FaultScore report
Owners have filed 536 complaints about the 1997 Ford Ranger with NHTSA between 1997 and 2021. The largest single group is the fuel & propulsion. Across this model's run it ranks 9 of 26 worst.
FaultScore 65/100
Higher is worse. Measured against the other years of the Ford Ranger.
How this is worked out536
Complaints
43
Crashes reported
10
Fires reported
33
Injuries reported
1 complaint reports a death.
100,000 mi
Median mileage at failure
Half of reported failures happened before this
10%
Failed under 36,000 miles
Inside a typical bumper-to-bumper warranty
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
2 crashes, 0 fires · median 63,300 mi
Median failure at 1,500 miles
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
FRONT SEAT BELT
STEERING KNUCKLE SEPARATIONS
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
VEHICLE SPEED CONTROL
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
TIRES:TREAD/BELT
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Risk: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
TIRES:TREAD/BELT
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
Risk: IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Other
On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Dealers will install a new switch or fused wiring harness. Note: This is an expansion of recall 2005028 (05S28) for vehicles not previously included in the campaign.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH MELTED. THE CONTACT STATED THAT HE HAD NOT EXPERIENCED A FAILURE PRIOR TO THE VEHICLE BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA complaint #10806187 — an unverified report by a vehicle owner.
AIR BAGS
WE WERE DOING 30MPH AND WE HIT A SHEET OF BLACK ICE. THEN WE HIT THE GUARDRAIL. WHEN WE HIT THE DRIVER SIDE AIR BAG DID NOT GO OFF UNTIL THE VEHICLE STOPPED AND THE PASSENGER SIDE AIR BAG DID NOT GO OFF.
NHTSA complaint #10496773 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
I CAME OUTSIDE TO MY 1997 FORD RANGER XLT AND IT WAS ON FIRE UNDER THE HOOD AN IN THE CAB ALREADY. THEN IT EXPLODED!
NHTSA complaint #10301995 — an unverified report by a vehicle owner.
SERVICE BRAKES, ELECTRIC
DROVE MY 1997 FORD RANGER TRUCK TO LUNCH AT WORK UPON RETURNING SITTING DOWN FOR 10 MINUTES A COWORKER RAN INTO THE PLANT SAYING MY TRUCK WAS ON FIRE MY MASTER CYLINDER FOR MY BRAKES WAS ON FIRE AND WAS PUT OUT THERE IS ALOT OF DAMAGE. I BELIEVE WAS CAUSED BY DEFECTIVE ABS BREAK SENSOR DON'T KNOW IF THERE IS A RECALL ON THEM OR NOT HOPE YOU CAN HELP.
NHTSA complaint #10284635 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
CONSUMER STATES THAT A COMPLAINT WAS MADE IN JUNE OF 2002 ABOUT A ROLLOVER ACCIDENT IN HER 1997 FORD RANGER AND WOULD LIKE AN INVESTIGATION OPEN.
NHTSA complaint #10263371 — an unverified report by a vehicle owner.
STRUCTURE:BODY:ROOF AND PILLARS
ROOF SUPPORT/ VEHICLE HAS A TENDENCY TO BOUNCE ALL OVER THE ROAD BAD SUSPENSION! HIGHER CENTER GRAVITY! MORE ACCESSIBLE TO ROLL, NOT ONLY TO ROLL AND LOSE CONTROL THE ROOF SUPPORT IS NOTHING BUT THIN CHEAP METAL THAT CAN BE EASILY SMUSHED. I KNOW I BROKE MY NECK AND NOW I AM DISABLE....FORD RANGERS SHOULDN'T BE ON THE ROAD WITH A HIGHER CENTER OF GRAVITY...MAKE THEM SAFER....WIDER OR LOWER BUT NOT THE WAY THEY ARE NOW TRUCK IS A HAZARD A LIFE THREATENING HAZARD..MORE WAYS THAN ONE!
NHTSA complaint #10140673 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE INSPECTION AT HALDEMAN FORD OF KUTZTOWN, INC. (15465 KUTZTOWN RD, KUTZTOWN, PA 19530, (610) 683-3553) THE MECHANIC DETERMINED THAT THE FRONT AND REAR SUBFRAME WAS SEVERELY CORRODED. AFTER HAVING AN EMISSIONS INSPECTION, THE VEHICLE WAS DEEMED UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 154,000.
NHTSA complaint #11396643 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS
NHTSA complaint #11360828 — an unverified report by a vehicle owner.
ENGINE
FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS
NHTSA complaint #11360828 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
FORD RANGER 4X4 XLT 4.0L HAS HAD PROBLEMS FROM THE BEGINNING FRONT TIRES TWO OUT , FOG LIGHTS, AIR CONDITIONING, TRANSMISSION SHIFT POINTS , CHECK ENGINE LIGHT WHEN NEW AND TO THIS DAY GAS MILEAGE NOT AS STATED ON WINDOW STICKER ,ALSO WINDOWS MOTOR AND CONTROLS
NHTSA complaint #11360828 — an unverified report by a vehicle owner.
UNKNOWN OR OTHER
BELT SEPARATION ON 2 TIRES IN ONE MONTH TIME SPAN. FUSION TOURING 195 70R14 91T. THESE TIRES HAVE 8/32 TREAD REMAINING. FAILURES WERE FRONT RIGHT, THEN LEFT READ ONE MONTH LATER. CAUSED DIFFICULTY STEERING AS THE CAR WAS ALL OVER THE ROAD PLUS BUMPY RIDE. THE TIRES ARE VISIBLY BULGING BALOON. I FELT TIRE TEMP WITH MY HAND. UNIFORMLY WARM EXCEPT AT THE BULGE WHERE IT WAS SO HOT AS TO BURN MY HAND. WOULD NTSB LIKE ME TO SAVE A TIRE FOR EVALUATION? THIS SECOND TIRE FAILURE OCCURRED AT 70 MPH ON I-94 IN MICHIGAN WHEN A SUDDEN VIBRATION OCCURRED AND I OBSERVED THE LEFT REAR FENDER BOUNCING UP AND DOWN. I STOPPED TO INVESTIGATE AND FOUND THE BULGE AND HOT SPOT.
NHTSA complaint #11149672 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 1997 FORD RANGER. UPON INSPECTION, IT WAS DISCOVERED THAT THE FUEL TANK WAS NOT SECURED AND WAS HANGING FROM THE SUBFRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FAILURE WAS CAUSED BY SEVERE RUSTING AND CORROSION OF THE SUBFRAME. THE FAILURE WAS NOT REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 233,479.
NHTSA complaint #11101460 — an unverified report by a vehicle owner.
STRUCTURE:BODY
EXCESSIVE RUST NOT CAUSED BY NORMAL WEAR AND TEAR, HAD SPARE TIRE CARRIER RUST OFF WHILE ON THE ROAD
NHTSA complaint #11080036 — an unverified report by a vehicle owner.
AIR BAGS
TAKATA RECALL -- I BELIEVE ALL AIRBAGS ARE DEFECTIVE AND MORE DANGEROUS THAN RIDING WITH SEAT BELTS ALONE. I RECOMMEND 100% DISABLING OF AIRBAGS AND THE REMOVAL OF ALL AIRBAGS AND ASSOCIATED HARDWARE FROM FUTURE VEHICLES.
NHTSA complaint #11006379 — an unverified report by a vehicle owner.
TIRES
I HAD FIVE (5) BF GOODRICH RADIAL ALL TERRAIN TA TIRES FAIL WHILE DRIVING THE SAME VEHICLE OVER ABOUT A TEN YEAR PERIOD. EACH FAILURE IS THE SAME. THE STEEL BELT OF THE TIRE PARTIALLY SEPARATES WHILE ROLLING. THE FIRST OCCURRED ABOUT TEN YEARS AGO ON THE INTERSTATE WHILE PULLING A SMALL FLATBED TRAILER. STEEL BELT THEN WHIPS AROUND INSIDE WHEEL WELL DAMAGING WHATEVER IT COMES IN CONTACT WITH. BF GOODRICH RADIAL ALL TERRAIN TA TIRES WERE ON THIS TRUCK WHEN PURCHASED USED. SECOND TIRE FAILED APPROXIMATELY THREE YEARS AGO THE SAME WAY AT LESS THAN 30 MPH. REPLACED ALL WITH USED SET OF FOUR TIRES WITH 50 % TREAD LEFT. LESS THAN A MONTH AFTER, THIRD TIRE FAILED ON INTERSTATE ONCE AGAIN IN THE SAME WAY. STEEL BELT CUT THE FIBERGLASS REAR OUTER FENDER IN HALF, RIPPED OUT THE REAR WIRING HARNESS, DESTROYED THE LEFT TAIL LIGHT, AND EVEN DAMAGED THE GASOLINE FILL TUBE AND DESTROYED ITS LOCKING GAS CAP FROM THE FORCE OF THE BELT WHIPPING ROUND AND ROUND THE WHEEL, PARTIALLY ATTACHED AND PARTIALLY OFF. NEARLY LOST CONTROL OF VEHICLE, BUT WAS NOT INVOLVED IN ACCIDENT. ALL TIRES FAILED WHILE IN DRIVER'S REAR WHEEL POSITION. THEN LAST MONTH AGAIN, THE LEFT REAR BF GOODRICH RADIAL ALL TERRAIN TA TIRE STEEL BELT CAME PARTIALLY OFF AT ABOUT 30 MPH. EACH TIME A USED TIRE REPLACED THE FAILED TIRE. THEN TWO DAYS LATER, A FIFTH BF GOODRICH RADIAL ALL TERRAIN TA BEGAN TO FAIL WITH STEEL BELT COMING APART. THIS TIME RIGHT REAR WHEEL LOCATION. NOTICED THE FAILURE BEFORE STEEL BELT CAME COMPLETELY OFF AND ANY DAMAGE WAS DONE. REPLACED WITH BF GOODRICH MUD TERRAIN TA THAT WERE ALSO USED BUT HAVE NOT FAILED.
NHTSA complaint #11000343 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
THE DOME LIGHT STARTED TURNING ITSELF ON WHILE PARKED IN FRONT OF MY HOUSE. SOMETIMES IT WOULD TURN ITSELF BACK OFF. IT WOULD ALSO TURN ON WHILE I WAS DRIVING AT NIGHT. I COULDN'T GET THE LIGHT COVER OFF SO I PULLED THE FUSE WHICH LEAVES ME WITH NO WINDSHIELD WASHER SQUIRTER. THE CHECK ENGINE LIGHT IS ALWAYS ON. NO MATER WHAT IS DONE OR FIXED, THE LIGHT STAYS ON WHICH IS A PROBLEM BECAUSE CARS WILL USUALLY AUTOMATICALLY FAIL INSPECTION WHEN THE CHECK ENGINE LIGHT IS ON. HOW AM I SUPPOSED TO GET IT TO PASS INSPECTION IF ITS ON 90% OF THE TIME? I NEVER HAD A PROBLEM WITH MY 93 RANGER BUT OTHER PEOPLE WITH RANGERS HAVE HAD THE SAME ISSUES & THIS SITE SHOWS OTHERS WITH THE SAME ISSUES. WHY WON'T FORD RECALL & FIX IT WHEN ITS A KNOWN PROBLEM? THESE THINGS ARE SAFETY ISSUES!! I CAN'T ADD WHEN THESE THINGS HAPPEN BECAUSE THEY ARE ONGOING ISSUES FOR THE LAST TENISH YEARS!
NHTSA complaint #10995244 — an unverified report by a vehicle owner.
ENGINE
THE DOME LIGHT STARTED TURNING ITSELF ON WHILE PARKED IN FRONT OF MY HOUSE. SOMETIMES IT WOULD TURN ITSELF BACK OFF. IT WOULD ALSO TURN ON WHILE I WAS DRIVING AT NIGHT. I COULDN'T GET THE LIGHT COVER OFF SO I PULLED THE FUSE WHICH LEAVES ME WITH NO WINDSHIELD WASHER SQUIRTER. THE CHECK ENGINE LIGHT IS ALWAYS ON. NO MATER WHAT IS DONE OR FIXED, THE LIGHT STAYS ON WHICH IS A PROBLEM BECAUSE CARS WILL USUALLY AUTOMATICALLY FAIL INSPECTION WHEN THE CHECK ENGINE LIGHT IS ON. HOW AM I SUPPOSED TO GET IT TO PASS INSPECTION IF ITS ON 90% OF THE TIME? I NEVER HAD A PROBLEM WITH MY 93 RANGER BUT OTHER PEOPLE WITH RANGERS HAVE HAD THE SAME ISSUES & THIS SITE SHOWS OTHERS WITH THE SAME ISSUES. WHY WON'T FORD RECALL & FIX IT WHEN ITS A KNOWN PROBLEM? THESE THINGS ARE SAFETY ISSUES!! I CAN'T ADD WHEN THESE THINGS HAPPEN BECAUSE THEY ARE ONGOING ISSUES FOR THE LAST TENISH YEARS!
NHTSA complaint #10995244 — an unverified report by a vehicle owner.
STRUCTURE:BODY
FARMR RUSTED THROUGH TRUCK WAS SITTING AT HOME PARKED WHEN IT BROKE THROUGH
NHTSA complaint #10971028 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
IDLE SPEED RISES TO 3,000 RPM IN BETWEEN SHIFTS AND WHILE COASTING WITH CLUTCH PEDAL DEPRESSED. DOES NOT DROP TO NORMAL IDLE SPEED UNTIL VEHICLE COMES TO A COMPLETE STOP. THIS CAUSES BRAKING TO BE LESS EFFECTIVE.
NHTSA complaint #10883846 — an unverified report by a vehicle owner.
ENGINE
IDLE SPEED RISES TO 3,000 RPM IN BETWEEN SHIFTS AND WHILE COASTING WITH CLUTCH PEDAL DEPRESSED. DOES NOT DROP TO NORMAL IDLE SPEED UNTIL VEHICLE COMES TO A COMPLETE STOP. THIS CAUSES BRAKING TO BE LESS EFFECTIVE.
NHTSA complaint #10883846 — an unverified report by a vehicle owner.
SERVICE BRAKES
IDLE SPEED RISES TO 3,000 RPM IN BETWEEN SHIFTS AND WHILE COASTING WITH CLUTCH PEDAL DEPRESSED. DOES NOT DROP TO NORMAL IDLE SPEED UNTIL VEHICLE COMES TO A COMPLETE STOP. THIS CAUSES BRAKING TO BE LESS EFFECTIVE.
NHTSA complaint #10883846 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1997 FORD RANGER. THE CONTACT STATED THAT THE SPEED CONTROL SWITCH MELTED. THE CONTACT STATED THAT HE HAD NOT EXPERIENCED A FAILURE PRIOR TO THE VEHICLE BEING REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.
NHTSA complaint #10806187 — an unverified report by a vehicle owner.
SUSPENSION
REAR LEAF SPRING HANGERS/SHACKLES RUSTED OFF AS WELL AS THE FRONT ONES ON THE REAR LEAF SPRINGS. SPARE TIRE CARRIER FELL DOWN DRAGGING THE SPARE TIRE ACROSS THE ROAD. ONE CROSSMEMBER HOLDING UP THE FRONT OF THE GAS TANK IS READY TO GO. BOTH GAS TANK STRAPS ROTTED OFF. TOYOTA WAS MADE TO FIX THESE ISSUES. WHY NOT FORD? I WORK AT A TOYOTA DEALERSHIP REPLACING ROTTEN FRAMES ON TUNDRAS, SEQUOIAS, AND TACOMA VEHICLES. THERE IS NO DIFFERENCE AS BOTH THE FRAMES FOR TOYOTA AND FORD ARE BUILT AT THE SAME FACTORY IF I AM CORRECT? THE VEHICLE WAS BEING DRIVEN DOWN THE ROAD ALL TIMES THE ABOVE LISTED FAILED. SOME TIMES ON THE HIGHWAY, OTHERS IN TOWN. I DO NOT FEEL SAFE SELLING THIS VEHICLE TO ANOTHER INDIVIDUAL WHEN IT'S READY TO GO.
NHTSA complaint #10781853 — an unverified report by a vehicle owner.
EXTERIOR LIGHTING
GUY NEXT DOOR KNOCKED ON MY DOOR LATE ONE NIGHT TO TELL ME THAT MY DOME LIGHT WAS ON. I LOOKED & IT WASN'T. HE SAID THAT WAS ODD BECAUSE HE EVEN WALKED BY IT & COULD SEE INSIDE. A FEW DAYS LATER IT HAPPENED AGAIN. THEN WHILE DRIVING AT NIGHT THE LIGHT CAME ON BY ITSELF. FROM THAT POINT ON IT WOULD RANDOMLY TURN ITSELF ON. NATURALLY FORD TOLD ME THAT WAS IMPOSSIBLE. THE ONLY WAY I COULD STOP IT WITHOUT PAYING A TON OF MONEY TO A GARAGE WAS TO PULL THE FUSE & I'VE HAD TO USE A FLASHLIGHT IF I NEED A LIGHT AT NIGHT EVER SINCE. MY TRUCK ALSO HAS A THEFT LIGHT BECAUSE A FACTORY ALARM WAS AN OPTION FOR MY TRUCK. I DO NOT HAVE AN ALARM BUT THE WORD ALARM IS STILL ON THE PANEL. THAT LIGHT WILL RANDOMLY TURN ON & SAY THEFT. I DO NOT HAVE AN ALARM! I TOLD FORD & THAT TOLD ME THAT WAS IMPOSSIBLE SINCE I DON'T HAVE AN ALARM. I SAID THAT MAYBE A WIRE WAS CROSSED SOMEWHERE BUT FORD TOLD ME," NO! ". TALKING TO OTHER RANGER OWNERS HERE & THERE I'VE FOUND OUT THAT NOT ONLY ARE THERE OTHERS DOING THE EXACT SAME THINGS BUT IT IS ALSO OTHER YEARS BESIDES 1997. I LIKE THE TRUCK JUST TIRED OF FORD & TIRED OF THE BS!!
NHTSA complaint #10744089 — an unverified report by a vehicle owner.
INTERIOR LIGHTING
GUY NEXT DOOR KNOCKED ON MY DOOR LATE ONE NIGHT TO TELL ME THAT MY DOME LIGHT WAS ON. I LOOKED & IT WASN'T. HE SAID THAT WAS ODD BECAUSE HE EVEN WALKED BY IT & COULD SEE INSIDE. A FEW DAYS LATER IT HAPPENED AGAIN. THEN WHILE DRIVING AT NIGHT THE LIGHT CAME ON BY ITSELF. FROM THAT POINT ON IT WOULD RANDOMLY TURN ITSELF ON. NATURALLY FORD TOLD ME THAT WAS IMPOSSIBLE. THE ONLY WAY I COULD STOP IT WITHOUT PAYING A TON OF MONEY TO A GARAGE WAS TO PULL THE FUSE & I'VE HAD TO USE A FLASHLIGHT IF I NEED A LIGHT AT NIGHT EVER SINCE. MY TRUCK ALSO HAS A THEFT LIGHT BECAUSE A FACTORY ALARM WAS AN OPTION FOR MY TRUCK. I DO NOT HAVE AN ALARM BUT THE WORD ALARM IS STILL ON THE PANEL. THAT LIGHT WILL RANDOMLY TURN ON & SAY THEFT. I DO NOT HAVE AN ALARM! I TOLD FORD & THAT TOLD ME THAT WAS IMPOSSIBLE SINCE I DON'T HAVE AN ALARM. I SAID THAT MAYBE A WIRE WAS CROSSED SOMEWHERE BUT FORD TOLD ME," NO! ". TALKING TO OTHER RANGER OWNERS HERE & THERE I'VE FOUND OUT THAT NOT ONLY ARE THERE OTHERS DOING THE EXACT SAME THINGS BUT IT IS ALSO OTHER YEARS BESIDES 1997. I LIKE THE TRUCK JUST TIRED OF FORD & TIRED OF THE BS!!
NHTSA complaint #10744089 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM
GUY NEXT DOOR KNOCKED ON MY DOOR LATE ONE NIGHT TO TELL ME THAT MY DOME LIGHT WAS ON. I LOOKED & IT WASN'T. HE SAID THAT WAS ODD BECAUSE HE EVEN WALKED BY IT & COULD SEE INSIDE. A FEW DAYS LATER IT HAPPENED AGAIN. THEN WHILE DRIVING AT NIGHT THE LIGHT CAME ON BY ITSELF. FROM THAT POINT ON IT WOULD RANDOMLY TURN ITSELF ON. NATURALLY FORD TOLD ME THAT WAS IMPOSSIBLE. THE ONLY WAY I COULD STOP IT WITHOUT PAYING A TON OF MONEY TO A GARAGE WAS TO PULL THE FUSE & I'VE HAD TO USE A FLASHLIGHT IF I NEED A LIGHT AT NIGHT EVER SINCE. MY TRUCK ALSO HAS A THEFT LIGHT BECAUSE A FACTORY ALARM WAS AN OPTION FOR MY TRUCK. I DO NOT HAVE AN ALARM BUT THE WORD ALARM IS STILL ON THE PANEL. THAT LIGHT WILL RANDOMLY TURN ON & SAY THEFT. I DO NOT HAVE AN ALARM! I TOLD FORD & THAT TOLD ME THAT WAS IMPOSSIBLE SINCE I DON'T HAVE AN ALARM. I SAID THAT MAYBE A WIRE WAS CROSSED SOMEWHERE BUT FORD TOLD ME," NO! ". TALKING TO OTHER RANGER OWNERS HERE & THERE I'VE FOUND OUT THAT NOT ONLY ARE THERE OTHERS DOING THE EXACT SAME THINGS BUT IT IS ALSO OTHER YEARS BESIDES 1997. I LIKE THE TRUCK JUST TIRED OF FORD & TIRED OF THE BS!!
NHTSA complaint #10744089 — an unverified report by a vehicle owner.
SEAT BELTS
AIR BAGS.. DEFLATING, UNSERVICEABLE, DEMAND USELESS, ONLY ON PASSENGER SIDE, DRIVERS SIDE DISLODGED HORN FUEL/PROPULSION.. WITH FUEL TANK FILLED, FIRST HALF(1/2) TANK HAVING EXCESSIVE FUEL CONSUMED. SECOND (1/2) OF FUEL CONSUMED AT OWNERS MANUAL SPECIFICATIONS OF CITY AND HIGHWAY MILES PER GALLON. THROTTLE PEDAL STIFF, STICKS, AFTER NORMAL DAILY WARM UP, EXTRA FOOT PRESSURE NEEDED TO DISLODGE PEDAL AND CABLE, REAL SLUGGISH AS IF NOT RECEIVING ENOUGH FUEL TO INJECTORS, EVEN AFTER REGULAR MAINTENANCE COMPLETED.. SEAT BELTS.. DRIVERS SIDE HOOKUP RETAINING LATCH MALFUNCTIONS AND " WILL NOT REMAIN LATCHED", SEVERAL ATTEMPTS NEED TO BE MADE BEFORE GETTING A STRONG SEATBELT CLIP TO LATCH LOCKED ON
NHTSA complaint #10725116 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAGS.. DEFLATING, UNSERVICEABLE, DEMAND USELESS, ONLY ON PASSENGER SIDE, DRIVERS SIDE DISLODGED HORN FUEL/PROPULSION.. WITH FUEL TANK FILLED, FIRST HALF(1/2) TANK HAVING EXCESSIVE FUEL CONSUMED. SECOND (1/2) OF FUEL CONSUMED AT OWNERS MANUAL SPECIFICATIONS OF CITY AND HIGHWAY MILES PER GALLON. THROTTLE PEDAL STIFF, STICKS, AFTER NORMAL DAILY WARM UP, EXTRA FOOT PRESSURE NEEDED TO DISLODGE PEDAL AND CABLE, REAL SLUGGISH AS IF NOT RECEIVING ENOUGH FUEL TO INJECTORS, EVEN AFTER REGULAR MAINTENANCE COMPLETED.. SEAT BELTS.. DRIVERS SIDE HOOKUP RETAINING LATCH MALFUNCTIONS AND " WILL NOT REMAIN LATCHED", SEVERAL ATTEMPTS NEED TO BE MADE BEFORE GETTING A STRONG SEATBELT CLIP TO LATCH LOCKED ON
NHTSA complaint #10725116 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
AIR BAGS.. DEFLATING, UNSERVICEABLE, DEMAND USELESS, ONLY ON PASSENGER SIDE, DRIVERS SIDE DISLODGED HORN FUEL/PROPULSION.. WITH FUEL TANK FILLED, FIRST HALF(1/2) TANK HAVING EXCESSIVE FUEL CONSUMED. SECOND (1/2) OF FUEL CONSUMED AT OWNERS MANUAL SPECIFICATIONS OF CITY AND HIGHWAY MILES PER GALLON. THROTTLE PEDAL STIFF, STICKS, AFTER NORMAL DAILY WARM UP, EXTRA FOOT PRESSURE NEEDED TO DISLODGE PEDAL AND CABLE, REAL SLUGGISH AS IF NOT RECEIVING ENOUGH FUEL TO INJECTORS, EVEN AFTER REGULAR MAINTENANCE COMPLETED.. SEAT BELTS.. DRIVERS SIDE HOOKUP RETAINING LATCH MALFUNCTIONS AND " WILL NOT REMAIN LATCHED", SEVERAL ATTEMPTS NEED TO BE MADE BEFORE GETTING A STRONG SEATBELT CLIP TO LATCH LOCKED ON
NHTSA complaint #10725116 — an unverified report by a vehicle owner.
FUEL/PROPULSION SYSTEM
LOOKED UNDER MY FORD RANGER AND SAW THAT BOTH OF THE METAL STRAPS THAT HOLD THE FUEL TANK TO THE VEHICLE HAD RUSTED THROUGH AND BROKEN IN HALF. I SAW THAT THERE WAS A RECALL FOR THE SAME ISSUES ON MY YEAR, BUT ONLY FOR THE FORD F150, NOT THE FORD RANGER, EVEN THOUGH THE ISSUE IS THE SAME.
NHTSA complaint #10715470 — an unverified report by a vehicle owner.
WHEELS
WHEEL BEARINGS KEEP GOING OUT ON FRONT TIRES BECOMING A REAL ISSUE AND HAZARD AND SAFETY THEY LOCK UP ON ROAD AND HAVE GOTTEN SLIDES OFF ROAD. AFRAID IT WILL BE WORSE NEXT TIME. THEY HAVE GONE OUT THREE TIMES AND BEEN REPLACED. THEY ARE GOING OUT AGAIN AND FEAR FOR OUR SAFETY BUT THIS IS OUR ONLY VEHICLE FOR WORK AN APPOINTMENT NEED THIS TRUCK. PLEASE HELP. I DON'T HAVE THE MONEY TO KEEP REPLACING BUT LOVE THIS TRUCK.
NHTSA complaint #10680431 — an unverified report by a vehicle owner.