83 of the
515 complaints filed about the Volvo XC70
are about the fuel system —
16% of everything owners reported.
The worst model year for it is 2004.
I own a 2004 Volvo XC70 that is experiencing the same fuel pump defect described in Recall R220 / NHTSA Campaign 09V483000 (fuel pump leak). My vehicle exhibits fuel system problems consistent with the recall description. However, my VIN is not included in the current recall population. When I contacted Volvo, I was told my case (ID #250827-000998) was escalated to corporate, but I was later informed that no goodwill assistance would be provided because my VIN is not covered. I specifically requested written confirmation of this determination. This defect poses a safety risk that aligns with the existing recall, and I believe additional vehicles outside the current VIN range may be affected. I am requesting that NHTSA review whether the recall should be expanded to include vehicles like mine.
NHTSA complaint #11687907 — an unverified report by a vehicle owner.
My car kept getting a light for its coolant levels despite me filling it with proper coolant-I noticed a leak of coolant on the ground & upon getting it inspected from an independent service center, they told me the issue was my radiator so we got the part to fix it and a week later fixed the radiator and I didn’t get the light for coolant again. Although the independent service center told me that i actually had a fuel leakage due to my pump and described the issues I’ve been having with my car for a few months as signs to what problems this is causing, this meaning a funky fuel smell, my car struggling to fully turn on-needing multiple tries to actually fully turn on etc. this puts my safety at risk because fuel leakage is extremely dangerous for multiple reasons. Not inspected by manufacturer police or insurance reps. Other than the coolant light issue and the noticed continued leak after the coolant leakage was fixed. After looking into this issue online I found a recall notice from VOLVO and called them and they claimed my car wasn’t on this recall notice but my year and model is indeed listed and since im having the same problem as the recall listed its concerning me.
NHTSA complaint #11665613 — an unverified report by a vehicle owner.
I replaced a catalytic converter and 2 O2 sensors a few months ago. Check engine light came on. Oil was pooling into the catalytic converter from the engine. Technician checked pistons. Said there was unusual wear and oil was coming in through the pistons.
NHTSA complaint #11623856 — an unverified report by a vehicle owner.
Fuel pump seal leak/ flange broke. Smelled gas, saw a puddle under the car. Upon fuel pump inspection a failed repair combined with original broken seal flange. We live in a state where the recall was not listed so our next step is to contact volvo.
NHTSA complaint #11456464 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 VOLVO XC70. THE CONTACT STATED THAT THERE WAS A FUEL ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC AND WAS INFORMED THAT THE VEHICLE HAD A DEFECTIVE FUEL PUMP AND FUEL PUMP SEAL. THE MECHANIC LINKED THE FAILURE TO NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE CONTACT THEN TOOK THE VEHICLE TO JIM FISHER VOLVO (2108 W BURNSIDE ST, PORTLAND, OR 97210) WHERE HE WAS INFORMED THAT THE VEHICLE WAS NOT UNDER RECALL. THE CONTACT WAS INFORMED THAT HE HAD TO PAY OUT OF POCKET FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED A DISCOUNT TOWARDS THE REPAIRS. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
NHTSA complaint #11377519 — an unverified report by a vehicle owner.
I JUST BOUGHT A 2004 VOLVO XC70 STATION WAGON AND IT SEEMS TO BE LEAKING FROM THE FUEL PUMP WHICH FROM MY UNDERSTANDING IS A RECALL. I BOUGHT THIS VEHICLE THINKING BECAUSE IT WAS A VOLVO IT WAS GOING TO BE A SAFE CAR FOR MY CHILDREN AND I. IF YOU CAN CONTACT ME AND LET ME KNOW IF YOU CAN HELP ME I WOULD GREATLY APPRECIATE IT MY NUMBER IS [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11374079 — an unverified report by a vehicle owner.
PARK THE CAR AND SMELL GAS DID SOME MORE RESEARCH AND HOW TO SET THE FUEL PUMP IS LEAKING GAS OUT OF THE CAR ON THE STREET AND SAD DOESN'T HAVE GAS PRESSURE AND IT LEAKS GAS UNDER THE BACK SEAT
NHTSA complaint #11351705 — an unverified report by a vehicle owner.
VEHICLE SHUTS DOWN AS IF IT IS NOT GETTING FUEL, STALLS AND SHUTS OFF. IT WILL RESTART AFTER SITTING FOR A WHILE BUT WILL ONLY GO A SHORT DISTANCE BEFORE DOING IT AGAIN. FIRST OCCURENCE VEHICLE WAS TRAVELING AT 65 MPH IN FAIRLY FAST MOVING TRAFFIC CREATING A VERY UNSAFE SITUATION. THIS CONTINUES TO HAPPEN AND NOW WE DO NOT DRIVE THE VEHICLE.
NHTSA complaint #11316997 — an unverified report by a vehicle owner.
ALTHOUGH THE 'CRACKED FUEL PUMP FLANGE' RECALL SERVICE (VOLVO RECALL R220, NHTSA 09V-483) WAS PREVIOUSLY PERFORMED ON MY VEHICLE, THE VOLVO XC70 HAS AN ADDITIONAL 'FUEL SENDING UNIT' ON THE DRIVER'S SIDE OF THE CAR. THIS ADDITIONAL FUEL COMPONENT HAS A SIMILARLY FORMED FLANGE WHICH ALSO DEVELOPS A CRACK. EVEN THOUGH THE UNITS ARE SIMILARLY COMPOSED AND BOTH IN THE SAME ENVIRONMENT, I HAVE BEEN TOLD THE AUXILIARY FUEL SENDING UNIT IS NOT COVERED UNDER VOLVO RECALL 220. EXACTLY AS DESCRIBED IN THE FUEL PUMP RECALL, THE CRACK IN THE DRIVER'S SIDE FUEL SENDING UNIT ALLOWS GASOLINE TO CONSTANTLY OOZE THROUGH THE CRACK AND SLOWLY POUR ONTO THE GROUND AND PUDDLE. IF A FUEL PUMP FLANGE CRACK ALLOWING GASOLINE TO POUR ONTO THE GROUND WAS CAUSE FOR A RECALL, WHY IS THE EXACT SAME PROBLEM IN THE AUXILIARY FUEL SENDING UNIT NOT ALSO A CAUSE FOR RECALL?
NHTSA complaint #11309852 — an unverified report by a vehicle owner.
VEHICLE STALLS, IT WILL START UP AGAIN, CAN BE DRIVEN A SHORT DISTANCE BUT STALLS AGAIN THIS HAPPENS WHILE VEHICLE IS IN MOTION HAS HAPPENED ON CITY STREETS AND ON THE HIGHWAY A RECALL IS ASSOCIATED WITH THIS PROBLEM VOLVO RECALL NO.R215 RECALL 09V3433000 COMPONENT: ELECTRICAL SYSTEM SOFTWARE
NHTSA complaint #11302645 — an unverified report by a vehicle owner.
PRIOR TO A 165 MILE ROAD TRIP THE FUEL GAUGE READ 1/4 TANK - 120 MILES TO EMPTY. I FILLED THE TANK TO FULL BEFORE HEADING OUT. AFTER REFUELING, I CLOSED THE GAS CAP BUT FORGOT TO SHUT THE FUEL DOOR. THE FUEL DOOR OPEN ERROR LIGHT CAME ON AND THE FUEL GAUGE STILL READ 1/4 TANK - 120 MILES TO EMPTY. I PULLED TO THE SIDE OF ROAD AND WITH THE VEHICLE RUNNING SHUT THE FUEL DOOR. THE FUEL DOOR OPEN ERROR LIGHT WAS STILL LIT AND THE FUEL GAUGE DID NOT CHANGE. I DROVE TOWARDS HOME ON WINDING MOUNTAIN ROADS IN HIGH SPEED L.A. TRAFFIC. THE INDICATOR READ 50 MILES TO EMPTY AND THE LOW FUEL INDICATOR CAME ON EVEN THOUGH THERE WAS STILL 3/4 OF A TANK OF GAS. AT THE APPROXIMATELY 120 MILE MARK WHILE DRIVING 65 MPH IN 5 LANES OF FAST-MOVING L.A. TRAFFIC THE VEHICLE STOPPED. I WAS ABLE TO SAFELY PULL OVER THROUGH 3 LANES OF TRAFFIC AND STOP SAFELY ON THE FREEWAY SHOULDER. THE VEHICLE FUEL GAUGE INDICATED THE TANK WAS EMPTY AND THE FUEL DOOR OPEN INDICATOR REMAINED ON EVEN THOUGH I HAD CLOSED THE DOOR. THE VEHICLE WOULD NOT RESTART AND I HAD IT TOWED TO THE MECHANIC WHO ROUTINELY SERVICES IT. I AM WAITING TO HEAR THE RESULT OF THE DIAGNOSTIC TESTS. I COULD HAVE BEEN KILLED IF THE VEHICLE HAD STOPPED ON THE WINDING MOUNTAIN ROADS WITH NO SHOULDERS AND NO WAY FOR ME TO SAFELY EXIT THE FREEWAY. AT NO TIME DID ANY OTHER VEHICLE WARNINGS DISPLAY OTHER THAN FUEL DOOR OPEN. I PURCHASED A VOLVO FOR ITS IMPECCABLE SAFETY RECORD. THIS INCIDENT CERTAINLY DOES NOT LIVE UP TO THE STELLAR VOLVO REPUTATION. I HAD NO IDEA THAT DRIVING WITH THE FUEL DOOR OPEN ERROR DISPLAYED COULD RESULT IN THE VEHICLE STOPPING ON THE HIGHWAY EVEN THOUGH THE GAS TANK REALLY WAS 3/4 FULL AND NOT EMPTY AS THE FUEL GAUGE INDICATED. THIS SHOULD DEFINITELY BE RECALLED AND OTHER DRIVERS MADE AWARE OF THE SAFETY ISSUE ASSOCIATED WITH WHAT APPEARS TO BE A MINOR NUISANCE BUT IS A MAJOR SAFETY CONCERN ULTIMATELY.
NHTSA complaint #11194578 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHILE DRIVING 30 MPH, THERE WAS AN ABNORMAL ODOR DETECTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. *BF .. CONSUMER STATED VOLVO HAD A RECALL ON FUEL PUMPS IN SOUTHERN STATES ONLY.
NHTSA complaint #11186885 — an unverified report by a vehicle owner.
STARTED MY CAR IN THE MORNING AND IT SOUNDED NORMAL (IT HAD DRIVEN PERFECTLY NORMAL THE DAY BEFORE). WHEN I TRIED TO BACK OUT OF THE DRIVEWAY, IT HAD NO POWER IN REVERSE AND BARELY CREPT ONTO THE ROAD. WHEN I PUT IT INTO DRIVE, IT HAD NO POWER EITHER-ONLY CRAWLED VERY SLOWLY. WHEN I PUT IT INTO MANUAL DRIVE, IT WENT NORMALLY. BACK INTO AUTOMATIC AND IT WAS CREEPING AGAIN. HAVEN'T TAKEN IT TO A GARAGE YET BECAUSE I DON'T TRUST IT ON THE ROAD NOW.
NHTSA complaint #11173301 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 VOLVO XC70. WHILE DRIVING VARIOUS SPEEDS, A FUEL ODOR WAS DETECTED INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO GOODWIN'S VOLVO (91 MAIN ST, TOPSHAM, ME 04086) WHERE IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 163,459. *TT CONSUMER STATED SMELLED GAS FROM, FROM THE BEGINNING, NOBODY COULD SMELL IT BUT MY DAUGHTER AND I FINALLY CHECKED BY USED CAR DEALER, THEY SAID IT WAS A LOOSE CLAMP, WHICH THEY TIGHTENED, I COULD SMELL IT SO THEY RECOMMENDED A SECOND OPINION TOOK IT TO GOODWINS VOLVO. TOPSHAM COPY OF FINDINDS ENCLOSED WHEN I TOOK IT BACK TO RENO MEADOWS AUTO, THEY SAID IT WAS THE VENT TUBE, THEY REPLACED THE COPY ENCLOSED, SEEMS TO BE OKAY NOW. UPDATED 10/15/18
NHTSA complaint #11109887 — an unverified report by a vehicle owner.
THE FUEL PUMP BEGAN LEAKING FUEL IN HOT WEATHER. IT LEAKS BOTH IF THE CAR IS BEING DRIVEN OR IF IT'S STATIONARY. THERE IS AN EXISTING RECALL THAT SEEMS TO COVER THIS ISSUE. IT IS REFERRED TO AS "RECALL 220" IN VOLVO'S DOCUMENTATION. THE ORIGINAL RECALL LIMITS THE AFFECTED VEHICLES TO ONES WHICH WERE ORIGINALLY PURCHASED IN SPECIFIC U.S. STATES. THIS IS ODDLY ARBITRARY CONSIDERING CARS CAN BE MOVED AROUND AND WARM WEATHER ISN'T EXCLUSIVE TO ANY SPECIFIC LOCATION. I'VE ATTEMPTED TO CONTACT THE MANUFACTURER AND THE NHTSA BUT AM IMMEDIATELY SHUT DOWN DUE TO MY VIN NOT BEING LISTED IN THEIR DATABASE. VOLVO ISSUED DOCUMENTATION TO THEIR SERVICE LOCATIONS ON HOW TO VISUALLY INSPECT A VEHICLE TO DETERMINE IF IT'S AFFECTED. I PERFORMED THOSE STEPS AND BELIEVE MY VEHICLE FITS THE GUIDELINES FOR THE RECALL.
NHTSA complaint #11105281 — an unverified report by a vehicle owner.
TL* THE CONTACT OWNS A 2004 VOLVO XC70. THE CONTACT STATED THAT THE VEHICLE FAILED TO START AND A STRONG FUEL ODOR WAS PRESENT. THE CONTACT STATED THAT THE FAILURE OCCURRED FOR APPROXIMATELY SIX MONTHS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE) BECAUSE IT WAS REGISTERED IN THE PARTICIPATING STATES PER THE RECALL INFORMATION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.
NHTSA complaint #11101796 — an unverified report by a vehicle owner.