Chevrolet Trax suspension problems

SUSPENSION

At 38,000 miles the right sway bar stabilizer linker failed and required replacement. This was inspected by a manufacturer associated dealer mechanic. No other symptoms or warning lamps prior to the failure.

NHTSA complaint #11754906 — an unverified report by a vehicle owner.

SUSPENSION

There are known issues with the control arms on these vehicles and I have had a clunk any time I hit the slightest bump or crack and it is especially bad when my wheels are turned. There is no recall linked to my vin but this is the exact issue that has been recalled on other vins. This makes driving the car with my children very unsafe.

NHTSA complaint #11745169 — an unverified report by a vehicle owner.

SUSPENSION

Both my control arms are loose and wheel baring is bad, plus a cracked catalytic converter. All of these are causing my car to be loud and burning smell, causing unsafe driving conditions for me and my children. Online states that the control arms are an issue with this vehicle make and model and have been recalled, however my VIN has not been recalled and I want to report this. improperly welded joints can fatigue and break, causing the lower control arm to partially separate from the vehicle. This can lead to a sudden loss of steering control and increase the risk of a crash. I have not gotten in an accident, but was at risk of this happening. My car is being worked on and it will cost me $800 for these repairs for the issues related to the 2018 Chevy traxs. I would like this VIN to be recalled and receive a refund for the work done to my vehicle.

NHTSA complaint #11741821 — an unverified report by a vehicle owner.

SUSPENSION

My lower control arm weld has cracked. It was checked shortly after purchase and passed inspection at the Chevy garage in Elkins, WV. Now the weld is cracked on both driver and passenger sides and it making a clunking sound. I do not feel safe to drive this vehicle. This problem should of been fixed when the recall came out, they should of replaced with new parts. My husband Inspected the problem and found the cracks. I took photos to document it. We found the problem on [XXX] but has been clunking for over a month INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11739885 — an unverified report by a vehicle owner.

SUSPENSION

The vehicle was brought to an authorized GM dealership for a scheduled appointment to address a check engine condition related to a purge valve and an open safety recall for the lower control arm. The VIN was provided and confirmed at the time the appointment was made; however, the recall was not completed during the visit. The dealership replaced the purge valve without documenting diagnostic testing to confirm the cause or verify the repair. The vehicle was returned with the same check engine light still present. Additional issues were communicated through technician video and text, including a potential oil leak and possible fluid mixing, but none were documented or diagnosed in the service record. A dealership manager later stated that the vehicle was “not safe to drive,” but no written explanation or safety guidance was provided, and the vehicle was released without clarification. No diagnostic records, technician notes, or findings have been provided by either the dealership or GM despite escalation. The consumer has worked through appropriate dealership and manufacturer channels for approximately one month without resolution. The consumer is now being directed to return the vehicle for additional diagnostics at the consumer’s expense without defined scope or explanation. The vehicle remains with an unresolved condition and an open safety recall, without clear guidance regarding safe operation. This lack of clear, documented information is particularly concerning for senior-aged owners who rely on accurate guidance to make safe decisions.

NHTSA complaint #11739353 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2016 Chevrolet Trax. The contact stated that while driving out of the driveway, there was a loud snapping sound coming from the vehicle. The contact stated that while attempting to drive back to the residence, the steering wheel became inoperable. Additionally, there was a grinding sound coming from the rear passenger’s side of the vehicle. The failure persisted, and the vehicle was towed. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer referred the contact to the manufacturer for further assistance. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 115,000.

NHTSA complaint #11731667 — an unverified report by a vehicle owner.

SUSPENSION

Repeatedly disply reduce engine warning, , stabiliTrak / traction warnings, loss of power while driving, and dashing board goes dark.

NHTSA complaint #11705494 — an unverified report by a vehicle owner.

SUSPENSION

My radio turns up and changes by itself . It’s leaking oil an I’ve replaced everything a can’t figure it out , if anything it’s the engine it just won’t make sense . I dumped so much money into it already

NHTSA complaint #11694367 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2020 Chevrolet Trax. The contact stated that while driving and making turns, the steering wheel had to be turned to the intended direction completely for the vehicle to turn as needed. The contact also stated that while driving and depressing the brake pedal to come to a complete stop, the vehicle failed to respond as intended, causing the braking distance to be extended. The vehicle was taken to the dealer, where it was diagnosed that the front passenger's side lower control arm had failed due to defective factory assembly. The dealer replaced the lower control arm, and the vehicle was repaired. Additionally, the contact stated that the A/C system was inoperable, and the infotainment system screen was significantly hot and turned off intermittently while driving. The vehicle was taken to an independent mechanic, where the A/C system motor was replaced; however, the failure persisted. The contact was advised that the A/C system motor was not the cause of the failure, and the contact was referred to the dealer for diagnostic testing. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 60,000.

NHTSA complaint #11685876 — an unverified report by a vehicle owner.

SUSPENSION

It’s either my ball joints or the suspension or the arms. But they have a recall of the same exact issues I’m having but my car isnt part of the recalled list. But I am having the same issues and I’m at 109k miles. And i wasn’t in an accident. It actually started happening after I had my car in the shop to replace my turbo. Since ive gotten it back it sounds and drives horribly and from what I’m hearing its my ball joints or suspension or arms to that.

NHTSA complaint #11644417 — an unverified report by a vehicle owner.

SUSPENSION

The service stabilitrak and service powersteering will come up. Have had vehicle hooked up to computer multiple times no codes. The vehicle would not drive. The vehicle has started shaking. The engine light comes on. There is 30k miles on the vehicle. I bought this 3 months ago to have a safe vehicle. My spouse and I are disabled and we do not feel secure. I googled and it says probably a computer error from factory. I'd appreciate if I can get my vehicle recalled & fixed. Thank you

NHTSA complaint #11616885 — an unverified report by a vehicle owner.

SUSPENSION

I was driving between 35 and 45 mph and ran over a manhole cover. The rear of my vehicle began to fishtail. I pulled into a gas station and upon attempting to leave my vehicle failed to drive forward. The car was still on but would not move forward. I had it towed by flatbed to the local chevy dealership where it was determined that the rear suspension swing bar has separated at the weld. If I were traveling at a higher rate of speed on the highway this could have been deadly. The current recall for this problem only mentions the front control arm but for the same issue. My car has been inspected by my insurance and the incident does not match the damage and I'm fighting to not have my vehicle considered totalled. There were no other warning signs or issues prior to this.

NHTSA complaint #11582649 — an unverified report by a vehicle owner.

SUSPENSION

I'm contacting nhtsa to make a recall request on chevys 2020 trax . less than 3 years old and has 23,300 miles , the chevy trax needed both control arms, both side tie rod ends , 2 alignments. I'm going to say to nhtsa I think chevy didn't manufacture the 2020 trax with strong enough front suspension and steering parts. What component or system failed or malfunctioned, and is it available for inspection upon request? The both front bottom control arms . I asked the ourisman dealership to give them to me after the repair was paid they didn't give . and the ourisman dealership said it was only one bad inner tie rod end but both where bad . I had the tie rod ends replaced at independent service center and they kept and gave me the old bad tie rod ends. How was your safety or the safety of others put at risk? If these parts broke off during driving would be a deadly crash of multiple vehicles especially on a interstate. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes by to ourisman dealerships and one independent service center. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? by the chevy dealerships but they didn't give me the parts after the repair but I did ask for the parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, didn't

NHTSA complaint #11571662 — an unverified report by a vehicle owner.

SUSPENSION

The steering of the vehicle is very tight and it doesn't spring back when turning the wheel on its own like most vehicles do . you have to manually bring your steering wheel back for the wheels to turn straight again..and this isn't normal by any means ... Also, The turbocharger in my vehicle isnt working correctly and is causing my check engine light to be on even after engine codes have issues have been repaired. I've changed air filters.. I've changed mass air flow sensors.. I've changed the intake manifold and the engine light comes back on after accelerating.. The engine code that keeps coming back on and returning is p0299.. this is an issue with the turbo boost.. And this is also something that has been recalled for other model Chevy lf the Chevy Trax.. my vehicle issues are recalls that are being done on other Chevy Trax but they're not being recalled for my model of the Chevy Trax as obvious that these recall issues pertain to my vehicle as well.. I know there are recalls on the Chevy Trax which are having these exact issues except my car isn't listed on the recall list.. and without a doubt it should be because these issues I'm having go hand and hand with other Chevy Trax models that are receiving recalls for these exact same issues

NHTSA complaint #11561648 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2015 Chevrolet Trax. The contact stated that upon entering the vehicle, the vehicle failed to emit an audible chime, indicating that the seat belts had not been fastened. While driving at an undisclosed speed, the contact heard an abnormal clicking sound coming from the front end of the vehicle. The check engine warning light was illuminated. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was then taken to an independent mechanic, who diagnosed a failure with the passenger’s side upper control arm. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V652000 (Suspension) and NHTSA Campaign Number: 16V422000 (Electrical System, Equipment) however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 94,000.

NHTSA complaint #11558804 — an unverified report by a vehicle owner.

SUSPENSION

I purchased this 2017 Chevrolet Trax in Dec 2020 with 36748 miles on it. In I believe 2022 I had to have the front driver side tire rode replaced as it was broken at just a little over 50,000 miles on it. Now at 73,027 miles I had to have both sway bars links replaced as they both were broken as well. Upon further inspection from dealership the also found the left front suspension strut needs replacing. I heard noises from front end when turning with popping and creaking as turning. Now after replacing sway bars I have more popping and creaking coming from front end but not just when turning now it's most of the time now and the steering is pulling at different times. It does not feel safe to drive this vehicle anymore. No light came on dash to warn of any issues at all. I have paid for most repairs on the vehicle, but these Costs are adding up more and more.

NHTSA complaint #11544360 — an unverified report by a vehicle owner.

SUSPENSION

Maher Chevrolet of St. Petersburg FL is refusing to fix a recalled item. They fixed the left control arm under warrantee in 2019. I brought it back the next day still hearing a noise and they said only the right side was bad and I was hearing a seat noise. I took their word for it although the noise never went away. Now 3 1/2 years and 10k miles later Tire Kingdom noticed that the left control arm was coming apart and was a safety problem. Maher said since they did one side the other side is no longer covered under warrantee and the would have to charge to fix it and wanted $150 just for a tech to look at it and tell me if that was the problem. Tire Kingdom couldn't help seeing the problem doing an oil change and gave me the info about the recall to contact Chevrolet about. My car has been sitting in my driveway for 2 weeks now waiting to see if a new or special recall can be issued. Mileage now is just under 20k. Next step will be the local news channel.

NHTSA complaint #11517745 — an unverified report by a vehicle owner.

SUSPENSION

The contact owns a 2018 Chevrolet Trax. The contact stated that while the vehicle was receiving an oil change, the contact was informed that the suspension was fracturing and detaching and needed to be replaced. The contact was also informed that the rear seat pivot lock failed, and the passenger’s side control arm needed to be replaced. The vehicle had not been repaired. The contact stated that there was a knocking sound while turning. The contact stated that there was grinding sound coming from the vehicle while accelerating. The manufacturer was made aware of the failure and that the driver’s side control arm was repaired under NHTSA Campaign Number: 19V652000 (Suspension) after an inspection. The approximate failure mileage is 10,153. The contact stated that the left side had been replaced a while back under the recall. They were unaware that both sides were supposed to get fixed. The right side now needs to be replaced but the dealership will not perform the repair because the recall is now closed. The contact stated that the dealer finally agreed to inspect the vehicle and now the noise no longer exists due to a loose bolt.

NHTSA complaint #11514142 — an unverified report by a vehicle owner.