312 of the 10,502 complaints filed about the Ford Ranger are about the other systems — 3% of everything owners reported. The worst model year for it is 2019.
312
Complaints
3%
Share of all complaints
12
Crashes
8
Fires
UNKNOWN OR OTHER
I was driving my brother in laws truck and went to dodge a deer My airbag deployed and caused me to crash into a sign on the driveway leading to my house causing extensive damage to the vehicle and the property sign I was knocked out unconscious and when I came to I got out and walked home and the next morning I had the truck towed to my house
NHTSA complaint #11756925 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
The cooling fan clutch control wire is supported by a "wire support hose" between the engine block and the fan clutch. the cooling fan clutch control freely rotates on a raceway on the drive shaft. The purpose of the support hose is to prevent the fan clutch control from freely rotating, but allows the control a limited range of movement as the drive shaft changes speed with engine RPM. The idea is that this hose prevents undue stress on the control wire. Hose is normally a consumable part that may need replaced with age, heat, etc. The hose is not sold as a replacement part and can only be obtained by purchasing a new fan clutch. When the hose fails, the control wraps around the drive shaft causing damage to the fan clutch control and wiring requiring replacement. The circuit on which the fan clutch control sits is integrated with no less than 6 other critical vehicle systems including oil pressure. When the incident occurs, all these systems generate errors that put the vehicle into limp mode until repair can be made. The fan clutch control wiring support hose should be a bracket with a different mechanical linkage solution to support wire while allowing the necessary limited movement. This low-tech hose solution causes outsized damage when it fails, effectively disabling the vehicle which creates a safety concern and undue hardship from an unnecessarily cascading damage effect. Ford acknowledges this defect by redesigning this feature for 6G Rangers but will not proactively correct through manufacturer recall 5G Rangers. If Ford will not correct, I believe the NHTSA should get involved and force Ford's hand at addressing this repair.
NHTSA complaint #11756686 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Chrome metal on 3 door handles sticking up. Cut my daughter's fingers and my fingers. Was reported to Ford and local dealer but Ford said I would have to pay out of pocket to replace full handle assemblies. Ford offerred a discount, but it was still expensive. Truck was too new for the chrome to be coming off. I rarely use the back seat/doors, and those handles are peeling up just like front handles.
NHTSA complaint #11755129 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Chrome metal peeling up on 3 door handles. Started peeling around 39K miles. Cut my fingers and my daughter's fingers. Brought it to local dealer who filed a repair request and Ford said I would have to pay for ful door handle assemblies out of pocket. Truck was too new and well taken care of for me to feel comfortable paying out of pocket.
NHTSA complaint #11755134 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
The 10R80 10-speed automatic transmission and the gear-shift linkage module are defective, and the truck remains available for inspection. Our safety is constantly put at risk because the transmission exhibits an extremely violent, highly intermittent powertrain lunging jolt during deceleration and stopping. The impact is so severe that it sounds and feels like a loud gunshot firing right next to the cabin occupants. Furthermore, the transmission simultaneously exhibits severe throttle hesitation and gear-skipping. This causes the vehicle to drop gears and completely fail to move when attempting to accelerate at busy stoplights, trapping us as a sitting duck in active traffic. Earlier in our timeline, the technician improperly reassembled the shift linkage, which caused the multi-ton vehicle to refuse to engage in Park and violently roll backward down a steep residential incline; an emergency parking brake deployment was required to prevent a catastrophic accident. The transmission defect was physically confirmed by [XXX] of Papillion, who verified scored, sticking fluid control valves inside the main control unit. Additionally, the hazard was officially confirmed by BBB AUTO LINE National Arbitrator Sharon Katt (Case XXX). The arbitrator officially signed a ruling certifying that our safety, use, and value concerns are completely valid, explicitly noting that the intermittent nature of this transmission failure does not minimize the extreme safety hazard. There were no warning lamps prior to the failure. The symptoms first appeared at ~49,000 miles. The dealer has since refused advanced diagnostics, executed an irrelevant radio reset instead, and willfully fabricated a fake service record on CARFAX on April 21, 2026, to force-close system safety alerts in their database. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11753464 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
No incident occurred. This is to report a safety issue related to the activation of the rear view camera while driving forward. There are times when a vehicle (automobile/motorcycle) may be following closely, and the rear view mirrors are inadequate to see the following vehicle clearly. If the rear view camera is activated, the image projected by the camera is obscurred by a message stating "Full View Not Available". There appears to be no way to remove this message so that the image in not obsurred. See attached photo.
NHTSA complaint #11753447 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Rear view camera has significant delay, lag, or stutter at times, in reverse, more noticeably at faster that idle reverse speeds.
NHTSA complaint #11751384 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Vehicle: 2021 Ford Ranger. Mileage: 44,000 My 2021 Ford Ranger begin experiencing dangerous transmission shifting issues with absolutely no warning signs or indicator lights prior to the incidents. On multiple occasions the truck suddenly and randomly stalled in the middle of the freeway and in the middle of the road, feeling as if the transmission went into neutral with no power to move the vehicle. These incidents occurred multiple times putting myself and my small child at serious risk of injury or death. At no point did any warning lights illuminate or any indication appeared on the dashboard to alert me of a problem before these dangerous events occurred. The truck was taken to a Ford dealership where it was diagnosed with an electrical fault in the transmission solenoids. The final diagnosis is a full Transmission R&I and overhaul at only 44,000 miles. This issue is covered under Ford TSB 21-2315 which acknowledges that the 10-speed automatic transmission may exhibit harsh engagement, delayed shifts, and shifting problems due to known defects. My 5yr/60,000-mile powertrain warranty expired 3 months ago by time only. I am well under the mileage limit at 44,000 miles. Ford has agreed to cover only $2,097.06 of the $5,242.65 repair, leaving me responsible for $3,145.59 for a known manufacturing defect. When I contacted Ford requesting full goodwill warranty coverage, I received poor customer service a manger (Luis) promised to call back multiple times with additional coverage options and never did. A full transmission overhaul at 44,000 miles is not consistent normal wear and tear and is clearly the result of a manufacturing defect that Ford has already acknowledged through TSB 21-2315. The sudden and unexpected nature of these failures with no warning, combined with the serious safety risk posed to myself and my child, makes this matter extremely urgent. I am requesting NHTSA investigate this matter and Ford's handling of this known defect.
NHTSA complaint #11744440 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
My interior door handles have chrome-plated stickers. They have started to bubble and peel to the point where my wife sliced her finger requiring an ER visit and stiches. I've seen on Reddit that other vehicle owners have had the same issues. I noticed on June 9th, 2026 Ford issued a recall for its For Expedition, for a similar issue but with its center console, not the door handles. I believe this is a serious issue that could easily cause bodily harm. This should be investigated. Thank you
NHTSA complaint #11743600 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Vehicle experienced unintended transmission gear change without driver input from the gear selector. While driving, the transmission shifted unexpectedly into 4H even though the selector was not touched. This created a safety hazard due to sudden change in vehicle behavior, including: loss of acceleration, lurching and unexpected movement. Issue occurred at approximately 30 mph. Concern is potential electronic transmission control or shift-by-wire malfunction causing unintended gear engagement.
NHTSA complaint #11739691 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
When using the rear camera while towing a trailer, the image is partially blocked by a persistent message stating “full view not available”. This creates a safety issue as it obscures the driver’s view of the trailer and/or the trailer load. It is critical to be able to monitor the trailer and the load during towing to ensure a hazardous condition is not developing. I believe the rear view camera is working as designed, that is I do not believe there is a defect or failure in the hardware. However the design of the message is the problem. If the driver needs to know that “full view not available” then the message should be moved to a different part of the screen to not obscure the view of the trailer.
NHTSA complaint #11738102 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Bought 2020 Ford Ranger Lariat in March 2024 with 13k miles. I have had no issues and have kept up maintenance needed. Vehicle currently has 19,128 miles and on 4/17/26 while driving the vehicle lost power. I was able to pull over and immediately called the dealership where vehicle was purchased and had towed to their facility for diagnosis. There we no warning lights prior to losing power. The dealership informed me a new transmission is needed pulling codes P0751 and P2700. The cost they informed me for replacement was $10k +/= indicating the Power Train warranty had expired in 2025. (5 yr/60,000) I find this appalling that at 19k I am responsible to replace something that has clearly had issues in past. Their only option was to replace transmission or they could take apart and overhaul to fix the codes which could be cheaper but also may result in transmission replacement anyways which will cost more in long run.
NHTSA complaint #11734620 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Became aware of open recalls circa 09.2025, and requested the parts be ordered at Ford Auto Nation (FAN) Panama City, FL. Was told by John, dealership would call when parts became available. Parts have not either been available and/or there have been no calls. Calling the dealer is ludicrous as all calls are answered by an incompetent call center. Dropped by the dealership today 04/25/2026, and Taylor could not book a service appointment, did not know if parts to fix recalls were available for my vehicle, and said I would need to speak with John whom was off today. It appears that Ford/FAN-PC is not interested in safety or repairing my vehicle.
NHTSA complaint #11733759 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Back up camera intermittently fails to operate giving a squiggly picture or a blank black screen. I have seen many articles involving the same issues with Ford Broncos and where recalls have been issued for those vehicles. When will the NTSB be calling for Ford to recall other vehicles models having the same issues?
NHTSA complaint #11727296 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
There is a foot and brake pedal clearance that is a safety issue. The driver side lower heat vent impinges on the driver right foot when when hitting the brake. Looking on the internet this is a known issue that Ford refuses to fix. Customers are modifying or removing the heat vent for their safety. Here is a link of several complaints and customers solutions. [XXX] This is not limited to large footed individuals nor 2026 vehicles. Older models have the problems as well. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11725352 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
he 2019 Ford Ranger the VIN [XXX] , the driver’s side AC only blows hot due to the climate control issue addressed in Fords service bulletin SSM 51313. This is a known issue with the early production model of the Ranger, hence the service bulletin SSM 51313. It is my belief that faulty parts were used on the early model Rangers and instead of a recall or extending the warranty on this issue only issued a service bulletin was put out. I am writing to have the Ford MOCO issue the proper recall or cover repairs under and extended warranty. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11719853 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
2019 ford ranger, 74,000 miles On way to pick up girlfriends engagement ring…. The truck started jerking, loosing power, no engine light came on. Turned around to go home and drive about 8 miles under 45 mph.Then truck started jerking again , like transmission issue. Engine light and tool wrench came on. As I was pulling in driveway, truck went into “limp” mode. Had it towed to Gullo Ford Conroe. Now they are saying need new transmission due to Internal transmission failure! Shouldn’t Ford. Over this! Only 60,000 mile warranty.
NHTSA complaint #11706629 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has confirmed the malfunction is caused by the blend door system, yet they have refused goodwill coverage for a repair that requires full dash removal and replacement of a known defective part. There were no warning lights, but the clicking noise and loss of temperature control began well before the warranty expired. The vehicle continues to experience the defect, and it poses an ongoing visibility and safety risk. Ford has acknowledged this exact failure mode in writing (SSM 49264), but has not issued a recall or safety campaign.
NHTSA complaint #11704505 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
Repeated failure of HVAC system, even after repairs, leads to not only a very cold truck in January in Maine, but inability to defrost the windshield and keep it defrosted. Repairs have been made in January 2025, April 2025, and now has to be repaired again in December 2025. My independent service provider who subscribes to OEM Ford subscriptions, was not made aware of an "internal" service memo until now. Neither from the subscription services or from contacts at a Ford dealer where he resourced parts and repair info. SSM 51313 indicates a different repair than was made on the previous two attempts. These repairs require the disassembly and reassembly of the instrument panel and are very expensive - especially when not apprised of correct. Now the SSM indicates a complete housing replacement to correct the defective part. See attached forms.
NHTSA complaint #11703201 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
since 2020 i have owned this ford ranger edge and have replaced drivers side exterior door handle 4 times, interior drivers side door handle 2 times and exterior passenger door handle 2 times. they keep breaking at the clip on the left side. It has been so bad that i actually had drivers side interior and exterior door handles break and could not get in on drivers side. It has caused me to be late for work, terminated from one service job, and a lot of stress. I have ordered handles a total of 5 times. Not any have been of quality to be called "Built Ford Tough"
NHTSA complaint #11700239 — an unverified report by a vehicle owner.