Owners have filed 52 complaints
about the 2022 Ford Ranger with NHTSA between 2022 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 26 of 26 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 7
Against the median year of the Ford Ranger. 50 means typical for this
model; 100 means roughly double.
Severity — 20
3.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
80% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
220.0%
1,000 – 9,999 miles
110.0%
10,000 – 24,999 miles
440.0%
25,000 – 49,999 miles
220.0%
75,000 – 99,999 miles
110.0%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Feb 2022peak 7Jul 2026
Recalls on the 2022 Ford Ranger
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V685000
EQUIPMENT:ELECTRICAL:ENGINE BLOCK HEATER
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Risk: An electrical short circuit can increase the risk of a fire.
25V442000
BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Risk: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
23V379000
EQUIPMENT:OTHER:LABELS
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco, 2023 Super Duty F-250, and 2019-2023 Ranger vehicles. The Tire and Loading Information (TREAD) label states the incorrect load carrying capacity, which can result in an overloaded vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire Selection and Rims."
Risk: An overloaded vehicle increases the risk of a crash.
22V685000
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
Ford Motor Company (Ford) is recalling certain 2022 Explorer and Ranger vehicles equipped with 2.3L engines. The fuel line may be loose due to improper tightening of the fuel line connection.
Risk: An improperly tightened fuel line connection may result in a fuel leak, increasing the risk of fire.
22V451000
VISIBILITY:WINDSHIELD
Ford Motor Company (Ford) is recalling certain 2022 Bronco and Ranger vehicles. The windshield may not have been properly bonded to the vehicle, which could allow it to detach during a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 212, "Windshield Mounting."
Risk: A windshield that separates from a vehicle during a crash can increase the risk of injury.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2026005138,783 units in Canada
Electrical
Issue: On certain vehicles, the engine block heater could leak coolant. If this happens, the block heater could short circuit when it's plugged in. Note: This recall replaces Transport Canada recall no. 2025-554. Vehicles that were repaired under that recall don't require this repair. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: To reduce the safety risk, Ford advises you not to use the engine block heater until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the block heater. Alternatively, owners can choose to have the dealership permanently disable the engine block heater.
Recall 2025554128,886 units in Canada
Electrical
This recall was replaced by Transport Canada recall no. 2026-005. Issue: On certain vehicles, the engine block heater could leak coolant. If this happens, the block heater could short circuit when it's plugged in. Safety Risk: A short circuit can create the risk of a fire. Corrective Actions: To reduce the safety risk, Ford advises you not to use the engine block heater until the recall repairs have been completed. Ford will notify owners by mail and advise you to take your vehicle to a dealership to replace the block heater.
Recall 202536016,575 units in Canada
Visual System
Issue: On certain vehicles, a software problem could cause the rearview camera image not to display when the transmission is shifted into reverse. Canadian regulations require the rearview image to display when the vehicle is reversing. Safety Risk: A rearview camera image that doesn't display could reduce a driver's ability to see behind the vehicle while backing up. This could increase the risk of a crash. Corrective Actions: Ford will notify owners by mail and advise you to take your vehicle to a dealership to update the SYNC software.
Recall 20233083,074 units in Canada
Label
Issue: On certain vehicles, the tire and loading information label lists the wrong maximum weight of occupants and cargo. Specifically, for Bronco and Super Duty models, the cargo capacity (payload) may have been calculated incorrectly. For the Ranger models, the weight of vehicle options may have been entered incorrectly. As a result, the vehicle could be overloaded. Canadian regulations require companies to print the maximum weight of occupants and cargo on the tire and loading information label. Safety Risk: Incorrect information about the vehicle's weight capacity could lead to overloading and increase the risk of a crash. Corrective Actions: Ford will mail a new tire and loading information label to each owner. If you would like help to install it, you can contact a Ford dealer to have it installed free of charge.
Recall 202252212 units in Canada
Fuel System
Issue: On certain vehicles equipped with a 2.3 L engine, the fuel line connections between the fuel pump and fuel rail may not have been tightened properly. As a result, fuel could leak. Safety Risk: A fuel leak can create the risk of a fire. Corrective Actions: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to inspect and, if necessary, replace the fuel line assembly.
Recall 20223354,294 units in Canada
Structure
Issue: On certain vehicles, the windshield may not be properly attached. As a result, the glass can become loose and could separate from the vehicle in a crash. Safety Risk: A windshield that detaches in a crash could create an increased risk of injury. Corrective Action: Ford will notify owners by mail and instruct you to take your vehicle to a dealership to remove and reinstall the windshield. The dealer will also recalibrate the front camera, if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Rhododendron, OR99 injured
SEATS
I have developed severe chronic neck and back pain due to the shape and position of the headrests in this vehicle (as well as my wife’s 2024 Hyundai Kona). There is no position that does no cause pain, and I am forced to remove them entirely, or lean forward and not use them, causing a lack of support and different muscle tension. This has been confirmed by my physical therapist. Due to NHTSA requirements, I cannot buy a newer vehicle that does not cause this condition, nor even purchase aftermarket replacements. Being forced to drive without a headrest at all is much more dangerous than having a comfortable option. I have to drive a lot to work and shop because I live in the mountains. Please help. I’m one of millions with this problem.
NHTSA complaint #11710143 — an unverified report by a vehicle owner.
at 17,000 milesForsyth MT, MTCrash
AIR BAGS
The contact owns a 2022 Ford Ranger. The contact stated that while her son was driving at 40 MPH, he ran a red light at an intersection and T-boned another vehicle. The impact bent the frame into the front tires. The air bags did not deploy. There were no injuries, and medical attention was not received. A police report was filed. The vehicle was towed to the body shop; however, the vehicle was not diagnosed or repaired. The vehicle was not deemed totaled by the insurance company. The manufacturer was made aware of the failure. The failure mileage was approximately 17,000.
NHTSA complaint #11545675 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Sierra Vista, AZ
POWER TRAIN
Vehicle was placed into Ford’s Neutral Tow mode according to the owner’s manual before being recreationally towed behind a motorhome. The instrument cluster displayed Ford’s confirmation that Neutral Tow was enabled and the vehicle was ready for four-wheel-down towing. The transmission failure occurred during the second day of towing. After highway travel, the transmission severely overheated, expelled transmission fluid and lost all ability to move in forward or reverse. Diagnostic code P0218, transmission over-temperature, was present. Neutral Tow was no longer enabled when the vehicle was subsequently checked. The Ford dealer states that the vehicle does not retain logs confirming whether Neutral Tow was enabled or remained enabled. Ford’s GSB 22-7086 directs the dealer to inspect for transmission damage associated with the drivetrain being rotated during recreational towing. However, the resulting damage cannot establish whether the owner failed to activate Neutral Tow or whether Ford’s electronically controlled Neutral Tow system confirmed activation and later failed to maintain the required mechanical state. The fact that the vehicle was successfully towed during the first day before failing on the second day raises concern that the transfer case, shift-control system or related electronics may have lost or failed to maintain Neutral Tow after it had been successfully activated. There are other reported incidents involving Ford Ranger, F-150 and Bronco vehicles in which owners state that Neutral Tow was confirmed but the drivetrain subsequently re-engaged, overheated or suffered catastrophic transmission damage during recreational towing. This condition presents a safety risk because Ford’s system may display that the vehicle is ready and safe to tow while potentially failing to keep the drivetrain mechanically isolated. In this incident, extremely hot transmission fluid was expelled onto the vehicle, tow equipment and surrounding roadway, creating a poss
NHTSA complaint #11753520 — an unverified report by a vehicle owner.
St.paul Park, MN
POWER TRAIN
Transmission. Total mechanical failure. TSB. 23-2250 TBS 24-2101 TBS. 25-2134. Transmission fluid was replaced at 83709. Replaced at 104263. Factory schedule 150000. Ford is aware they are selling a product that has Factory mechanical issues.
NHTSA complaint #11748529 — an unverified report by a vehicle owner.
Fairland, OK
POWER TRAIN
Complete transmission failure with normal driving use just outside of warranty
NHTSA complaint #11733138 — an unverified report by a vehicle owner.
Moscow Mills, MO
ELECTRICAL SYSTEM
What component or system failed or malfunctioned, and is it available for inspection upon request? Inspection available if needed. The ignition coils and spark plugs failed due to Ford’s negligence to provide an engine cover. Water has gotten in to the engine and caused these systems to fail How was your safety or the safety of others put at risk? The engine violently shakes and causes you to lose speed. I was going 20 under the limit on the highway due to this and could have caused an accident. The vehicle felt as if it was shutting off and I got off at the next available exit. It placed my family at risk and others as it could have caused a bad accident if someone would have rear ended me due to the slow speed. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, this is a known issue and Ford refuses to repair the vehicle and advises it is out of pocket. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by a repair facility. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The check engine light was flashing and then stayed solid. This first appeared on 1/27/26
NHTSA complaint #11715118 — an unverified report by a vehicle owner.
Moscow Mills, MO
ENGINE
What component or system failed or malfunctioned, and is it available for inspection upon request? Inspection available if needed. The ignition coils and spark plugs failed due to Ford’s negligence to provide an engine cover. Water has gotten in to the engine and caused these systems to fail How was your safety or the safety of others put at risk? The engine violently shakes and causes you to lose speed. I was going 20 under the limit on the highway due to this and could have caused an accident. The vehicle felt as if it was shutting off and I got off at the next available exit. It placed my family at risk and others as it could have caused a bad accident if someone would have rear ended me due to the slow speed. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, this is a known issue and Ford refuses to repair the vehicle and advises it is out of pocket. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by a repair facility. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? The check engine light was flashing and then stayed solid. This first appeared on 1/27/26
NHTSA complaint #11715118 — an unverified report by a vehicle owner.
Brighton, MI
POWER TRAIN
Engine Valve Cover has Cracked. High Pressure Pump Seals and gaskets needed to be replaced. Confirmed by 2 dealerships It has been inspected No warning lamps messages.
NHTSA complaint #11713696 — an unverified report by a vehicle owner.
Brighton, MI
ENGINE
Engine Valve Cover has Cracked. High Pressure Pump Seals and gaskets needed to be replaced. Confirmed by 2 dealerships It has been inspected No warning lamps messages.
NHTSA complaint #11713696 — an unverified report by a vehicle owner.
Summerville, SC
POWER TRAIN
Several occasions, pulling out into traffic and giving it gas the truck jerks repeatedly and won't go and then we'll kick into normal speed several times driving out of nowhere RPM shoot up truck almost comes to a complete stop in the middle of traffic but no Code is popping up saying there's anything wrong with the vehicle and in order to have Ford looking at it. It's gonna cost $399 since as of now there is no recall on anything for this.
NHTSA complaint #11710384 — an unverified report by a vehicle owner.
Rhododendron, OR99 injured
SEATS
I have developed severe chronic neck and back pain due to the shape and position of the headrests in this vehicle (as well as my wife’s 2024 Hyundai Kona). There is no position that does no cause pain, and I am forced to remove them entirely, or lean forward and not use them, causing a lack of support and different muscle tension. This has been confirmed by my physical therapist. Due to NHTSA requirements, I cannot buy a newer vehicle that does not cause this condition, nor even purchase aftermarket replacements. Being forced to drive without a headrest at all is much more dangerous than having a comfortable option. I have to drive a lot to work and shop because I live in the mountains. Please help. I’m one of millions with this problem.
NHTSA complaint #11710143 — an unverified report by a vehicle owner.
Crestview, FL
ELECTRICAL SYSTEM
Wiper arm stops working or stays in up position. Intermittent issue.
NHTSA complaint #11709077 — an unverified report by a vehicle owner.
Crestview, FL
VISIBILITY/WIPER
Wiper arm stops working or stays in up position. Intermittent issue.
NHTSA complaint #11709077 — an unverified report by a vehicle owner.
Moorefield, WV
ELECTRICAL SYSTEM
The ACM (Audio Control Module) failed, causing a network failure in the CAN system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic warning. Additionally, while the turn signals worked, there was no inside audio or visual confirmation that it was functioning. Also no high beam headlight indicator and no automatic high-low beams. Cost of repair was $739.00 and the dealer had to order the part.
NHTSA complaint #11705968 — an unverified report by a vehicle owner.
Moorefield, WV
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The ACM (Audio Control Module) failed, causing a network failure in the CAN system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic warning. Additionally, while the turn signals worked, there was no inside audio or visual confirmation that it was functioning. Also no high beam headlight indicator and no automatic high-low beams. Cost of repair was $739.00 and the dealer had to order the part.
NHTSA complaint #11705968 — an unverified report by a vehicle owner.
The ACM (Audio Control Module) failed, causing a network failure in the CAN system. This caused a condition of no speedometer reading, no automatic braking, no adaptive cruise control, no fuel gauge reading, no blind spot monitoring, no forward collision, no rear cross traffic warning. Additionally, while the turn signals worked, there was no inside audio or visual confirmation that it was functioning. Also no high beam headlight indicator and no automatic high-low beams. Cost of repair was $739.00 and the dealer had to order the part.
NHTSA complaint #11705968 — an unverified report by a vehicle owner.
Bethlehem, PA
POWER TRAIN
We where driving down the PA Turnpike Pike when the transmission began to shift between 8 and 9th gears. A wrench icon turned on. I pulled over and the transmission stayed stuck in 9th gear even when parked. I turned off the truck and opened the door which turned the ignition off. When I opened the door I heard a click from the transmission. Turned the truck back on and it ran normal and the wrench went away. I use a code reader at all times and was able to record the code. This occurred while overtaking another car and almost caused a multi car and semi accident.
NHTSA complaint #11704938 — an unverified report by a vehicle owner.
Kendall Park, NJ
POWER TRAIN
Started having issues with 10R80 transmission at 40k then a complete replacement at 53k, nothing but continued problems, now back at shop a week later for knocking and transmission.
NHTSA complaint #11702894 — an unverified report by a vehicle owner.
Brighton, MI
POWER TRAIN
While driving my 2022 Ford Ranger, the transmission failed to engage Drive. I started my morning as usual, letting the vehicle warm up and the RPMs settle before leaving my neighborhood. As I pulled onto the main road, the truck began acting strangely—I noticed it wasn’t accelerating normally and felt constant gear shifting without gaining speed. To avoid blocking traffic, I pulled over at a local store and shifted into Park. When I tried to shift back into Drive, the transmission would not engage. Pressing the gas felt like the truck was in Neutral. I turned the vehicle off for about a minute and restarted it, but the same issue occurred. I then called my local dealer, who suggested using Sport mode and manually selecting gear 2. This worked, and I was able to drive home safely since I was only about a minute away. After that, I contacted the warranty company and arranged for a tow. Component/System: Transmission Safety Risk: Loss of acceleration on a main road created a risk of collision with other vehicles. Reproduced/Confirmed: UNKNOWN until December 15th if the issue has been reproduced or confirmed by the dealer. Inspection: Dealer is scheduled to inspect the vehicle on December 15. Warning Lamps/Messages: None appeared prior to the failure. None After. Until repairs are completed, I am without a vehicle and will only be reimbursed for a rental while repairs are worked on
NHTSA complaint #11702974 — an unverified report by a vehicle owner.
Brighton, MI
VEHICLE SPEED CONTROL
While driving my 2022 Ford Ranger, the transmission failed to engage Drive. I started my morning as usual, letting the vehicle warm up and the RPMs settle before leaving my neighborhood. As I pulled onto the main road, the truck began acting strangely—I noticed it wasn’t accelerating normally and felt constant gear shifting without gaining speed. To avoid blocking traffic, I pulled over at a local store and shifted into Park. When I tried to shift back into Drive, the transmission would not engage. Pressing the gas felt like the truck was in Neutral. I turned the vehicle off for about a minute and restarted it, but the same issue occurred. I then called my local dealer, who suggested using Sport mode and manually selecting gear 2. This worked, and I was able to drive home safely since I was only about a minute away. After that, I contacted the warranty company and arranged for a tow. Component/System: Transmission Safety Risk: Loss of acceleration on a main road created a risk of collision with other vehicles. Reproduced/Confirmed: UNKNOWN until December 15th if the issue has been reproduced or confirmed by the dealer. Inspection: Dealer is scheduled to inspect the vehicle on December 15. Warning Lamps/Messages: None appeared prior to the failure. None After. Until repairs are completed, I am without a vehicle and will only be reimbursed for a rental while repairs are worked on
NHTSA complaint #11702974 — an unverified report by a vehicle owner.
at 300 milesElkins, WV
ELECTRICAL SYSTEM
The contact owns a 2022 Ford Ranger. The contact stated while driving on several occasions, the infotainment system screen turned black intermittently. Additionally, the contact stated that upon starting the vehicle and accelerating, the vehicle failed to accelerate as intended. The vehicle was taken to an unknown dealer on several occasions, but the failure could not be replicated. The vehicle was taken to AutoZone, where it was diagnosed that an unknown O2 sensor located behind the glove box, and the sensors connected to the catalytic converter had failed. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 300.
NHTSA complaint #11674261 — an unverified report by a vehicle owner.
at 300 milesElkins, WV
ENGINE AND ENGINE COOLING
The contact owns a 2022 Ford Ranger. The contact stated while driving on several occasions, the infotainment system screen turned black intermittently. Additionally, the contact stated that upon starting the vehicle and accelerating, the vehicle failed to accelerate as intended. The vehicle was taken to an unknown dealer on several occasions, but the failure could not be replicated. The vehicle was taken to AutoZone, where it was diagnosed that an unknown O2 sensor located behind the glove box, and the sensors connected to the catalytic converter had failed. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 300.
NHTSA complaint #11674261 — an unverified report by a vehicle owner.
Seaford, DE
POWER TRAIN
Harsh/Delayed Engagement and Harsh/Delayed Shifting from 3rd to 4th and sometimes 5th to 6th There's a Ford service bulletin out for this #25-2134 My truck was built on 08/26/2022 but this bulletin only covers trucks built before 08/15/2022 It occurs daily. My dealer tells me to live with it.
NHTSA complaint #11663593 — an unverified report by a vehicle owner.
Dayton, OH
ELECTRICAL SYSTEM
Truck cut off at an intersection without warning and would not turn back over. After multiple attempts and AAA service members checking batter car would not start. Has power but will not turn over dealership is saying there is a module issue but is not sure.
NHTSA complaint #11630642 — an unverified report by a vehicle owner.
at 38,000 milesTiverton, RI
STEERING
The contact owns a 2022 Ford Ranger equipped with Bridgestone Tires, Tire Line: Dueler HT685, Tire Size: 255/70/R16, DOT Number: 1VN0KDH2 3422. The contact stated that the driver’s side front inner tire was excessively worn. The contact noticed that the steel belts were showing through. The contact replaced the tire with a spare. There was no warning light illuminated. The vehicle was taken to an independent mechanic, who informed him that the alignment bolt s could not be adjusted. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The vehicle and tire failure mileage were approximately 38,000.
NHTSA complaint #11622476 — an unverified report by a vehicle owner.
Severna Park, MD
POWER TRAIN
Five separate incidents where the truck suddenly accelerated to 4500 rpm while in drive. Usually at low speeds. Last incident occurred in driveway where the truck left skid marks on the pavers.
NHTSA complaint #11607226 — an unverified report by a vehicle owner.
at 14,000 milesFort Worth, TX
ELECTRICAL SYSTEM
The contact owns a 2022 Ford Ranger. The contact stated while the vehicle was parked, the vehicle failed to start with the key in the ignition. The contact stated that the vehicle started after the battery was recharged. The contact was able to start the vehicle using the key instead of the key fob. The vehicle was taken to a local dealer to be diagnosed; however, no cause for the failure was found. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 14,000.
NHTSA complaint #11600236 — an unverified report by a vehicle owner.