679 of the
10,532 complaints filed about the Ford Ranger
are about the electrical system —
100% of everything owners reported.
The worst model year for it is 1992.
When setting up my vehicle for neutral towing behind my motorhome and having parts installed for the proper operation of my turn signal and brake lights when vehicle is flat towed it was found that for it to happen were the brake lights do not override the turn signal when both activated at the same time you have to let the vehicle enter into a sleep mode for 10 minutes with the key FOB completely isolated from the vehicle for 10 minutes. If you stayed near the vehicle or approached with the key fob closer than 30ft it would come out of the sleep mode and when pushing on the brake pedal and using your turn signal at the same time from your motorhome you would override the turn signal with the brake lights. Normal checks for RV'ers would not identify this issue as you would stand behind the vehicle you are towing to check right and left turn signals then shut them off and check the brake light then final check would be rear, front and marker lights never pushing the break and having the turn signal on at the same time. This is a safety issue for anyone behind you as they can see you are braking but not be aware you are turning if you have awaken your vehicle modules by it getting a signal from the Key FOB. This issue was found and verified by my installer and myself when checking as to why the turn signal would shutoff at the same point I pushed the brake pedal in my RV. The manufacturer has no information in its manually about this 10 minute delay nor that the FOB can keep the delay from occurring by being near the vehicle. When you actually keep the vehicle in the sleep mode what happens is the active turn signal blinks and the opposite light indicates a brake light.
NHTSA complaint #11763888 — an unverified report by a vehicle owner.
Yes this is my second time filing a complaint regarding my new truck switching drive modes on its own. The first time it tried going into 4 low while i was going over 45 mph, with only 800 miles. The next time it did it was at around 1200 miles it switched drive modes completely and tried switching into 4 wd while at hoghway speeds. This is clearly a safety issue, their are numerous threads on reddit, facebook and ranger forums regarding it. Ford cannot replicate so they dont fix, what will it take one of us getting killed before we get a recall for whatever part or module is broken.
NHTSA complaint #11763583 — an unverified report by a vehicle owner.
The consumer owns a 2024 Ford Ranger. The consumer received notification of NHTSA Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that the parts were unavailable, even though the recall notification stated that parts were available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The vehicle remained with the dealer unrepaired since June 22, 2026. The contact stated that the interior lights, including the dome light and the sun visor lights, were inoperable. The dealer confirmed the failure.
NHTSA complaint #11763428 — an unverified report by a vehicle owner.
lariat ranger 2024 changes modes without input from driver. This has happened dozen times btu not consistent It has happened at 80mph on interstate ,35 mph on road, leaving parking space, and turning corner after stopping for stop light This time went in to 4wheel drive low on dry pavement very difficult to steer until stopped and put back into 2 wheel drive. Has happened in dry weather and rainy weather. 50 degrees and 100 degrees dealer says ford has no reported problems to dealers. dealer says can not do anything without replicating problem while they test drive I am not leaving my Ranger with them to test drive for weeks. It is an inconsistent problem that can not be replicated by any one action
NHTSA complaint #11763219 — an unverified report by a vehicle owner.
2025 Ford Ranger XLT experienced an electrical short-circuit causing a persistent speaker hiss with the vehicle turned off, accompanied by an electrical burning smell. The radio and audio became very staticky and a constant hissing sound with the radio and the truck turned off. By the time the dealer looked at the vehicle it was operating normally. Dealership refused to inspect wiring or ACM due to intermittent nature of the failure.
NHTSA complaint #11761748 — an unverified report by a vehicle owner.
This 2024 Ford Ranger Pickup is part of recall # 26V238. The vehicle has been at the dealer since 6/20/2026. Today is 8/30/2026. There have been several dates given for the release of the fix for this recall and all have come and gone. Ford does not seem to be acting in a timely manner to correct this issue. Since i purchased the vehicle used, I do not qualify for a buy back nor does it fall under lemon laws. Ford has provided a loaner vehicle but it is a compact SUV not the truck that I need for my daily needs. PLEASE do what you can to get Ford to correct this issue soon. Thank you
NHTSA complaint #11760789 — an unverified report by a vehicle owner.
On multiple occasions while driving the vehicle will randomly change drive modes by its self. It will try to go into 4x4 low gear (rock crawl mode) at highway speeds. This has happened a dozen times since I purchased the vehicle new.
NHTSA complaint #11760214 — an unverified report by a vehicle owner.
The contact owns a 2024 Ford Ranger. The contact received notification of NHTSA Campaign Number: 26V238000 (Structure, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that there was an abnormal burning odor inside the vehicle, and the instrument cluster flickered while driving. The dealer was contacted and confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure and informed the contact that a second letter would be sent once the remedy was available, and parts were anticipated by the end of August 2026. The failure mileage was approximately 323.
NHTSA complaint #11758045 — an unverified report by a vehicle owner.
Vehicle received and installed an over-the-air software update to the Body Control Module, identified on the vehicle screen as BCM-26.6.3 and associated with Safety Recall 26S29 (A-pillar/sun visor wiring, NHTSA 26V238000). The update screen displayed a status of "Not Completed." Since that update the vehicle will not start and is inoperative. Current condition: opening the driver door wakes the center infotainment screen only. The instrument cluster does not illuminate. Pressing the brake pedal produces no response - no cluster illumination, no warning lamps, no chimes, no messages, no crank. 12V power is present; the manufacturer's telematics app still reaches the vehicle and returns status. Symptoms are consistent with a Body Control Module that is powered but not communicating on the vehicle network. No warning lamps, messages, or symptoms were present before the update. The vehicle operated normally until the update was installed. Safety risk: the vehicle became immobile without warning immediately following installation of a manufacturer-pushed safety recall remedy. The transmission cannot be shifted electronically, requiring the manual park release to move or tow the vehicle. Had this occurred away from home or in a traffic lane, the vehicle would have been stranded and unable to move under its own power. The BCM also governs exterior lighting and hazard lamp function. Note: the update screen header displayed "25S29" while the body text referenced completing Safety Recall 26S29. The vehicle has a dealer-installed Ford Performance ProCal calibration. The vehicle has not yet been inspected by the dealer or manufacturer. It is available for inspection upon request.
NHTSA complaint #11757184 — an unverified report by a vehicle owner.
The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.
NHTSA complaint #11756686 — an unverified report by a vehicle owner.
Hello, I have a 24-ford ranger raptor, this incident happened twice, I was driving approximately 60 MPH and vehicle on its own started changing drive modes. It switched itself to baja mode which is 4-wheel drive and very dangerous at these speeds. I took my truck to local ford dealer in Valencia Ca, Dealer stated no codes or issues found. This is deeply concerning to me; I Have family that also drives this vehicle. I have read online that other same vehicle owners are experiencing same symptoms and heavy concerns. Not sure where to go from here, any help or feedback would greatly appreciated. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11755976 — an unverified report by a vehicle owner.
The vehicle went into BAJA Mode 4wd high then 4wd low range out of nowhere while driving. It shot me off the road , and ive been researching it. There is a 6 page thread about new rangers and ranger raptors doing this on 6G ranger forum, tons of people with the same issue. Super scary. Fear injury or fatality will happen from this as it shoots you hard off the road
NHTSA complaint #11752831 — an unverified report by a vehicle owner.
I have waited years to get the air bags repaired. My wife is scared to ride in the truck. Now the electronics have started messing up. Ford should have to pay me back some of what this vehicle cost because of poor quality workmanship.
NHTSA complaint #11752720 — an unverified report by a vehicle owner.
I was driving the vehicle, when I started to fell a " Shuddering " sensation on acceleration. I let off the gas pedal and the Shuddering went away. A few miles down the road the check engine light came on and was flashing. I immediately pulled and shut the vehicle off. After sitting for 10 minutes I restarted the vehicle and the check engine light was no longer on, but the " Shuddering " sensation was still present. I took it to Dupratt Ford in Auburn,Ca. and they diagnosed it as a Cylinder 1 mis-fire. Upon further inspection they found water in the Cylinder 1 spark plug well. After doing some research I found out the Ford issued TSB 23-2011for this exact issue, but did not order a recall to fix the faulty windshield cowl which is the problem. I found thousands of complaints and numerous Ranger owners who have had the exact same issue and had to pay out of pocket to get the issue and damaged fixed. Meanwhile Ford knew about the issue and did absolutely nothing, did not even alert the owners of the issue. I was lucky and did not have to replace the cylinder head, but others have not been so lucky. I had to pay over $1800 to have the mis-fire issue fixed and had to do my own preventative measures to seal the windshield cowl. I contacted Ford and they were only willing to reimburse me $725 dollars of my repair bill which was 100% their fault.
NHTSA complaint #11747696 — an unverified report by a vehicle owner.
Received safety recall 25S72 sync software and had repaired in Feb. 2026. Same issue has already resurfaced. Many issues are related to this. Sync software affects B/U camera, Ford pass will not work, phones will not sync, internal components will not work properly. IE: Radio, etc. Was repaired during warranty period but now a few weeks out of warranty and dealer will not repair again without a healthy charge. I just wanted to report since initial repair failed again so quickly. Thanks
NHTSA complaint #11747442 — an unverified report by a vehicle owner.
While driving at highway speeds vehicle changes the drive mode at random. Even attempting to go into 4 low at high speeds. If the vehicle is able to change into 4 low at high speeds this could send the vehicle into uncontrollable lock down to the drive train and potently creating uncontrollable spin out. Car has been at the dealership for this issue, but they cannot find any problems or able to replicate the issue.
NHTSA complaint #11744966 — an unverified report by a vehicle owner.
The truck shifted its drive mode from normal driving into Baja mode by itself, and also shifted the transmission from 2H to 4H, potentially damaging the transmission and causing a safety issue on the highway.
NHTSA complaint #11744587 — an unverified report by a vehicle owner.
My Ford Ranger is on a safety recall. They sold it to us on May 9,2025 then kept the truck. June 1 they told use the recall issue was solved. We were not given documents on this. We are now seeing the parts needed are not available until the end of June. A Fedaral and State law was broken in selling us a vehicle on a safety recall. We were not aware of this issue until we research the recall. I am so frustrated. We lost a month of use of this vehicle In waiting. So frustrated.
NHTSA complaint #11742182 — an unverified report by a vehicle owner.
During low speed driving, mainly stop and go traffic the truck will randomly lunge forward when the brake pedal is engaged. It happens when accelerating and the truck will shift in to second gear, then if you apply the brake the truck will act like it is going to stall, the engine rpm will spike and the truck will launch forward. If you dont force the brake pedal to the floor, the truck will continue to accelerate, potentially slamming into another vehicle. This has happened multiple times, the dealer has rebuilt the transmission and that fixed the issue for the last 6-8k miles. the issue has returned and the truck is back at the dealership for diagnostics. This is becoming a serious safety concern and the potential that someone gets hurt grows every day. I have seen other complaints on the internet about this same issue in trucks with the same transmission.
NHTSA complaint #11741626 — an unverified report by a vehicle owner.