1996 Dodge RAM 3500 problems

AIR BAGS

DASH IS ALL CRACKED UP ALLOWING SHARP PLASTIC PROJECTILES IN AND ABOUT THE CAB THAT CAN CUT YOU IN A WRECK SUN GETTING ON ELECTRICAL WIRES DESTROYING THEM AND NOW SHORTS AND SOMETIMES DONT WORK RIGHT

NHTSA complaint #11233910 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DASH IS ALL CRACKED UP ALLOWING SHARP PLASTIC PROJECTILES IN AND ABOUT THE CAB THAT CAN CUT YOU IN A WRECK SUN GETTING ON ELECTRICAL WIRES DESTROYING THEM AND NOW SHORTS AND SOMETIMES DONT WORK RIGHT

NHTSA complaint #11233910 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

DASH IS ALL CRACKED UP ALLOWING SHARP PLASTIC PROJECTILES IN AND ABOUT THE CAB THAT CAN CUT YOU IN A WRECK SUN GETTING ON ELECTRICAL WIRES DESTROYING THEM AND NOW SHORTS AND SOMETIMES DONT WORK RIGHT

NHTSA complaint #11233910 — an unverified report by a vehicle owner.

TIRES

1996 DODGE RAM 3500. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE TREAD SHREDS OFF CASING AND CAUSES SEVERE DAMAGE TO VEHICLE UNDERCARRIAGE. *SMD

NHTSA complaint #10914573 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

"TAKATA RECALL" THE DASH ON MY TRUCK IS ALL CRACKED UP AND I TAKE VERY GOOD CARE OF MY TRUCK. IO CAME ACROSS AN ARTICLE ABOUT THE DODGE DASH'S I WENT RIGHT OUT SIDE AND PULLED MY DASH COVER BACK AND TOOK A LOOK AND TO MY SURPRISE MY DASH IS ALL CRACKED UP IN MANY PIECE'S . AND I HAVE HAD IT COVERED SINCE NEW...I DO FEEL THAT DODGE SHOULD BE HELD REASONABLE FOR THIS , LOOKS LIKE THEY USED CHEAP PLASTIC ON THESE, I CAN SEE IT NOW IF I WAS TO HAVE A WREAK PLASTICS PIECES FLYING ALL OVER THE PLACE.

NHTSA complaint #11022149 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

HEAT CAUSED THE DASH TO DRY OUT AND CRACK INTO LARGE JAGGED PIECES, THAT COULD HAVE FATAL CONSEQUENCES IF IN ANY TYPE OF ACCIDENT.

NHTSA complaint #11002913 — an unverified report by a vehicle owner.

STRUCTURE

DASH FALLING APART DODGE DOES NOT HAVE REPLACEMENT/CANNOT FIND REPLACMENT.

NHTSA complaint #10712994 — an unverified report by a vehicle owner.

STEERING

STEERING WOBBLES/SHAKES VIOLENTLY WHEN DRIVING. OFTEN INITIATED BY A MINOR IRREGULARITY IN ROAD PAVEMENT. REQUIRES COMING TO A FULL STOP TO ELIMINATE THE WOBBLE. RECURS OFTEN. DIFFICULT TO EXCEED 30MPH IN ORDER TO AVOID SHAKING. NO NOTICEABLY BAD OR BROKEN SUSPENSION PARTS.

NHTSA complaint #10501390 — an unverified report by a vehicle owner.

SUSPENSION

STEERING WOBBLES/SHAKES VIOLENTLY WHEN DRIVING. OFTEN INITIATED BY A MINOR IRREGULARITY IN ROAD PAVEMENT. REQUIRES COMING TO A FULL STOP TO ELIMINATE THE WOBBLE. RECURS OFTEN. DIFFICULT TO EXCEED 30MPH IN ORDER TO AVOID SHAKING. NO NOTICEABLY BAD OR BROKEN SUSPENSION PARTS.

NHTSA complaint #10501390 — an unverified report by a vehicle owner.

STEERING

TL* THE CONTACT OWNS A 1996 DODGE RAM 3500. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE VIGOROUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHERE THE MECHANIC PERFORMED REPAIRS TO THE STEERING ASSEMBLY. THE CONTACT WAS UNAWARE OF THE EXACT REPAIRS PERFORMED. APPROXIMATELY TWO YEARS AFTER THE REPAIR, THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

NHTSA complaint #10441012 — an unverified report by a vehicle owner.

STEERING

1996 DODGE 3500 4X4 DUALLY HAS A FRONT END SHAKE AT ANY SPEED HAVE PUT NEW BALLJOINTS IN PUT A NEW TRACK BAR IN THAN PUT A DOUBLE FRONT STEERING STABILIZER ON AND THE TRUCK STILL SHAKES AFTER IT DOES IT ONCE AND YOU HAVE TO TRY AND GET OUT OF HIGHWAY TRAFFIC AND STOP IT WILL JUST RANDOMLY KEEP DOING IT BUMP OR NOT JUST A ROUGH ROAD.

NHTSA complaint #10399485 — an unverified report by a vehicle owner.

TIRES

ON MARCH 26TH 2011 WHILE TRAVELING WESTBOUND ON I 76 IN COLORADO OUR DRIVERSIDE FRONT TIRE BLEW OUT. THE TIRE WAS A TEMPRA TRAIL CUTTER RADIAL RT LT 255/85R16. AFTER A LOUD SHOTGUN TYPE NOISE, OUR VEHICLE WENT OUT OF CONTROL. WE REGAINED CONTROL AND BROUGHT THE VEHICLE TO THE SIDE OF THE INTERSTATE AND STOPPED. WE CONTACTED COOPER TIRE WHO MANUFACTURES THIS BRAND ON 03/29/2011 AND WE WERE TOLD THAT THIS TIRE WAS NOT CURRENTLY UNDER RECALL.

NHTSA complaint #10393082 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

BRAKE FAILURE, DUE TO BRAKE LINE TO REAR WHEELS RUSTED OUT IN FRAME CLIP BEHIND FUEL TANK.

NHTSA complaint #10355895 — an unverified report by a vehicle owner.

TIRES

TL*THE CONTACT OWNS A 1996 DODGE RAM 3500 EQUIPPED WITH GENERAL TIRE HIGHWAY SCOUT (NA) TIRES. THE CONTACT STATED THAT HE MADE SEVERAL ATTEMPTS TO LOCATE THE TIRE MANUFACTURER AND WAS UNSUCCESSFUL. THE TIRE SIZE WAS 215/85R16 AND THE DOT NUMBER ADOP1LD1204 WERE LISTED ON THE HIGHWAY SCOUT TIRES. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH, WHEN BOTH REAR TIRES BLEW OUT AND THE TREAD SEPARATED. THE FAILURE CAUSED DAMAGE TO THE REAR FENDER. THE FAILURE OCCURRED TWICE; SIX TIRES BLEW OUT AND THE TREAD SEPARATED WITHIN THREE MONTHS. THERE WAS ONLY A QUARTER INCH OF TREAD DEPTH REMAINING ON THE TIRES. THE CONTACT CALLED THE TIRE MANUFACTURER BUT DISCOVERED THAT THEY WERE NO LONGER IN BUSINESS. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE ON THE TIRES WAS APPROXIMATELY 18,000.

NHTSA complaint #10327519 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:HEADLIGHTS

TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP FOR A THROTTLE CABLE REPAIR MARCH 2010 BUT THE DEALER ONLY REPLACED THE THROTTLE CABLE AND NO OTHER REQUIRED PARTS THAT WOULD KEEP THE CABLE FROM FAILING. AS A RESULT, THE CABLE BECAME LOOSE TWICE AFTER THE REPAIR WHILE THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP. THE DEALER REPLACED THE FAILED THROTTLE TWICE. THE CONTACT THEN TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AS THE DEALER WAS NOT ABLE TO CORRECT THE PROBLEM. THE MECHANIC AT THE REPAIR SHOP INFORMED HER THAT THE FAILURE WAS CAUSED BY THE THROTTLE ROD BALL, THE BALL STUD, THROTTLE CABLE STUD, THE THROTTLE ROD THREAD (LEFT AND RIGHT) AND THE THROTTLE RETURN SPRING. IN ADDITION TO THE THROTTLE FAILURE, CONTACT STATED THAT THE HEADLIGHT REPAIR PERFORMED JUNE 2009 DID NOT CORRECT THE PROBLEM; THE HEADLIGHT PLASTIC AND SWITCH MELTED EVEN AFTER THE REPAIR. SHE CALLED THE MANUFACTURER AND FILED A COMPLAINT; THE MANUFACTURER EXPLAINED THAT THE THROTTLE FAILURE WAS NOT DUE TO A MANUFACTURERS DEFECT BUT INSTEAD TO THE DEALERS POOR WORKMANSHIP. THE FAILURE MILEAGE WAS APPROXIMATELY 221,010. THE CURRENT MILEAGE WAS 221,061.

NHTSA complaint #10323521 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP FOR A THROTTLE CABLE REPAIR MARCH 2010 BUT THE DEALER ONLY REPLACED THE THROTTLE CABLE AND NO OTHER REQUIRED PARTS THAT WOULD KEEP THE CABLE FROM FAILING. AS A RESULT, THE CABLE BECAME LOOSE TWICE AFTER THE REPAIR WHILE THE CONTACT WAS DRIVING AT APPROXIMATELY 35 MPH. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP. THE DEALER REPLACED THE FAILED THROTTLE TWICE. THE CONTACT THEN TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AS THE DEALER WAS NOT ABLE TO CORRECT THE PROBLEM. THE MECHANIC AT THE REPAIR SHOP INFORMED HER THAT THE FAILURE WAS CAUSED BY THE THROTTLE ROD BALL, THE BALL STUD, THROTTLE CABLE STUD, THE THROTTLE ROD THREAD (LEFT AND RIGHT) AND THE THROTTLE RETURN SPRING. IN ADDITION TO THE THROTTLE FAILURE, CONTACT STATED THAT THE HEADLIGHT REPAIR PERFORMED JUNE 2009 DID NOT CORRECT THE PROBLEM; THE HEADLIGHT PLASTIC AND SWITCH MELTED EVEN AFTER THE REPAIR. SHE CALLED THE MANUFACTURER AND FILED A COMPLAINT; THE MANUFACTURER EXPLAINED THAT THE THROTTLE FAILURE WAS NOT DUE TO A MANUFACTURERS DEFECT BUT INSTEAD TO THE DEALERS POOR WORKMANSHIP. THE FAILURE MILEAGE WAS APPROXIMATELY 221,010. THE CURRENT MILEAGE WAS 221,061.

NHTSA complaint #10323521 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

LOW BEAM HEADLIGHT FAILURE---CHECKED ON LINE FOUND RECALL # 819---WENT TO CHRYSLER DEALER---WAS ADVISED THAT THE RECALL HAD BEEN DONE ON THAT VIN# AND CHRYSLER HAD NO OBLIGATION---I PULLED THE HEADLIGHT SWITCH AND FOUND THAT IT WAS DAMAGED, THE CONNECTOR MELTED AND NO RELAY PACK SPECIFIED IN THE RECALL FIX-----IT WAS APPEARS THE RECALL WAS PENCIL WHIPPED AND THE REPAIR WAS NEVER MADE------HOW DO YOU INSURE THAT RECALLS ARE REALLY DONE AND HOW MANY MORE LIKE MINE ARE OUT THERE????????

NHTSA complaint #10315963 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC

TL*THE CONTACT OWNS A 1996 DODGE RAM 3500. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE SLOWED DOWN AFTER SEVERAL ATTEMPTS. THE BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS DRIVEN ONTO THE SIDE OF THE ROAD AND TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE WAS RELATED TO RUST IN THE BRAKE LINE SYSTEM. THE FAILURE OCCURRED ON TWO SEPARATE OCCASIONS. THE VEHICLE HAS NOT BEEN REPAIRED; HOWEVER,THE CONTACT WILL PERFORM THE REPAIR HIMSELF. THE FAILURE MILEAGE WAS 103,753 AND CURRENT MILEAGE WAS 104,000.

NHTSA complaint #10235147 — an unverified report by a vehicle owner.

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

TL*THE CONTACT OWNS A 1996 DODGE 3500. THE CONTACT STATED THAT THE ABS ADAPTIVE BRAKE CONTROL UNIT (PART NUMBER 56029032AB) HAS BEEN DISCONTINUED BY THE MANUFACTURER. HE STATED THAT THE PART WAS NEEDED TO REPAIR HIS VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 211,000.

NHTSA complaint #10198996 — an unverified report by a vehicle owner.