Owners have filed 451 complaints
about the 1995 Ford Ranger with NHTSA between 1995 and 2020.
The largest single group is the brakes.
Across this model's run it ranks 14 of 26 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 61
Against the median year of the Ford Ranger. 50 means typical for this
model; 100 means roughly double.
Severity — 74
14.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 0
0% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
25,000 – 49,999 miles
11.7%
50,000 – 74,999 miles
813.6%
75,000 – 99,999 miles
813.6%
100,000 – 149,999 miles
1627.1%
150,000+ miles
2644.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 1995peak 16Oct 2020
NHTSA investigations into the 1995 Ford Ranger
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA02011Opened 2 Jul 2002Closed 21 May 2003SEAT BELTS
SAFETY BELT ASSEMBLY FAILURE
ODI RECEIVED 18 CONSUMER COMPLAINTS AND FORD IDENTIFIED ANOTHER FOUR REPORTS ASSOCIATED WITH THE ALLEGED DEFECT.MOST OF THE COMPLAINTS INDICATE INABILITY TO LATCH THE DRIVER SEAT BELT BUCKLE CAUSED BY A BROKEN LATCH RELEASE SPRING.NONE OF THESE 22 REPORTS RESULTED IN ANY INJURIES OR CRASHES.NO COMPLAINTS HAVE BEEN RECEIVED IN THE PAST 6 MONTHS.FORD CONDUCTED LIFE-CYCLE TESTING ON 6 FIELD SAMPLE BUCKLE ASSEMBLIES.THE RESULTS OF THAT TESTING DEMONSTRATED THAT THE TESTED BUCKLE ASSEMBLIES COULD BE EXPECTED TO OPERATE PROPERLY BEYOND THE EXPECTED LIFE OF THE VEHICLE.BASED ON THE LIMITED NUMBER OF...
Recalls on the 1995 Ford Ranger
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09V399000
VEHICLE SPEED CONTROL
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
08E050000
EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
01X001000
TIRES:TREAD/BELT
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Risk: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
00T005000
TIRES:TREAD/BELT
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
Risk: IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2009292492,877 units in Canada
Other
On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Dealers will install a new switch or fused wiring harness. Note: This is an expansion of recall 2005028 (05S28) for vehicles not previously included in the campaign.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 230,000 milesSouth Jordan, UTFire
WHEELS
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 230,000 milesSouth Jordan, UTFire
EXTERIOR LIGHTING
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 230,000 milesSouth Jordan, UTFire
ENGINE
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 200,000 milesWaynesboro, VACrash1 injured
SEAT BELTS
TL* THE CONTACT OWNED A 1995 FORD RANGER. WHILE DRIVING 35 MPH, THE CONTACT'S VEHICLE WAS INVOLVED IN A CRASH WITH ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT PRETENSIONER FAILED TO OPERATE AS INTENDED. AS A RESULT, THE CONTACT SUFFERED A FRACTURED C7 AND T5 VERTEBRAE. THE CONTACT WAS TRANSPORTED TO THE LOCAL HOSPITAL AND THEN TO UVA MEDICAL CENTER TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. A POLICE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE OFFICE OF CHIEF COUNSEL WOULD RESPOND WITHIN 15 DAYS. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA complaint #11064722 — an unverified report by a vehicle owner.
at 200,000 milesWaynesboro, VACrash1 injured
AIR BAGS
TL* THE CONTACT OWNED A 1995 FORD RANGER. WHILE DRIVING 35 MPH, THE CONTACT'S VEHICLE WAS INVOLVED IN A CRASH WITH ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT PRETENSIONER FAILED TO OPERATE AS INTENDED. AS A RESULT, THE CONTACT SUFFERED A FRACTURED C7 AND T5 VERTEBRAE. THE CONTACT WAS TRANSPORTED TO THE LOCAL HOSPITAL AND THEN TO UVA MEDICAL CENTER TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. A POLICE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE OFFICE OF CHIEF COUNSEL WOULD RESPOND WITHIN 15 DAYS. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA complaint #11064722 — an unverified report by a vehicle owner.
at 226,000 milesDuvall, WACrash
AIR BAGS
BRAKES LOCKED UP A 50 MPH, HIT LARGE GRASS/DIRT BANK AT 40 MPH APROX. AND AIR BAG DID NOT DEPLOY.
NHTSA complaint #10874126 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 230,000 milesSouth Jordan, UTFire
WHEELS
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 230,000 milesSouth Jordan, UTFire
EXTERIOR LIGHTING
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 230,000 milesSouth Jordan, UTFire
ENGINE
I WAS DRIVING DOWN THE ROAD WHEN I SMELLED SMOKE AND SAW FLAMES COMING OUT FROM UNDER THE HOOD AND THE POWER TO THE VEHICLE BEGAN TO CUT OUT MAKING IT DIFFICULT TO MOVE OR STEER THE TRUCK TO SAFETY I THEN EXITED THE VEHICLE AND FLAMES WERE COMING OUT OF THE FRONT PASSENGER SIDE GOOD AND HEADLIGHT. SO I CALLED THE FIRE DEPARTMENT AND THEY CAME AND SPRAYED THE TRUCK PUTTING THE FLAMES OUT. AND CUTTING THE WIRES TO THE BATTERY
NHTSA complaint #11366006 — an unverified report by a vehicle owner.
at 195,000 milesGranville, NY
UNKNOWN OR OTHER
THE REAR HALF OF THE TRUCK FRAME IS ROTTED TO PIECES. THE BRACKETS THAT ARE SUPPOSED TO HOLD THE SHOCKS ARE RUSTED OFF AND MISSING..
NHTSA complaint #11241619 — an unverified report by a vehicle owner.
at 195,000 milesGranville, NY
SUSPENSION
THE REAR HALF OF THE TRUCK FRAME IS ROTTED TO PIECES. THE BRACKETS THAT ARE SUPPOSED TO HOLD THE SHOCKS ARE RUSTED OFF AND MISSING..
NHTSA complaint #11241619 — an unverified report by a vehicle owner.
at 195,000 milesGranville, NY
STRUCTURE:BODY
THE REAR HALF OF THE TRUCK FRAME IS ROTTED TO PIECES. THE BRACKETS THAT ARE SUPPOSED TO HOLD THE SHOCKS ARE RUSTED OFF AND MISSING..
NHTSA complaint #11241619 — an unverified report by a vehicle owner.
at 52,000 milesWahiawa, HI
VEHICLE SPEED CONTROL
CHASSIS FRAME IS RUSTING AWAY. ALL ENAMEL PAINT IS GONE AND CHUNKS OF RUSTED METAL IS FLAKING OFF
NHTSA complaint #11171298 — an unverified report by a vehicle owner.
at 52,000 milesWahiawa, HI
UNKNOWN OR OTHER
CHASSIS FRAME IS RUSTING AWAY. ALL ENAMEL PAINT IS GONE AND CHUNKS OF RUSTED METAL IS FLAKING OFF
NHTSA complaint #11171298 — an unverified report by a vehicle owner.
at 52,000 milesWahiawa, HI
STRUCTURE:BODY
CHASSIS FRAME IS RUSTING AWAY. ALL ENAMEL PAINT IS GONE AND CHUNKS OF RUSTED METAL IS FLAKING OFF
NHTSA complaint #11171298 — an unverified report by a vehicle owner.
at 200,000 milesWaynesboro, VACrash1 injured
SEAT BELTS
TL* THE CONTACT OWNED A 1995 FORD RANGER. WHILE DRIVING 35 MPH, THE CONTACT'S VEHICLE WAS INVOLVED IN A CRASH WITH ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT PRETENSIONER FAILED TO OPERATE AS INTENDED. AS A RESULT, THE CONTACT SUFFERED A FRACTURED C7 AND T5 VERTEBRAE. THE CONTACT WAS TRANSPORTED TO THE LOCAL HOSPITAL AND THEN TO UVA MEDICAL CENTER TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. A POLICE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE OFFICE OF CHIEF COUNSEL WOULD RESPOND WITHIN 15 DAYS. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA complaint #11064722 — an unverified report by a vehicle owner.
at 200,000 milesWaynesboro, VACrash1 injured
AIR BAGS
TL* THE CONTACT OWNED A 1995 FORD RANGER. WHILE DRIVING 35 MPH, THE CONTACT'S VEHICLE WAS INVOLVED IN A CRASH WITH ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT PRETENSIONER FAILED TO OPERATE AS INTENDED. AS A RESULT, THE CONTACT SUFFERED A FRACTURED C7 AND T5 VERTEBRAE. THE CONTACT WAS TRANSPORTED TO THE LOCAL HOSPITAL AND THEN TO UVA MEDICAL CENTER TO SEEK MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT FACILITY. A POLICE REPORT WAS FILED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE OFFICE OF CHIEF COUNSEL WOULD RESPOND WITHIN 15 DAYS. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.
NHTSA complaint #11064722 — an unverified report by a vehicle owner.
at 133,282 milesKenova, WV
UNKNOWN OR OTHER
THE FRAME IS RUSTED THROUGH AND CRACKED ON THE LEFT REAR END. THE BARS TO SUPPORT THE DRIVE SHAFT IS RUSTED OFF AND THE MOUNTS FOR THE REAR SPRINGS HAVE BEEN REPAIRED ONCE AND ARE ALMOST RUSTED OFF AGAIN. THERE IS HEAVY RUST ON THE RIGHT SIDE FRAME BUT NOT RUSTED THROUGH. THE TRUCK BODY HAS ONLY 3 SURFACE RUST MARKS AND 2 SMALL DINGS. THE TRUCK HAS ORIGINAL PAINT (EXCEPT FOR LEFT FENDER AND HOOD). TRUCK WAS GARAGE KEPT AND INTERIOR IS PERFECT.
NHTSA complaint #10968783 — an unverified report by a vehicle owner.
at 226,000 milesDuvall, WACrash
AIR BAGS
BRAKES LOCKED UP A 50 MPH, HIT LARGE GRASS/DIRT BANK AT 40 MPH APROX. AND AIR BAG DID NOT DEPLOY.
NHTSA complaint #10874126 — an unverified report by a vehicle owner.
at 175,000 milesLatrobe, PA
UNKNOWN OR OTHER
MY COMPLAINT IS THE VEHICLE FRAME, SPECIFICALLY THE REAR MOST PART WHERE THE REAR BUMPER MOUNTS TO THE FRAME. THE FRAME IS FULL OF RUST HOLES IN THAT AREA AND I CAN ONLY SURMISE IN A LIGHT REAR END COLLISION THAT THIS AREA WILL CRUMBLE. THIS IS ABSOLUTLY A FAILUREBY FORD TO ISSUE A RECALL WITH A PROPER REPAIR! NOW AT THE OWNERS EXPENSE, NOT INEXOENSIVE BY ANY MEANS A FULL FRAME OR REAR FRAME SECTION REPLACEMENT! THIS IS ON MANY RANGERS, IN FACT I REPLACED A FRAME ON A FAMILIES1997, TOTAL BALONEY! WHO ADE THE FRAME TOYOTA?!!
NHTSA complaint #10852795 — an unverified report by a vehicle owner.
at 200,000 milesAshtabula, OH
SUSPENSION
1995 FORD RANGER. MY NEPHEW WAS DRIVING ON THE HIGHWAY WHEN THE RIGHT REAR SHACKLE LET LOOSE AND HE LOST STABILITY. I REPLACED BOTH RIGHT SIDE FRONT AND REAR SHACKLES. I PULLED THE BED OFF TO REPLACE THE SENDING UNIT AND FOUND BOTH LEFT SIDE SHACKLES ROTTED, LEFT SIDE FRAME ROTTED IN HALF, CROSS MEMBER, GAS TANK SPLASH PAN AND STRAPS, ALONG WITH ALL CAB MOUNTS ROTTED COMPLETELY. I PARKED THE TRUCK AND HAVE NOT DROVE IT SCIENCE 2012. THE BODY IS BEAUTIFUL, AND ALL THE MECHANICS HAVE BEEN KEPT UP. I DON'T WANT TO GIVE UP ON THIS TRUCK.
NHTSA complaint #10809479 — an unverified report by a vehicle owner.
Westville, IN
SUSPENSION
ALL LEAF SPRING BRACKETS AND FRAME HAVE RUSTED OUT COMPLETELY IT IS MY UNDERSTANDING THAT THIS IS A COMMON DEFECT AND HAVE SEEN THIS MANY TIMES.
NHTSA complaint #10795266 — an unverified report by a vehicle owner.
Laurens, SC
AIR BAGS
I'M INTERESTED IN KNOWING ABOUT THE SAFETY OF MY PASSENGERS AS OF RIGHT NOW I HAVE TO CUT OFF THE PASSENGER SIDE AIRBAG / AND AM WORRIED ABOUT TRANSPORTING MY YOUNG GREAT NEICE & OR NEPHEW PICKING THEM UP FROM SOME SCHOOL FUNCTIONS ....AND WOULD APPRECIATE A CALL OR LETTER KNOWING THIS IS GOING TO SOON BE TAKEN CARE OF ..THANKS
NHTSA complaint #10780049 — an unverified report by a vehicle owner.
at 194,785 milesLitchfield, MI
SUSPENSION
I HAVE HAD TO REPLACE 3 OF THE 4 SHACKLES IN MY RANGER DUE TO THEM RUSTING OFF AND BREAKING. THE FOURTH SHACKLE IS WELL ON ITS WAY TO BEING RUSTED OFF. THE FRAME OF THE TRUCK SEEMS TO BE GETTING WEAK IN THE SPOTS AROUND THE SHACKLES AS WELL.
NHTSA complaint #10712963 — an unverified report by a vehicle owner.
at 193,278 milesRiver, KY
SUSPENSION
I WAS DRIVING AT WORK GOING FROM POINT A TO POINT B AND I HEARD THE REAR BRAKES GRINDING, METAL TO METAL SOUND, WAS GOING ABOUT 40 MPH, SLOW DOWN AND MADE IT TO POINT B, ABOUT 1 MILE, IN TOWN.... PARKED AND CHECKED UNDER THE TRUCK.... AND DISCOVERED THE EMERGENCY BRAKE CABLE WAS STRETCHED TIGHT... CRAWLED UNDER TRUCK AND DISCOVERED THAT FRAME WAS RUSTED IN HALF (BROKEN ALL THE WAY THRU) ON DRIVER'S SIDE AND PASSENGER SIDE WAS ALMOST AS BAD.... ALSO A CROSS MEMBER WAS RUSTED AWAY... AND THE DRIVER'S SIDE SHOCK WAS HANGING DOWN (BRACKET RUSTED AWAY) TRUCK IS NOW PARKED AT HOME CAN'T FIX IT.... HAD TO BUY A USED VAN FROM MY BOSS SO I COULD GET TO WORK..... I WILL HAVE TO JUNK THE TITLE IN THE NEXT FEW DAYS.... TRUCK RUNS FINE BUT JUST CAN'T FIX A RUSTED OUT FRAME... NOT SAFE FOR ANYONE TO DRIVE... BY THE WAY THE END OF THE FRAME WHERE THE REAR BUMPER ATTACHES RUSTED ABOUT 18 MONTHS AGO AND HAD TO PUT 1/2 INCH STEEL IN TO REATTACH IT.... THE FRAME WAS A LITTLE RUSTY AT THAT TIME BUT NO HOLES OR BREAKS.... I THINK FORD SHOULD COMPENSATE ALL RANGER OWNERS FOR RUSTED OUT FRAMES, I HAVE READ BLOGS AND THERE ARE A LOT OF THESE RANGER FRAMES RUSTED OUT... I HAVE PICTURES IF NEEDED...
NHTSA complaint #10712102 — an unverified report by a vehicle owner.
at 193,278 milesRiver, KY
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
I WAS DRIVING AT WORK GOING FROM POINT A TO POINT B AND I HEARD THE REAR BRAKES GRINDING, METAL TO METAL SOUND, WAS GOING ABOUT 40 MPH, SLOW DOWN AND MADE IT TO POINT B, ABOUT 1 MILE, IN TOWN.... PARKED AND CHECKED UNDER THE TRUCK.... AND DISCOVERED THE EMERGENCY BRAKE CABLE WAS STRETCHED TIGHT... CRAWLED UNDER TRUCK AND DISCOVERED THAT FRAME WAS RUSTED IN HALF (BROKEN ALL THE WAY THRU) ON DRIVER'S SIDE AND PASSENGER SIDE WAS ALMOST AS BAD.... ALSO A CROSS MEMBER WAS RUSTED AWAY... AND THE DRIVER'S SIDE SHOCK WAS HANGING DOWN (BRACKET RUSTED AWAY) TRUCK IS NOW PARKED AT HOME CAN'T FIX IT.... HAD TO BUY A USED VAN FROM MY BOSS SO I COULD GET TO WORK..... I WILL HAVE TO JUNK THE TITLE IN THE NEXT FEW DAYS.... TRUCK RUNS FINE BUT JUST CAN'T FIX A RUSTED OUT FRAME... NOT SAFE FOR ANYONE TO DRIVE... BY THE WAY THE END OF THE FRAME WHERE THE REAR BUMPER ATTACHES RUSTED ABOUT 18 MONTHS AGO AND HAD TO PUT 1/2 INCH STEEL IN TO REATTACH IT.... THE FRAME WAS A LITTLE RUSTY AT THAT TIME BUT NO HOLES OR BREAKS.... I THINK FORD SHOULD COMPENSATE ALL RANGER OWNERS FOR RUSTED OUT FRAMES, I HAVE READ BLOGS AND THERE ARE A LOT OF THESE RANGER FRAMES RUSTED OUT... I HAVE PICTURES IF NEEDED...
NHTSA complaint #10712102 — an unverified report by a vehicle owner.
at 193,278 milesRiver, KY
SERVICE BRAKES
I WAS DRIVING AT WORK GOING FROM POINT A TO POINT B AND I HEARD THE REAR BRAKES GRINDING, METAL TO METAL SOUND, WAS GOING ABOUT 40 MPH, SLOW DOWN AND MADE IT TO POINT B, ABOUT 1 MILE, IN TOWN.... PARKED AND CHECKED UNDER THE TRUCK.... AND DISCOVERED THE EMERGENCY BRAKE CABLE WAS STRETCHED TIGHT... CRAWLED UNDER TRUCK AND DISCOVERED THAT FRAME WAS RUSTED IN HALF (BROKEN ALL THE WAY THRU) ON DRIVER'S SIDE AND PASSENGER SIDE WAS ALMOST AS BAD.... ALSO A CROSS MEMBER WAS RUSTED AWAY... AND THE DRIVER'S SIDE SHOCK WAS HANGING DOWN (BRACKET RUSTED AWAY) TRUCK IS NOW PARKED AT HOME CAN'T FIX IT.... HAD TO BUY A USED VAN FROM MY BOSS SO I COULD GET TO WORK..... I WILL HAVE TO JUNK THE TITLE IN THE NEXT FEW DAYS.... TRUCK RUNS FINE BUT JUST CAN'T FIX A RUSTED OUT FRAME... NOT SAFE FOR ANYONE TO DRIVE... BY THE WAY THE END OF THE FRAME WHERE THE REAR BUMPER ATTACHES RUSTED ABOUT 18 MONTHS AGO AND HAD TO PUT 1/2 INCH STEEL IN TO REATTACH IT.... THE FRAME WAS A LITTLE RUSTY AT THAT TIME BUT NO HOLES OR BREAKS.... I THINK FORD SHOULD COMPENSATE ALL RANGER OWNERS FOR RUSTED OUT FRAMES, I HAVE READ BLOGS AND THERE ARE A LOT OF THESE RANGER FRAMES RUSTED OUT... I HAVE PICTURES IF NEEDED...
NHTSA complaint #10712102 — an unverified report by a vehicle owner.
at 70,000 milesSparta, NJ
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 1995 FORD RANGER. THE CONTACT STATED THAT THE SUBFRAME WAS SEVERELY CORRODED AND FRACTURED. AS A RESULT, THE REAR SPRINGS AND TIRES SEPARATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000.
NHTSA complaint #10664312 — an unverified report by a vehicle owner.
at 86,000 milesHagaman, NY
STRUCTURE
MY 1995 FORD RANGER WAS PURCHASED BRAND NEW, ORDERED TO MY SPECIFICATIONS, I AM THE ORIGINAL OWNER AND THE TRUCK HAS 86K ORIGINAL MILES. THE BODY OF MY TRUCK IS IN VERY GOOD CONDITION, AS I HAVE MAINTAINED MY TRUCK THE ENTIRE LIFE OF IT, THROUGH CONTINUOUS CLEANINGS TO KEEP THE SALT DEBRIS OFF DURING THE WINTER MONTHS. THIS TRUCK HAS BEEN MY PRIDE AND JOY AS IT WAS MY VERY FIRST NEW VEHICLE. I AM NOW VERY DISGUSTED AS THE FRAME ON THE LEFT SIDE, BOTH FRONT AND REAR IS COMPLETELY ROTTING AWAY AND EXTREMELY UNSAFE TO DRIVE. EVEN THOUGH THE BODY OF MY TRUCK LOOKS EXCELLENT, MY TRUCK WILL NO LONGER PASS INSPECTION DUE TO ITS DEFECTIVE FRAME. TOYOTA HAD THE SAME ISSUE WITH ITS TACOMA TRUCKS AND MADE GOOD ON THEM WITH A RECALL. I AM LOOKING FOR THE SAME SATISFACTION, AS I AM A 3 TIME OWNER OF FORD VEHICLES. I CURRENTLY OWN MY SECOND FORD E-250 CARGO VAN, THAT WITH ONLY 62K ORIGINAL MILES I HAD TO REPLACE THE TRANSMISSION. I PURCHASED FORD PRODUCTS AS I WAS ALWAYS TOLD FORD STANDS BY THEIR PRODUCTS, AND I AM HOPING THAT IS TRUE, BECAUSE NOW I OWN A $19K PIECE OF FORD JUNK THAT WITH OUT AN INSPECTION BECAUSE OF A ROTTED FRAME IS USELESS. I DID MY PART OVER THE YEARS TAKING EXCELLENT CARE OF MY FORD RANGER AND FOR WHAT? I AM A VERY DISSATISFIED CUSTOMER AND I FEEL THAT THE FRAME ON MY 1995 FORD RANGER IS DEFECTIVE, JUST LIKE THE TOYOTA WAS AND I AM HOPING THAT SINCE I AM NOT THE ONLY ONE WITH A ROTTED FRAME ON THEIR FORD RANGER THAT FORD WILL BE MAKING GOOD ON THIS DEFECTIVE FRAME. I HAVE FOUND NUMEROUS OTHER COMPLAINTS ON THE INTERNET OF CUSTOMERS THAT ALSO HAD A 1995 FORD RANGER WITH TWICE THE MILES THAT I HAVE AND THEIR FRAME WAS ALSO ROTTED AND DEFECTIVE. PLEASE LET ME KNOW WHAT THE NECESSARY STEPS ARE THAT I NEED TO TAKE TO HAVE MY DEFECTIVE FRAME LOOKED INTO FURTHER FOR A REPLACEMENT DUE TO A RECALL ON FORD'S DEFECTIVE RANGER FRAMES.
NHTSA complaint #10592600 — an unverified report by a vehicle owner.
Orange Grove, TX
SUSPENSION:FRONT
PURCHASED BILSTEIN SHOCKS FOR FORD RANGER 95 XLT 2WD 6CYL 4.0 3 YEARS AGO FRONT SHOCKS WENT SOFT AFTER 5K MILES. PERSEVERED AND PURCHASED NEW FRONT SHOCKS [BILSTEIN] A FEW MONTHS AGO. FRONT SHOCKS SUBSTANDARD. CONTACTED BILSTEIN. SENT ALL 6 SHOCKS IN. RECEIVED 6 REPLACEMENT SHOCKS. FRONT SHOCKS ARE SUBSTANDARD. TOOK VEHICLE TO REPUTABLE MECHANIC IN AUSTIN. CONCERNS WERE VERIFIED. CONTACTED BILSTEIN WITH INFORMATION. MY PATIENCE HAS RUN OUT. THIS IS A STANDARD PICKUP. STANDARD SUSPENSION HIGHWAY USE ONLY. 10K MILES PER YEAR. NUMBERS ON SHOCK ABSORBER BOX ARE: 24-022361 AND F4-B46-2236-H1 I CONSIDER THIS A SAFETY ISSUE. BRAKING AND HANDLING OF MY VEHICLE ARE COMPROMISED. ARE THERE OTHER COMPLAINTS ABOUT THESE SHOCKS? I AM IN POSSESSION OF THE BRAND NEW UNUSED PAIR OF FRONT SHOCKS SUPPLIED BY BILSTEIN I COULD SUBMIT FOR INDEPENDENT TESTING. I WOULD ALSO BE ABLE TO TAKE MY VEHICLE TO ANY INDEPENDENT MECHANIC TO VERIFY THIS PROBLEM.
NHTSA complaint #10555967 — an unverified report by a vehicle owner.
at 156,876 milesDestin, FL
SERVICE BRAKES
IN 2011, I WAS INFORMED BY LETTER THAT THERE WAS A RECALL ON MY VEHICLE. I WENT INTO THE DEALER IN FORT WALTON BEACH FL. AND THEY INSTALLED A WIRE CONNECTION TO THE BRAKE MASTER CYLINDER AREA ON THE ABS CONTROL. THEY SAID EVERYTHING WAS OK. IN SPRING OF 2013 THE ABS LIGHT CAME ON AS IT DOES EVERY TIME I START THE CAR. THIS TIME IT STAYED ON AND DOES NOT GO OUT EVERY TIME THE VEHICLE IS DRIVEN. THIS IS A SAFETY ISSUE AND MUST BE RESOLVED. THIS LIGHT INDICATES A FAILURE IN THE BRAKING SYSTEM.
NHTSA complaint #10538309 — an unverified report by a vehicle owner.