30 of the
948 complaints filed about the Volvo XC60
are about the throttle and cruise control —
3% of everything owners reported.
The worst model year for it is 2022.
30
Complaints
3%
Share of all complaints
11
Crashes
1
Fires
Acceleration & Cruise Control complaints by model year
While parking our Volvo in the parking lot of Trader Joe's grocery store on [XXX], the Volvo suddenly accelerated and collided with the adjacent car in the next parking slip and rammed the car in the forward parking slip pushing about 15 to 20 feet ahead. Luckily, nobody was hurt though it could have been a disaster is someone was standing there near either of the other two cars. No one other than the auto body shop has inspected the car. The police came but did not write up a report because it was on private property and there were no injuries. Nothing on the instrument panel then or now shows any indication of a malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11754817 — an unverified report by a vehicle owner.
The contact owns a 2025 Volvo XC60. The contact stated that while his wife was pulling into a parking space slowly, the vehicle independently accelerated, causing the vehicle to sideswipe a vehicle nearby on the driver’s side of the vehicle and then rear-end another vehicle before coming to a complete stop. The vehicle stopped and was turned off. There was no property damage reported. There were no air bags deployed. The vehicle was not towed and was deemed inoperable. No warning lights were illuminated prior to the failure. A Police report was not filed. No injuries were reported. The dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 19,000.
NHTSA complaint #11753727 — an unverified report by a vehicle owner.
The contact owned a 2020 Volvo XC60 II. The contact stated while reversing, the rear view camera displayed a black screen. The contact stated that the accelerator pedal was depressed, however the vehicle failed to accelerate as intended. The vehicle's speed independently accelerated. The contact's vehicle crashed into a parked vehicle. The contact stated that there were two additional occupants in the vehicle. The contact sustained pain in the right knee, no medical treatment was provided. The passenger, who was seated in the rear seat, sustained neck and upper back injuries. The passenger received medical treatment at the local medical center. The vehicle was driven to the residence. The failure was intermittent. The contact stated that the vehicle was previously taken to the dealer, however the failure was not duplicated. The contact later received a recall notification, NHTSA Campaign Number: 25V908000 (Back Over Prevention). The manufacturer was not made aware of the failure. The failure mileage was 40,000
NHTSA complaint #11750906 — an unverified report by a vehicle owner.
The contact owns a 2018 Volvo XC60. The contact stated that after starting the vehicle, while driving at a slow speed, the brake pedal was depressed while approaching a speed pump and the vehicle unintendedly accelerated and drove at a high rate of speed before crashing into a fence. The contact stated that the vehicle had exceeded 40 MPH. During the crash, the front end of the vehicle was damaged; however, no air bags were deployed. The contact was not injured. The Police and EMS were called to the scene, and the driver and front seat passenger were examined. The driver and passenger suffered emotional stress from the crash. The cause of the failure was not yet determined. The manufacturer and local dealer were not yet notified of the failure. The failure mileage was 87,843.
NHTSA complaint #11746434 — an unverified report by a vehicle owner.
3rd time driving our Volvo on the road and having the automatic emergency brake engage too early or in this instance, with no vehicle in front of us. We have been dealing with issues related to the safety systems and error messages in our Volvo related to “blind spot”, “automatic emergency braking”, and sensor failures or errors since having our vehicle leased since 2023. It has been in the shop MULTIPLE times to have sensors replaced only for errors to come back. Our system current says to clean the front sensors even though there is no debris on them. We also experienced this errors while driving 2025 loaner models with our vehicle in for repairs. We feel unsafe in our vehicle and can’t rely on the safety systems. We have also experienced the entire auto system failing in our car multiple times. This leads to any sounds system including emergency warnings to turn signals from not producing ANY sounds.
NHTSA complaint #11729489 — an unverified report by a vehicle owner.
At the end of a downhill cloverleaf coming coming on and off a highway, the car slowed to a crawl but would not stop. It was going slowly as if "creeping" like when in B mode but was not in B mode. The brakes would not stop it. I was able to shift gears from Drive to N to P but no response, car continued to creep forward until it gently bumped into the back of an 18 wheeler. There was no collision alarm at the time. I turned the car on and off, and powering down seemed to re set the issue, but the collision alarm went off like 10 minutes later when there was nothing to set it off (seemed like it was just delayed). No error code came up, nothing. I submitted my claim to Volvo, esp since there are similar recalls so I thought it was a known thing, but apparently not reported on my exact make and model (there were not very many made). I did not know there was damage to my vehicle, and the truck driver and myself did not even get out, he didn't feel me, and I assumed the bumper just bumped him so no police report. This was an intermittant failure and after I re booted the vehicle I slowly drove home after brakes seemed to be working after power on/off. I did not know that it was my HOOD that bumped the truck. I did not know there was damage until I got home. If this car's make and model were NOT included in the recall, they should be. TERRIFYING. And volvo did not acknowledge or reassure. requested documentation on what they inspected, and did not receive.
NHTSA complaint #11726185 — an unverified report by a vehicle owner.
My car periodically shuts down while on highway and once a week is completely dead and requires a jump or a tow. I have brought this to the dealerships attention for over 18 months and they continue to tell me that the problem is fixed. The car shut down and was completely dead again this week. No one from NA Volvo has ever called me back when I report the problem or has responded to countless inquiries.
NHTSA complaint #11710328 — an unverified report by a vehicle owner.
Component/System that failed: The engine (T5 Drive-E) experienced sudden loss of propulsion and entered reduced engine performance mode. The vehicle is currently available for inspection and was towed to an authorized Volvo dealer following the incident. How safety was put at risk: On July 3, 2025, while driving approximately 75 mph on a crowded interstate highway in rural Ohio with cruise control engaged, the vehicle suddenly and without warning lost propulsion. Traffic included semi-trucks and other vehicles, with limited shoulder availability. The sudden loss of acceleration at highway speed created an immediate risk of rear-end collision and left the vehicle unsafe to operate. Confirmation or reproduction: Prior to the failure, in July 2024 at approximately 92,000 miles, I reported abnormal oil consumption to an authorized Volvo dealer and raised a known Volvo service advisory related to oil consumption in the T5 Drive-E engine. The dealer acknowledged the advisory but refused testing, stating the vehicle did not meet Volvo’s internal threshold. After the failure, a service agent acknowledged that this issue is known to occur in this model at approximately this mileage. Inspections: The vehicle was serviced at an authorized Volvo dealer in Bethesda, Maryland just days prior to the incident. Following the failure, the vehicle was towed to an authorized Volvo dealer in Columbus, Ohio. Volvo Cars USA has not repaired the vehicle and denied a goodwill request. Warnings or symptoms prior to failure: There were no warning lamps or messages prior to the loss of propulsion. The engine warning light and a “Reduced Engine Performance” message appeared only after power was lost.
NHTSA complaint #11708737 — an unverified report by a vehicle owner.
While driving on crowded I40 near Statesville NC, the engine started to stutter and moments later quit entirely. Fortunately we were able to move to the shoulder with only a few seconds to spare. This was very dangerous as we had to move through the right lane in front of speeding semi trucks. The only warning light received was that there was an engine problem, that the car would go into “safe” mode. This was mere seconds before entirely disabling the engine. Had we come to a halt on the highway there would have been a serious accident and injury to ourselves and most likely others. We contacted Volvo, a tow was dispatched and the car was winched on to a flat bed trailer and we were transported to a dealer in Hickory. Later it was confirmed that the Integrated Starter General (ISG) had failed and that power had been interrupted to the hybrid battery. There is a serious problem here and I suspect may impact other “mild hybrid” systems that install integrated alternator/starter motor systems between the engine and transmission.
NHTSA complaint #11694242 — an unverified report by a vehicle owner.
Issue: Sudden, unexpected acceleration when in reverse. Details At about 10:15 am PDT on Saturday September 20th, 2025. My 2025 Volvo XC 60 car was in Pure mode with Creep mode toggled off. I put the car into reverse with the intent to back up 6-8ft. I lightly depressed the accelerator and the car lurched/accelerated backwards at a high rate of speed. I stopped the car by braking, and it is possible the Volvo automatic braking also engaged. I parked the car. When I came back to the car, in order to back out of the space safely, I engaged/toggled the creep mode on. The creep mode allowed me to keep my foot on the brake while backing up just it case the car rapidly accelerated again. I have asked the Volvo dealer for the EDR, but I have been told they are not allowed to provide this information. This was frightening and dangerous situation and I am fortunate no one was in the vicinity.
NHTSA complaint #11689941 — an unverified report by a vehicle owner.
Three incidents have occurred in three months. Unintended Acceleration Incident #1. While turning right after a full stop on an uphill incline, the vehicle accelerated so quickly that the steering wheel couldn't be return to the neutral position before hitting a roadside signpost approximately 25 ft away. The impact was severe enough to cause the right front headlight to be broken, the right front wheel well liner to be ripped out, the right A-pillar to be dented, and the right mirror to be ripped off. No physical injuries occurred. Unintended Acceleration Incident #2, six weeks later. While on the same incline as incident #1, after removing my foot from the accelerator, the vehicle continued to accelerate, even during braking. Total time was approximately 2 sec. There was no damage to the vehicle, and no physical injury. I checked, and the floor mat was locked in place. Both incidents were reported to Volvo, and permission was given to extract data from the vehicle. The data was extracted at a Volvo service center. Unexpected Acceleration Incident #3 (after data extraction, before Volvo report). While turning right and into a parking space in front of a sidewalk and coming to a stop on an uphill incline, the vehicle quickly moved forward approximately 2 ft after my foot was removed from the brake. I was able to brake again to regain control and put the car in park. Unexpected Acceleration Incident #4 (after data extraction, before Volvo report). While traveling on an uphill incline, after removing my foot from the accelerator, the engine remained at a high enough RPM to sustain forward motion. Even after full-stop braking, the vehicle would move forward on its own, on an uphill incline, without depressing the accelerator. After incident #4, Volvo reported that they concluded that the vehicle was operating as designed at the time of their inspection and during a test drive, that no fault codes were found, and that no unintended acceleration was observed.
NHTSA complaint #11645394 — an unverified report by a vehicle owner.
When I had to slow down or suddenly stop because there were other cars in front of me, I. stepped on the break, but it did not stop; maybe it slowed down a little, but the acceleration seemed to accelerate faster. I could hear the acceleration sound. I had to push the gear to stop. The car finally stopped. But I almost hit the front car. Similar occurrences happened when I came to a stop signal, which could have involved me in a serious accident, even fatal. I still drive the car because I have only one car. Most of the time, it works normally, but the problem occurs occasionally. I am scared, thinking it will happen again.
NHTSA complaint #11618357 — an unverified report by a vehicle owner.
Case number 240821-000271 was opened on 8/21/24 with Volvo Car USA Support. I have three main concerns: 1) The infotainment system losing the favorites that I have saved in the Sirius application. This had been an intermittent problem that I had been having since I purchased the car. I finally took it into the service department at Volvo Cars of Gilbert on 1/7/23 for this problem (Invoice Number VOCS110975). The service department was unable to recreate the problem so they did nothing. 2)A complete car system reboot while I was driving on 6/10/24. As I was driving down the road the HVAC system shut off and the dash and infotainment system screens went blank. All car systems completely shut down except the engine. This was an extremely frightening experience as all of this happened with no warning whatsoever WHILE I WAS DRIVING. This is a huge safety issue! Within about a minute of driving like this the systems started to come back up. I proceeded home. The next morning I took the car to Volvo Cars of Gilbert again. They had the car for 5 days and performed a software update on the IHU (Infotainment Head Unit) (Invoice Number VOCS120164). 3)The failure of the infotainment system to update after starting the car and driving. This happened on 8/7/24 and I took the car directly to Volvo Cars of Gilbert again. The infotainment system was stuck on “Infotainment system starting…” for the entire 12-minute drive to Volvo. Volvo Cars of Gilbert had my car for 8 days this time and this time they did a reload to the existing IHU (Invoice Number VOCS121204). I asked that they replace the IHU. Volvo refused to replace the IHU because it was too expensive at $3200. Also, the problem of the infotainment system losing its radio favorites has become much worse. It happens daily now. I believe there is an opportunity for a catastrophic event to happen while I am driving if this IHU problem is not corrected immediately.
NHTSA complaint #11616735 — an unverified report by a vehicle owner.
The speedometer stopped working - no numbers were visible on my dash. It was unsafe as I was not aware what speed I was traveling. This happened on December 24, 2023 and has not happened again after that nor was it reproduced or confirmed by a dealer or service center. The vehicle has not been inspected by anyone. There were no warning lamps/messages/or anything.
NHTSA complaint #11565234 — an unverified report by a vehicle owner.
I've experienced many problems with the Google built in system in this Volvo. But the one that keeps happening is the speed sensors. The car is supposed to read traffic signs, including speed signs and alarm when exceeding the posted speed limit. It does not work. For example on I66 East bound in Virginia, the speed limit is not 80mph, it is either 60, 65 or 70 if using the express lanes. The Volvo keeps showing the speed limit on this interstate as 80, see attached images showing speed limit sign at 80. Complained to Volvo, they blamed Google. Complained to Google, they blamed Volvo. Other roads have the same sign recognition. The car infotainment & safety features randomly shut down, or fail, while driving and the vehicle has to be reset often. Back up cameras quit working while backing up sometimes it will not go into reverse without shutting off the car or doing a reset.
NHTSA complaint #11548899 — an unverified report by a vehicle owner.
I purchased the car in April 2022. Did not have any issues until February 2023. Initially, the engine light came on with a turtle icon in the dash screen. I was driving and the car would not go over 45 mph. on a busy street . The car was hesitating badly and also said something about the propulsion? Volvo Ontario towed it from my business and supposedly fixed it. Fast forward the following week, engine light came. Back to dealer, who said the software at that time was not available and it was a recall. A few days later they said they were disconnecting the engine light until new update was available. Back to dealer with update now installed, supposedly this would fix all the engine issues. A few days later, 3/7 I got into car and started it . This mesage came on, "Slow down, the vehicle will reduce speed. Propulsion system failure", Followed by ,"Propulsion System Service Required" with yellow engine light on. Backed out of the driveway and the car started vibrating and shaking violently. Currently waiting on Volvo for next steps. I am so dissapointed with this car and it is a huge concern for safety. I purchased this car because of their reputation for safety.
NHTSA complaint #11510620 — an unverified report by a vehicle owner.
The screen does not come on, so no heat, no safety stuff, no reverse camera and no sensors. All the above ADAS features do not work either. This is definitely a safety hazard, which I think traces back to the vehicle operating system. Details reported to Volvo in this tweet--> https://twitter.com/ameyaroskar/status/1608642311923339266?t=CUl77cpdg6qWIP8AJqetyQ&s=19
NHTSA complaint #11499450 — an unverified report by a vehicle owner.
WAS DRIVING ON HIGHWAY. I LET GO OF THE GAS PEDAL BUT THE CAR STILL UNCONTROLLABLY ACCELERATES! GAS PEDAL IS STUCK. HITTING THE BREAKS SLOWS THE CAR A BIT. THIS WENT ON FOR ABOUT 10 SECONDS AND FINALLY AND LUCKILY THE "R-DESIGN" GAS PEDAL COVER FELL OFF AND I WAS ABLE TO STOP ACCELERATING. INTENDED TO DRIVE AT 65 MPH BUT THE CAR ITSELF ACCELERATED TO UP TO 80 MPH MOMENTARILY.
NHTSA complaint #11348520 — an unverified report by a vehicle owner.