28 of the
1,361 complaints filed about the Ford E-350
are about the other systems —
2% of everything owners reported.
The worst model year for it is 2008.
I was driving on 14-W from Vancouver, WA toward I-5S. 60 mph. 60 degrees, light rain. My front moonroof unexpectedly exploded for no reason. I was not driving under an overpass, so I was not hit my a fallen object. The truck is under 4 months old, with no previous damage or incidents.
NHTSA complaint #11697769 — an unverified report by a vehicle owner.
To whom it may concern, i recently purchased a 2003 ford econoline e150 vin# [XXX] . from a private party in the state of michigan, im am being refused insurance because the van is coming up as incomplete , the van was sent and finished by Elk automotive Inc , on [XXX] MPV [XXX] they company that manufactured it ,gave it the same vin # [XXX] with completion date as [XXX] the identification sticker from Elk automotive is on the door jam and has been dot approved, i have the michigan title in my name , it says nothing about incomplete on title, but NHTSA website keeps popping up incomplete and my insurance provider wont insure it please contact me or help please. my name is [XXX] , [XXX] or by phone is [XXX] or, my email is : [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11642121 — an unverified report by a vehicle owner.
The vehicle was very difficult to keep on the road. It wanted to go all over the road. It was a struggle to keep it in the lane. We took the RV back to the dealer we bought it from & they told us they didn't work on that & to find a Ford dealer that would work on it. After many phone calls I found a Ford dealer that would work on it. They told us nothing was wrong with the steering. It was engineered badly. They said the back end was too heavy & was making the front end light & "squirrely" & difficult to steer. They said it needed heavier suspension on the back end. They suggested heavier springs or installing suspension air bags. The other problem was the dash board lights started flashing off & on. Most of the time the dashboard lights were off. We could only see the speedometer, gas gauge & other gauges when the lights flashed on. But we didn't know if they were accurate when they were on. At one point we smelled wires burning & then the cruise control went out. The electrical problems started 07/19/2021.
NHTSA complaint #11427787 — an unverified report by a vehicle owner.
We have a 2015 Coachmen Freelander 21R RV (with a Ford F-350). Recently, while driving on the freeway a car near us kicked up some debris. This went under the RV and within 30-60 seconds after we heard a loud explosion/boom. My husband immediately pulled over and we were thinking it was blown front tire but just as he pulled over we noticed a large cloud of white "smoke." The "smoke" turned out to be propane coming from our propane tank. Later he crawled under the RV and found a large hole in the tank. It appears that whatever hit it was hard enough to create a large hole in it and therefore causing the explosion. Fortunately, that was the only damage and no injuries were sustained. The reason for my email is that we were very surprised to see that there was no protective cage/rock guard around the propane tank to keep debris from damaging the tank. I personally think it's a design flaw and that any propane tank accessible from the side and but located under the RV should have some sort of protection around it. If that "cage" had existed, we wouldn't have experienced such a close call with a fire and possibly more. Thank you for your consideration.
NHTSA complaint #11426157 — an unverified report by a vehicle owner.
MAY 3, 2019 NHTSA CAMPAIGN NUMBER: 19V342000 BRAKE LIGHT MAY RANDOMLY ILLUMINATE IF THE BRAKE LIGHTS INCORRECTLY ILLUMINATE, IT CAN CONFUSE OTHER DRIVERS, POSSIBLY INCREASING THE RISK OF A CRASH. NHTSA CAMPAIGN NUMBER: 19V342 MANUFACTURER TAYLOR MADE AMBULANCES COMPONENTS EXTERIOR LIGHTING POTENTIAL NUMBER OF UNITS AFFECTED 17 SUMMARY TAYLOR MADE AMBULANCES IS RECALLING CERTAIN 2017-2018 FORD E-350, F-450, E-450, F-550, AND GMC G3500-BASED AMBULANCES EQUIPPED WITH WHELEN BRAKE LIGHTS. DEPENDING ON THE SPECIFIC WIRING OF THE VEHICLE, THESE BRAKE LIGHTS MAY ILLUMINATE WHEN THE BRAKE PEDAL HAS NOT BEEN PRESSED. REMEDY TAYLOR MADE WILL NOTIFY OWNERS AND WHELEN WILL REPLACE THE BRAKE LIGHTS, FREE OF CHARGE. THE RECALL BEGAN JUNE 5, 2019. OWNERS MAY CONTACT TAYLOR MADE AMBULANCES CUSTOMER SERVICE AT 1-800-468-1310. COMPANY CLOSED, UNABLE TO DRIVE OUR AMBULANCE
NHTSA complaint #11339999 — an unverified report by a vehicle owner.
DRIVING DOWN THE ROAD, STARTED SMELLING GAS, SO I PULLED OVER THE CHECK WHY I SMELLED GAS AND AS SOON ASI OPENS THE HOOD, THE VAN BURST INTO FLAMES FROM UNDER THE HOOD. IT FULLY ENGULFED THE VAN IN ABOUT 3 TO 4 MINUTES AND IS A TOTAL LOSS. THIS HAPPENED ON THE HIGHWAY AND HAD ONLY BEEN DRIVING FOR 15 MINUTES. UNKNOWN WHAT ACTUALLY CAUSED THE FIRE.
NHTSA complaint #11129699 — an unverified report by a vehicle owner.
THIS 350 ECONOLINE, 8CYL., EXTENDED BODY VAN WAS PURCHASED NEW, AND I AM THE ORIGINAL OWNER. THE VEHICLE HAS ONLY 120K MILES ON IT SINCE 2002. BEGINNING SEVERAL YEARS AGO, MY MECHANIC COMPLAINED OF SEVERE FRAME EROSION, HAVING HAD TO REINFORCE AND RE-WELD SEVERAL PARTS BACK ONTO THE FRAME, INCLUDING BUT NOT LIMITED TO THE BRACKETS WHICH SUPPORT THE REAR LEAF SPRINGS. (TWO OCURRANCES-- LEFT AND RIGHT SIDES). LAST WEEK, MY EMPLOYEE COMPLAINED OF SOME REAR END SWAYING AT MODERATE SPEED CORNERING. WE DISCOVERED A CROSS-TIE CONNECTION BETWEEN THE SIDE RAILS AT THE REAR OF THE VEHICLE'S FRAME HAD ROTTED AWAY, THUS CAUSING SOME UNWANTED FRAME MOVEMENT. IF IT WEREN'T FOR A HEAVY-DUTY TOWING PACKAGE I HAD PURCHASED WITH THE VEHICLE IN 2002, I BELIEVE THE LEFT AND RIGHT SIDES OF THE VEHICLE'S UNDER-FRAMING WOULD HAVE TWISTED AND SEPARATED FROM THE BODY YEARS AGO ! ALSO BEGINNING A FEW YEARS AGO, WAS THE DECAY OF THE VEHICLE'S ENGINE BLOCK, AS THREE SEPARATELY TIMED SPARK PLUGS HAD LITERATELY 'BLOWN' OUT OF THE THREADED WELLS OF THE ENGINE BLOCK. MY MECHANIC HAD TO ADAPT HELI-COIL KITS INTO RE-BORED HOLES IN THE VEHICLE'S SPARK PLUG WELLS. IT'S ONLY A MATTER OF TIME BEFORE THESE KITS COME LOOSE, AND BLOW -OUT AGAIN. I'M ALREADY EXPERIENCING A PAINFULLY OMINOUS COMPRESSION LOSS IN ONE (OR MORE) OF THE CYLINDERS. COULD FORD HAVE PURCHASED SOME INFERIOR METALS, THUS PRODUCING A LINE OF JUNK VEHICLES?
NHTSA complaint #11029878 — an unverified report by a vehicle owner.
THIS CAR BASSED FOR LAST 2 SMOG CHECKS AND STILL THE LIGHT FOR CHECK ENGINE ON ? AND I HAVE VIDEO FOR THAT. / PLUS THE LAST INSPECTION 03/02/2017 IN CARFAX I SEE SOMETHING WRONG ( I SEE THAT IT WAS A RENTAL VEHICLE SO 81,963 MILES IN A LITTLE OVER TWO YEARS IS NOT UNCOMMON. WE ARE ALSO SHOWING THAT ON 7/13/2012 THE VEHICLE WAS SERVICED AND AT THAT TIME THE ODOMETER READING WAS RECORDED AS 153,548 MILES. CA DMV REPORTED THAT THIS VEHICLE HAD 155,061 MILES ON 8/6/2012. BOTH THESE ODOMETER READINGS ARE HIGHER THAN 98,384 MILES AND THEY BOTH COME FROM DIFFERENT SOURCES. THEREFORE IT APPEARS THAT THE 3/2/2017 ODOMETER READING OF 98,384 MILES IS IN ERROR
NHTSA complaint #10994065 — an unverified report by a vehicle owner.
UNIROYAL LAREDO LT 245/75R16 LRE - DOT BE11 JDUU 0812 NHTSA RECALL NUMBER 12T-019 HTTP://WWW.UNIROYALTIRES.COM/ASSETS/PDF/TIRE_OWNER_LETTER.PDF THIS SET OF TIRES WAS INSTALLED ON A VEHICLE WHICH I PURCHASED FROM A USED VAN/TRUCK DEALER. SINCE BUYING THE VEHICLE 2 YEARS AGO, I HAVE DRIVEN 13,000 MILES ON THE TIRES, AND THERE ARE STILL 12/32" TREAD DEPTH, EVEN ACROSS THE TREAD ON ALL 4 TIRES. I HAD THE TIRES INSPECTED BEFORE A TRIP, AND I WAS ADVISED TO REPLACE THE TIRES DUE TO EXCESSIVE WEATHER CHECKING / CRACKING. THAT IS WHEN I DID AN INTERNET SEARCH AND FOUND THE ABOVE CITED RECALL. EVIDENTLY THE TIRES RECALLED WERE LIMITED TO THE 3RD WEEK OF 2012, AND MY TIRES WERE MANUFACTURED IN THE 8TH WEEK OF 2012. UNIROYAL/MICHELIN HAS REFUSED TO REPLACE THE DEFECTIVE TIRES. I NEED HELP. PLEASE SEE THE PHOTOS. THERE IS NO WAY THAT I COULD TAKE A TRIP WITH MY FAMILY IN THE VAN, WITH THESE AWEFUL DEFECTIVE TIRES ON THE ROAD.
NHTSA complaint #10887865 — an unverified report by a vehicle owner.
THIS IS A 2009 PLEASURE WAY EXCEL TS MOTOR HOME, BUILT BY PLEASURE WAY INDUSTRIES IN CANADA. THIS MOTOR HOME CAME WITH HANKOOK, DYNAPRO AS TIRES , SO FAR I HAVE HAD 3 OF THESE TIRES BLOW UP ON ME TRAVELING AT ABOUT 60 MPH, AND 2 MORE BUBBLING UP ON THE SIDE AND INSIDE, BUT THEY DID NOT BLOW SINCE I NOTICED IT AND INSTALL THE SPARE, ONE OF THIS LAST TWO THE BUBBLING WAS FOUND WHEN I REPLACED ALL FOUR TIRES WITH NEW MICHELIN. THE 1ST 3 TIRES WERE REPLACED ON A PRORATED ORDER, I HAVING TO PAY FOR BALANCING AND MOUNTING. THE FIRST 3 TIRES WERE REPLACED WITH DYNAPRO HT TIRES WHICH 2 OF THEM FAILED THE SAME WAY. (THE SIDE WALL BUBBLES INSIDE AND OUT UNTIL IT BLOWS UP. THE LAST TWO TIRES HAVE NOT BEEN APPROVED FOR REPLACEMENT BY HANKOOK BECAUSE THEY WANT TO VISUALLY INSPECT THEM SO THE TIRES ARE HAVING TO BE SENT TO THEM BY THE SEARS AUTO CENTER IN CORAL GABLES, FLORIDA. IN THE MEAN TIME I HAVE INSTALLED MICHELIN TIRES, DO NOT TRUST HANKOOK WHAT SO EVER. I HAVE PHOTOS, INVOICES, MILEAGE WHEN ALL THESE TIRES FAILED, WHICH DEPENDING ON THE OUTCOME OF THIS COMPLAIN I CAN SEND THEM TO YOU SINCE YOU A LIMIT TO UPLOAD THESE ITEMS. I BELIEVE THERE IS A SAFETY PROBLEMS WITH THESE TIRE AS TO BE OVERRATED OR SOMETHING, EVEN THOUGH ONE OF THE TIRES WAS ON THE FRONT ON THE VEHICLE, AND NOT SUBJECT TO WEIGHT OR PRESSURE SINCE IT HAD 55 LBS OF AIR PRESSURE AND THEY ARE RATED TO 80 LBS. IN MY SAFETY CONCERN HAD ANY ON THIS TIRES WOULD OF HAVE BLOWN ON THE FRONT, I WOULD PROBABLY NOT BE WRITING THIS COMPLAIN, AND GOD ONLY KNOWS WHAT ELSE COULD OF HAPPENED. ALL THESE TIRES HAVE FAILED FROM 05/23/2012 TO 04/19/2016 AND MILEAGE FROM 9690 TO 17323 MILES. PICTURED INCLUDED ARE ONLY FOR THE 09/16/2015 INCIDENT ONLY, I HAVE OTHERS IF NEEDED INCLUDING INVOICES.
NHTSA complaint #10861689 — an unverified report by a vehicle owner.
WHILE DRIVING THE VEHICLE THE SPARE TIRE BROKE OFF THE UNDERSIDE OF THE VEHICLE AND LANDEDON THE ROAD. THERE WAS A VEHICLE BEHIND US AND WAS ABLE TO AVOID THE TIRE.. THE BOLT HOLDING THE TIRE IN PLACE SHEARED OFF. THE VEHICLE IS ONLY ONE YEAR OLD AND RUST WAS NOT A FACTOR AS UPON FURTHER INSPECTOIN THE BOLD IN QUESTION STILL IS HAS HALF OF IT IN THE BRACKET A NON METAL BOLT AS IT IS WHITE IN APPEARANCE.
NHTSA complaint #10785490 — an unverified report by a vehicle owner.
WHILE STOPPED AT A THRUWAY REST AREA IN W. VIRGINIA. IT HAD BEEN RAINING QUITE A BIT ON THIS - OUR FIRST DAY OF VACATION. OUR NEW 2014 FORD E-350 WOULD NOT SHIFT OUT OF PARK! ALL OF THE DASH LIGHTS STARTED FLASHING, THEN STOPPED, THEN FLASHED AGAIN. THIS HAPPENED A FEW TIMES. THE TRUCK WOULD START WOULD NOT SHIFT OUT OF PARK. AFTER DISCUSSIONS WITH FORD ROADSIDE ASSIST, THE TRUCK WAS TOWED TO A FORD DEALER. THE MAIN ENGINE ELECTRICAL COMPONENT'S COMPARTMENT WAS NOT SEALED CORRECTLY, LETTING WATER INTO THE COMPARTMENT AND SHORTING OUT THE ELECTRICAL SYSTEM IN THE TRUCK. THE WHOLE ELECTRICAL COMPONENT HAD TO BE REPLACED. THANKFULLY, WE WERE STOPPED IN A REST AREA WHEN DISCOVERED AND NOT ON THE ROAD! THIS IS A SAFETY ISSUE, SINCE THE TRUCK COULD HAVE STALLED OUT AT ANY TIME WHILE DRIVING. THE FORD DEALER HAD THE TRUCK FOR 2 WEEKS, WHILE WORKING TO FIND AND FIX THIS ISSUE.
NHTSA complaint #10722657 — an unverified report by a vehicle owner.
RENTED BUDGET TRUCK IN ALABAMA ON 8/30. DROVE FROM ALABAMA TO IOWA. RENTED AN AUTO TRANSPORT IN ADDITION TO THE FORD E-350 (2012). THE E-350 WAS THE ONLY ONE AVAILABLE AND I NEEDED TO TAKE IT BECAUSE I HAD NO OTHER OPTION BUT TO MOVE ON THAT DATE. THE E-350 HAD THE FOLLOWING DANGEROUS ISSUES: 1) NEARLY BALD FRONT LEFT TIRE. 2) WINDSHIELD WIPERS DID NOT RELIABLY CLEAR RAIN FROM WINDSHIELD (BLURRED VISION) 3) HAD TO MANUALLY PUMP FUEL EVERY 1/2 GALLON. THE FUEL PUMP WOULD CUT OFF EVERY 1/2 GALLON EVEN THOUGH THE TRUCK WAS HALF FULL OF FUEL. THIS HAPPENED AT TWO DIFFERENT GAS STATIONS. 4) THE AUTO TRANSPORT WAS RUSTED AND APPEARED TO HAVE NEVER BEEN INSPECTED THOROUGHLY. 5) THE AUTO TRANSPORT WAS RENTED TO ME WITH LOW TIRE PRESSURE IN THE RIGHT SIDE TIRES. 6) THE AUTO TRANSPORT HAD DEFECTIVE RATCHET STRAPS WHICH WERE USED FOR THE SECURING OF THE TOWED VEHICLE. 7) THE AUTO TRANSPORT'S TONGUE JACK WAS DAMAGED WITH BENT METAL WHERE THE CONNECTION PIN WAS LOCATED. WHILE I GOT TO MY DESTINATION SAFELY, I USED VERY SAFE DRIVING TECHNIQUES IN ORDER TO ENSURE THAT NEITHER I NOR MY WIFE WERE INJURED DURING OUR DRIVE. SHE DROVE IN A SEPARATE CAR AND WOULD DRIVE NEXT TO THE E-350 TO INSPECT THE INTEGRITY OF THE RATCHET STRAPS ON THE AUTO TRANSPORT EVERY 20 MILES TO ENSURE THEY WERE STILL WORKING. I HAVE DRIVEN MANY VEHICLES IN MY LIFETIME, EVEN MILITARY VEHICLES, AND I HAVE NEVER FELT SO UNSAFE AS I DID IN THIS BUDGET TRUCK RENTAL WITH AUTO TRANSPORT. THIS WAS ONE OF THE WORST EXPERIENCES OF MY DRIVING HISTORY AND I WILL NEVER RENT FROM BUDGET TRUCK RENTAL AGAIN.
NHTSA complaint #10630984 — an unverified report by a vehicle owner.
THERE IS A LOUD "POPPING" NOISE WHEN THE BRAKING OF THE VAN COMES TO A COMPLETE STOP. SOMETIMES I AM AFRAID THE VAN IS NOT GOING TO STOP ALL THE WAY. FROM WHAT I AM READING ONLINE, IT MAY BE UNDER PREVIOUS RECALL FOR THE BRAKE SYSTEM. I HAVE NO IDEA HOW TO GO ABOUT GETTING RECALL INFORMATION, ETC. TO HAVE A FORD DEALERSHIP FIX THIS PROBLEM.
NHTSA complaint #10609091 — an unverified report by a vehicle owner.