, V90CC, XC90, and 2021-2022 V60, XC60, S60 vehicles. The seat belt automatic locking retractors may deactivate early, which can prevent the child restraint system from securing properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Risk: An unsecured child restraint system can increase the risk of injury during a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202571840,673 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Note: This recall replaces Transport Canada recall no. 2025-233. Vehicles that were repaired under that recall also require this repair. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the vehicle software. Alternatively, you may schedule an appointment to have the update performed at a Volvo dealership.
Recall 202523340,673 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the vehicle software. Alternatively, you may schedule an appointment to have the update performed at a Volvo dealership.
Recall 2025147585 units in Canada
High Voltage
Issue: On certain vehicles, there could be a problem inside the high-voltage battery. As a result, the battery modules could overheat and short circuit. Note: This recall only affects certain plug-in hybrid (PHEV) models. Safety Risk: A short circuit in the high-voltage battery can create a fire risk, even while the vehicle is parked and turned off. Corrective Actions: To reduce the safety risk, Volvo advises not to charge your vehicle until the recall repairs have been completed. Volvo will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, replace the high-voltage battery module(s). The dealer will also install an advanced diagnostic software that will monitor the high-voltage battery and warn you if it detects a problem. If you see this warning, you should contact a dealership to arrange replacement of the affected high-voltage battery module(s).
Recall 202259531,117 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the top-view camera to display instead of the rearview camera image when you are reversing. Canadian regulations require the rearview image to display when reversing. Note: This recall only affects vehicles equipped with a 360-degree park assist camera. Safety Risk: A rearview camera image that does not display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Volvo will notify owners in writing and send a wireless over-the-air update to each vehicle. If the update cannot be completed successfully, or for vehicles without over-the-air (OTA) update capability, Volvo will instruct you to schedule an appointment to have the update performed by a dealer.
Recall 20215403,078 units in Canada
Seats And Restraints
Issue: On certain vehicles, the passenger seat belt assemblies may contain defective automatic locking retractors (ALR). As a result, the seat belts may not properly lock to secure a child seat. Note: The vehicle's lower universal anchorage system (UAS) is not affected by this defect and may still be used to secure a child seat. Safety Risk: A seat belt that is used to secure a child restraint but is not properly locked could increase the risk of injury in a crash. Corrective Actions: Volvo will notify owners by mail and instruct you to take your vehicle to a dealer to inspect the seat belts. They will be replaced, if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 40,000 milesRenton, WACrash2 injured
VEHICLE SPEED CONTROL
The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000
NHTSA complaint #11750906 — an unverified report by a vehicle owner.
at 40,000 milesRenton, WACrash2 injured
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000
NHTSA complaint #11750906 — an unverified report by a vehicle owner.
Norman, OKCrash
VEHICLE SPEED CONTROL
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
Norman, OKCrash
SERVICE BRAKES
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
Norman, OKCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
at 53,000 milesRidgeway, WI1 injured
FORWARD COLLISION AVOIDANCE
The contact owns a 2022 Volvo XC60. The contact stated that while driving approximately 45 MPH during nighttime, the Forward Collision Avoidance system engaged while there were no vehicles or objects in front of the vehicle. The contact stated that the failure caused pain in her rib cage when the brake was suddenly applied. Medical attention was not sought. No warning lights were illuminated; however, the message "Front Collision Aversion Engaged" was displayed on the instrument panel. The vehicle was taken back to the residence, and the dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.
NHTSA complaint #11714457 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Colorado Springs, CO
ELECTRICAL SYSTEM
On [XXX], at 82,371 miles, my daughter's 2022 Volvo XC60 T8 Recharge was diagnosed with DTC BECM-P0BBD92 (Hybrid/High Voltage Battery Pack Voltage Variation) and a confirmed Cell Module F failure (Repair Order #[XXX], Bob Penkhus Motor Co Volvo Cars, Colorado Springs, CO). The dealer instructed her not to charge the vehicle pending repair. The replacement part (Cell Module F, Part #36003341) has been on indefinite backorder since diagnosis — initially quoted at 6 weeks, still unavailable as of this report. This vehicle falls within NHTSA Recall 25V-179 (LG high-voltage battery modules, fire risk when fully charged and parked). NHTSA's VIN lookup shows this VIN as having no unrepaired recalls, which I believe reflects only a prior software-monitoring update rather than a physical hardware fix — this diagnosed cell failure occurred after that update, is consistent with the exact failure mode described in the recall, and cannot currently be repaired because the remedy part is unavailable. Volvo Cars USA opened and then closed a corporate case (#[XXX], closed June 19, 2026) declining further assistance, stating its only obligation is to repair the vehicle — which it cannot presently do. It has been 138 days with no resolution on this matter. My name is [XXX] (father) and I can provide notarized authorization to act on my daughter's behalf on this matter. Thank you very much for your kind assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11762590 — an unverified report by a vehicle owner.
Colorado Springs, CO
ENGINE
On [XXX], at 82,371 miles, my daughter's 2022 Volvo XC60 T8 Recharge was diagnosed with DTC BECM-P0BBD92 (Hybrid/High Voltage Battery Pack Voltage Variation) and a confirmed Cell Module F failure (Repair Order #[XXX], Bob Penkhus Motor Co Volvo Cars, Colorado Springs, CO). The dealer instructed her not to charge the vehicle pending repair. The replacement part (Cell Module F, Part #36003341) has been on indefinite backorder since diagnosis — initially quoted at 6 weeks, still unavailable as of this report. This vehicle falls within NHTSA Recall 25V-179 (LG high-voltage battery modules, fire risk when fully charged and parked). NHTSA's VIN lookup shows this VIN as having no unrepaired recalls, which I believe reflects only a prior software-monitoring update rather than a physical hardware fix — this diagnosed cell failure occurred after that update, is consistent with the exact failure mode described in the recall, and cannot currently be repaired because the remedy part is unavailable. Volvo Cars USA opened and then closed a corporate case (#[XXX], closed June 19, 2026) declining further assistance, stating its only obligation is to repair the vehicle — which it cannot presently do. It has been 138 days with no resolution on this matter. My name is [XXX] (father) and I can provide notarized authorization to act on my daughter's behalf on this matter. Thank you very much for your kind assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11762590 — an unverified report by a vehicle owner.
Colorado Springs, CO
FUEL/PROPULSION SYSTEM
On [XXX], at 82,371 miles, my daughter's 2022 Volvo XC60 T8 Recharge was diagnosed with DTC BECM-P0BBD92 (Hybrid/High Voltage Battery Pack Voltage Variation) and a confirmed Cell Module F failure (Repair Order #[XXX], Bob Penkhus Motor Co Volvo Cars, Colorado Springs, CO). The dealer instructed her not to charge the vehicle pending repair. The replacement part (Cell Module F, Part #36003341) has been on indefinite backorder since diagnosis — initially quoted at 6 weeks, still unavailable as of this report. This vehicle falls within NHTSA Recall 25V-179 (LG high-voltage battery modules, fire risk when fully charged and parked). NHTSA's VIN lookup shows this VIN as having no unrepaired recalls, which I believe reflects only a prior software-monitoring update rather than a physical hardware fix — this diagnosed cell failure occurred after that update, is consistent with the exact failure mode described in the recall, and cannot currently be repaired because the remedy part is unavailable. Volvo Cars USA opened and then closed a corporate case (#[XXX], closed June 19, 2026) declining further assistance, stating its only obligation is to repair the vehicle — which it cannot presently do. It has been 138 days with no resolution on this matter. My name is [XXX] (father) and I can provide notarized authorization to act on my daughter's behalf on this matter. Thank you very much for your kind assistance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11762590 — an unverified report by a vehicle owner.
Canton, GA
UNKNOWN OR OTHER
Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display home button for 20–30 seconds, but the complete audio failure recurs every few drive cycles.
NHTSA complaint #11762138 — an unverified report by a vehicle owner.
Canton, GA
LANE DEPARTURE: BLIND SPOT DETECTION
Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display home button for 20–30 seconds, but the complete audio failure recurs every few drive cycles.
NHTSA complaint #11762138 — an unverified report by a vehicle owner.
Canton, GA
LANE DEPARTURE: WARNING
Component Failure & Inspection Availability: Infotainment Head Unit (IHU) / Audio Module (AUD) running Android Automotive OS. The vehicle and its components are available for inspection upon request. Safety Risk: The audio system completely crashes approximately every 3 drive cycles. This failure disables all safety-critical audio features, including turn signal clicks, backup camera and parking sensor chimes, blind-spot/cross-traffic warning alerts, and emergency system tones. Operating the vehicle without audible turn signals or proximity chimes creates significant driver distraction and an immediate hazard to traffic safety. Dealer / Service Confirmation: The issue occurs intermittently during daily operation and is being reported to Volvo dealer service Prior Inspection: The vehicle has been inspected by Volvo service department Symptoms & Onset: The problem began following a recent Android Automotive OS software update. No warning lamps, error messages, or indicators appear prior to the failure. The entire audio bus shuts off either at vehicle start or mid-drive. The only temporary workaround is forcing an infotainment reboot by holding the center display home button for 20–30 seconds, but the complete audio failure recurs every few drive cycles.
NHTSA complaint #11762138 — an unverified report by a vehicle owner.
Palm Harbor, FL
BACK OVER PREVENTION: WARNINGS
All audio including all warnings intermittently shuts off. No warning when it fails.
NHTSA complaint #11761105 — an unverified report by a vehicle owner.
Palm Harbor, FL
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
All audio including all warnings intermittently shuts off. No warning when it fails.
NHTSA complaint #11761105 — an unverified report by a vehicle owner.
Palm Harbor, FL
LANE DEPARTURE: WARNING
All audio including all warnings intermittently shuts off. No warning when it fails.
NHTSA complaint #11761105 — an unverified report by a vehicle owner.
Sacramento, CA
ELECTRICAL SYSTEM
The vehicle goes silent, no audio system, no driving alerts— turn signals, alerts etc. Only is fixed by a hard reset to the sound system happens multiple times a week sometimes multiple times a day. According to technicians, this is a known issue with no fix.
NHTSA complaint #11757274 — an unverified report by a vehicle owner.
Castle Rock, CO
ELECTRICAL SYSTEM
Turn signal audio not present (lights working. No audio from radio, phone , collision warnings rear cross traffic warnings, door ajar audio warnings. Resetting the display fixes the problem. However, the issue returns the next day.
NHTSA complaint #11756075 — an unverified report by a vehicle owner.
Castle Rock, CO
BACK OVER PREVENTION: WARNINGS
Turn signal audio not present (lights working. No audio from radio, phone , collision warnings rear cross traffic warnings, door ajar audio warnings. Resetting the display fixes the problem. However, the issue returns the next day.
NHTSA complaint #11756075 — an unverified report by a vehicle owner.
Castle Rock, CO
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
Turn signal audio not present (lights working. No audio from radio, phone , collision warnings rear cross traffic warnings, door ajar audio warnings. Resetting the display fixes the problem. However, the issue returns the next day.
NHTSA complaint #11756075 — an unverified report by a vehicle owner.
at 40,000 milesRenton, WACrash2 injured
VEHICLE SPEED CONTROL
The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000
NHTSA complaint #11750906 — an unverified report by a vehicle owner.
at 40,000 milesRenton, WACrash2 injured
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000
NHTSA complaint #11750906 — an unverified report by a vehicle owner.
Bloomfield, NJ
ELECTRICAL SYSTEM
After a software update to the infotainment system (Android Automotive OS version 5.1.17, installed on 06/03/2026), my 2022 Volvo XC60 B5 intermittently loses all audio output. When the failure occurs, the vehicle produces no sound of any kind: no audible rear parking/proximity sensor warning while in reverse, no turn-signal indicator tones, and no media audio. The rear-view camera image still displays normally, so the loss of the audible backup warning is not obvious to the driver — the parking-assist system appears functional while its audible warnings are in fact disabled. On multiple occasions the failure was already present as I backed out of my garage and began driving, leaving me with no audible obstacle warning while reversing and no turn-signal tones while maneuvering. The display, navigation, and camera continue to function while audio is dead, which indicates the audio service stops responding rather than a hardware fault. The only way to restore audio is to fully restart (reboot) the infotainment head unit; the failure then recurs intermittently. The fault began immediately after the 5.1.17 update and was sporadic at first. After noticing a pattern, I documented occurrences on 06/15/2026, 06/17/2026, and 06/20/2026 with timestamped photographs, which are available on request. No crash or injury has occurred, but the loss of audible backup-warning tones while reversing is a safety hazard, particularly for pedestrians or obstacles behind the vehicle. I am not aware of a current recall covering this issue and am requesting investigation.
NHTSA complaint #11746024 — an unverified report by a vehicle owner.
Bloomfield, NJ
BACK OVER PREVENTION: WARNINGS
After a software update to the infotainment system (Android Automotive OS version 5.1.17, installed on 06/03/2026), my 2022 Volvo XC60 B5 intermittently loses all audio output. When the failure occurs, the vehicle produces no sound of any kind: no audible rear parking/proximity sensor warning while in reverse, no turn-signal indicator tones, and no media audio. The rear-view camera image still displays normally, so the loss of the audible backup warning is not obvious to the driver — the parking-assist system appears functional while its audible warnings are in fact disabled. On multiple occasions the failure was already present as I backed out of my garage and began driving, leaving me with no audible obstacle warning while reversing and no turn-signal tones while maneuvering. The display, navigation, and camera continue to function while audio is dead, which indicates the audio service stops responding rather than a hardware fault. The only way to restore audio is to fully restart (reboot) the infotainment head unit; the failure then recurs intermittently. The fault began immediately after the 5.1.17 update and was sporadic at first. After noticing a pattern, I documented occurrences on 06/15/2026, 06/17/2026, and 06/20/2026 with timestamped photographs, which are available on request. No crash or injury has occurred, but the loss of audible backup-warning tones while reversing is a safety hazard, particularly for pedestrians or obstacles behind the vehicle. I am not aware of a current recall covering this issue and am requesting investigation.
NHTSA complaint #11746024 — an unverified report by a vehicle owner.
Bloomfield, NJ
BACK OVER PREVENTION: REARVIEW SYSTEM BRAKING
After a software update to the infotainment system (Android Automotive OS version 5.1.17, installed on 06/03/2026), my 2022 Volvo XC60 B5 intermittently loses all audio output. When the failure occurs, the vehicle produces no sound of any kind: no audible rear parking/proximity sensor warning while in reverse, no turn-signal indicator tones, and no media audio. The rear-view camera image still displays normally, so the loss of the audible backup warning is not obvious to the driver — the parking-assist system appears functional while its audible warnings are in fact disabled. On multiple occasions the failure was already present as I backed out of my garage and began driving, leaving me with no audible obstacle warning while reversing and no turn-signal tones while maneuvering. The display, navigation, and camera continue to function while audio is dead, which indicates the audio service stops responding rather than a hardware fault. The only way to restore audio is to fully restart (reboot) the infotainment head unit; the failure then recurs intermittently. The fault began immediately after the 5.1.17 update and was sporadic at first. After noticing a pattern, I documented occurrences on 06/15/2026, 06/17/2026, and 06/20/2026 with timestamped photographs, which are available on request. No crash or injury has occurred, but the loss of audible backup-warning tones while reversing is a safety hazard, particularly for pedestrians or obstacles behind the vehicle. I am not aware of a current recall covering this issue and am requesting investigation.
NHTSA complaint #11746024 — an unverified report by a vehicle owner.
Gardiner, NY
ELECTRICAL SYSTEM
Re: Demand for repurchase or replacement under warranty — VIN [XXX] Vehicle: 2022 Volvo XC60 (pre‑certified) Purchase date: 08/19/2024 Dealer: [Dealer name, [XXX] ] Dear Volvo Cars USA Customer Care: I am the owner of the above-referenced vehicle. Since the date of purchase (08/19/2024) the vehicle’s infotainment system has repeatedly failed: it shuts down and reboots frequently (as often as 10 times within one hour of normal driving). Each shutdown disables navigation, HVAC controls and Bluetooth, and on reboot I must reset settings. This defect creates a significant safety hazard while driving, especially in unfamiliar areas. Since purchase I have returned the vehicle to the dealer for diagnosis and repair on multiple occasions. The vehicle has received software updates approximately 3–4 times, most recently on05//05/2026. The problem persists. I have retained copies of all repair orders and service records documenting these visits. (Copies attached.) This recurring failure remains unresolved despite multiple repair attempts and continues to present a SERIOUS safety risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11737401 — an unverified report by a vehicle owner.
Pittsburgh, PA
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
2022 Volvo XC60 T8 Recharge VIN: [XXX] Mileage at time of complaint: ~38,400 Purchased: November 2023 (Certified Preowned) DESCRIPTION OF PROBLEM: The vehicle's infotainment system and backup camera have experienced repeated failures since the time of purchase. The backup camera intermittently fails to display an image when the vehicle is placed in reverse, leaving the driver without rear visibility. The infotainment system freezes, goes black, or becomes unresponsive without warning. These failures affect the federally mandated rearview camera display required under FMVSS 111. The vehicle has been brought to authorized Volvo retailers (Jim Fisher Volvo, Portland, OR and Germain Volvo North Hills, Wexford, PA) more than eight times for in-person service for this concern. The same issues have also been troubleshot remotely by phone or text on approximately ten additional occasions. Software updates, system resets, and other attempted repairs have not permanently resolved the problem. On one occasion, the backup camera failed to display while reversing, which contributed to minor rear bumper damage. The driver was relying on the camera display as designed and federally required, and the system did not perform. I am aware that NHTSA Recall 25V282 (Volvo R10320) was issued in April 2025 for this defect across 413,000+ vehicles including the 2022 XC60. Despite the recall, the underlying infotainment and camera reliability issues in my vehicle have not been resolved. A second recall (25V392) was issued after the initial software fix caused braking concerns in some vehicles. No injuries have occurred. No crashes have occurred beyond the minor bumper contact described above. Volvo Customer Care Case #XXX was opened and a goodwill assistance request was denied. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11733331 — an unverified report by a vehicle owner.
Mykolaiv, AZ
ENGINE
Reporting a manufacturing defect in a 2022 Volvo XC60. The vehicle developed a metallic ticking noise in the timing area, audible at idle. Symptoms strictly match Volvo Technical Journal 36551.9.1 (NHTSA ID: MC-11015995-0001) regarding faulty camshaft seals. The noise disappeared when the oil filler cap was loosened, exactly as described in the TJ. An authorized Volvo dealer confirmed the defect and replaced the camshaft seals per Volvo’s protocol (Work Act No. ЗН-0131107). This repair completely resolved the issue, proving it was a manufacturing fault. The manufacturer refused warranty coverage citing 'salvage title' status, without proving any causal link between the title and this specific engine defect. Failure of timing components poses a significant safety risk, including sudden engine stall or oil leaks during operation. The owner was forced to pay out-of-pocket for the repair of a recognized factory defect. Supporting documents and video evidence are available upon request.
NHTSA complaint #11729583 — an unverified report by a vehicle owner.
Auburn, WA
UNKNOWN OR OTHER
Sunroof cracking, shattering
NHTSA complaint #11726341 — an unverified report by a vehicle owner.
Norman, OKCrash
VEHICLE SPEED CONTROL
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
Norman, OKCrash
SERVICE BRAKES
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
Norman, OKCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.